maintenance Seat Leon 5D 2010 Owner's Guide

Checking and refilling levels233
Safety First
Operating Instructions
Practical Tips
Technical Specifications
Brake fluidChecking the brake fluid level
The brake fluid is checked at the intervals given in the service
schedule.– Read off the fluid level at the transparent brake fluid reservoir. It
should always be between the “MIN” and “MAX” marks.The position of the brake fluid reservoir is shown in the corresponding engine
compartment illustration ⇒page 277. The brake fluid reservoir has a black
and yellow cap.
The brake fluid level drops slightly when the vehicle is being used as the
brake pads are automatically adjusted as they wear. However, if the level goes down noticeably in a short time, or drops below the
“MIN” mark, there may be a leak in the brake system. A display on the instru-
ment panel will warn you if the brake fluid level is too low
⇒page 77.
WARNING
Before opening the bonnet to check the brake fluid level, read and observe
the warnings ⇒page 221.Changing the brake fluid
The Maintenance Programme indicates the brake fluid
change intervals.We recommend that you have the brake fluid changed by an Authorised
Service Centre.
Before opening the bonnet, please read and follow the warnings ⇒ in
“Safety instructions on working in the engine compartment” on page 221 in
section “Safety notes for working in the engine compartment”.
Brake fluid absorbs moisture. In the course of time, it will absorb water from
the ambient air. If the water content in the brake fluid is too high, the brake
system could corrode. This also considerably reduces the boiling point of the
brake fluid. Heavy use of the brakes may then cause a vapour lock which
could impair the braking effect.
It is important that you use only brake fluid compliant with US standard
FMVSS 116 DOT 4. We recommend the use of Genuine SEAT brake fluid.
WARNING
Brake fluid is poisonous. Old brake fluid impairs the braking effect.
Fig. 151 In the engine
compartment: Brake fluid
reservoir cover
Leon_EN.book Seite 233 Mittwoch, 1. September 2010 6:16 18

Checking and refilling levels
234•Before opening the bonnet to check the brake fluid level, read and
observe the warnings ⇒page 221.•Brake fluid should be stored in the closed original container in a safe
place out of reach of children. There is a toxic risk.•Complete the brake fluid change according to the Maintenance
Programme. Heavy use of the brakes may cause a vapour lock if the brake
fluid is left in the system for too long. This would seriously affect the effi-
ciency of the brakes and the safety of the vehicle. This may cause an acci-
dent.Caution
Brake fluid could damage the paintwork. Wipe off any brake fluid from the
paintwork immediately.
For the sake of the environment
The brake pads and fluid must be collected and disposed of according the
applicable regulations. The SEAT Technical Service network has the necessary
equipment and qualified personnel for collecting and disposing of this waste
material.
Vehicle batteryWarnings on handling the battery
WARNING
Always be aware of the danger of injury and chemical burns as well as the
risk of accident or fire when working on the battery and the electrical
system:•Wear eye protection. Protect your eyes, skin and clothing from acid and
particles containing lead.•Battery acid is very corrosive and caustic. Wear protective gloves and
eye protection. Do not tilt the batteries. This could spill acid through the
vents. Rinse battery acid from eyes immediately for several minutes with
clear water. Then seek medical care immediately. Neutralise any acid
splashes on the skin or clothing with a soapy solution, and rinse off with
plenty of water. If acid is swallowed by mistake, consult a doctor immedi-
ately.•Fires, sparks, open flames and smoking are prohibited. When handling
cables and electrical equipment, av oid causing sparks and electrostatic
WARNING (continued)

Wear eye protection

Battery acid is very corrosive and caustic. Wear protective
gloves and eye protection!
Ž
Fires, sparks, open flames and smoking are prohibited!
Ÿ
A highly explosive mixture of gases is released when the bat-
tery is under charge.

