battery RENAULT PULSE 2012 1.G Workshop Manual
[x] Cancel search | Manufacturer: RENAULT, Model Year: 2012, Model line: PULSE, Model: RENAULT PULSE 2012 1.GPages: 352, PDF Size: 6.46 MB
Page 250 of 352
> ( G L W 0 R G H O . $ 2 ( 0 B 5 H Q D X O W @
8-4Maintenance and do-it-yourself
Window washer fluid*:
Check that there is adequate fluid in the reser\foir.
M\bINTEN\bNCE PREC\bUTIONS
When performing any inspection or maintenance work
on your \fehicle, always take care to pre\fent serious
accidental injury to yourself or damage to the \fehicle.
The following are general precautions which should be
closely obser\fed.
WARNING:
.Park the vehicle on a level surface, apply the
parking brake securely and block the wheels
to prevent the vehicle from moving. Move
the selector lever to the “P”(Park) position
or the shift lever to the “N”(Neutral) position.
. Be sure the ignition switch is in the “OFF”or
“LOCK” position when performing any parts
replacement or repairs.
. Do not work under the hood while the
engine is hot. Always turn off the engine
and wait until it cools down.
. If you must work with the engine running,
keep your hands, clothing, hair and tools
away from moving fans, belts and any other
moving parts.
. It is advisable to secure or remove any loose
clothing and any jewelry, such as rings,
watches, etc. before working on your vehi-
cle.
. If you must run the engine in an enclosed
space such as a garage, be sure there is
proper ventilation for exhaust gases to
escape. .
Never get under the vehicle while it is
supported by a jack.
. Keep smoking materials, flame and sparks
away from fuel and the battery.
. Never connect or disconnect either the
battery or any transistorized component
connector while the ignition switch is in the
“ON” position.
. On gasoline engine models with the Multi-
port Fuel Injection (MFI) system, the fuel
filter and fuel lines should be serviced by a
RENAULT dealer because the fuel lines are
under high pressure even when the engine is
turned off.
. Your vehicle is equipped with an automatic
engine cooling fan. It may come on at any
time without warning, even if the ignition
switch is in the “OFF” position and the
engine is not running. To avoid injury, always
disconnect the negative battery cable before
working near the fan.
. Always wear eye protection whenever you
work on your vehicle.
. Never leave the engine or the transmission
related component harness connector dis-
connected while the ignition switch is in the
“ON” position.
. Avoid direct contact with used engine oil and
coolant. Improperly disposed engine oil,
engine coolant, and/or other vehicle fluids
can hurt the environment. Always conform to
local regulations for disposal of vehicle
fluids.
This “8. Maintenance and do-it-yourself” section
pro\fides instructions regarding only those items which are relati\fely easy for an owner to perform.
You should be aware that incomplete or improper
ser\ficing may result in operating difficulties or ex-
cessi\fe emissions, and could affect your warranty
co\ferage.
If in doubt about any servicing, have it
done by a RENAULT dealer.
& R Q G L W L R Q
Page 252 of 352
> ( G L W 0 R G H O . $ 2 ( 0 B 5 H Q D X O W @
8-6Maintenance and do-it-yourself
HR12DE ENGINE MODEL
JVC011\fX
1. En\bine drive belts
2. Brake and clutch* fluid reservoir— Ri\bht-Hand Drive (RHD) model
3. En\bine oil filler cap
4. Air cleaner
5. Brake and clutch* fluid reservoir — Left-Hand Drive (LHD) model
6. Fuse/fusible link box \f. Window washer fluid reservoir
8. En\bine oil dipstick
9. Radiator cap
10. Battery
11. En\bine coolant reservoir
*: For Manual Transmission (MT) Model
& R Q G L W L R Q
Page 253 of 352
> ( G L W 0 R G H O . $ 2 ( 0 B 5 H Q D X O W @
HR15DE ENGINE MODEL
JVC0118X
1. E\fgi\fe \brive belts
2. Brake a\f\b clutch* flui\b reservoir— Right-Ha\f\b Drive (RHD) mo\bel
3. E\fgi\fe oil filler cap
4. Air clea\fer
5. Brake a\f\b clutch* flui\b reservoir — Left-Ha\f\b Drive (LHD) mo\bel
6. Fuse/fusible li\fk box 7. Wi\f\bow washer flui\b reservoir
8. E\fgi\fe oil \bipstick
9. Ra\biator cap
10. Battery
11. E\fgi\fe coola\ft reservoir
*: For Ma\fual Tra\fsmissio\f (MT) Mo\bel
Maintenance and do-it-yourself8-7
& R Q G L W L R Q
Page 261 of 352
> ( G L W 0 R G H O . $ 2 ( 0 B 5 H Q D X O W @
DRAINING WATER
Drain water in the fue\f fi\fter accordin\b to the
maintenance \fo\b shown in a separate maintenance
book\fet.
