lock RENAULT KANGOO VAN ZERO EMISSION 2012 X61 / 2.G Workshop Manual

4.11
Glass instrument panel(e.g. instrument panel, clock, exterior
temperature display, radio display, etc.)
Use a soft cloth (or cotton wool).
If this does not clean it properly, use a
soft cloth (or cotton wool) slightly mois-
tened with soapy water and then wipe
clean with a soft damp cloth or cotton
wool.
Finally, carefully dry off with a soft dry
cloth.
Cleaning products containing alco-
hol must not be used under any cir-
cumstances.
Seat belts
These must be kept clean.
Use products selected by our Technical
Department (Approved outlets) or
warm, soapy water and a sponge and
wipe with a dry cloth.
Detergents or dyes must not be used
under any circumstances.
INTERIOR TRIM MAINTENANCE (1/2)
Textiles (seats, door trim, etc)
Vacuum-clean the textiles regularly.
Liquid stain
Use soapy water.
Dab lightly (never rub) with a soft cloth,
rinse and remove the excess.
Solid or pasty stain
Carefully remove the excess solid or
pasty material immediately with a
spatula (working from the edges to the
centre to avoid spreading the stain).
Clean as for a liquid stain.
Special instructions for sweets or
chewing gum
Put an ice cube on the stain to solidify
it, then proceed as for a solid stain.
A well-maintained vehicle will last
longer. It is therefore recommended to
maintain the interior of the vehicle regu-
larly.
A stain should always be dealt with
swiftly.
Whatever type of stain is on the trim,
use
cold (or warm) soapy water with
natural soap.
Detergents (washing-up liquid, pow-
dered products, alcohol-based prod-
ucts) should not be used.
Use a soft cloth.
Rinse and soak up the excess.
For further recommendations for
maintaining the interior, and/or for
any unsatisfactory results, please
see an authorised dealer.

5.2
PUNCTURE/EMERGENCY SPARE WHEEL
To access the emergency spare
wheel
– Open the tailgate.
– Undo the nut with the wheelbrace 1.
– Detach the cage using handle 3.
– Release the emergency spare wheel.
To store the wheel in the cage
– Make sure the wheel is correctly po- sitioned in the cage, valve facing
down.
– Reposition the cage using handle 3
and retighten the nut using span-
ner 1 to refit the assembly.
– Make sure it is correctly locked.
If the emergency spare
wheel has been stored
for several years, have it
checked by your Dealer to
ensure that it is safe to use.
2
3
1
Emergency spare wheel 2
This is stored in cage 4 under the floor
at the rear of the vehicle.
4
In the event of a puncture, there is
either an emergency spare wheel or
tyre inflation kit available, depending on
the vehicle (refer to the information in
the following pages).

5.17
REAR LIGHTS: changing bulbs (2/3)
High-level brake light
– Version with tailgate: it is located
above the rear screen, in the centre.
– Version with hinged doors: it is lo-
cated above the rear screen, on the
left-hand door. Remove the two plastic blanking
covers 7
from the inside. Unclip the
light using a screwdriver, by pressing in
the metal clip housings.
Remove light 8 from the outside.
Replace the bulb without disconnecting
the wiring.
Bulb type: W16W
For refitting, proceed in the reverse
order to removal.
Check the tabs are correctly locked in
position.
78

5.25
FUSES (2/2)
Number Allocation
1 Traction battery charger
2 Electric motor control unit
3 Air conditioning, pedestrian
horn
4 heating, brake lights,
traction battery
5 Rear windscreen wiper
6 Horn, diagnostic socket
7 Heated seats
8 Traction battery
9 Passenger compartment
ECU
10 Windscreen washer
11 Brake lights
12 Passenger compartment
unit, ABS, ESP
13 Electric windows, child
safety, heating and air
conditioning system, ECO
mode
14 Not used
15 Starter
12
3456
78910
11121314
15161718
19202122
23242526
27
28
29
Allocation of fusesThe presence of certain fuses de-
pends on the vehicle equipment
level.
Number Allocation
16 Brake lights, additional
equipment, navigation, ABS,
ESP, boot light, interior
lights, rain and light sensor,
charging warning light
17 Radio, navigation system,
display, alarm
18 Additional equipment
19 Heated door mirrors
20 Hazard lights, rear fog lights
21 Central locking of opening
elements
22 Instrument panel
23 Not used
24 ESP, radio, heating and air
conditioning system, heated
seats, stop lights
25 Front accessories socket
26 Towbar
27 Electric front windows
28 Rear-view mirror control
29 Engine cooling fan