Keep children away from acid and batteries!
Leon_EN.book Seite 234 Mittwoch, 1. September 2010 6:16 18

Checking and refilling levels
236Charging and changing the vehicle battery
The battery is maintenance-free and is checked during the
inspection service. All work on the vehicle battery requires
specialist knowledge.If you often drive short distances or if the vehicle is not driven for long
periods, the battery should be checked by a specialised workshop between
the scheduled services.
If the battery has discharged and you have problems starting the vehicle, the
battery might be damaged. If this happens, we recommend you have the
vehicle battery checked by an Authorised Service Centre where it will be re-
charged or replaced.
Charging the battery
The vehicle battery should be charged by a specialised workshop only, as
batteries using special technology have been installed and they must be
charged in a controlled environment.
Replacing a vehicle battery
The battery has been developed to suit the conditions of its location and has
special safety features.
Genuine SEAT batteries fulfil the maintenance, performance and safety spec-
ifications of your vehicle.
WARNING
•We recommend you use only maintenance-free or cycle free leak-proof
batteries which comply with standards T 825 06 and VW 7 50 73. This
standard applies as of 2001.•Before starting any work on the batteries, you must read and observe
the warnings ⇒ in “Warnings on handling the battery” on page 234.
For the sake of the environment
Batteries contain toxic substances such as sulphuric acid and lead. They
m ust b e d isp ose d of app ro pr iate ly a nd m ust no t b e disp ose d of wit h or di na r y
household waste.
Leon_EN.book Seite 236 Mittwoch, 1. September 2010 6:16 18

Description of specifications273
Safety First
Operating Instructions
Practical Tips
Technical Specifications
Technical SpecificationsDescription of specificationsImportant informationImportant
The information in the vehicle documentation always has
precedence.All technical specifications provided in this manual are valid for the standard
model in Spain. The vehicle data card included in the Maintenance
Programme or the vehicle registration documents shows which engine is
installed in the vehicle.
The figures may be different depending on if additional equipment is fitted,
for different models, for special vehicles and for other countries. Abbreviations used in the Technical Specifications section
Abbrevia-
tion
Meaning
kW
Kilowatt, engine power measurement.
PS
Pferdestärke (horsepower), formerly used to denote engine
power.
rpm
Revolutions per minute - engine speed.
Nm
Newton metres, unit of engine torque.
l/100 km
Fuel consumption in litres per 100 km.
g/km
Carbon dioxide emissions in grams per km travelled.
CO2
Carbon dioxide
CN
Cetane number, indication of the diesel combustion power.
RON
Research octane number, indication of the knock resistance
of petrol.
Leon_EN.book Seite 273 Mittwoch, 1. September 2010 6:16 18

Description of specifications
274Vehicle identification data
The most important information is given on the identification
plate and the vehicle data sticker.Vehicles for certain export countries do not have an identification plate.
Identification plate
The identification plate is located on the left rib inside the engine compart-
ment.
Vehicle identification number
The vehicle identification number (chassis number) can be read from outside
the vehicle through a viewer in the windscreen. This is located on the left-
hand side of the vehicle in the lower area of the windscreen. It is also located
on the right hand side of the engine compartment. Vehicle data
The data sticker is placed on the inside of the spare wheel recess in the
luggage compartment.
The following information is provided on the vehicle data sticker:
⇒fig. 185 .
These data are also provided in the Maintenance Programme. Production control number
Vehicle identification number (chassis number)
Model code number
Model designation / engine power output
Engine and gearbox code letters
Paintwork number / interior trim code
Optional equipment codes
Consumption values
CO
2 emissions values
Data from 2 to 9 are also provided in the Maintenance Programme.
Consumption figures and CO
2
Consumption (litres/100 km) / CO
2 emissions (g/km) urban
Consumption (litres/100 km) / CO2 emissions (g/km) motorway
Consumption (litres/100 km) / CO2 emissions (g/km) mixed
Fig. 185 Vehicle data
sticker (luggage compart-
ment)
A1A2A3A4A5A6A7A8A9AAABAC
Leon_EN.book Seite 274 Mittwoch, 1. September 2010 6:16 18

