RENAULT PULSE 2012 1.G Owners Manual
Manufacturer: RENAULT, Model Year: 2012, Model line: PULSE, Model: RENAULT PULSE 2012 1.GPages: 352, PDF Size: 6.46 MB
Page 261 of 352
> ( G L W 0 R G H O . $ 2 ( 0 B 5 H Q D X O W @
DRAINING WATER
Drain water in the fue\f fi\fter accordin\b to the
maintenance \fo\b shown in a separate maintenance
book\fet.
If the water-in-fue\f-fi\fter\u warnin\b \fi\bht
i\f\fuminates
whi\fe the en\bine is runnin\b, there mi\bht be water in the
fue\f fi\fter.
The fue\f fi\fter can be accessed after removin\b the fuse
box and the battery from the vehic\fe. Therefore,
RENAULT recommends that you contact a RENAULT
dea\fer for servicin\b.
BLEEDING FUEL SYSTEM
SDI2714
B\feed air out of the fue\f system after refi\f\fin\b an empty
fue\f tank by the fo\f\fowin\b action:
1. Squeeze the primin\b pump
*1\focated in the
en\bine compartment severa\f times unti\f there is a
sudden resistance fe\ft in the pressure, then stop.
2. Crank the en\bine unti\f it starts. Do not crank the en\bine for more than 30 seconds.
3. If the en\bine does not start, stop crankin\b and repeat step 1 above. 4. If the en\bine does not operate smooth\fy after it has
started, race it two or three times.
JVM0061XHR12DDR engine1. Superchar\ber
2. Water pump
3. A\fternator
4. E\fectroma\bnetic c\futch
5. Crankshaft pu\f\fey
6. Drive be\ft auto-tensioner
7. Air conditioner compressor
Maintenance and do-it-yourself8-15
FUEL FILTER (diesel engine model)
DRIVE BELTS
& R Q G L W L R Q
Page 262 of 352
> ( G L W 0 R G H O . $ 2 ( 0 B 5 H Q D X O W @
8-16Maintenance and do-it-yourself
SDI2573HR 12DE engine or HR 15DE engine1. Water pu\fp
2. Alternat\br
3. Crankshaft pulley
4. Air c\bnditi\bner c\b\fpress\br (with air c\b\fpres-s\br)
Idler pulley (with\but air c\b\fpress\br)
!: Tensi\bn checking p\bint
SDI2484K9K engine1. Crankshaft pulley
2. Drive belt aut\b-tensi\bner
3. Alternat\br
4. Air c\bnditi\bner c\b\fpress\br
Be sure the igniti\bn switch is in the “OFF” p\bsiti\bn. Visually inspect each belt f\br signs \bf unusual wear,
cuts, fraying \br l\b\bseness. Check regularly f\br c\bndi-
ti\bn and tensi\bn. If the belt is in p\b\br c\bnditi\bn \br l\b\bse,
have it replaced \br adjusted by a RENAULT dealer.
WARNING:
Be sure the engine and ignition switch are off
and that the parking brake is applied.
Replace the spark plugs acc\brding t\b the \faintenance
l\bg sh\bwn in a separate \faintenance b\b\bklet.
If replace\fent is required, c\bntact a RENAULT dealer.
SDI1895
IRIDIUM-TIPPED SPARK PLUGS (if
equipped)
It is n\bt necessary t\b replace the iridiu\f-tipped*Aspark plugs as frequently as the c\bnventi\bnal type \bf
spark plugs. These spark plugs are designed t\b last
\fuch l\bnger than the c\bnventi\bnal type \bf spark plug.
CAUTION:
.
Do not reuse the iridium-tipped spark plugs
by cleaning or re-gapping.
. Always replace with the recommended ir-
idium-tipped spark plugs.
SPARK PLUGS (gasoline engine
model)
& R Q G L W L R Q
Page 263 of 352
> ( G L W 0 R G H O . $ 2 ( 0 B 5 H Q D X O W @
NICKEL-TIPPED SPARK PLUGS (if
e\fuipped\b
It is not necessary to replace the nickel-tipped*Aspark plugs as fre\fuently as the conventional type of
spark plugs. These spark plugs are designed to last
much longer than the conventional type of spark plug.
CAUTION:
.Do not reuse the nickel-tipped spark plugs
by cleaning or re-gapping.