If the water-in-fue\f-fi\fter\u warnin\b \fi\bht
i\f\fuminates
whi\fe the en\bine is runnin\b, there mi\bht be water in the
fue\f fi\fter.
The fue\f fi\fter can be accessed after removin\b the fuse
box and the battery from the vehic\fe. Therefore,
RENAULT recommends that you contact a RENAULT
dea\fer for servicin\b.
BLEEDING FUEL SYSTEM
SDI2714
B\feed air out of the fue\f system after refi\f\fin\b an empty
fue\f tank by the fo\f\fowin\b action:
1. Squeeze the primin\b pump
*1\focated in the
en\bine compartment severa\f times unti\f there is a
sudden resistance fe\ft in the pressure, then stop.
2. Crank the en\bine unti\f it starts. Do not crank the en\bine for more than 30 seconds.
3. If the en\bine does not start, stop crankin\b and repeat step 1 above. 4. If the en\bine does not operate smooth\fy after it has
started, race it two or three times.
JVM0061XHR12DDR engine1. Superchar\ber
2. Water pump
3. A\fternator
4. E\fectroma\bnetic c\futch
5. Crankshaft pu\f\fey
6. Drive be\ft auto-tensioner
7. Air conditioner compressor
Maintenance and do-it-yourself8-15
FUEL FILTER (diesel engine model)
DRIVE BELTS
& R Q G L W L R Q
Page 269 of 352
> ( G L W 0 R G H O . $ 2 ( 0 B 5 H Q D X O W @
VEHICLE BATTERY
SDI1573
WARNING:
Do not operate the vehicle if the fluid in the
battery is low. Low battery fluid can cause a
higher load on the battery which can generate
heat, reduce battery life, and in some cases lead
to an explosion.
Maintenance and do-it-yourself8-\f3
BATTERY
& R Q G L W L R Q
Page 270 of 352
> ( G L W 0 R G H O . $ 2 ( 0 B 5 H Q D X O W @
8-24Maintenance and do-it-yourself
Checking battery fl\fid level
D\b0137MAType A
SD\b1480Type A
JVM0065XType BCheck the fl\fid level in each cell. The battery fl\fid level
sho\fld be between the UPPER LEVEL*1and
LOWER LEVEL*2lines.
\bf it is necessary to add fl\fid, add only demineralized/
distilled water to bring the level to the indicator in each
filler opening. Do not overfill.
1. Remove the cell pl\fgs
*A, if eq\fipped.
2. Add demineralized/disti\llled water \fp to the UPPER LEVEL
*1line.
3. Replace and tighten the cell pl\fgs.
. Vehicles operated in high temperat\fres or \fnder
severe conditions req\fire freq\fent checks of the
battery fl\fid level.
. Keep the battery s\frface clean and dry. Clean the
battery with a sol\ftion of baking soda and water.
. Make certain the terminal connections are clean
and sec\frely tightened.
. \bf the vehicle is not to be \fsed for more than 30
days, disconnect the negative ( í) battery terminal
cable to prevent battery discharge.
. For a maintenance free battery (for Type B) it is not
req\fired to check the fl\fid level. However,
RENAULT recommends to vis\fally check the green indicator
*Bstat\fs periodically. \bf the color
of the indicator is changed, please contact a
RENAULT dealer as soon as possible.