5.26
Replacing windscreen wiper
blades 2
– With the ignition switched off , lift
wiper arm 2 slightly;
– pull tab 1 upwards;
– move the blade in the direction of the arrow.
For refitting, proceed in the reverse
order and ensure that the blade is cor-
rectly clipped on.
WINDSCREEN WIPER BLADES (1/2)
Check the condition of the wiper
blades. You are responsible for their
service life:
– clean the blades, windscreen and rear screen regularly with soapy
water;
– do not use them when the wind- screen or rear screen are dry;
– free them from the windscreen or rear screen when they have not
been used for a long time.
1
Replacing windscreen wiper
blades 3
– With the ignition on and the engine
switched off , lower the windscreen
wiper stalk fully: they stop slightly
away from the bonnet;
– lift wiper arm 5 , pull tab 4 (move-
ment A) and push the blade up-
wards.
To refit
Slide the blade along the arm until it
clips on. Make sure that the blade is
correctly locked in position. Return the
windscreen wiper stalk to the park po-
sition.
3
4
5
A
2

5.28
Choice of breakdown service
In the event of an energy fault
In the event of a fully discharged trac-
tion battery, any type of towing is per-
mitted: towing on a flatbed truck or
towing on the road using the tow eye
(please see following pages).
All other cases
Only towing on a flatbed truck is per-
mitted.
TOWING, BREAKDOWN (1/3)
Before repairs, insert the key in the igni-
tion to unlock the steering column. Turn
it to position M.
The regulations in force for breakdown
recovery must always be observed.Towing on a flatbed truck
Breakdown recovery must be per-
formed on a flat surface under all cir-
cumstances except where the vehicle
is immobilised following a full discharge
of the traction battery. In the event of a
total energy loss, please see the follow-
ing pages.

5.29
Bring lever to position N.
TOWING, BREAKDOWN (2/3)
In the event of an energy
fault: towing
In the event of a fully discharged trac-
tion battery:
– the warning light
 flashes;
– needle 1 is in the lower section of the
reserve zone.
It is possible to recover on a flatbed
truck or tow the vehicle using the tow
eye, following the instructions below.
When the engine is
stopped, steering and brak-
ing assistance are not op-
erational.
Before towing, insert the key in the
switch to unlock the steering column.
Turn it to position M.
The column is unlocked, the acces-
sory functions are supplied: the vehi-
cle lights can be used (hazard warn-
ing lights, brake lights etc.). The towed
vehicle’s lights must be switched on at
night.
The speed specified by current legis-
lation for towing must always be ob-
served.
4
1
2
If the lever is stuck in P ,
even though you are de-
pressing the brake pedal,
the lever can be released
manually.
To do this, unclip the cover at the
base of the lever.
Press simultaneously on mark 2 and
on the unlocking button on the lever.

5.35
FAULTSPOSSIBLE CAUSESWHAT TO DO
The additional heating does not work. Fill up the fuel tank. Fill up with fuel – see information on the
“Additional heating tank” in Section 1.
The programmable heating does not
work. One of the usage conditions is not
complied with (the traction battery is
not charged, etc.).Refer to the information on “Heating/air
conditioning: programmable heating” in
Section 3.
The vehicle clock is poorly adjusted
or not adjusted. Adjust the clock on the instrument panel
see the information on “Clock and exterior
temperature” in Section 1.
OPERATING FAULTS (2/4)

