wheel SSANGYONG MUSSO 1998 Workshop Repair Manual
[x] Cancel search | Manufacturer: SSANGYONG, Model Year: 1998, Model line: MUSSO, Model: SSANGYONG MUSSO 1998Pages: 1463, PDF Size: 19.88 MB
Page 1273 of 1463

6E-4 STEERING WHEEL AND COLUMN
6. Disconnect each connectors.
7. Remove the vacuum hose from the ignition switch(Diesel
only) .
9. Remove the lower shaft by removing the bolt of the steering
column shaft.
Installation Notice
Tightening Torque 9 - 14 Nm
8. Remove the combination switch assembly.
10. Remove the dash panel mounting bolts.
Installation Notice
Tightening Torque 30 - 40 Nm
Page 1274 of 1463

STEERING WHEEL AND COLUMN 6E-5
Tightening Torque 30 - 40 Nm 11. Remove the steering column upper mounting bolt and pull
out steering column assembly.
Installation Notice
12. Installation is reverse order of the removal.
Page 1307 of 1463

SUPPLEMENTAL RESTRAINT SYSTEM(SRS) 8B-3
CAUTIONS
Failure to follow the correct service procedure can cause air bag damage or personal injury due to unexpected air
bag deployment. Before service (removal and installation of part, check for replacement), please be weal noticed of
following items for your correct service.
1. For service, turn the ignition switch to ‘LOCK’ position and wait for 30 seconds after disconnecting the negative
battery cable.
2. If the vehicle collapsed, remove the air bag ECU first to reserve the crash records.
3, Never use other vehicles’ air bag components and replace with specified new part.
4. Never disassemble or repair the air bag module, air bag unit and wiring harness to re-use.
5. Replace the air bag module and air bag unit with new if it dropped, cracked or damaged.
6. Only qualified technicians in service shop should check or repair the air bag,
7. Before service, should be well noticed of warning labels on the vehicle.
A. Sun Visor Side
[Warning]
Pull down the sun visor and see SRS air bag
warning lamp on the head lining.
B. Head Lining
[Warning]
1 . This vehicle is equipped with air bag. Air bag is
supplemental device for the seatbelt. Fasten
your seatbelt.
2. This air bag should be replaced by authorized
supplier within replacement intervals.
3. When the ignition key is turned to ON position,
SRS warning lamp will turn on for 6 sec. and go
off. In this case, the system is normal.
For the following cases, see service manual.
- SRS warning lamp does not turn on.
- SRS warning lamp does not go off.
- SRS warning lamp continues to blink.
C. Steering Wheel Body Inner
[Warning]
Before removing the steering wheel, read service
manual first. Set the front wheels straight forward
and align the center position marks of SRS clock
spring. Improper removal or installation of the
steering wheel can damage the SRS components.D. Engine Compartment
[Warning]
This vehicle is equipped with air bag. Before
checking the engine compartment, read service
manual first. Faultuy check and service can cause
SRS air bag deployment and system defects that
can be led to severe damage.
E. Battery Cable
[Warning]
Before disconnecting the battery power, read
service manual first.
Page 1310 of 1463

8B-6 SUPPLEMENTAL RESTRAINT SYSTEM(SRS)
AIR BAG MODULE
Air bag module is installed in the pad of steering wheel center and inflator is consisted of igniter, explosives, gas
generating material and bag. When crashed, the air bag control unit sends current to the air bag module through
squib line and this current ignites as ignition energy (6mJ) momentarily igniting explosives and bag will be inflated
by nitrogen gas protecting driver at the same and then deflates.
1 Air bag Module
2 Module Housing
3 Bag
4 Module Bracket
5 Retainer Ring
6 Inflator
7 Horn Switch
8 Backing Plate
Page 1322 of 1463

8B-18 SUPPLEMENTAL RESTRAINT SYSTEM(SRS)
MAINTENANCE AND REPAIR
ON-VEHICLE SERVICE
AIR BAG MODULE
Removal & Installation Procedure
1. Remove the steering wheel rid (LH,RH) with a screwdriver.
Installation Notice
Each position mark (LH,RH) is stamped on the inner surface
of the rids.
Tightening Torque 7 - 11 Nm
3. Disconnect the connectors and remove the air bag module.
4. Installation should follow the removal procedure in the
reverse order. 2. Unscrew the bolts from both sides.
Installation Notice
Page 1324 of 1463

