service indicator Seat Exeo ST 2010 Maintenance programme

SEAT maintenance programme7
SEAT maintenance programmeGeneral informationTo ensure that you have each service carrie d out on time and that none are
forgotten, there is a reminder sticker on the dr iver side door pillar and a
reminder will also be shown via the serv ice interval display on the instrument
panel.
The service intervals quoted are for vehicles used under normal operating
conditions .
However, if the vehicle is used in adverse conditions, it may require work
before the next established service interval or ev en between service inter-
vals.
Adverse conditions include:•the use of fuel with a high sulphur content•frequent short journeys•leaving the engine idling for long periods o f time (as occurs with taxis)•driving on dusty roads or in dusty areas•frequently using the vehicle for towing•mainly driving in the city, in heavy traffic whe re it is necessary to continu-
ously brake and start, and•using the vehicle mainly in the winter
This particularly affects:•the air filter•the timing belt•the engine oil and•the diesel particulate filter In some countries diesel fuel has a high sulp
hur content; in these cases the
oil and the fuel filter should be changed every 7,5 00 km (5,000 miles). Your
Official SEAT Service will be able to tell y ou which countries have diesel with
a high sulphur content.
The service advisor at your Official SEA T Service will advise you on the need
to carry out additional work on your vehicle, t aking into account the usage
conditions of the vehicle.
A list of the work to be carried out at th e SEAT services is given on the
following pages. These services are valid at the time of printing and can be
subject to further modifications for technical reaso ns. Your Official SEAT
Service always has the latest available information and will be able to tell
you if your vehicle requires any other additio nal inspections established by
law.
The cost of the SEAT service may vary, depen ding on the vehicle type, equip-
ment fitted, additional work and statutory inspec tions. Your Official SEAT
Service will tell you how much the SEAT se rvice will cost (labour and parts).
LongLife ServiceWhat is the LongLife service interval?
The service intervals are flexible
Oil change
Inspection
according to a flexible
service interval indicator
Prog Manto Exeos_EN.book Seite 7 Die nstag, 31. August 2010 4:49 16

SEAT maintenance programme9
Please observe inspection intervals and en sure your vehicle is serviced as
required. Please note that failure to obse rve the inspection intervals may
lead to damage to your vehicle.
Note
•We recommend that you visit an Authorised SEAT Service Centre whenever
you require any work done on your vehicle.•SEAT keeps its Technical Services up-to-da te on new product develop-
ments. They have tools and highly specia lised personnel who can guarantee
the safety and performance of your vehicle.•Scrupulously following the General Programme for Inspection Services in
Authorised SEAT Services will ensure you m aintain greater value for your
vehicle.Oil change serviceOperations to be performed on your vehicl e:•Engine oil and oil filter: Replace.•Front and rear brake pads: Check.•Service interval indicator: Reset to zero.•“Next service” sticker: Write the date and mile age, and attach it onto the
door frame.
Inspection Service every 30,000 km (20,000 miles) or 2 yearsOperations to be performed on your vehicle:•Battery: Check condition•Self-diagnosis: Check fault memory in all systems.•Service interval indicator: Reset to zero.•Sunroof: Check operation, clean guttering a nd lubricate guides.•Windscreen wiper and headlight wiper system : Check operation and look
for possible damage, fill if necessary.•Tyres (including the spare wheel): Check sur face, tread and tyre pressure.•Engine oil and oil filter: Replace.•Front and rear brake pads: Check.•Brake system: Check for leaks and damage•Engine and engine compartment componen ts (from below) : Check for
leaks and damage•Steering ball joints: Check fastenings and a bsence of leaks and damage,
and verify play.•Engine and engine well components (from abov e): Visual check for leaks
and damage.•Brake fluid level, according to brake pad w ear: Check.•Servo steering hydraulic system: Check for leaks and check fluid levels,
topping up with hydraulic oil where necess ary.•Test run, brake system, parking brake, gear c ontrol, steering system, air
conditioning: Check operation.•“Next service” sticker: Write the date and mile age, and attach it onto the
door frame.
Prog Manto Exeos_EN.book Seite 9 Die nstag, 31. August 2010 4:49 16

SEAT maintenance programme
10Inspection Service every 60,000 km (40,000 miles) or 4 yearsOperations to be performed on your vehicle:•Battery: Check condition•Front/rear lights, luggage compartment lighti ng, indicators and hazard
lights: Check operation.•Interior and glove compartment lighting, lig hter, warning lights and horn:
Check operation.•Self-diagnosis: Check fault memory in all syste ms.•Service interval indicator: Reset to zero.•Door and tailgate hinges: Lubricate.•Door arresters, lock cylinders and bonnet arrester hooks: Lubricate•Sunroof: Check operation, clean guttering and lubricate guides.•Windscreen wiper and headlight wiper system: Check operation and look
for possible damage, fill if necessary.•Tyres (including the spare wheel): Check sur face, tread and tyre pressure.•Engine oil and oil filter: Replace.•Front and rear brake pads: Check.•Exhaust system : Check fastenings and abse nce of leaks and damage•Underside protection: Check visually for damage•Brake system: Check for leaks and damage•Engine and engine compartment component s (from below) : Visual check
for leaks and damage.•Steering knuckles: Check attachment s and check for leaks and damage.
Check for play.
•Engine and engine well components (from abov e): Visual check for leaks
and damage.•Coolant system : Check coolant and frost pr otection level.•Brake fluid level, according to brake pad wear : Check.•Servo steering hydraulic system: Check for leaks and check fluid levels,
topping up with hydraulic oil where nece ssary.•Headlights: Checking their adjustment.•Test run, brake system, parking brake, gear control, steering system, air
conditioning: Check operation.•“Next service” sticker: Write the date and mil eage, and attach it onto the
door frame.Additional tasksIn addition to the Inspection Service, addit ional maintenance jobs may have
to be carried out, depending on the conditions i n which your vehicle is used
and on the equipment carried. This addi tional work should be carried out in
accordance with time/distance travelled to en sure your vehicle remains reli-
able. Your Technical Service will provide detailed information about the addi-
tional work that may be necessary. This can be done independently of the
obligatory services, taking into account the notes on the Maintenance
Programme (or the label: Next service). Your SEAT Service Centre will be
happy to advise you and quote the prices for this add itional work. Additional
jobs completed are marked on the work shop sheet with the receipt.
Prog Manto Exeos_EN.book Seite 10 Di enstag, 31. August 2010 4:49 16