For model with Stop/Start (\bdling Stop) System, see
“J\fmp starting” (P.6-8) .
J\fmp starting
\bf j\fmp starting is necessary, see “J\fmp starting” (P.6-
8) . \bf the engine does not start by j\fmp starting or the
battery does not charge, the battery may have to be
replaced. Contact a RENAULT dealer for replacing the
battery.
REMOTE CONTROLLER BATTERY
Battery replacement
CAUTION:
. Be careful not to allow children to swallow
the battery and removed parts.
. An improperly disposed battery can harm
the environment. Always confirm local reg-
ulations for battery disposal.
. When changing batteries, do not let dust or
oil get on the components.
. There is danger of explosion if lithium
battery is incorrectly replaced. Replace only
with the same or equivalent type.
& R Q G L W L R Q
Page 271 of 352
> ( G L W 0 R G H O . $ 2 ( 0 B 5 H Q D X O W @
JVM0105X
To replace the battery\f
1. Remo\be the screw
*A.
2. Insert a small screwdri\ber into the slit of the corner
*Band twist it to separate the upper part from
the lower part. Use a cloth to protect the casing.
3. Replace the battery with a new one.
Recommended battery\f CR1620 or equi\balent
.Do not touch the internal circuit and electricterminals as doing so could cause a malfunc-
tion.
.Make sure that the + side faces the bottom ofthe case*C.
4. Close the lid and install the screw securely.
5. Operate the buttons to check its operation.
See a RENAULT dealer if you need assistance for
replacement.
FCC WARNING:
Changes or modifications not expressly ap-
proved by the party responsible for compliance
could void the user’s authority to operate the
equipment.
This device complies with Part 15 of the FCC
Rules. Operation is subject to the following two
conditions; (1) This device may not cause harm-
ful interference, and (2) this device must accept
any interference received, including interference
that may cause undesired operation of the
device.
INTELLIGENT KEY BATTERY
Battery replacement
CAUTION:
. Be careful not to allow children to swallow
the battery and removed parts.
. An improperly disposed battery can harm
the environment. Always confirm local reg-
ulations for battery disposal.
. When changing batteries, do not let dust or
oil get on the components.
. There is danger of explosion if lithium
battery is incorrectly replaced. Replace only
with the same or equivalent type.
SDI2451
To replace the battery\f
1. Release the lock knob at the back of the Intelligent
Key and remo\be the mechanical key.
2. Insert a small screwdri\ber into the slit of the corner and twist it to separate the upper part from the
lower part. Use a cloth to protect the casing.
3. Replace the battery with a new one.
.Recommended battery\f CR2025 or equi\balent.Do not touch the internal circuit and electric terminals as doing so could cause a malfunc-
tion.
Maintenance and do-it-yourself8-25
& R Q G L W L R Q
Page 272 of 352
> ( G L W 0 R G H O . $ 2 ( 0 B 5 H Q D X O W @
8-26Maintenance and do-it-yourself
.Make sure that the+side faces the botto\f of
the case.
SD\b2452
4. Align the tips of the upper and lower parts*1,
and then push the\f together until it is securely
closed
*2.
5. Operate the buttons to check its operation.
See a RENAULT dealer if you need assistance for
replace\fent.
CAUTION:
. Do not ground accessories directly to the
battery terminal. Doing so will bypass the
variable voltage control system and the
vehicle battery may not charge completely.
. Use electrical accessories with the engine
running to avoid discharging the vehicle
battery.
Your vehicle is equipped with a variable voltage control
syste\f. This syste\f \feasures the a\fount of electrical
discharge fro\f the battery and controls voltage
generated by the alternator.
ENG\bNE COMPARTMENT
SD\b2575
For checking and/or replacing, see a RENAULT dealer.
Fusible links
\bf any electrical equip\fent does not operate and the
fuses are in good condition, check the fusible links. \bf
any of these fusible links are \felted, replace only with
genuine RENAULT parts.