8B-20 SUPPLEMENTAL RESTRAINT SYSTEM(SRS)
Removal & Installation Procedure
preceding work : removal of steering wheel
1. Turn the ignition switch to “OFF” position and disconnect
the battery negative cable. Start the procedure after waiting
over 3oseconds.
2. Unscrew 3 screws from lower cover on steering column shaft
and remove the lower cover.
3. Unscrew 4 screws from clock spring and remove the clock
spring
Installation Notice
lDon’t try to repair and modify the clock spring.
lWhen aligning the neutral position, turn to clockwise until it
stops, and turn to counter clockwise until the marks are
aligned
Page 1335 of 1463

BODY WIRING SYSTEM 9A-9
44 Joint Connector.................................................... Ground
45 Door Unlock Switch
46 Front Fog Lamp Switch
47 Rear Defogger Switch
4 8 ECS Switch
49 Rear Fog Lamp Switch........................................Rear Fog Lamp
50 Digital Clock
51 Thermo Amplifier
52 Glove Box Lamp Switch
53 Air Conditioner Wiring Connetor
54 Glove Box Lamp
55 Ground 6
56 Ground 6.............................................................Gasoline E/G
57 Ground 7.............................................................Gasoline E/G
58 Wheel Speed Sensor (FR)..................................ABS 5.0 or ABD 5.0
59 O
2 Sensor............................................................E32 Gasoline E/G
60 Engine Main Wiring Connector............................Gasoline E/G with MSE ECU
61 HFM .....................................................................Gasoline E/G with HFM ECU
61-1 MSE .....................................................................Gasoline E/G with MSE ECU
62 Front Door Wiring Connector (Passenger Side)
63 Front door Wiring Connector (Passenger Side)
64 Joint Connector (B+)
65 Audio
66 Audio
67 Air Bag Wiring Connector
68 Chime Bell
6 9 Buzzer
70 Kick Down Switch.................................................Automatic Transmission
71 Diode 2................................................................Manual Transmission
72 Ground 3
73 Ground 4
74 Front Cigarette Lighter
75 Diode 3................................................................Automatic Transmission, MB
76 S/E Mode Selector Switch....................................Automatic Transmission
76-1Mode Switch........................................................Automatic Transmission
77 “B” Position Switch..............................................Automatic Transmission
78 “P” Position Switch..............................................Automatic Transmission
79 Shift Lock Solenoid Valve.....................................Automatic Transmission
8 0 TCCU
81 Ground 5.............................................................Gasoline E/G
81-1Ground 7.............................................................Diesel E/G
82 Seat Extension Wiring Connector
83 Transmission Extension Wiring Connector...........E23 & E32 Gasoline E/G with Manual Transmission
83-1 Transmission Extension Wiring Connector...........Diesel E/G with MB A/T
84 Transmission Extension Wiring Connector...........Gasoline E/G with Manual Transmission
84-1 Transmission Extension Wiring Connector...........Diesel E/G with Manual Transmission or BTRE A/T
85 Transmission Extension Wiring Connector...........E23 & E32 Gasoline E/G with A/T
85-1 Transmission Extension Wiring Connector...........Diesel E/G with BTRE A/T
86 Transfer Case Motor
87 Transfer Case Motor
88 Vehicle Speed Sensor
89 Fuel Gauge
90 Acceleration Sensor.............................................ABS 5.0
91 Seat Belt Switch (Passenger)
92 Seat Heater Switch
93 Head Lamp Leveling Device Switch.....................Leveling Device
Page 1337 of 1463

BODY WIRING SYSTEM 9A-11
ENGINE ROOM
1 Engine Room Relay Box
1.1 Main Wiring Connector
1.2 Main Wiring Connector
1.3 Main Wiring Connector........................................Gasoline E/G
1.4 Joint
1.5 Compressor, Condenser Fan Relay.....................Diesel E/G
1.6 Condenser Fan Relay 2
1.7 Air Conditioner Relay
1.8 Resistor with Diode..............................................Gasoline E/G
1.9 Front Fog Lamp Relay
1.10 Condenser Fan Relay 1
1.11 Tail Lamp Relay
1.12 Horn Relay
2 Octane Selector...................................................Gasoline E/G with HFM
3 Preheating Unit....................................................Diesel E/G
4 Preheating Timer Unit..........................................Diesel E/G
5 ECS Main Wiring Connector................................ ECS
6 Brake Leveling Fluid Sensor
7 ABD Main Wiring Connector................................ABD 5.0
7-1 ABS Main Wiring Connector................................ABD 5.0
8 ABD main Wiring Connector................................ABD 5.0
9 Engine Temperature Sensor................................Diesel E/G
10 ABS 5.0 ECU.......................................................ABS 5.0
10-1ABD 5.0 Modulator...............................................ABD 5.0
11 Front Washer Motor.............................................Diesel E/G
12 Head Lamp Relay
13 Compressor .........................................................Air Conditioner
14 Wheel Speed Sensor...........................................ABS 5.0 or ABD 5.0
Page 1338 of 1463