. Always replace with the recommended nick-
el-tipped spark plugs.
CHECKING PARKING BRAKE
Lever type
SDI1447A
From the released position, pull the parking brake lever
up slowly and firmly. If the number of clicks is out of the
range listed, see a RENAULT dealer.
For Thailand, Indonesia, Singapore, China, Hong
Kong, Brunei and Pakistan:
9 to 10 clicksPulling force 196 N (20 kg, 44 lb)
For India: 8 to 9 clicks (for model with ABS or K9K
engine model)
9 to 10 clicks (for model without ABS)Pulling force 196 N (20 kg, 44 lb)
For Australia and New Zealand: 11 to 12 clicksPulling force 196 N (20 kg, 44 lb) Except for Thailand, Indonesia, Singapore, Chi-
na, Hong Kong, Brunei, India, Australia, New
Zealand and Pakistan:
8 to 9 clicksPulling force 196 N (20 kg, 44 lb)
CHECKING FOOT BRAKE PEDAL
DI1020MR
WARNING:
See a RENAULT dealer for a brake system check
if the foot brake pedal height does not return to
normal.
With the engine running, check the distance
*Abetween the upper surface of the pedal and the metal
floor. If it is out the range listed, see a RENAULT
dealer.
*A: Depressing force
490 N (50 kg, 110 lb)
— 80 mm (3.15 in) or more
Maintenance and do-it-yourself8-17
BRAKES
& R Q G L W L R Q
Page 264 of 352
> ( G L W 0 R G H O . $ 2 ( 0 B 5 H Q D X O W @
8-18Maintenance and do-it-yourself
Self-adjusting brakes
\four vehi\ble is equipped with self-adjusting brakes.
The brakes are adjusted by the foot brake pedal
operation.
Brake pad wear indi\bator
The dis\b brake pads on your vehi\ble have audible wear
indi\bators. When a brake pad requires repla\bement, it
will make a high pit\bhed s\braping or s\bree\bhing sound
when the vehi\ble is in motion. The noise will be heard
whether or not the foot brake pedal is depressed. Have
the brakes \bhe\bked as soon as possible if the wear
indi\bator sound is heard.
Under some driving or \blimate \bonditions, o\b\basional
brake squeaks, squeals or other noises may be heard.
O\b\basional brake noise during light to moderate stops
is normal and does not affe\bt the fun\btion or
performan\be of the brake system.
The rear drum brakes do not have audible wear
indi\bators. Should you ever hear an unusually loud
noise from the rear drum brakes, have them \bhe\bked
as soon as possible by a RENAULT dealer.
Proper brake inspe\btion intervals should be followed.
For additional information, see a separate maintenan\be
booklet.
BRAKE BOOSTER
Che\bk the brake booster fun\btion as follows:
1. With the engine off, depress and release the footbrake pedal several times. When the foot brake
pedal movement (distan\be of travel) remains the
same from one pedal appli\bation to the next,
\bontinue on to the next step.
2. While depressing the foot brake pedal, start the engine. The pedal height should drop a little. 3. With the foot brake pedal depressed, stop the
engine. Keep the pedal depressed for about 30
se\bonds. The pedal height should not \bhange.
4. Run the engine for 1 minute without depressing the foot brake pedal, then turn it off. Depress the
foot brake pedal several times. The pedal travel
distan\be will de\brease gradually with ea\bh de-
pression as the va\buum is released from the
booster.
If the brakes do not operate properly, have the brakes
\bhe\bked by a RENAULT dealer.
WARNING:
. Use only new fluid from a sealed container.
Old, inferior, or contaminated fluid may
damage the brake system. The use of
improper fluids can damage the brake
system and affect the vehicle’ s stopping
ability.
. Clean the filler cap before removing.
. Brake fluid is poisonous and should be
stored carefully in marked containers out
of the reach of children.
CAUTION:
Do not spill the fluid on painted surfaces. This
will damage the paint. If fluid is spilled, wash it
off with plenty of water immediately.
SDI0890
Che\bk the fluid level in the reservoir. If the brake fluid is
below the MIN line, the brake warning light will
illuminate. Add brake fluid up to the MAX line. (See
“Re\bommended fuel/lubri\bants and \bapa\bities” (P.9-2)
for re\bommended types of brake fluid.)
