headlights SAAB 9-5 2002 User Guide

233 Car care and technical information
Washing the carThe bodywork must be washed frequently.
When the car is new, the body should be
washed by hand using plain cold water and
a clean, soft brush, or in a brushless car-
wash that uses mild detergent. Automatic
car washes with brushes should be avoided
when the car is new. Do not use automatic
car washes for the first five or six months,
before the paintwork has hardened prop-
erly. Thereafter, use a high quality car wash
soap added to lukewarm water.
Do not use a pressure washer at close
range on stone chip damage, scratches or
other damage to the paintwork. The paint
can otherwise start to flake.
Remove any bird droppings without delay,
as these can discolor the paintwork and
prove difficult to polish out.
Use a soft cloth moistened with methyl alco-
hol to remove splashes of tar or asphalt. Do
not use strong cleaners, as these can dry
out the paintwork. The underside of the car also needs wash-
ing regularly, and this should be done extra
thoroughly at the end of winter. Clean the
underside of the car by hand if the car is usu-
ally washed in an automatic car wash with-
out special facilities for underbody cleaning.
Never wash or leave the car to dry in the
sun, but wipe it dry with a chamois leather
immediately after washing to avoid smears
and streaks.
Clean the window glass inside and out using
a high quality window cleaner. This is partic-
ularly important when the car is new, as
upholstery and trim have a tendency to
sweat a little at first.
Keep the glass well cleaned, as this helps to
prevent misting.
Waxing and polishingDo not wax a new car during the first three
or four months. In fact, there is no need to
polish the car before the paintwork has
started to go dull through oxidation. Other
than in exceptional cases, do not use abra-
sive polishes containing a cutting agent on
a new car. Always wash the car thoroughly
before waxing or polishing.Engine compartmentClean the engine compartment using an
engine detergent and rinse with hot water.
Cover the headlights. Do not use high-pres-
sure washer. Avoid spraying the hood liner,
as this can become heavy and hang down
and touch the engine when the hood is
closed.
Do not use gasoline as a cleaning agent or
solvent when carrying out repairs or mainte-
nance. Saab recommends the use of envi-
ronmentally safe degreasing agents.
NOTEAvoid using any alcohol-based cleaners
on the front and rear light clusters, as
these can cause cracking of the lenses.
NOTE The door mirrors must be fully
retracted before the car enters an
automatic car wash.
 Remove fixed antennas, e.g. for
mobile phone, before putting car
through an automatic car wash.
 Try your brakes on leaving a car wash.
Wet brake discs reduce the braking
effect.
ProCarManuals.com

239 Car care and technical information
Headlight aimingThe vehicle has a visual optical headlight
aiming system equipped with vertical
aiming device. The aim has been preset at
the factory and should normally not need
further adjustments.
If your headlights are damaged in a crash,
the headlight aim may be affected. If you
believe your headlights need to be
re-aimed, we recommend that you take it to
your Saab dealer for service, however, it is
possible for you to re-aim your headlights as
described in the following procedure.To check the aim, the vehicle should be
properly prepared as follows:
 The vehicle shall be placed so that the
headlights are 25 ft (7.6 m) from a light
colored wall or other flat surface. The
aiming area should be darkened, this will
improve your ability to see the beam of the
low beam headlight being aimed.
 The vehicle must have all four wheels on
a perfectly level surface which is level all
the way to the wall or other flat surface.
 The vehicle should be placed so it is
perpendicular to the wall or other flat
surface.
 The vehicle should be unloaded and fuel
tank full, and one person or 160 lbs.
(75 kg) on the drivers seat.  The vehicle should be fully assembled
and all other work stopped while headlight
aiming is being done.
 The vehicle should not have any snow, ice
or mud attached to it.
 Tires should be inflated to the prescribed
pressure.
 Close all doors.
 Rock the vehicle to stabilize the suspen-
sion.
Headlight aiming is done with the vehicle
low beam lamps. The high beam lamps will
be correctly aimed if the low beam lamps
are aimed properly.
WARNING
Before checking/adjusting the headlight
aiming, switch off the engine to avoid
danger of fingers and hands being injured
by moving parts.
The radiator fan can start up even when
the engine is switched off.NOTETo make sure that your headlights are
aimed properly read all instructions
before beginning. Failure to follow these
instructions could cause damage to
headlight parts or a not correctly aimed
headlight.
ProCarManuals.com

