instrument panel SATURN SKY 2007 Service Manual
[x] Cancel search | Manufacturer: SATURN, Model Year: 2007, Model line: SKY, Model: SATURN SKY 2007Pages: 384, PDF Size: 2.47 MB
Page 241 of 384
Hood Release
To open the hood, do the following:
1. Locate the interior
hood release lever.
It is located below
the instrument panel
on the driver’s side
of the vehicle.2. Pull down on the
rear edge of the
lever to release
the hood latch.
3. Go to the side of the vehicle and pull up on
the rear edge of the hood, near the windshield
to open the hood.
Notice:Closing the hood with the doors open
may damage the hood and/or doors. Always
close the doors before closing the hood.
Before closing the hood, be sure all the ller caps
are on properly. Then, pull the hood down and
close it rmly.
241
ProCarManuals.com
Page 258 of 384
Adding Coolant
If you need more coolant, add the proper
DEX-COOL®coolant mixture at the coolant surge
tank, but only when the engine is cool. If the
coolant surge tank is empty, a special ll
procedure is necessary. SeeEngine Overheating
on page 258for instructions on “How to Add
Coolant to the Coolant Surge Tank.”
{CAUTION:
You can be burned if you spill coolant
on hot engine parts. Coolant contains
ethylene glycol, and it will burn if the
engine parts are hot enough. Do not spill
coolant on a hot engine.
When replacing the pressure cap, make sure it
is hand-tight and fully seated.
Coolant Surge Tank Pressure Cap
Notice:If the pressure cap is not tightly
installed, coolant loss and possible engine
damage may occur. Be sure the cap is properly
and tightly secured.
The coolant surge tank pressure cap must be fully
installed on the coolant surge tank. SeeEngine
Compartment Overview on page 242for more
information on location.
Engine Overheating
There is an engine coolant temperature warning
light on your vehicle’s instrument panel. See
Engine Coolant Temperature Warning Light
on page 137for more information.
258
ProCarManuals.com
Page 317 of 384
4. Continue to gently rub the soiled area until the
cleaning cloth remains clean.
5. If the soil is not completely removed, use a
mild soap solution and repeat the cleaning
process that was used with plain water.
If any of the soil remains, a commercial fabric
cleaner or spot lifter may be necessary. When a
commercial upholstery cleaner or spot lifter is to be
used, test a small hidden area for colorfastness
rst. If the locally cleaned area gives any
impression that a ring formation may result, clean
the entire surface.
After the cleaning process has been completed,
a paper towel can be used to blot excess moisture
from the fabric or carpet.
Leather
A soft cloth dampened with water may be used
to remove dust. If a more thorough cleaning
is necessary, a soft cloth dampened with a mild
soap solution can be used. Allow the leather to dry
naturally. Do not use heat to dry. Never use
steam to clean leather. Never use spot lifters or
spot removers on leather. Many commercial
leather cleaners and coatings that are sold topreserve and protect leather may permanently
change the appearance and feel of your leather
and are not recommended. Do not use silicone or
wax-based products, or those containing organic
solvents to clean your vehicle’s interior because
they can alter the appearance by increasing
the gloss in a non-uniform manner. Never use
shoe polish on your leather.
Instrument Panel, Vinyl, and
Other Plastic Surfaces
A soft cloth dampened with water may be used to
remove dust. If a more thorough cleaning is
necessary, a clean soft cloth dampened with a
mild soap solution can be used to gently remove
dust and dirt. Never use spot lifters or removers
on plastic surfaces. Many commercial cleaners and
coatings that are sold to preserve and protect
soft plastic surfaces may permanently change the
appearance and feel of your interior and are
not recommended. Do not use silicone or
wax-based products, or those containing organic
solvents to clean your vehicle’s interior because
they can alter the appearance by increasing
the gloss in a non-uniform manner.
317
ProCarManuals.com
Page 318 of 384
Some commercial products may increase gloss on
your instrument panel. The increase in gloss
may cause annoying re ections in the windshield
and even make it difficult to see through the
windshield under certain conditions.
Care of Safety Belts
Keep belts clean and dry.
{CAUTION:
Do not bleach or dye safety belts. If you
do, it may severely weaken them. In a
crash, they might not be able to provide
adequate protection. Clean safety belts
only with mild soap and lukewarm water.
Weatherstrips
Silicone grease on weatherstrips will make them
last longer, seal better, and not stick or squeak.
