flat tire SATURN OUTLOOK 2008 User Guide

7. Place the jack under the vehicle as identied in
Step 3. Raise the vehicle by turning the lug wrench
clockwise in the jack. Raise the vehicle far enough
off the ground so that there is enough room for the
spare tire to t under the wheel well.
8. Remove all the wheel nuts and the at tire.9. Remove the spare tire heat shield by pulling the
rubber latch. Store the spare tire heat shield. See
Storing a Flat or Spare Tire and Tools on page 5-96
for more information.
5-90
ProCarManuals.com

{CAUTION:
Rust or dirt on a wheel, or on the parts to
which it is fastened, can make wheel nuts
become loose after time. The wheel could
come off and cause an accident. When you
change a wheel, remove any rust or dirt from
places where the wheel attaches to the vehicle.
In an emergency, you can use a cloth or a
paper towel to do this; but be sure to use a
scraper or wire brush later, if needed, to get
all the rust or dirt off. SeeChanging a Flat
Tire on page 5-84.
{CAUTION:
Never use oil or grease on bolts or nuts.
Because the nuts might come loose. The
vehicle’s wheel could fall off, causing a crash.10. Remove any rust or dirt
from the wheel bolts,
mounting surfaces,
and spare wheel.
11. Place the spare tire on the wheel mounting surface.
12. Put the nuts on by hand by turning the clockwise
until the wheel is held against the mounting surface.
Make sure the rounded end is toward the wheel.
13. Lower the vehicle by attaching the lug wrench to
the jack and turning the wrench counterclockwise.
Lower the jack completely.
5-91
ProCarManuals.com

Secondary Latch System
Your vehicle has an underbody mounted tire hoist
assembly that has a secondary latch system. It is
designed to stop the compact spare tire from suddenly
falling off your vehicle if the cable holding the spare tire
is damaged. For the secondary latch to work, the tire
must be stowed with the valve stem pointing down. See
Storing a Flat or Spare Tire and Tools on page 5-96for
instructions on storing the spare tire correctly.
{CAUTION:
Before beginning this procedure read all the
instructions. Failure to read and follow the
instructions could damage the hoist assembly
and you and others could get hurt. Read and
follow the instructions listed next.To release the spare tire from the secondary latch:
{CAUTION:
Someone standing too close during the
procedure could be injured by the jack.
If the spare tire does not slide off the jack
completely, make sure no one is behind you
or on either side of you as you pull the jack
out from the under spare.
1. If the cable is not visible, start this procedure at
Step 3.
5-93
ProCarManuals.com

Storing a Flat or Spare Tire and
Tools
Storing the Spare Tire
{CAUTION:
The underbody-mounted spare tire needs to be
stored with the valve stem pointing down. If the
spare tire is stored with the valve stem pointing
upwards, its secondary latch will not work
properly and the spare tire could loosen and
suddenly fall from your vehicle. If this happened
when your vehicle was being driven, the tire
might contact a person or another vehicle,
causing injury and, of course, damage to itself
as well. Be sure the underbody-mounted spare
tire is stored with its valve stem pointing down.
{CAUTION:
Storing a jack, a tire, or other equipment in the
passenger compartment of the vehicle could
cause injury. In a sudden stop or collision,
loose equipment could strike someone.
Store all these in the proper place.
To store the spare tire:
1. Lay the compact spare tire near the rear of the
vehicle with the valve stem down.
2. Reinstall the plastic spare tire heat shield on the
compact spare tire.
3. Slide the cable retainer through the center of the
wheel and start to raise the compact spare tire.
Make sure the retainer is fully seated across
the underside of the wheel.
4. When the compact spare tire is almost in the stored
position, turn the tire so the valve is toward the rear
of the vehicle.
This position helps when checking the air pressure
in the compact spare tire.
5-96
ProCarManuals.com

5. Raise the tire fully against the underside of the
vehicle. Continue turning the lug wrench until you
feel more than two clicks. This indicates that the
compact spare tire is secure and the cable is tight.
The spare tire hoist cannot be overtightened.
6. Make sure the tire is stored securely. Push, pull (A),
and then try to turn (B) the tire. If the tire moves,
use the lug wrench to tighten the cable.Storing the Flat Tire
Notice:Storing the full-size at tire in the
underbody hoist system can expose it to heat
from the exhaust system. This can damage the
tire and underbody hoist system. Do not store the
full-size at tire in the underbody hoist system.
1. Remove the cable package from the jack
storage area.
2. Remove the small center cap by tapping the back
of the cap with the extension of the shaft, if the
vehicle has aluminum wheels.
3. Put the at tire in the rear storage area with the
valve stem pointing toward the rear of the vehicle.
5-97
ProCarManuals.com