VARIABLE VOLTAGE CONTROL
SYSTEM (if equipped) FUSES
& R Q G L W L R Q
Page 274 of 352
> ( G L W 0 R G H O . $ 2 ( 0 B 5 H Q D X O W @
8-28Maintenance and do-it-yourself
NOTE:
The extended storage fuse switch is used for
long term vehicle storage. If the extended
storage fuse switch is broken, it is not necessary
to replace it. Remove the fuse from the switch
then replace only the fuse to the fuse box.
How to remove the extended storage fuse
switch:
1. To remove the extended storage \fuse swit\bh, besure the ignition swit\bh is in the “OFF” or “LOCK”
position.
2. Be sure the headlight swit\bh is in the “OFF” position.
3. Remove the \fuse box \bover.
4. Pin\bh the storage \fuse swit\bh and pull it in the dire\btion o\f the arrow.HEADLIGHTS
Fog may temporarily \form inside the lens o\f the exterior
lights in the rain or in a \bar wash. A temperature
di\f\feren\be between the inside and the outside o\f the
lens \bauses the \fog. This is not a mal\fun\btion. I\f large
drops o\f water \bolle\bt inside the lens, \bonta\bt a
RENAULT dealer.
Repla\bing halogen headlight bulb
The halogen headlight is a semi-sealed beam type
whi\bh uses repla\beable headlight (halogen) bulbs.
They \ban be repla\bed \from inside the engine \bompart-
ment without removing the headlight assembly.
CAUTION:
.High-pressure halogen gas is sealed inside
the bulb. The bulb may break if the glass
envelope is scratched or the bulb is dropped.
JVM0109X
1. Dis\bonne\bt the battery negative \bable.
2. Dis\bonne\bt the ele\btri\bal \bonne\btor
*A\from the
rear end o\f the bulb.
3. Pull o\f\f the rubber \bap
*B.
4. Push and turn the retaining pin
*Cto loosen it.
5. Remove the headlight bulb. Do not shake or rotate the bulb when removing it.
6. Install the new bulb in the reverse order o\f removal.
LIGHTS
& R Q G L W L R Q
Page 293 of 352
> ( G L W 0 R G H O . $ 2 ( 0 B 5 H Q D X O W @
FOR EUROPE
Remote keyless entry system (if e\fuipped\b
Hereby, ALPS ELECTRIC CO.,LTD. declares that
these Keyless and TPMS TUNER; model TWC1G124
and Keyless Transmitter; model TWB1U761 are in
compliance with the essential re\fuirements and other
relevant provisions of Directive 1999/5/EC.
CAUTION:
Do not exposed to excessive heat such as
sunshine, fire or the like.
CAUTION:
Danger of explosion if battery is incorrectly
replaced. Replace only with the same or equiva-
lent type.
Intelligent Key system (if e\fuipped\b
Hereby, ALPS ELECTRIC CO.,LTD. declares that
these Passive Entry System(Hand Unit\b;model
TWB1G662, Passive Entry System(Tuner\b;model
TWC1G135, ANT ASSY-IMMOBILISER;model
TWK1A002 are in compliance with the essential
re\fuirements and other relevant provisions of Directive
1999/5/EC.
CAUTION:
Do not exposed to excessive heat such as
sunshine, fire or the like.
CAUTION:
Danger of explosion if battery is incorrectly
replaced. Replace only with the same or equiva-
lent type.
Anti-Theft System immobilizer
Hereby, CalsonicKansei Corp. declares that this ANT
ASSY-IMMOBILISER;model MW1014 is in compli-
ance with the essential re\fuirements and other
relevant provisions of Directive 1999/5/EC.
CAUTION:
Do not exposed to excessive heat such as
sunshine, fire or the like.
CAUTION:
Danger of explosion if battery is incorrectly
replaced. Replace only with the same or equiva-
lent type.
FOR CROATIA
Remote keyless entry system (if e\fuipped\b
JVT0008X
Technical information9-9
RADIO APPROVAL NUMBER AND
INFORMATION
& R Q G L W L R Q