Apply silicone grease with a clean cloth. During
very cold, damp weather frequent application may
be required. SeeRecommended Fluids and
Lubricants on page 345.
Washing Your Vehicle
The paint nish on your vehicle provides beauty,
depth of color, gloss retention, and durability.
The best way to preserve your vehicle’s nish is
to keep it clean by washing it often with lukewarm
or cold water.
Do not wash your vehicle in the direct rays of the
sun. Use a car washing soap. Do not use strong
soaps or chemical detergents. Be sure to rinse the
vehicle well, removing all soap residue completely.
You can get approved cleaning products from your
retailer. SeeVehicle Care/Appearance Materials
on page 323. Do not use cleaning agents that are
petroleum based, or that contain acid or abrasives.
All cleaning agents should be ushed promptly and
not allowed to dry on the surface, or they could
stain. Dry the nish with a soft, clean chamois or
an all-cotton towel to avoid surface scratches and
water spotting.
High pressure car washes may cause water to
enter your vehicle.
318
ProCarManuals.com
Page 324 of 384
Vehicle Identi cation
Vehicle Identi cation Number (VIN)
This is the legal identi er for your vehicle. It
appears on a plate in the front corner of the
instrument panel, on the driver’s side. You can see
it if you look through the windshield from outside
your vehicle. The VIN also appears on the Vehicle
Certi cation and Service Parts labels and the
certi cates of title and registration.
Engine Identi cation
The eighth character in the VIN is the engine
code. This code will help you identify your vehicle’s
engine, speci cations, and replacement parts.
Service Parts Identi cation Label
You will nd this label on the inside of the glove
box. It is very helpful if you ever need to order
parts. On this label, you will nd the following:
VIN
Model designation
Paint information
Production options and special equipment
Do not remove this label from the vehicle.
324
ProCarManuals.com
Page 327 of 384
Fuses Usage
6 Ampli er
7 Cluster
8 Ignition Switch, PassKey III+
9 Stoplamp
10Climate Control System,
PassKey III+
11 Empty
12 Spare
13 Airbag
14 Spare
15 Wiper
16Climate Control System,
Automatic Occupant Sensing
Module, Clutch Switch, Crank
Relay, Instrument Panel Cluster
17 Empty
18 EmptyFuses Usage
19Electric Power Steering,
Steering Wheel Controls
20 Spare
21 Spare
22 Empty
23 Radio
24 Sensing and Diagnostic Module
25Engine Control Module,
Transmission Control Module
26 Door Locks
27 Interior Lamps
28 Steering Wheel Control Backlighting
29 Power Windows
30 Climate Control System
31 Empty
32 Retained Accessory Power
327
ProCarManuals.com
Page 330 of 384
Fuses Usage
43Engine Control Module,
Transmission
44 Anti-lock Brake System
45Injectors, Ignition Coils (LE5);
Ignition Coils (LNF)
46Back-up Lamps
(Manual Transmission);
Empty (Automatic Transmission)
47 Empty
48 Daytime Running Lamps Relay
49 Daytime Running Lamps
50Cooling Fan 1 Relay (LE5);
Empty (LNF)
51 Run/Crank Relay
52 Windshield Wiper Low/High Relay
53 Fog Lamps
54 Fog Lamps Relay
55 Horn Relay
56S Band, OnStar
®, Remote
Keyless Entry System
Fuses Usage
57 Anti-lock Brake System
58 Wiper Diode
59 Windshield Wiper
60 Horn
61 Anti-lock Brake System
62 Instrument Panel Ignition
63 Driver’s Side High Beam
64 Canister Vent
65 Driver’s Side Low-Beam Headlamp
66Passenger’s Side Low-Beam
Headlamp
67Passenger’s Side High-Beam
Headlamp
68 Parking Lamps Relay
69 Parking Lamps
70 Windshield Wiper On/Off Relay
71 Low-Beam Headlamp Relay
72 High-Beam Headlamp Relay
330
ProCarManuals.com
Page 371 of 384
A
Accessories and Modi cations..................... 233
Accessory Power Outlet(s).......................... 121
Adding Equipment to Your Airbag-Equipped
Vehicle....................................................... 55
Additives, Fuel............................................ 236
Add-On Electrical Equipment....................... 325
Air Cleaner/Filter, Engine............................. 252
Air Conditioning........................................... 122
Airbag
Passenger Status Indicator....................... 131
Readiness Light....................................... 130
Airbag Sensing and Diagnostic
Module (SDM).......................................... 363
Airbag System............................................... 43
Adding Equipment to Your
Airbag-Equipped Vehicle......................... 55
How Does an Airbag Restrain?.................. 48
Passenger Sensing System....................... 50
Servicing Your Airbag-Equipped Vehicle..... 54
What Makes an Airbag In ate?.................. 48
What Will You See After an Airbag
In ates?................................................. 48
When Should an Airbag In ate?................. 47
Where Are the Airbags?............................. 45Antenna, Fixed Mast................................... 190
Antenna, XM™ Satellite Radio Antenna
System.................................................... 190
Anti-Lock Brake System (ABS).................... 197
Anti-Lock Brake, System Warning Light....... 135
Appearance Care
Aluminum or Chrome-Plated Wheels........ 320
Care of Safety Belts................................ 318
Chemical Paint Spotting........................... 322