Index301
Headlights
Driving abroad . . . . . . . . . . . . . . . . . . . . . . . 198
Fog lights . . . . . . . . . . . . . . . . . . . . . . . . . . . 117
Headlight washer system* . . . . . . . . . . . . . 131
Heated front seats . . . . . . . . . . . . . . . . . . . . . . . 139
Heated rear window 2C-Climatronic . . . . . . . . . . . . . . . . . . . . . . . 155
Heating element wires . . . . . . . . . . . . . . . . 207
Heating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 148
High pressure cleaners . . . . . . . . . . . . . . . . . . . 205
Hill-start aid . . . . . . . . . . . . . . . . . . . . . . . . . . . . 177
Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
How to jump start description . . . . . . . . . . . . . 268
Hydraulic Brake Assist . . . . . . . . . . . . . . . . . . . . 185IIdentification number . . . . . . . . . . . . . . . . . . . . 274
Identification plate . . . . . . . . . . . . . . . . . . . . . . 274
Ignition key . . . . . . . . . . . . . . . . . . . . . . . . . . . . 162
Ignition lock . . . . . . . . . . . . . . . . . . . . . . . . . . . . 162
Information in the multifunction display Memory displays . . . . . . . . . . . . . . . . . . . . . . 64
Information messages in the display . . . . . . . . . 66
Instrument and switch lighting . . . . . . . . . . . . . 121
Instrument lighting . . . . . . . . . . . . . . . . . . . . . . . 55
Instrument panel menus Configuration menu . . . . . . . . . . . . . . . . . . . . 74
Example of menu use . . . . . . . . . . . . . . . . . . 68
Lights and visibility menu . . . . . . . . . . . . . . . 76 Main menu . . . . . . . . . . . . . . . . . . . . . . . . . . . 68
Vehicle status menu . . . . . . . . . . . . . . . . . . . 73
Instruments . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
Interior lights . . . . . . . . . . . . . . . . . . . . . . . . . . . 125
Interior mirror . . . . . . . . . . . . . . . . . . . . . . . . . . . 131
ISOFIX system . . . . . . . . . . . . . . . . . . . . . . . . . . . 52
JJump leads . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 267
Jump-starting . . . . . . . . . . . . . . . . . . . . . . . . . . . 267KKeys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 105LLeather cleaning . . . . . . . . . . . . . . . . . . . . . . . . 210
Lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 117
Load compartment in the luggage compartment See Loading the luggage compartment . . . . 16
Loading the luggage compartment . . . . . . . . . . 16
Locker . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 141
Locks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 207
LPG . . . . . . . . . . . . . . . . . . . . . . . . . . . 60, 166, 216
LPG system Driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 166
Filler neck adapter . . . . . . . . . . . . . . . . . . . . 218
Level indicator . . . . . . . . . . . . . . . . . . . . . . . . 60
Refuelling . . . . . . . . . . . . . . . . . . . . . . . . . . . 216 Luggage compartment . . . . . . . . . . . . . . . . . . . 146
See also Loading the luggage compartment 16
MMain beam . . . . . . . . . . . . . . . . . . . . . . . . 117, 124
Main beam headlights
Indicator lamp . . . . . . . . . . . . . . . . . . . . . . . . 84
Main headlight bulbs . . . . . . . . . . . . . . . . . . . . 260
Maintenance Airbags . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Maintenance and cleaning . . . . . . . . . . . . . . . . 203
Manual gearbox . . . . . . . . . . . . . . . . . . . . . . . . . 170
Manual mode 2C-Climatronic . . . . . . . . . . . . . . . . . . . . . . . 157
MEDIA-IN connector . . . . . . . . . . . . . . . . . . . . . . 145
MFI . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Mirrors Exterior mirrors . . . . . . . . . . . . . . . . . . . . . . 132
Interior mirror . . . . . . . . . . . . . . . . . . . . . . . . 131
Vanity mirrors . . . . . . . . . . . . . . . . . . . . . . . 127
Mobile phones and two-way radios . . . . . . . . . 213
Multifunction display . . . . . . . . . . . . . . . . . . . . . 63NNumber of seats . . . . . . . . . . . . . . . . . . . . . . . . . 19OObservations . . . . . . . . . . . . . . . . . . . . . . . . . . . 198
Leon_EN.book Seite 301 Mittwoch, 1. September 2010 6:16 18

