service Seat Ibiza 5D 2010 Workshop Manual

If and when211
Safety First
Operating Instructions
Practical Tips
Technical Specifications
It also contains the instructions for using the compressor.
WARNING
•Do not attempt to repair a puncture with the sealing compound if the
tyre has been damaged by driving the vehicle after the tyre has lost its air.•Always observe warnings and follow safety instructions concerning
compressor and sealing compound carefully.•Do not drive faster than 80 km/h, avoid heavy acceleration, hard
braking and fast cornering.•Tyres which have been repaired with sealing compound are only suit-
able for temporary use over a short period. Therefore, please drive carefully
to the next available specialised workshop.For the sake of the environment
If you have to dispose of a sealant can, go to a specialised waste ser vice or to
a SEAT Technical Service, where the product can be recycled in an appropriate
waste container.
Note
•If sealant should leak out, leave it to dry. This way you can pull it off like a
piece of foil.•Observe the expiry date stated on the sealing compound can. Have the
sealing compound exchanged by a specialised workshop.•Seek professional assistance if the repair of a tyre puncture is not
possible with the sealing compound.
What to do first
Certain steps must be taken before repairing a tyre.– If you have a flat tyre or puncture, park the vehicle as far away from the flow of traffic as possible.
–Apply the handbrake firmly.
– Engage first gear , or put the selector lever to position P.
–All passengers should leave the vehicle. They should wait in a
safe area (for instance behind the roadside crash barrier).
– Check whether a repair is possibl e using the Tyre Mobility System
“General information and safety notes.”
– Unscrew inflation cap from the affected wheel.
– Take the tyre repair kit out of the luggage compartment.
WARNING
Switch on the hazard warning lights and place the warning triangles in
position. This is for your own safety and also warns other road users.
Caution
Take special care if you have to repair a tyre on a slope.
Note
•Please observe legal requirements when doing so.•Remember to replace the sealing compound as soon as possible.
Ibiza_EN.book Seite 211 Mittwoch, 1. September 2010 5:24 17

If and when
224
– First fit the glass with the fastening tabs over the frame of the switch. Next press the front part until the two long tabs click on
the support.Additional brake lights*Given the difficulty involved in the replacement of this light it should be done
by the Technical Service.Luggage compartment light*
– Extract the tulip shaped fitting by pressing on the inside edge of this -arrow- using the flat side of a screwdriver ⇒fig. 151 .
– Press the bulb sideways and remove it from its housing ⇒fig. 152 .Jump-startingJump leads
The jump lead must have a sufficient wire cross section.If the engine fails to start because of a discharged battery, the battery can be
connected to the battery of another vehicle to start the engine.
Fig. 151 Luggage
compartment light
Fig. 152 Luggage
compartment light
Ibiza_EN.book Seite 224 Mittwoch, 1. September 2010 5:24 17

Description of specifications
234If the maximum permissible drawbar load cannot be met (e.g. with small,
empty and light-weight single axle trailers or tandem axle trailers with a
wheelbase of less than 1 metre), at least 4% of the actual trailer weight is a
legal stipulation for a drawbar load.
WARNING
•For safet y reas ons , d o not excee d the 8 0 k m/h limit . Th is is als o valid in
countries where higher speeds are permitted.•Never exceed the maximum trailer weights or the drawbar load. If the
permissible axle load or the permissible total weight is exceeded, the
driving characteristics of the vehicle may change, leading to accidents,
injuries and damage to the vehicle.
WheelsTyre pressure, snow chains, wheel boltsTyre pressures
The sticker with the tyre pressure values can be found on the inside of the
tank flap. The tyre pressure values given there are for cold tyres. The slightly
raised pressures of warm tyres must not be reduced ⇒.
Snow chains
Snow chains may be fitted only to the front wheels, and only for the following
tyres: Wheel bolts
After the wheels have been changed, the tightening torque
of the wheel bolts
s ho uld b e che cke d as s o on as p ossible wit h a to rqu e w re nch ⇒ . The tight-
ening torque for steel and alloy wheels is 120 Nm.