Cleaning Exterior Lamps/Lenses.............. 319
Cleaning the Inside of Your Vehicle.......... 315
Convertible Top........................................ 320
Fabric/Carpet........................................... 316
Finish Care.............................................. 319
Finish Damage......................................... 322
Instrument Panel, Vinyl, and Other
Plastic Surfaces.................................... 317
Leather.................................................... 317
Sheet Metal Damage............................... 321
Tires........................................................ 321
Underbody Maintenance........................... 322
Vehicle Care/Appearance Materials.......... 323
Washing Your Vehicle .............................. 318
Weatherstrips........................................... 318
Windshield and Wiper Blades................... 319
Ashtray(s).................................................... 122
371
ProCarManuals.com
Page 373 of 384
Care of
Safety Belts............................................. 318
Your CD Player........................................ 190
Your CDs ................................................. 190
CD, MP3 ..................................................... 179
Center Console Storage Area...................... 100
Chains, Tire................................................. 303
Charging System Light................................ 133
Check
Engine Light............................................ 138
Checking Things Under the Hood................ 240
Chemical Paint Spotting.............................. 322
Child Restraints
Child Restraint Systems............................. 34
Infants and Young Children........................ 30
Lower Anchors and Tethers for Children..... 38
Older Children........................................... 28
Securing a Child Restraint in the
Passenger Seat Position......................... 38
Cigarette Lighter.......................................... 122
Cleaning
Aluminum or Chrome-Plated Wheels........ 320
Convertible Top........................................ 320Cleaning (cont.)
Exterior Lamps/Lenses............................. 319
Fabric/Carpet........................................... 316
Finish Care.............................................. 319
Inside of Your Vehicle .............................. 315
Instrument Panel, Vinyl, and Other
Plastic Surfaces.................................... 317
Leather.................................................... 317
Tires........................................................ 321
Underbody Maintenance........................... 322
Washing Your Vehicle .............................. 318
Weatherstrips........................................... 318
Windshield and Wiper Blades................... 319
Climate Control System............................... 122
Outlet Adjustment..................................... 126
Clutch, Hydraulic......................................... 254
Collision Damage Repair............................. 364
Content Theft-Deterrent................................. 73
Control of a Vehicle..................................... 196
Convertible Top........................................... 100
Coolant
Engine Temperature Warning Light........... 137
Surge Tank Pressure Cap........................ 258
373
ProCarManuals.com
Page 377 of 384
Hood
Checking Things Under............................ 240
Release................................................... 241
Horn............................................................ 110
How to Use This Manual................................ 4
How to Wear Safety Belts Properly............... 18
Hydraulic Clutch.......................................... 254
I
Ignition Positions........................................... 78
Infants and Young Children, Restraints.......... 30
In ation - Tire Pressure............................... 292
In ator Kit, Tire........................................... 304
Instrument Panel
Overview.................................................. 108
Instrument Panel (I/P)
Brightness................................................ 120
Cluster..................................................... 128
J
Jump Starting.............................................. 272
K
Keyless Entry System................................... 62
Keys............................................................. 60
L
Labeling, Tire Sidewall................................. 287
Lamps
Battery Run-Down Protection................... 121
Fog .......................................................... 120
Mirror Reading......................................... 120
LATCH System
Child Restraints......................................... 38
Latches, Seatback......................................... 12
License Plate Lamps................................... 282
Light
Airbag Readiness..................................... 130
Anti-Lock Brake System Warning............. 135
Brake System Warning............................. 134
Charging System..................................... 133
Electronic Stability Control........................ 136
Engine Coolant Temperature Warning....... 137
Fog Lamp................................................ 142
377
ProCarManuals.com