Index
302Octane number . . . . . . . . . . . . . . . . . . . . . . . . . 219
Odometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62
Oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
224
Oil change . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 227
Oil properties . . . . . . . . . . . . . . . . . . . . . . . . . . . 225
One-touch opening and closing
Electric windows . . . . . . . . . . . . . . . . . . . . . 113
Opening and locking . . . . . . . . . . . . . . . . . . . . 110
Outside temperature display . . . . . . . . . . . . 65, 73
Overview Control lamps . . . . . . . . . . . . . . . . . . . . . . . . 77
Dash panel . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
Indicator lamps . . . . . . . . . . . . . . . . . . . . . . . 80
Instruments . . . . . . . . . . . . . . . . . . . . . . . . . . 57
Warning lamps . . . . . . . . . . . . . . . . . . . . 77, 80PPaintworkPolishing . . . . . . . . . . . . . . . . . . . . . . . . . . . 206
Parking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 176
Parking lights . . . . . . . . . . . . . . . . . . . . . . . . . . 124
Parking system . . . . . . . . . . . . . . . . . . . . . . . . . 178
Parking system plus . . . . . . . . . . . . . . . . . . . . . 179
Parts replacement . . . . . . . . . . . . . . . . . . . . . . . 212
Passenger See Correct sitting position . . . . . . . . . . 11, 12
Pedals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Petrol . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 219 Driving abroad . . . . . . . . . . . . . . . . . . . . . . . 198
Petrol additives . . . . . . . . . . . . . . . . . . . . . . . . . 220 Physical principles of a frontal collision . . . . . . 21
Plastic parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . 206
Plastic parts cleaning . . . . . . . . . . . . . . . . . . . . 209
Pollen filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . 158
Pollution filter . . . . . . . . . . . . . . . . . . . . . . . . . . 158
Power steering . . . . . . . . . . . . . . . . . . . . . . . . . . 191
Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . 88
Products for vehicle maintenance . . . . . . . . . . 203
RRadio frequency remote control . . . . . . . . . . . . 106 Changing the battery . . . . . . . . . . . . . . . . . 107
Radio navigation steering wheel controls Audio + telephone version . . . . . . . . . . . . . . 96
Audio version . . . . . . . . . . . . . . . . . . . . . . . . 96
Rain sensor* . . . . . . . . . . . . . . . . . . . . . . . . . . . 129
Rear fog light Indicator lamp . . . . . . . . . . . . . . . . . . . . . . . . 83
Warning lamp . . . . . . . . . . . . . . . . . . . . . . . 117
Rear interior lights . . . . . . . . . . . . . . . . . . . . . . 126
Rear reading lights . . . . . . . . . . . . . . . . . . . . . . 126
Rear seats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 140
Rear shelf . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 147
Rear window automatic wiper/washer . . . . . . 130
Rear window wiper . . . . . . . . . . . . . . . . . . . . . . 130
Recommended gear display . . . . . . . . . . . . . . . . 62
Refuelling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 214
Registration light . . . . . . . . . . . . . . . . . . . . . . . . 266 Remote control key
Buttons . . . . . . . . . . . . . . . . . . . . . . . . . . . . 106
Synchronising . . . . . . . . . . . . . . . . . . . . . . . 107
Removing and fitting the wheel . . . . . . . . . . . . 251
Repairs Airbags . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Replacement keys . . . . . . . . . . . . . . . . . . . . . . . 105
Rev counter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
Reverse gear Manual gearbox . . . . . . . . . . . . . . . . . . . . . 170
Roll-back function Sliding/tilting sunroof . . . . . . . . . . . . . . . . 116
Windows . . . . . . . . . . . . . . . . . . . . . . . . . . . 113
Roof aerial* . . . . . . . . . . . . . . . . . . . . . . . . . . . . 213
Roof rack* . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 147
Rubber seals . . . . . . . . . . . . . . . . . . . . . . . . . . . 207
Run-flat tyres . . . . . . . . . . . . . . . . . . . . . . . . . . . 240
Running in Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 193
SSafe driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Safe security system . . . . . . . . . . . . . . . . . . . . . 100
Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Safety equipment . . . . . . . . . . . . . . . . . . . . . . . . . 7
Safety instructions
Coolant temperature . . . . . . . . . . . . . . . . . . . 83
Safety notes Airbags . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Curtain airbags . . . . . . . . . . . . . . . . . . . . . . . 42
Leon_EN.book Seite 302 Mittwoch, 1. September 2010 6:16 18