241 Car care and technical information
5 Turn on the low beam headlights and
place a piece of cardboard or equivalent
(although not directly on the lens) in front
of the headlight not being aimed. This
should allow the beam cut-off of the
headlight being aimed to be seen on the
flat surface.6 Turn the vertical aiming screw until the
horizontal cut-off of the headlight is alig-
ned with the horizontal line on the wall.NOTEDo not cover a headlight to improve beam
cut-off when aiming. Covering a headlight
may cause excessive heat build-up which
may cause damage to the headlight.
IB1953
Horizontal line on wall or other flat surface
IB1954
Correctly adjusted low beam
ProCarManuals.com

262 IndexDoor handles
____________________ 38
Door mirrors ___________________ 123
Doors, locks & luggage compartment
_37
Drive belt
______________________ 253
Drive belt, alternator
_____________ 201
Drive belts, length
_______________ 253
Driver’s seat, programmable
_______ 120
Driving in hot weather
____________ 173
Driving with a load
_______________ 178
EElectric heating seat
_____________ 121
Electric heating, front seats
________ 121
Electric windows
________________ 125
Electrical system, technical data
____ 253
Electrically heated rear seat
_______ 121
Electronic Stability Program, ESP
___ 168
Electronic starting interlock
_________ 39
Emergency operation of sunroof
____ 127
Emission control systems
_________ 191
Engine bay, 3.0t V6
______________ 190
Engine bay, 4-cyl
_______________ 189
Engine bay, cleaning _____________ 233
Engine number
_________________ 257
Engine oil, grade ________________ 251
Engine, description _________ 192
, 193
Engine, technical data
____________ 250
Engine, temperature gauge
________ 57
Engine-oil level, checking
_________ 193
Expansion tank, coolant
__________ 196
FFault codes, Audio System
________103
Flat spot, tire
___________________230
Fluid level, automatic transmission
__195
Folding the rear seat, 9-5 Sedan
____132
Folding the rear seat, 9-5 Wagon ___135
Frequently asked questions on airbag
35
Front fog lights
__________________68
Frost warning
___________________60
Fuel
__________________________152
Fuel consumption
________________59
Fuel filler flap
___________________143
Fuel gauge
_____________________57
Fuel grade _____________________250
Fuse box under hood
____________220
Fuse panel
____________________216
Fuses
________________________216
GGearbox number
________________257
Gearbox oil, checking
____________195
Gearbox, technical data, __________254
Glove compartment
______________129
HHandbrake
_____________________185
Hazard warning lights
_____________68
Head restraint
___________________18
Headlight flasher _________________65
Headlights
______________________65Holidaying abroad
______________ 237
Hood
________________________ 188
Horn _________________________ 122
IIgnition switch
_________________ 146
Immobilizer
____________________ 39
Indicator and warning lights
________ 50
Indicator lights
__________________ 50
Instrument illumination
___________ 67
Instruments and controls __________ 49
Integral child seat
_______________ 27
Interior equipment ______________ 117
Interior lighting
__________________ 69
Interior rearview mirror
__________ 123
JJack
_________________________ 228
KKey
__________________________ 38
Key to chassis number
__________ 258
Key, remove
__________________ 146
LLATCH (child safety)
_____________ 20
Labels
_________________________ 8
Leather upholstery, care of
_______ 232
Light horn
_____________________ 65
ProCarManuals.com