spare tire SATURN RELAY 2007 Owner's Manual

Storing the Flat or Spare Tire
{CAUTION:
The underbody-mounted spare tire needs
to be stored with the valve stem pointing
down. If the spare tire is stored with
the valve stem pointing upwards, its
secondary latch will not work properly
and the spare tire could loosen and
suddenly fall from your vehicle. If this
happened when your vehicle was being
driven, the tire might contact a person or
another vehicle, causing injury and, of
course, damage to itself as well. Be sure
the underbody-mounted spare tire is
stored with its valve stem pointing down.To store the spare tire, do the following:
1. Lay the tire near the rear of the vehicle with
the valve stem down.
2. Remove the small center cap by tapping the
back of the cap with the extension of the
shaft, if the vehicle has aluminum wheels.
3. Slide the cable retainer through the center of
the wheel and start to raise the tire.
Make sure the retainer is fully seated across
the underside of the wheel.
4. When the tire is almost in the stored position,
turn the tire so the valve is towards the rear
of the vehicle.
This will help when you check and maintain
tire pressure in the spare.
5. Raise the tire fully against the underside of
the vehicle. Continue turning the folding
wrench until you feel more than two clicks.
This indicates that the compact spare
tire is secure and the cable is tight. The
spare tire hoist cannot be overtightened.
498
ProCarManuals.com

To replace the cover, line up the tabs on the right
of the cover with the slots in the cover opening.
Push the cover in place and push down the tab
so that it rests in the groove. This secures
the cover in place.
Store the center cap or the plastic bolt-on wheel
covers until a full size tire is put back on the
vehicle. When you replace the compact spare with
a full-size tire, reinstall the bolt-on wheel covers
or the center cap. Hand-tighten them over
the wheel nuts, using the folding wrench.
Compact Spare Tire
Although the compact spare tire was fully inated
when the vehicle was new, it can lose air after
a time. Check the ination pressure regularly.
It should be 60 psi (420 kPa).
After installing the compact spare on the vehicle,
stop as soon as possible and make sure the spare
tire is correctly inated. The compact spare is made
to perform well at speeds up to 65 mph (105 km/h)
for distances up to 3,000 miles (5 000 km), so
you can nish your trip and have the full-size tire
repaired or replaced at your convenience.Of course, it is best to replace the spare with a
full-size tire as soon as possible. The spare tire will
last longer and be in good shape in case it is
needed again.
Notice:When the compact spare is installed,
do not take your vehicle through an automatic
car wash with guide rails. The compact
spare can get caught on the rails. That can
damage the tire and wheel, and maybe
other parts of your vehicle.
Do not use the compact spare on other vehicles.
And do not mix the compact spare tire or
wheel with other wheels or tires. They will not t.
Keep the spare tire and its wheel together.
Notice:Tire chains will not t your compact
spare. Using them can damage your vehicle
and can damage the chains too. Do not use tire
chains on your compact spare.
500
ProCarManuals.com

At Each Fuel Fill
It is important to perform these underhood checks
at each fuel ll.
Engine Oil Level Check
Check the engine oil level and add the proper oil
if necessary. SeeEngine Oil on page 423for
further details.
Notice:It is important to check your oil
regularly and keep it at the proper level. Failure
to keep your engine oil at the proper level
can cause damage to your engine not covered
by your warranty.
Engine Coolant Level Check
Check the engine coolant level and add
DEX-COOL®coolant mixture if necessary. See
Engine Coolant on page 432for further details.
Windshield Washer Fluid Level Check
Check the windshield washer uid level in
the windshield washer uid reservoir and add
the proper uid if necessary.
At Least Once a Month
Tire Ination Check
Visually inspect your vehicle’s tires and make
sure they are inated to the correct pressures.
Do not forget to check the spare tire. See
Ination - Tire Pressure on page 469. Check to
make sure the spare tire is stored securely.
SeeChanging a Flat Tire on page 484.
Tire Wear Inspection
Tire rotation may be required for high mileage
highway drivers prior to the Engine Oil Life System
service notication. Check the tires for wear
and, if necessary, rotate the tires. SeeTire
Inspection and Rotation on page 472.
527
ProCarManuals.com

