check oil SAAB 9-2X 2006 Owner's Manual

Maintenance and service
11 - 2 3
11
– CONTINUED –
Rear differential gear oil
Checking the gear oil levelYour vehicle may be equipped with a rear
differential protector. The differential pro-
tector provides protection to the rear dif-
ferential assembly during off-road use.
Removal of the rear differential protector
is not required when checking the oil level.1) Filler plug
2) Drain plug1) Filler hole
2) Drain hole
3) Oil level
Remove the plug from the filler hole and
check the oil level. The oil level should be
kept even with the bottom of the filler hole.
If the oil level is below the bottom edge of
the hole, add oil through the filler hole to
raise the level.

Recommended grade and
viscosityEach oil manufacturer has its own base
oils and additives. Never use different
brands together.Oil grade:
API classification GL-5
21
B00373
3
1
2
B00434

Be careful not to spill rear differ-
ential gear oil when adding it. If
rear differential gear oil touches
the exhaust pipe, it may cause a
bad smell, smoke, and/or a fire. If
rear differential gear oil gets on
the exhaust pipe, be sure to wipe
it off.

If the vehicle requires frequent re-
filling, there may be an oil leak. If
you suspect a problem, have the
vehicle checked at your Saab
dealer.
A1910BE-A-GSAAB.book Page 23 Tuesday, September 6, 2005 8:37 AM
ProCarManuals.com

11 - 2 4
Maintenance and service
SAE viscosity no. and applicable tem-
perature
Power steering fluid
Checking the fluid level1) Reservoir tankThe power steering fluid expands greatly
as its temperature rises; the fluid level dif-
fers according to fluid temperature. There-
fore, the reservoir tank has two different
checking ranges for hot and cold fluids.
Check the power steering fluid level
monthly.
1. Park the vehicle on a level surface, and
stop the engine.
1) Specified range2. Check the fluid level of the reservoir
tank.
When the fluid is hot after the vehicle has
been run: Check that the oil level is be-
tween “HOT MIN” and “HOT MAX” on the
surface of the reservoir tank.
When the fluid is cool before the vehicle is
run: Check that the oil level is between
“COLD MIN” and “COLD MAX” on the sur-
face of the reservoir tank.
3. If the fluid level is lower than the appli-
cable “MIN” line, add the recommended
fluid as necessary to bring the level be-
tween the “MIN” and “MAX” line.
If the fluid level is extreme low, it may indi-
cate possible leakage. Consult your Saab
dealer for an inspection.
-30 -20 -10 0 10 20 30 40
-20 0 6020
80W
75W/9080 100 40
85W90
B00032
1
B00375
1
1
B00376
A1910BE-A-GSAAB.book Page 24 Tuesday, September 6, 2005 8:37 AM
ProCarManuals.com

Maintenance and service
11 - 3 5
11
– CONTINUED –
NOTEWhen any of the wheels is removed
and replaced for tire rotation or to
change a flat tire, always check the
tightness of the wheel nuts after driv-
ing approximately 600 miles (1,000
km). If any nut is loose, tighten it to the
specified torque.
Aluminum wheelsAluminum wheels can be scratched and
damaged easily. Handle them carefully to
maintain their appearance, performance,
and safety.

When any of the wheels is removed and
replaced for tire rotation or to change a
flat, always check the tightness of the
wheel nuts after driving approximately 600
miles (1,000 km). If any nut is loose, tight-
en it to the specified torque.

Never apply oil to the threaded parts,
wheel nuts, or tapered surface of the
wheel.

Never let the wheel rub against sharp
protrusions or curbs.

Be sure to fit tire chains on uniformly
and completely around the tire, otherwise
the chains may scratch the wheel.

When wheel nuts, balance weights, or
the center cap is replaced, be sure to re-
place them with genuine Saab parts de-
signed for aluminum wheels.
Windshield washer fluidIf you spray washer fluid on the windshield
but the supply of washer fluid appears to
diminish, check the level of washer fluid in
the tank. Use only those wheels that are
specified for your vehicle. Wheels
not meeting specifications could in-
terfere with brake caliper operation
and may cause the tires to rub
against the wheel well housing dur-
ing turns. The resulting loss of vehi-
cle control could lead to an acci-
dent.
300523
A1910BE-A-GSAAB.book Page 35 Tuesday, September 6, 2005 8:37 AM
ProCarManuals.com

Consumer information and Reporting safety defects
13-7
13
– CONTINUED –

Maximum inflation pressure
The maximum cold inflation pressure
to which a tire may be inflated.
Recommended inflation pres-
sure
The cold inflation pressure recom-
mended by a vehicle manufacturer.
Intended outboard sidewall
1)The sidewall that contains a
whitewall, bears white lettering or
bears manufacturer, brand, and/or
model name molding that is higher
or deeper than the same molding
on the other sidewall of the tire, or
2)The outward facing sidewall of an
asymmetrical tire that has a particu-
lar side that must always face out-
ward when mounting on a vehicle.
Accessory weight
The combined weight (in excess of
those standard items which may be
replaced) of floor mats, leather seats
and cross bars to the extent that these
items are available as factory-in-
stalled equipment (whether installed
or not).
Curb weight
The weight of a motor vehicle with
standard equipment including themaximum capacity of fuel, oil, and
coolant and air conditioning.