WARNING
•Check the tyre pressure at least once per month. Checking the tyre
pressure is very important. If the tyre pressure is too high or too low, there
is an increased danger of accidents, particularly at high speeds.•If the torque of the wheel bolts is too low, they could loosen while the
vehicle is in motion. Risk of accident! If the tightening torque is too high,
the wheel bolts and threads can be damaged.Note
We recommend that you ask your Authorised Service Centre for information
about appropriate wheel, tyre and snow chain size.175/70R14
185/60R15
Chains with links not exceeding 15 mm (including the
chain closure)
215/45R16
Chains with links not exceeding 9 mm (including the
chain closure)
215/40R17
Chains with links not exceeding 7mm (including the
chain closure)
Ibiza_EN.book Seite 234 Mittwoch, 1. September 2010 5:24 17

Technical Specifications235
Safety First
Operating Instructions
Practical Tips
Technical Specifications
Technical SpecificationsChecking fluid levelsFrom time to time, the levels of the different fluids in the
vehicle must be checked. Never fill with incorrect fluids,
otherwise serious damage to the engine may be caused.
Coolant expansion tank
Engine oil dipstick
Engine oil filler cap
Brake fluid reservoir
Vehicle battery
Windscreen washer fluid container
The checking and refilling of service fluids are carried out on the components
mentioned above. These operations are described in the ⇒page 183.
Overview
You will find further explanations, instructions and restrictions on the tech-
nical specifications as of ⇒page 231.Note
The layout of parts may vary depending on the engine.
Fig. 158 Diagram for the
location of the various
elements
Fig. 159 For vehicles with
the battery in the luggage
compartment.
A1A2A3A4A5A6
Ibiza_EN.book Seite 235 Mittwoch, 1. September 2010 5:24 17

Index
258Fog lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89
Fog lights with cornering function . . . . . . . . . . . 92
Front airbags . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Description . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Safety notes . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Front ashtray . . . . . . . . . . . . . . . . . . . . . . . . . . . 114
Front cup holder* . . . . . . . . . . . . . . . . . . . . . . . 113
Front interior light . . . . . . . . . . . . . . . . . . . . . . . . 96
Front passenger airbag deactivation . . . . . . . . . 35
Front reading light . . . . . . . . . . . . . . . . . . . . . . . . 97
Front seat adjustment Lumbar support . . . . . . . . . . . . . . . . . . . . . . 107
Fuel Diesel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 182
Petrol . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 181
Fuel level Indicator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
Fuel reserve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64
Fuel Tank Opening the fuel tank flap . . . . . . . . . . . . . 180
Fuel tank See Fuel reserve . . . . . . . . . . . . . . . . . . . . . . 64
Fuel: save . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 161
Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 212GG 12 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 190
Gear shift pattern . . . . . . . . . . . . . . . . . . . . . . . 136
General overview of the engine compartment 235 Glove compartment . . . . . . . . . . . . . . . . . . . . . . 110
Glow plug system . . . . . . . . . . . . . . . . . . . . . . . 133
Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . 60
GRA . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 148
HHandbrake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 144 Warning lamp . . . . . . . . . . . . . . . . . . . . 63, 145
Hazard warning lights . . . . . . . . . . . . . . . . . . . . . 94
HBA . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 153
Head restraints Adjusting . . . . . . . . . . . . . . . . . . . . . . . 105, 106
Adjustment of the head restraint angle . . . 106
Removing . . . . . . . . . . . . . . . . . . . . . . . . . . . 106
Headlight flashers . . . . . . . . . . . . . . . . . . . . . . . . 95
Headlight range control . . . . . . . . . . . . . . . . . . . 91
Headlights Driving abroad . . . . . . . . . . . . . . . . . . . . . . . 163
Fog lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89
Headlight washer . . . . . . . . . . . . . . . . . . . . 101