Who is Covered?
Roadside Assistance coverage is for the vehicle
operator, regardless of ownership. A person driving
this vehicle without the consent of the owner is
not eligible for coverage.
The following services are provided in the U.S.
during the Bumper-to-Bumper warranty period and
in Canada, during the Base Warranty coverage
period of the New Vehicle Limited Warranty, up to
a maximum coverage of $100.
Fuel Delivery:Delivery of enough fuel for the
customer to get to the nearest service station
(approximately $5 in the U.S. and 10 litres
in Canada). Service to provide diesel may
be restricted. For safety reasons, propane
and other alternative fuels will not be provided
through this service.
Lock-out Service:To ensure security, the
driver must present the vehicle registration and
personal ID before lock-out service is provided.
Lock-out service will be covered at no charge if
you are unable to gain entry into your vehicle.If you vehicle will not start, Roadside
Assistance will arrange to have your vehicle
towed to the nearest authorized retailer. In the
U.S., replacement keys made at the customer’s
expense will be delivered within 10 miles.
Emergency Tow From a Public Roadway
or Highway:Tow to the nearest Saturn retailer
for warranty service or in the event of a
vehicle-disabling accident. Winch-out
assistance provided when the vehicle is mired
in sand, mud, or snow.
Flat Tire Change:If your vehicle has a spare
time, installation of that tire, in good condition,
will be covered at no charge. The customer is
responsible for the repair or replacement of the
tire if not covered by a warrantable failure.
Jump Start:No-start occurrences which
require a battery jump start will be covered
at no charge.
544
ProCarManuals.com

Climate Control System............................... 205
Air Filter, Passenger Compartment........... 217
Dual......................................................... 209
Outlet Adjustment..................................... 212
Rear...............................................212, 215
Collision Damage Repair............................. 548
Comfort Guides, Rear Safety Belt................. 52
Compact Spare Tire.................................... 500
Compass..................................................... 240
Content Theft-Deterrent............................... 133
Control of a Vehicle..................................... 362
Convenience Net......................................... 173
Coolant
Engine Temperature Gage........................ 228
Heater, Engine......................................... 141
Cooling System........................................... 438
Cruise Control............................................. 188
Cruise Control Light.................................... 233
Cupholder(s)................................................ 167
Customer Assistance Information
Customer Assistance for Text
Telephone (TTY) Users......................... 542
Customer Assistance Offices.................... 542
Customer Satisfaction Procedure.............. 538
GM Mobility Reimbursement Program...... 543
Reporting Safety Defects to Saturn.......... 552Customer Assistance Information (cont.)
Reporting Safety Defects to the
Canadian Government.......................... 552
Reporting Safety Defects to the
United States Government.................... 552
Roadside Assistance Program.................. 543
Service Publications Ordering
Information........................................... 553
D
Daytime Running Lamps/Automatic
Headlamp System.................................... 193
Defensive Driving........................................ 358
Delayed Lighting.......................................... 196
Delayed Locking.......................................... 116
DIC Compass.............................................. 240
Disc, MP3................................................... 287
Doing Your Own Service Work.................... 413
Dome Lamp................................................ 196
Door
Automatic Door Lock................................ 117
Delayed Locking...................................... 116
Dual Sliding Doors................................... 118
Locks....................................................... 114
558
ProCarManuals.com

Rear Reading Lamps.................................. 197
Rear Safety Belt Comfort Guides.................. 52
Rear Seat Audio (RSA)......................325, 328
Rear Seat Entertainment System........294, 309
Rear Seat Operation..................................... 14
Rear Seat Passengers, Safety Belts.............. 49
Rear Windshield Washer/Wiper.................... 187
Rearview Mirrors......................................... 153
Reclining Seatbacks...................................... 11
Recommended Fluids and Lubricants.......... 530
Recreational Vehicle Towing........................ 396
Remote Keyless Entry System.................... 106
Remote Keyless Entry System, Operation ... 107
Removing the Flat Tire and Installing the
Spare Tire................................................ 488
Removing the Spare Tire and Tools............ 485
Replacement Bulbs..................................... 460
Reporting Safety Defects
Canadian Government............................. 552
Saturn...................................................... 552
United States Government....................... 552
Restraint System Check
Checking the Restraint Systems............... 101
Replacing Restraint System Parts
After a Crash........................................ 102
Retained Accessory Power (RAP)................ 139Right Front Passenger Position,
Safety Belts............................................... 48
Roadside
Assistance Program................................. 543
Rocking Your Vehicle to Get it Out.............. 391
Routing, Engine Drive Belt.......................... 533
Running the Engine While Parked............... 152
S
Safety Belt
Passenger Reminder Light....................... 222
Pretensioners............................................. 55
Reminder Light........................................ 222
Safety Belts
Care of.................................................... 504
Driver Position........................................... 38
How to Wear Safety Belts Properly............ 38
Questions and Answers About
Safety Belts............................................ 37
Rear Safety Belt Comfort Guides............... 52
Rear Seat Passengers............................... 49
Right Front Passenger Position.................. 48
Safety Belt Extender.................................. 55
Safety Belt Use During Pregnancy............. 48
566
ProCarManuals.com