If the brake fluid must be added frequently, the brake
BRAKE FLUID
& R Q G L W L R Q
Page 265 of 352
> ( G L W 0 R G H O . $ 2 ( 0 B 5 H Q D X O W @
system should be thoroughly checked by a REN\fULT
dealer\bWARNING:
.Use only new fluid from a sealed container.
Old, inferior, or contaminated fluid may
damage the clutch system.
. Clean the filler cap before removing.
. Clutch fluid is poisonous and should be
stored carefully in marked containers out of
the reach of children.
CAUTION:
Do not spill the clutch fluid on painted surfaces.
This will damage the paint. If clutch fluid is
spilled, wash it off with plenty of water immedi-
ately.
SDI0890
Check the fluid level in the reservoir\b If the fluid is
below the MIN line, add fluid up to the M\fX line\b (See
“Recommended fuel/lubricants and capacities” (P\b9-2)
for the recommended types of fluid\b)
If the fluid must be added frequently, the clutch system
should be thoroughly checked by a REN\fULT dealer\b Contact a REN\fULT dealer if checking or replacement
is required\b
CAUTION:
.
Use only fluids approved by our technical
department. Do not mix with other fluids.
. Using automatic transmission fluid other
than fluids approved by our technical de-
partment will cause deterioration in drive-
ability and transmission durability, and may
damage the transmission, which is not
covered by the warranty.
Maintenance and do-it-yourself8-19
CLUTCH FLUID (if equipped)
AUTOMATIC TRANSMISSION FLUID
(ATF) (if equipped)
& R Q G L W L R Q
Page 266 of 352
> ( G L W 0 R G H O . $ 2 ( 0 B 5 H Q D X O W @
8-20Maintenance and do-it-yourself
Contact a RENAULT dea\fer if c\becking or rep\facement
is required.
CAUTION:
.Use only fluids approved by our technical
department. Do not mix with other fluids.
. Using transmission fluid other than fluids
approved by our technical department will
damage the CVT, which is not covered by the
warranty. T\be viscous paper type fi\fter e\fement s\bou\fd not be
c\feaned and reused.
T\be dry paper type fi\fter e\fement may be c\feaned and
reused.
Rep\face t\be air c\feaner fi\fter according to t\be main-
tenance \fog s\bown in a separate maintenance book\fet.
Contact a RENAULT dea\fer if maintenance or rep\face-
ment is required.
WARNING:
Operating the engine with the air cleaner filter
off can cause you or others to be burned. The air
cleaner filter not only cleans the intake air, it
also stops flame if the engine backfires. If the air
cleaner filter is not installed and the engine
backfires, you could be burned. Never drive with
the air cleaner filter off. Be cautious working on
the engine when the air cleaner filter is off.
WINDSHIELD WIPER BLADES
C\feaning
If t\be winds\bie\fd does not become c\fear after using t\be
winds\bie\fd was\ber or if t\be wiper b\fades c\batter w\ben
operating t\be winds\bie\fd wipers, wax or ot\ber materia\fs
may be on t\be winds\bie\fd and/or wiper b\fades.
C\fean t\be outside of t\be winds\bie\fd surface wit\b a
was\ber so\fution or mi\fd detergent. Your winds\bie\fd is
c\fean if beads do not form w\ben rinsing wit\b water.
C\fean t\be b\fade by wiping it wit\b a c\fot\b soaked in a
was\ber so\fution or a mi\fd detergent. Rinse t\be b\fade
wit\b water. If your winds\bie\fd is sti\f\f not c\fear after
c\feaning t\be b\fades and using t\be wipers, rep\face t\be
b\fades.
CONTINUOUSLY VARIABLE
TRANSMISSION (CVT) FLUID (if
equipped)
AIR CLEANER FILTER
WIPER BLADES
& R Q G L W L R Q
Page 267 of 352
> ( G L W 0 R G H O . $ 2 ( 0 B 5 H Q D X O W @
SDI1865
Be careful not to clog t\fe was\fer nozzle*A\b T\fis may
cause improper winds\field was\fer operation\b If t\fe
nozzle is clogged, remove any objects wit\f a needle or
small pin
*B\b Be careful not to damage t\fe nozzle\b
Replacing
SDI1803
1\b Lift t\fe wiper arm away from t\fe winds\field\b
2\b Pus\f and \fold t\fe release tab
*A, and t\fen move
t\fe wiper blade down t\fe wiper arm to remove
*1\b
3\b Remove t\fe wiper blade\b
4\b Insert t\fe new wiper blade onto t\fe wiper arm until it clicks into place\b
CAUTION:
.After wiper blade replacement, return the
wiper arm to its original position. Otherwise
the wiper arm or the engine hood may be
scratched and may cause damage.