Heated exterior mirrors* . . . . . . . . . . . . . . . . . . 102
Heated front seats . . . . . . . . . . . . . . . . . . . . . . . 108
Heated rear window Heating element wires . . . . . . . . . . . . . . . . 170
Heating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 119
Heating system . . . . . . . . . . . . . . . . . . . . . . . . . 120
High pressure cleaners . . . . . . . . . . . . . . . . . . . 168
Hill-start assist . . . . . . . . . . . . . . . . . . . . . . . . . 146
Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47
How to jump start description . . . . . . . . . . . . . 225 Hydraulic Brake Assist
Automatic hazard warning lights activation . . .153
IIdentification number . . . . . . . . . . . . . . . . . . . . 232
Identification plate . . . . . . . . . . . . . . . . . . . . . . 232
Ignition key . . . . . . . . . . . . . . . . . . . . . . . . . . . . 130
Ignition lock . . . . . . . . . . . . . . . . . . . . . . . . . . . . 130
Information in the multifunction display
Memory displays . . . . . . . . . . . . . . . . . . . . . . 52
Instrument and switch lighting . . . . . . . . . . . . . 91
Instrument lighting . . . . . . . . . . . . . . . . . . . . . . . 47
Instrument panel Service interval display . . . . . . . . . . . . . . . . 54
Instruments . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
Interior mirror . . . . . . . . . . . . . . . . . . . . . . . . . . 101
Interior monitoring and anti-towing alarm* Activation . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81
ISOFIX system . . . . . . . . . . . . . . . . . . . . . . . . . . . 42JJump leads . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 224
Jump-starting . . . . . . . . . . . . . . . . . . . . . . . . . . . 224KKeys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77
Ibiza_EN.book Seite 258 Mittwoch, 1. September 2010 5:24 17

Index
260Rear seat
folding down . . . . . . . . . . . . . . . . . . . . . . . . 109
Rear seats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 109
Rear shelf . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 117
Rear view mirrors . . . . . . . . . . . . . . . . . . . . . . . . 101
Rear window automatic wiper/washer . . . . . . 100
Rear window wiper . . . . . . . . . . . . . . . . . . . . . . 100
Recommended gear display . . . . . . . . . . . . . . . . 51
Refuelling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 180
Remote control key Buttons . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 78
Synchronising . . . . . . . . . . . . . . . . . . . . . . . . 79
Removing and fitting the wheel . . . . . . . . . . . . 209
Repairs Airbags . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Replacement keys . . . . . . . . . . . . . . . . . . . . . . . . 77
Replacement of parts . . . . . . . . . . . . . . . . . . . . 175
Rev counter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
Reverse gear Manual gearbox . . . . . . . . . . . . . . . . . . . . . 136
Roll-back function Panorama/ tilting sunroof . . . . . . . . . . . . . . 88
Windows . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85
Roof aerial . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 176
Roof rack* . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 118
Rubber seals . . . . . . . . . . . . . . . . . . . . . . . . . . . 170
Running in Brake pads . . . . . . . . . . . . . . . . . . . . . . . . . . 158
Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 158
Tyres . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 158 Running in tyres . . . . . . . . . . . . . . . . . . . . . . . . 158
SSafe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72
Safe driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Safe Security system . . . . . . . . . . . . . . . . . . . . . . 72
Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Safety equipment . . . . . . . . . . . . . . . . . . . . . . . . . 7
Safety instructions
Coolant temperature . . . . . . . . . . . . . . . . . . . 66
Safety notes Airbags . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Deactivating front passenger airbag . . . . . . 36
Front airbags . . . . . . . . . . . . . . . . . . . . . . . . . 31
Seat belt tensioners . . . . . . . . . . . . . . . . . . . 25
Side airbags . . . . . . . . . . . . . . . . . . . . . . . . . 33
Using child seats . . . . . . . . . . . . . . . . . . . . . . 37
Using seat belts . . . . . . . . . . . . . . . . . . . . . . 20