Safety Belts (cont.)
Safety Belts Are for Everyone.................... 32
Shoulder Belt Height Adjuster.................... 47
Safety Warnings and Symbols......................... 4
Scheduled Maintenance............................... 522
Seats
Bucket Seats, Rear.................................... 14
Captain Chairs........................................... 22
Head Restraints......................................... 13
Heated Seats............................................. 10
Manual........................................................ 9
Power Seats.............................................. 10
Rear Seat Operation.................................. 14
Reclining Seatbacks................................... 11
Third Row Seat......................................... 27
Second Row Center Console...................... 171
Secondary Latch System............................. 495
Securing a Child Restraint
Rear Seat Position..................................... 77
Right Front Seat Position........................... 79
Security Light.............................................. 232
Service........................................................ 412
Accessories and Modications.................. 412
Adding Equipment to the Outside of
Your Vehicle......................................... 414
California Proposition 65 Warning............. 413Service (cont.)
Doing Your Own Work............................. 413
Engine Soon Light................................... 229
Publications Ordering Information............. 553
Servicing Your Airbag-Equipped Vehicle......... 99
Setting the Time.......................................... 272
Sheet Metal Damage................................... 508
Shifting Into Park (P)................................... 148
Shifting Out of Park (P)............................... 149
Shoulder Belt Height Adjuster........................ 47
Signals, Turn and Lane-Change.................. 184
Sliding Door, Power..................................... 121
Sliding Doors, Dual..................................... 118
Spare Tire
Accessory Inator..................................... 480
Compact.................................................. 500
Installing.................................................. 488
Removing................................................ 485
Storing..................................................... 497
Specications, Capacities............................ 518
Speedometer............................................... 221
StabiliTrak
®System..................................... 367
Starting Your Engine................................... 140
Steering...................................................... 369
Steering Wheel Controls, Audio................... 353
Steering Wheel, Tilt Wheel.......................... 182
567
ProCarManuals.com

Storage Areas............................................. 167
Convenience Net..................................... 173
Cupholder(s)............................................ 167
Floor Console Storage Area..................... 170
Folding Tray............................................. 170
Glove Box................................................ 167
Hideaway Rear Storage Bins................... 174
Luggage Carrier....................................... 172
Overhead Console..........................168, 170
Second Row Center Console................... 171
Stuck in Sand, Mud, Ice, or Snow............... 390
Sun Visors.................................................. 132
Switchbanks
Overhead Console................................... 200
T
Tachometer................................................. 221
Taillamps
Turn Signal, Stoplamps and
Back-up Lamps..................................... 458
TCS Warning Light...................................... 228
Theft-Deterrent, Radio................................. 352
Theft-Deterrent Systems.............................. 133
Content Theft-Deterrent............................ 133
PASS-Key
®III .......................................... 135
PASS-Key®III Operation.......................... 136Third Row Seat............................................. 27
Tilt Wheel.................................................... 182
Tires........................................................... 462
Aluminum Wheels, Cleaning..................... 507
Buying New Tires..................................... 474
Chains..................................................... 480
Changing a Flat Tire................................ 484
Cleaning.................................................. 507
Compact Spare Tire................................. 500
Different Size........................................... 476
High-Speed Operation.............................. 471
If a Tire Goes Flat................................... 483
Ination - Tire Pressure............................ 469
Inator, Accessory.................................... 480
Inspection and Rotation............................ 472
Installing the Spare Tire........................... 488
Removing the Flat Tire............................. 488
Removing the Spare Tire and Tools......... 485
Secondary Latch System ......................... 495
Storing a Flat or Spare Tire and Tools..... 497
Tire Sidewall Labeling.............................. 463
Tire Terminology and Denitions............... 466
Uniform Tire Quality Grading.................... 477
Wheel Alignment and Tire Balance........... 478
Wheel Replacement................................. 478
When It Is Time for New Tires................. 473
568
ProCarManuals.com