Maximum loaded vehicle weight
The sum of curb weight, accessory
weight, vehicle capacity weight and
production options weight.
Normal occupant weight
150 lbs (68 kg) times the number of
occupants (3 occupants).
Occupant distribution
Distribution of occupants in a vehicle,
2 in front, 1 in rear seat.
Production options weight
The combined weight of those in-
stalled regular production options
weighing over 5.1 lbs (2.3 kg) in ex-
cess of those standards items which
they replace, not previously consid-
ered in curb weight or accessory
weight.
Vehicle capacity weight
The total weight of cargo, luggage
and occupants that can be added to
the vehicle.
Vehicle maximum load on a tire
Load on an individual tire that is deter-
mined by distributing to each axle its
share of the maximum loaded vehicle
weight and dividing by two.

Vehicle normal load on a tire
Load on an individual tire that is deter-
mined by distributing to each axle its
share of the curb weight, accessory
weight, and normal occupant weight
and dividing by two.
Tire care – maintenance and
safety practices
Check on a daily basis that the tires
are free from serious damage, nails,
and stones. At the same time, check
the tires for abnormal wear.
Inspect the tire tread regularly and
replace the tires before their tread
wear indicators become visible. When
a tire’s tread wear indicator becomes
visible, the tire is worn beyond the ac-
ceptable limit and must be replaced
immediately. With a tire in this condi-
tion, driving at even low speeds in wet
weather can cause the vehicle to hy-
droplane. Possible resulting loss of
vehicle control can lead to an acci-
dent.
To maximize the life of each tire and
ensure that the tires wear uniformly, it
is best to rotate the tires every 7,500
miles (12,500 km). Rotating the tires
A1910BE-A-GSAAB.book Page 7 Tuesday, September 6, 2005 8:37 AM
ProCarManuals.com

Index
14-3
14
CHECK ENGINE warning light/Malfunction indicator
lamp .............................................................................. 3-11
Checking
Brake pedal free play ................................................. 11-27
Brake pedal reserve distance .................................... 11-28
Clutch function ........................................................... 11-28
Clutch pedal free play ................................................ 11-28
Engine oil level ............................................................ 11-8
Fluid level .................................. 11-20, 11-24, 11-25, 11-26
Gear oil level ......................................... 11-19, 11-22, 11-23
Child restraint systems ..................................................... 1-22
Installation with A/ELR seatbelt ................................... 1-25
Lower and tether anchorages ...................................... 1-29
Child safety ............................................................................ 5
Locks ........................................................................... 2-17
Chime
Key ................................................................................ 3-5
Seatbelt ................................................................ 1-10, 3-9
Cigarette lighter socket ....................................................... 6-5
Cleaning
Aluminum wheels ........................................................ 10-3
Interior ......................................................................... 10-5
Ventilation grille ........................................................... 4-11
Climate control system
Automatic ....................................................................... 4-7
Manual ........................................................................... 4-3
Clock ................................................................................ 3-15
Clutch fluid ...................................................................... 11-26
Clutch pedal ................................................................... 11-28
Coat hook ........................................................................... 6-8
Coin tray ............................................................................. 6-4
Cooling system ............................................................... 11-12Corrosion protection .................................................. 8-8, 10-4
Cruise control .................................................................... 7-21
Indicator light ................................................................ 3-14
Set indicator light ......................................................... 3-15
Cup holder .......................................................................... 6-5
D
Daytime running light system ............................................ 3-17
Differential gear oil
Front ........................................................................... 11-22
Rear ........................................................................... 11-23
Dimensions ....................................................................... 12-2
Disarming the system ....................................................... 2-15
Disc brake pad wear warning indicators ........................... 7-16
Dome light ................................................................ 6-2, 11-52
Door locks ........................................................................... 2-4
Door open warning light .................................................... 3-13
Drive belts ....................................................................... 11-18
Driving
Car phone/cell phone ........................................................ 7
Drinking ............................................................................. 6
Drugs ................................................................................ 7
Foreign countries ........................................................... 8-4
Pets ................................................................................... 7
Snowy and icy roads ...................................................... 8-7
Tips ......................................................................... 7-9, 8-5
Tired or sleepy .................................................................. 7
E
EBD (Electronic brake force distribution) system ............. 7-18
Electrical system ............................................................... 12-3
A1910BE-A-GSAAB.book Page 3 Tuesday, September 6, 2005 8:37 AM
ProCarManuals.com