Seals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 170
Seat adjustment . . . . . . . . . . . . . . . . . . . . 104, 107
Seat belt cleaning . . . . . . . . . . . . . . . . . . . . . . . 174
Seat belt position Pregnant women . . . . . . . . . . . . . . . . . . . . . . 23
Seat belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Seat belt protection . . . . . . . . . . . . . . . . . . . . . . 20
Seat belt release . . . . . . . . . . . . . . . . . . . . . . . . . 24
Seat belt tensioner Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . 27
Seat belt warning lamp . . . . . . . . . . . . . . . . . . . . 16 Seat belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Incorrectly fastened . . . . . . . . . . . . . . . . . . . 24
Not worn . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Safety notes . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . 16
Seat heating . . . . . . . . . . . . . . . . . . . . . . . . . . . 108
Selective opening* . . . . . . . . . . . . . . . . . . . . . . . 73
Semiautomatic air conditioning controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . 122
Service interval display . . . . . . . . . . . . . . . . . . . 54
Side airbags . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32 Description . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
Safety notes . . . . . . . . . . . . . . . . . . . . . . . . . . 33
Side lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89
Sitting position Driver . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Front passenger . . . . . . . . . . . . . . . . . . . . . . 10
Sitting position, occupants . . . . . . . . . . . . . . . . . 9
Snow chains . . . . . . . . . . . . . . . . . . . . . . . 203, 234
Soot accumulation in the diesel engine particulate filter *
Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . 60
Spanner symbol . . . . . . . . . . . . . . . . . . . . . . . . . 55
Spare parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . 175
Spare wheel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 204
Speed selector lever lock warning lamp . . . . . . . . . . . . . . . . . . . . . . . . 64
Speedometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
Starting Petrol engines . . . . . . . . . . . . . . . . . . . 132
Ibiza_EN.book Seite 260 Mittwoch, 1. September 2010 5:24 17

Index261
Starting petrol engines . . . . . . . . . . . . . . . . . . . 132
Starting the engine . . . . . . . . . . . . . . . . . . . . . . 132
After the fuel tank has been run dry . . . . . . 133
Start-Stop Function . . . . . . . . . . . . . . . . . . . . . . . . . . . . 134
Switching on and off . . . . . . . . . . . . . . . . . . 135
Steam jets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 168
Steering . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 129 Steering lock . . . . . . . . . . . . . . . . . . . . . . . . 130
Steering column controls Audio Control . . . . . . . . . . . . . . . . . . . . . . . . . 68
Steering wheel height adjustment . . . . . . . . . . 129
Storage compartment Front passenger side . . . . . . . . . . . . . . . . . . 110
Right-hand front seat . . . . . . . . . . . . . . . . . 112
Sun visor Sliding/tilting sunroof . . . . . . . . . . . . . . . . . . 87
Sun visors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 97
Switch Hazard warning lights . . . . . . . . . . . . . . . . . . 94
Heated rear window . . . . . . . . . . . . . . . . . . . . 93
Light switch . . . . . . . . . . . . . . . . . . . . . . . . . . 89
Switches Electric windows . . . . . . . . . . . . . . . . . . . . . . 84
Sliding/tilting sunroof . . . . . . . . . . . . . . . . . . 87
Switching off the engine . . . . . . . . . . . . . . . . . . 133
TTailgate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82 Emergency opening . . . . . . . . . . . . . . . . . . . . 83
Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . . 65
Tank Fuel level . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
Reserve indicator . . . . . . . . . . . . . . . . . . . . . . 50
Tank capacity . . . . . . . . . . . . . . . . . . . . . . . . . 50
TCS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 154
TCS (Traction control system) Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . . 62
Technical modifications . . . . . . . . . . . . . . . . . . 175
The danger of not using the seat belt . . . . . . . . 19