7.1
ALPHABETICAL INDEX (1/5)
A
ABS ....................................................................\
...2.10 → 2.12
accessories.............................................................\
........... 5.32
accessories socket ............................................................ 3.17
additional heating fuel........................................................ 1.88
additional heating tank....................................................... 1.88
additional methods of restraint .......................................... 1.42
additional heating ..................................................... 3.9 – 3.10 additional heating fuel tank .......................................... 1.88
additional tank capacity ..................................................... 1.88
additional tank filling .......................................................... 1.88
air bag.................................................................\
...1.38 → 1.42
activating the front passenger air bags ............1.54 → 1.56
deactivating the front passenger air bags ........1.54 → 1.56
air conditioning ................................................. 3.4 → 3.6, 3.11
air vents ...................................................................... 3.2 – 3.3
anti-corrosion check ..............................................6.14 → 6.18
anti-corrosion protection ...................................................... 4.9
anti-lock braking system: ABS ...............................2.10 → 2.12
ashtrays ...............................................................\
.............. 3.17
audible and visual signals.................................................. 1.78
B
12 volt battery breakdown recovery ......................................... 5.22 – 5.23
maintenance ......................................................... 4.6 – 4.7
12 volt battery ........................1.2 → 1.6, 4.6 – 4.7, 5.22 – 5.23
battery troubleshooting ................................................. 5.22 – 5.23
battery (remote control) ..................................................... 5.33
bonnet..................................................................\
....... 4.2 – 4.3
brake fluid ........................................................................\
.... 4.5
brake lights changing bulbs .................................................. 5.16 – 5.17
bulbs changing ..........................................................5.13 \
→ 5.21C
changing a bulb ............................... 5.13
→ 5.15, 5.19 → 5.21
changing a wheel........................................................\
......... 5.8
changing gear ............................................................. 2.3 – 2.4
charge meter ....................................................... 1.66, 2.5, 2.8
charging cord ..................................................1.8 → 1.14, 1.17
charging flap ............................................................1.7 → 1.14
charging socket ..................................... 1.2 → 1.6, 1.8 → 1.14
child minder mirror ............................................................. 3.14
child restraint/seat .............................1.44 – 1.45, 1.47 → 1.56
child safety.....1.15, 1.17, 1.19, 1.44 – 1.45, 1.47 → 1.56, 3.15
child seats..........................................1.44 – 1.45, 1.4\
7 → 1.53
children ................................................................... 1.44 – 1.45
cigar lighter ........................................................................\
3.17
cleaning: inside the vehicle .............................................. 4.11 – 4.12
clock ..................................................................\
................ 1.77
closing the doors ...................................................1.18 → 1.22
connected services .............................................................. 1.3
control instruments ................................................1.65 → 1.73
controls ...............................................................\
...1.58 → 1.61
coolant ................................................................\
................. 4.4
courtesy light .......................................................... 3.12 – 3.13
courtesy mirrors ................................................................. 3.14
cruise control .........................................................2.16 → 2.19
D
dashboard..............................................................1\
.58 → 1.61
deadlocking the doors ....................................................... 1.17
de-icing ...............................................................\
................. 3.5
dimensions ................................................................. 6.4 – 6.5
display ................................................................\
...1.62 → 1.67
doors...................................................................\
...1.18 → 1.25
driver’s position .....................................................1.58 → 1.64
driving .................................................. 2.3 → 2.6, 2.10 → 2.21

7.3
ALPHABETICAL INDEX (3/5)
hubcap tool ........................................................................\
.. 5.6
I
indicators ......................................................... 1.78, 5.14, 5.19
indicators:direction indicators .............................................. 5.14, 5.19
instrument panel ..............................................1.62 → 1.67
instrument panel ....................................................1.62 → 1.76
instrument panel messages...................................1.68 → 1.76
interior lighting: changing bulbs .................................................. 5.20 – 5.21
interior trim maintenance ..................................................... 4.11 – 4.12
Isofix .................................................................\
.....1.47 → 1.53
J
jack ...................................................................\
............ 5.6, 5.8
L
levels: brake fluid ...................................................................... 4.5
coolant ................................................................\
........... 4.4
windscreen washer reservoir ......................................... 4.5
lifting the vehicle changing a wheel .................................................. 5.8 – 5.9
lighting: interior ............................................................... 3.12 – 3.13
lights adjustment ........................................................ 1.83 – 1.84
changing bulbs .................................................. 5.13 – 5.14
fog lights ...................................................................... 5.15
front ................................................................... 5.13 – 5.14
lights: brake lights .................................................................. 5.16
dipped beam headlights ............................. 1.62, 1.80, 5.13
direction indicators ..................................... 1.62, 1.78, 5.16 fog lights .................................................... 1.62, 1.82, 5.15
hazard warning ............................................................ 1.78
main beam headlights .............................. 1.62, 1.80 – 1.81
number plate lights ...................................................... 5.18
reversing lights ............................................................. 5.16
side lights ..................................................................... 1.80
lights-on warning buzzer........................................... 1.18, 1.81
locking the doors .................................................... 1.23 – 1.24
luggage retaining net ......................................................... 3.26
M
maintenance: bodywork ............................................................ 4.9 – 4.10
interior trim ........................................................ 4.11 – 4.12
mechanical .........................................4.2 – 4.3, 6.8 → 6.13
map reading lights .................................................. 3.12 – 3.13
methods of restraint in addition to the front seat belts ..............
1.38 → 1.40
methods of restraint in addition to the seat belts ...1.38 → 1.42
multimedia (equipment) ..................................................... 3.27
multimedia equipment .............................................. 3.27, 5.31
N
navigation .............................................................\
............. 3.27
navigation system .............................................................. 3.27
O
opening the doors ..................................................1.18 → 1.22
operating faults ................................ 1.62 → 1.64, 5.34 → 5.37
P
paintwork maintenance ....................................................... 4.9 – 4.10
reference ..............................................................\
.......... 6.2
parking distance control.......................................... 2.20 – 2.21
partition ..............................................................\
................ 1.33