. Worn windshield wiper blades can damage
the windshield and impair driver vision.
REAR WINDOW WIPER BLADE (if
equipped)
Contact a RENAULT dealer if c\fecking or replacement
is required\b
Maintenance and do-it-yourself8-21
& R Q G L W L R Q
Page 268 of 352
> ( G L W 0 R G H O . $ 2 ( 0 B 5 H Q D X O W @
8-22Maintenance and do-it-yourself
SDI2574Type A
JVM0023XType B
WARNING:
Anti-freeze is poisonous and should be stored
carefully in marked containers out of the reach
of children.
Type \f: Che\bk the fluid level in the window washer
reservoir. If the fluid level is low, add window washer
fluid up to the M\fX level.
Type B: To \bhe\bk the fluid level, use your finger to plug
the \benter hole
*1of the \bap/tube assembly, then
remove it from the reservoir. If there is no fluid in the
tube, add fluid. \fdd a washer solvent to the water for better \bleaning.
In the winter season, add a windshield washer anti-
freeze. Follow the manufa\bturer’s instru\btions for the
mixture ratio.
WINDOW WASHER FLUID
& R Q G L W L R Q
Page 269 of 352
> ( G L W 0 R G H O . $ 2 ( 0 B 5 H Q D X O W @
VEHICLE BATTERY
SDI1573
WARNING:
Do not operate the vehicle if the fluid in the
battery is low. Low battery fluid can cause a
higher load on the battery which can generate
heat, reduce battery life, and in some cases lead
to an explosion.
Maintenance and do-it-yourself8-\f3
BATTERY
& R Q G L W L R Q
Page 270 of 352
> ( G L W 0 R G H O . $ 2 ( 0 B 5 H Q D X O W @
8-24Maintenance and do-it-yourself
Checking battery fl\fid level
D\b0137MAType A
SD\b1480Type A
JVM0065XType BCheck the fl\fid level in each cell. The battery fl\fid level
sho\fld be between the UPPER LEVEL*1and
LOWER LEVEL*2lines.
\bf it is necessary to add fl\fid, add only demineralized/
distilled water to bring the level to the indicator in each
filler opening. Do not overfill.
1. Remove the cell pl\fgs
*A, if eq\fipped.
2. Add demineralized/disti\llled water \fp to the UPPER LEVEL
*1line.
3. Replace and tighten the cell pl\fgs.
. Vehicles operated in high temperat\fres or \fnder
severe conditions req\fire freq\fent checks of the
battery fl\fid level.
. Keep the battery s\frface clean and dry. Clean the
battery with a sol\ftion of baking soda and water.
. Make certain the terminal connections are clean
and sec\frely tightened.
. \bf the vehicle is not to be \fsed for more than 30
days, disconnect the negative ( í) battery terminal
cable to prevent battery discharge.
. For a maintenance free battery (for Type B) it is not
req\fired to check the fl\fid level. However,
RENAULT recommends to vis\fally check the green indicator
*Bstat\fs periodically. \bf the color
of the indicator is changed, please contact a
RENAULT dealer as soon as possible.
For model with Stop/Start (\bdling Stop) System, see
“J\fmp starting” (P.6-8) .
J\fmp starting
\bf j\fmp starting is necessary, see “J\fmp starting” (P.6-
8) . \bf the engine does not start by j\fmp starting or the
battery does not charge, the battery may have to be
replaced. Contact a RENAULT dealer for replacing the
battery.
REMOTE CONTROLLER BATTERY
Battery replacement
CAUTION:
. Be careful not to allow children to swallow
the battery and removed parts.
. An improperly disposed battery can harm
the environment. Always confirm local reg-
ulations for battery disposal.
. When changing batteries, do not let dust or
oil get on the components.
. There is danger of explosion if lithium
battery is incorrectly replaced. Replace only
with the same or equivalent type.
& R Q G L W L R Q