Tightening torque of wheel bolts . . . . . . . . . . . 234
Tilting sunroof . . . . . . . . . . . . . . . . . . . . . . . . . . . 87
Tools . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 204
Top Tether system . . . . . . . . . . . . . . . . . . . . . . . . 43
Tow starting Comments . . . . . . . . . . . . . . . . . . . . . . . . . . 227
Towing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 227
Towing a trailer . . . . . . . . . . . . . . . . . . . . 163, 233
Towing bracket . . . . . . . . . . . . . . . . . . . . . . . . . 164
Towing bracket, fitting . . . . . . . . . . . . . . . . . . . 178
Towing eye . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 227
Towing eyes . . . . . . . . . . . . . . . . . . . . . . . . . . . . 228
Tow-starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . 227
Traction control system Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . . 62 Trailer turn signals
Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . 95
Trailer weights . . . . . . . . . . . . . . . . . . . . . . . . . . 233
Turn signals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 95 Indicator lamp . . . . . . . . . . . . . . . . . . . . . . . . 66
Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . 95
Two-way radio . . . . . . . . . . . . . . . . . . . . . . . . . . 176
Tyre Mobility-System (Tyre repair kit) . . . . . . . . 205
Tyre pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . 199
Tyre pressure warning lamp . . . . . . . . . . . . . . . . 63
Tyre pressures . . . . . . . . . . . . . . . . . . . . . . . . . . 234
Tyre repair kit . . . . . . . . . . . . . . . . . . . . . . 205, 210
Tyre-Mobility-System (Tyre repair kit) . . . . . . . . 210
Tyres and wheels Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . 201
Tyres service life . . . . . . . . . . . . . . . . . . . . . . . . 200
Tyres tread depth . . . . . . . . . . . . . . . . . . . . . . . . 200
Tyres with directional tread pattern . . . . . . . . . 199
UUnderbody protection . . . . . . . . . . . . . . . . . . . . 172VVehicle battery . . . . . . . . . . . . . . . . . . . . . . . . . . 196
Vehicle data . . . . . . . . . . . . . . . . . . . . . . . . . . . . 232
Vehicle identification data . . . . . . . . . . . . . . . . 232
Vehicle identification number . . . . . . . . . . . . . 232
Vehicle interior heating or cooling system . . . 123
Vehicle modifications . . . . . . . . . . . . . . . . . . . . 175
Ibiza_EN.book Seite 261 Mittwoch, 1. September 2010 5:24 17

SEAT S.A. is permanently concerned about continuous development of its types and models. For this reason we ask you to understand, that
at any given time, changes regarding shape, equipment and technique may take place on the car delivered. For this reason no rig ht at all
may derive based on the data, drawings and descriptions in this current handbook.
All texts, illustrations and standards in this handbook are based on the status of information at the time of printing. Except for error or omis-
sion, the information included in the current handbook is valid as of the date of closing print.
Re-printing, copying or translating, whether total or partial is not allowed unless SEAT allows it in written form.
SEAT reserves all rights in accordance with the "Copyright" Act.
All rights on changes are reserved.
This paper has been manufactured using bleached non-chlorine cellulose.
© SEAT S.A. - Reprint: 15.09.10
Vehicle data
1.
2.
3.
4.
5.
1.Vehicle identification number
2
.Identification numbers
Type/Model/Engine
Gearbox/Finishes
3
.Identification letters
Engine/Gearbox/Paintwork
Equipment
4
.Identification codes of variable equipment
5
.Consumption (l/100 km) / CO2Emissions (g/km) urban
Consumption (l/100 km) / CO
2Emissions (g/km) motorway
Consumption (l/100 km) / CO
2Emissions (g/km) mixed
Note
• We recommend that you visit an Authorised SEAT Service Centre when-
ever you require any work done on your vehicle.
• SEAT regularly communicates to its Authorised Service Centres new
product developments. They have tools and highly specialized person-
nel who can guarantee the safety and performance of your vehicle.
• Scrupulously following the General Programme for Inspection
Services in Authorised SEAT Service Centres will ensure you maintain
greater value for your vehicle.
Portada PM_interior.qxd:Interior Manual TOLEDO 26/7/10 15:57 Página 3