At Least Once a Month
Tire Ination Check
Inspect the vehicle’s tires and make sure they are
inated to the correct pressures. Do not forget to
check the spare tire. SeeInflation - Tire Pressure on
page 5-56. Check to make sure the spare tire is stored
securely. SeeChanging a Flat Tire on page 5-84.
Tire Wear Inspection
Tire rotation may be required for high mileage highway
drivers prior to the Engine Oil Life System service
notication. Check the tires for wear and, if necessary,
rotate the tires. SeeTire Inspection and Rotation on
page 5-63.
At Least Once a Year
Starter Switch Check
{CAUTION:
When you are doing this inspection, the
vehicle could move suddenly. If the vehicle
moves, you or others could be injured.
1. Before you start, be sure you have enough room
around the vehicle.
2. Firmly apply both the parking brake and the regular
brake. SeeParking Brake on page 2-34.
Do not use the accelerator pedal, and be ready to
turn off the engine immediately if it starts.
3. Try to start the engine in each gear. The vehicle
should start only in PARK (P) or NEUTRAL (N).
If the vehicle starts in any other position, contact
your dealer/retailer for service.
6-9
ProCarManuals.com

Who is Covered?
Roadside Assistance coverage is for the vehicle
operator, regardless of ownership. In Canada, a person
driving this vehicle without the consent of the owner
is not eligible for coverage.
Services Provided
The following services are provided in the U.S. and
Canada up to 5 years/100,000 miles (160 000 km),
whichever comes rst, and, in Canada only, up
to a maximum of $100.
Fuel Delivery:Delivery of enough fuel for the
vehicle to get to the nearest service station
(approximately $5 Canada). In Canada, service to
provide diesel may be restricted. For safety reasons,
propane and other alternative fuels are not
provided through this service.
Lock-Out Service:Lock-out service is covered at
no charge if you are unable to gain entry into your
vehicle. A remote unlock may be available if
you have an active OnStar
®subscription. To ensure
security, the driver must present personal
identication before lock-out service is provided. In
Canada, the vehicle registration is also required.
Emergency Tow From a Public Roadway or
Highway:Tow to the nearest Saturn retailer for
warranty service or in the event of a vehicle-disabling
crash. Winch-out assistance is provided when the
vehicle is mired in sand, mud, or snow.
Flat Tire Change:Installation of a spare tire in good
condition, when equipped and properly inated, is
covered at no charge. The customer is responsible
for the repair or replacement of the tire if not covered
by a warrantable failure.
Jump Start:A battery jump start is covered at no
charge if the vehicle does not start.
Trip Routing Service (Canada Only):Upon
request, Roadside Assistance will send you detailed,
computer personalized maps, highlighting your
choice of either the most direct route or the most
scenic route to your destination, anywhere in North
America, along with helpful travel information
pertaining to your trip.
Please allow three weeks before your planned
departure date. Trip routing requests are limited to
six per calendar year.
7-8
ProCarManuals.com

E
EDR .............................................................7-18
Electrical System
Add-On Equipment.....................................5-110
Fuses and Circuit Breakers.........................5-111
Instrument Panel Fuse Block.......................5-111
Power Windows and Other Power Options.......5-111
Underhood Fuse Block...............................5-115
Windshield Wiper Fuses.............................5-110
Electronic Immobilizer
PASS-Key
®III+...........................................2-23
Electronic Immobilizer Operation
PASS-Key
®III+...........................................2-24
Engine
Air Cleaner/Filter.........................................5-18
Check and Service Engine Soon Light............3-48
Coolant......................................................5-20
Coolant Heater............................................2-29
Coolant Temperature Gage...........................3-47
Coolant Temperature Warning Light................3-47
Drive Belt Routing.......................................6-14
Engine Compartment Overview......................5-12
Exhaust.....................................................2-37
Oil .............................................................5-13
Oil Life System...........................................5-16Engine (cont.)
Overheated Protection Operating Mode...........5-25
Overheating................................................5-23
Starting......................................................2-27
Entry Lighting.................................................3-18
Event Data Recorders.....................................7-18
Extender, Safety Belt.......................................1-38
Exterior Lamps...............................................3-15
F
Filter
Engine Air Cleaner......................................5-18
Finish Damage.............................................5-107
Flashers, Hazard Warning.................................. 3-6
Flash-to-Pass.................................................3-10
Flat Tire........................................................5-72
Flat Tire, Changing.........................................5-84
Flat Tire, Storing.............................................5-96
Floor Mats.....................................................2-57
Fluid
Automatic Transmission................................5-20
Power Steering...........................................5-32
Windshield Washer......................................5-33
Fog Lamp
Fog ...........................................................3-17
5
ProCarManuals.com