Index
304Tightening torque of wheel bolts . . . . . . . . . . . 276
Tilting sunroof . . . . . . . . . . . . . . . . . . . . . . . . . . 114
Tools . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 245
Top Tether system . . . . . . . . . . . . . . . . . . . . . . . . 52
Tow starting
Comments . . . . . . . . . . . . . . . . . . . . . . . . . . 270
Towing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 270
Towing a trailer . . . . . . . . . . . . . . . . . . . . . . . . . 275
Towing bracket . . . . . . . . . . . . . . . . . . . . . . . . . 200
Towing bracket, fitting . . . . . . . . . . . . . . . . . . . 201
Towing eye . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 270
Towing eyes . . . . . . . . . . . . . . . . . . . . . . . . . . . . 272
Tow-starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . 270
Traction control system Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . 89
Trailer Trailer towing . . . . . . . . . . . . . . . . . . . . . . . . 199
Trailer turn signals Warning lamp . . . . . . . . . . . . . . . . . . . . . . . 124
Trailer weights . . . . . . . . . . . . . . . . . . . . . . . . . . 275
Turn signals . . . . . . . . . . . . . . . . . . . . . . . . . . . . 124 Indicator lamp . . . . . . . . . . . . . . . . . . . . . . . . 83
Warning lamp . . . . . . . . . . . . . . . . . . . . . . . 124
Tyre Mobility System (Tyre repair kit) . . . . . . . . 252
Tyre Mobility-System (Tyre repair kit) . . . . . . . 247
Tyre pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . 237 Loss . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 239
Tyre pressure monitoring . . . . . . . . . . . . . . . . . 238
Tyre pressure warning lamp . . . . . . . . . . . . . . . . 85
Tyre pressures . . . . . . . . . . . . . . . . . . . . . . . . . . 276 Tyre repair kit . . . . . . . . . . . . . . . . . . . . . . . 247, 252
Tyres and wheels
Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . 242
Tyres service life . . . . . . . . . . . . . . . . . . . . . . . . 239
Tyres tread depth . . . . . . . . . . . . . . . . . . . . . . . 240
Tyres with directional tread pattern . . . . . . . . . 237
UUnderbody protection . . . . . . . . . . . . . . . . . . . . 208
Unlocking and locking Personalisation . . . . . . . . . . . . . . . . . . . . . . 102VVehicle battery . . . . . . . . . . . . . . . . . . . . . . . . . 234
Vehicle data . . . . . . . . . . . . . . . . . . . . . . . . . . . . 274
Vehicle identification data . . . . . . . . . . . . . . . . 274
Vehicle identification number . . . . . . . . . . . . . 274
Vehicle modifications . . . . . . . . . . . . . . . . . . . . 212
Vehicle paintworkMaintenance . . . . . . . . . . . . . . . . . . . . . . . . 205
Products for vehicle maintenance . . . . . . . 203
Vehicle tools Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . 245
Vehicle washing . . . . . . . . . . . . . . . . . . . . . . . . 204
Ventilation slits . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Volumetric sensor* Activation . . . . . . . . . . . . . . . . . . . . . . . . . . . 108
Deactivation . . . . . . . . . . . . . . . . . . . . . . . . 108
WWarning lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Warning lamps . . . . . . . . . . . . . . . . . . . . . . . . . . 77
Warning messages in the display . . . . . . . . . . . 66
Warning reportsRed . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 66, 80
Yellow . . . . . . . . . . . . . . . . . . . . . . . . . . . 66, 81
Warning symbols . . . . . . . . . . . . . . . . . . . . . . . . 80
Warning triangle . . . . . . . . . . . . . . . . . . . . . . . . 145
Washer fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . 230
Washing by hand . . . . . . . . . . . . . . . . . . . . . . . 204
Washing the vehicle . . . . . . . . . . . . . . . . . . . . . 204
Washing with high pressure cleaners . . . . . . . 205
Water Warning message . . . . . . . . . . . . . . . . . . . . . 67
Water in the windscreen washer tank . . . . . . . 230
Wear indicators . . . . . . . . . . . . . . . . . . . . . . . . . 240
Wearing suitable shoes . . . . . . . . . . . . . . . . . . . 16
Wheel bolts . . . . . . . . . . . . . . . . . . . . . . . . 249, 276 Tightening torque . . . . . . . . . . . . . . . . . . . . 243
Wheel trims . . . . . . . . . . . . . . . . . . . . . . . . . . . . 248
Wheels . . . . . . . . . . . . . . . . . . . . . . . . . . . . 237, 276
Why assume the correct sitting position? . . . . . 30
Why should head restraints be correctly adjusted? 13
Why wear seat belts? . . . . . . . . . . . . . . . 19, 21, 30
Windows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 112
Windscreen interval wipe . . . . . . . . . . . . . . . . . 128
Leon_EN.book Seite 304 Mittwoch, 1. September 2010 6:16 18