9A-12 BODY WIRING SYSTEM
15 LH Damper........................................................... ECS
16 Ground 1
17 Ground 2
18 Locking Hub Solenoid
19 Condenser Fan Relay.........................................Gasoline E/G
20 LH Position Lamp
21 LH Head Lamp
22 LH Head Lamp Leveling Device...........................Leveling Device
23 Thermo Switch 2..................................................Gasoline E/G with HFM
24 Thermo Switch 3..................................................Gasoline E/G with HFM & Air Conditioner
25 LH Front Fog Lamp
26 LH Horn...............................................................Black Out Driving Lamp (Domestic)
27 Condenser Fan Motor.........................................Diesel E/G
28 Black Out Driving Lamp.......................................Black Out Driving Lamp (Domestic)
29 LH Horn...............................................................Leveling Device
30 LH Condenser Fan Motor....................................Gasoline E/G with Air Conditioner
31 Thermo Switch 1..................................................Diesel E/G or Gasoline E/G with HFM
32 Resistor...............................................................Gasoline E/G with Air Conditioner
33 Thermo Switch 4..................................................Gasoline E/G with HFM & Air Conditioner
34 Ambient Censor...................................................Air Conditioner
35 RH Condenser Fan Motor....................................Gasoline E/G
36 RH Horn
37 RH Front Fog Lamp
38 RH Position Lamp
39 RH Head Lamlp
40 RH Head Lamp Leveling Device..........................Leveling Device
41 Wheeling Sensor................................................. ECS
42 Wheel Speed Sensor (FR)..................................ABS 5.0, 5.3 or ABD 5.0, 5.3
43 RH Damper.......................................................... ECS
44 Alternator Extension Connector...........................Gasoline E/G
45 Alternator .............................................................Gasoline E/G
46 Alternator Extension Joint box..............................Diesel E/G
47 Alternator Extension Connector...........................Diesel E/G
48 Ground 3
49 Fusible Link Box...................................................Gasoline E/G
49-1Fusible Link Box...................................................Diesel E/G
50 Receiver Dryer.....................................................Gasoline E/G with Air Conditioner
50-1Receiver Dryer.....................................................Diesel E/G with Air Conditioner
51 Hood Switch.........................................................Diesel E/G with Black Out Driving Lamp
52 Front Washer Motor.............................................Gasoline E/G
53 Main Wiring Connector
Page 1339 of 1463

BODY WIRING SYSTEM 9A-13
FLOOR
1 ECS Main Wiring Connector........................ ECS
2 Main Wiring Connector
3 Main Wiring Connector
4 Main Wiring Connector
5 ABD Main Wiring Connector........................ ABD
6 LH Front Door Switch
7 LH Tension Reducer
8 Ground 1
9 LH Rear Door Wiring Connector
10 Wheel Speed Sensor (RL)..................ABD, ABS
11 Damper (RL)................................................ ECS
12 LH Rear Door Switch
13 LH Rear Speaker
14 Ground 2
15 Power Socket
16 Power Antenna
17 Diode
18 LH Rear Combination Lamp
19 Tail Gate Wiring Connector
20 Tail Gate Wiring Connector21 Tail Gate Wiring Connector
22 Rear Heated
23 Luggage Lamp
2 4 ABD ECU..................................................... ABD
25 Ground 4..................................................... ABD
26 ECS ............................................................. ECS
27 Wheel Speed Sensor (RR).................ABD, ABS
28 Damper (RR)............................................... ECS
29 RH Rear Door Switch
30 RH Rear Speaker
31 Ground 3
32 RH Rear Combination Lamp
33 Trailer Connector
34 Rear Washer Motor
35 RH Tension Reducer
36 RH Front Door Switch
37 RH Rear Door Wiring Connector
38 RH Front Door Wiring Connector
39 Wheel Speed Sensor (RR).................ABD, ABS
40 Acceleration Sensor..................................... ABD