Recommended Fluids and Lubricants.................6-11
Recreational Vehicle Towing.............................4-27
Remote Keyless Entry (RKE) System.................. 2-4
Remote Keyless Entry (RKE) System,
Operation..................................................... 2-5
Remote Vehicle Start........................................ 2-7
Removing the Flat Tire and Installing the
Spare Tire..................................................5-88
Removing the Spare Tire and Tools...................5-85
Replacement Bulbs.........................................5-47
Replacement Parts, Maintenance......................6-13
Reporting Safety Defects
Canadian Government..................................7-15
Saturn.......................................................7-16
United States Government............................7-15
Restraint System Check
Checking the Restraint Systems....................1-80
Replacing Restraint System Parts
After a Crash..........................................1-81
Retained Accessory Power (RAP)......................2-27
Roadside
Assistance Program....................................... 7-7
Rocking Your Vehicle to Get it Out....................4-22
Routing, Engine Drive Belt...............................6-14
Running Out of Fuel........................................2-38S
Safety Belt
Reminder Light............................................3-39
Safety Belts
Care of ....................................................5-103
How to Wear Safety Belts Properly................1-23
Lap-Shoulder Belt........................................1-32
Safety Belt Extender....................................1-38
Safety Belt Use During Pregnancy.................1-38
Safety Belts Are for Everyone.......................1-18
Safety Warnings and Symbols.............................. iii
Scheduled Maintenance..................................... 6-4
Seats
Driver Seat Height Adjuster............................. 1-3
Head Restraints..........................................1-11
Heated Seats............................................... 1-5
Manual Lumbar............................................. 1-4
Memory, Mirrors............................................ 1-6
Power Lumbar .............................................. 1-5
Power Seats................................................. 1-3
Rear Seat Operation....................................1-12
Reclining Seatbacks...................................... 1-8
Third Row Seat...........................................1-14
Second Row Center Console............................2-56
Secondary Latch System.................................5-93
11
ProCarManuals.com

Theft-Deterrent, Radio....................................3-126
Theft-Deterrent Systems...................................2-21
Content Theft-Deterrent................................2-22
PASS-Key
®III+ Electronic Immobilizer............2-23
PASS-Key®III+ Electronic Immobilizer
Operation................................................2-24
Tilt Wheel........................................................ 3-7
Time, Setting..................................................3-84
Tire
Pressure Light.............................................3-48
Tires.............................................................5-49
Aluminum or Chrome-Plated Wheels,
Cleaning...............................................5-106
Buying New Tires........................................5-65
Chains.......................................................5-71
Changing a Flat Tire....................................5-84
Cleaning...................................................5-106
Compact Spare Tire...................................5-100
Different Size..............................................5-67
If a Tire Goes Flat.......................................5-72
Ination - Tire Pressure................................5-56
Inspection and Rotation................................5-63
Installing the Spare Tire................................5-88
Pressure Monitor Operation...........................5-59
Pressure Monitor System..............................5-58
Removing the Flat Tire.................................5-88
Removing the Spare Tire and Tools...............5-85
Secondary Latch System..............................5-93
Storing a Flat or Spare Tire and Tools............5-96Tires (cont.)
Tire Sealant and Compressor Kit...................5-73
Tire Sidewall Labeling..................................5-50
Tire Terminology and Denitions....................5-53
Uniform Tire Quality Grading.........................5-68
Wheel Alignment and Tire Balance.................5-70
Wheel Replacement.....................................5-70
When It Is Time for New Tires......................5-64
Tow/Haul Mode ...............................................2-33
Tow/Haul Mode Light.......................................3-52
Towing
Recreational Vehicle.....................................4-27
Towing a Trailer..........................................
4-31
Your Vehicle...............................................4-27
Traction
Stabilitrak
®System........................................ 4-6
Transmission
Fluid, Automatic...........................................5-20
Transmission Operation, Automatic....................2-30
Turn and Lane-Change Signals.......................... 3-9
Turn Signal/Multifunction Lever........................... 3-8
U
Ultrasonic Rear Parking Assist (URPA)...............2-44
Uniform Tire Quality Grading............................5-68
Universal Home Remote System.......................2-50
Operation...................................................2-51
Using this Manual............................................... iii
13
ProCarManuals.com