Index
14-5
14
J
Jack and jack handle ........................................................ 9-15
Jump starting ...................................................................... 9-8
K
Key
Interlock release ............................................................ 3-5
Number .......................................................................... 2-2
Reminder chime ............................................................ 3-5
Keys ................................................................................... 2-2
L
Leather seat materials ...................................................... 10-5
Light
Cargo area .......................................................... 6-2, 11-52
Dome .................................................................. 6-2, 11-52
Map ..................................................................... 6-2, 11-52
Light control switch ........................................................... 3-15
Limited slip differential (LSD) ............................................ 7-14
Loading your vehicle ........................................................ 8-10
LSD (Limited slip differential) ............................................ 7-14
M
Main fuse ........................................................................ 11-42
Maintenance
Precautions .................................................................. 11-3
Schedule ...................................................................... 11-3
Seatbelt ....................................................................... 1-17
Tools ............................................................................ 9-15
Malfunction indicator lamp (Check Engine light) .............. 3-11
Manual climate control system ........................................... 4-3Manual transmission (MT) .................................................. 7-8
Map light .................................................................. 6-2, 11-52
Maximum load limits ......................................................... 8-13
Meters and gauges ............................................................. 3-6
Mirrors ............................................................................... 3-24
N
New vehicle break-in driving – the first 1,000 miles
(1,600 km) ....................................................................... 8-2
O
Odometer/Trip meter ........................................................... 3-6
Off road driving ................................................................... 8-6
Oil filter .............................................................................. 11-8
Oil level
Engine .......................................................................... 11-8
Front differential gear oil (AT vehicles) ....................... 11-22
Manual transmission .................................................. 11-19
Rear differential .......................................................... 11-23
Oil pressure warning light ................................................. 3-11
Outside mirrors ................................................................. 3-25
Outside temperature indicator ............................................. 3-8
Overheating engine .......................................................... 9-10
P
Parking
Brake ............................................................................ 7-19
Brake stroke ............................................................... 11-30
Light switch .................................................................. 3-19
Tips .............................................................................. 7-19
Periodic inspections ............................................................ 8-4
A1910BE-A-GSAAB.book Page 5 Tuesday, September 6, 2005 8:37 AM
ProCarManuals.com

Index
14-7
14
Speedometer ...................................................................... 3-6
SRS airbag (Supplemental Restraint System airbag) .. 4, 1-33
SRS airbag system monitors ............................................ 1-53
SRS airbag system servicing ............................................ 1-54
SRS airbag system warning light ...................................... 3-10
SRS side airbag ............................................................... 1-48
Starting the engine .............................................................. 7-6
State emission testing (U.S. only) ....................................... 7-5
Stopping the engine ............................................................ 7-8
Storage compartments ....................................................... 6-4
Sun shades ...................................................................... 2-22
Sun visors ........................................................................... 6-3
Moonroof ................................................................. 2-21, 9-14
Supplemental Restraint System airbag (SRS) ............. 4, 1-33
Synthetic leather upholstery ............................................. 10-5
T
Tachometer ......................................................................... 3-7
Temperature gauge ............................................................ 3-8
Temporary spare tire ........................................................... 9-2
Tie-down hooks ................................................................ 9-11
Tilt steering wheel ............................................................. 3-26
Tire
Chains ........................................................................... 8-9
Inspection .................................................................. 11-30
Pressures and wear ................................................... 11-31
Replacement ............................................................. 11-33
Rotation ..................................................................... 11-33
Tires .................................................................................. 12-4
Types ......................................................................... 11-30
Tires and wheels ............................................................ 11-30
Top tether anchorages ...................................................... 1-31Towing ............................................................................... 9-10
All wheels on the ground .............................................. 9-12
Flat-bed truck ............................................................... 9-12
Trailer
Hitches ......................................................................... 8-16
Towing .......................................................................... 8-13
Towing tips ................................................................... 8-18
Turn signal
Indicator lights .............................................................. 3-14
Lever ............................................................................ 3-17
V
Valet mode ........................................................................ 2-15
Vanity mirror ........................................................................ 6-3
Vehicle
Capacity weight ............................................................ 8-11
Identification ............................................................... 12-10
Symbols ............................................................................ 3
Ventilation ........................................................................... 4-2
W
Warning and indicator lights ................................................ 3-9
Warning lights
ABS .............................................................................. 3-12
All-Wheel Drive ............................................................ 3-14
Anti-lock Brake System ................................................ 3-12
AT OIL TEMPerature .................................................... 3-12
Brake system ............................................................... 3-13
Charge ......................................................................... 3-11
CHECK ENGINE .......................................................... 3-11
Door open .................................................................... 3-13
A1910BE-A-GSAAB.book Page 7 Tuesday, September 6, 2005 8:37 AM
ProCarManuals.com