warning light SSANGYONG RODIUS 2012 Service Manual

03-18
3. CAUTIONS FOR DI ENGINE
1) Cautions for DI Engine
This chapter describes the cautions for DI engine equipped vehicle. This includes the water
separation from engine, warning lights, symptoms when engine malfunctioning, causes and
actions.
DI Engine 1.
Comparatively conventional diesel engines, DI engine controls the fuel injection and timing
electrically, delivers high power and reduces less emission.
System Safety Mode 2.
When a severe failure has been occurred in a vehicle, the system safety mode is activated to
protect the system. It reduces the driving force, restricts the engine speed (rpm) and stops
engine operation. Refer to "Diagnosis" section in this manual.
Engine CHECK Warning Lamp 3.
The Engine CHECK warning lamp on the instrument cluster comes on when the
fuel or major electronic systems of the engine are not working properly. As a result,
<009b008f008c0047008c0095008e00900095008c02c5009a004700970096009e008c009900470096009c009b0097009c009b00470094008800a00047008b008c008a0099008c0088009a008c0047009600990047009b008f008c0047008c0095008e009000
95008c00470094008800a00047009a009b0088009300930055>
Water Separator Warning Lamp 4.
When the water level inside water separator in fuel filter exceeds a certain level
(approx. 45 cc), this warning light comes on and buzzer sounds.
Also, the driving force of the vehicle decreases (torque reduction). If these
conditions occur, immediately drain the water from fuel filter.

02-218710-01
4) Door Ajar Warning
<007b008f008c0047009e00880099009500900095008e004700930090008e008f009b004700900095004700900095008b0090008a0088009b009600990047008b0090009a00970093008800a00047008a00960094008c009a0047009600950047009e008f00
8c0095004700960097008c009500900095008e004700880095>y of driver’s door,
<00970088009a009a008c0095008e008c009902c5009a0047008b009600960099005300470099008c008800990047008b0096009600990047009600990047009b008800900093008e0088009b008c0047009e008f00900093008c0047009b008f008c004700
9d008c008f0090008a0093008c0047009a0097008c008c008b> is below 6 km/h (V1).
The warning light goes off when closing the door under step 1.
The warning light blinks when the vehicle speed is over 10 km/h (V1) for more than 2 seconds
while the warning light is turned on.
The warning light blinks when a door is opened while the vehicle speed is over 10 km/h (V1)
(while the warning light is turned off).
The warning light goes off when closing the door under step 3.
The warning light comes on when the vehicle speed is below 3 km/h (V2) under step 3. 1.
2.
3.
4.
5.
6.

02-22
5) Seat Belt Warning
The seat belt warning light comes on and the chime buzzer in the ICM box sounds for 6
<009a008c008a00960095008b009a0047009e008f008c00950047009b009c0099009500900095008e0047009b008f008c00470090008e00950090009b00900096009500470092008c00a00047009b0096004702c80076007502c90047008d00990096009400
4702c80076006d006d02c9005500470070008d0047009b008f>e seat belt is fastened before
<009b009c0099009500900095008e0047009b008f008c00470090008e00950090009b00900096009500470092008c00a00047009b0096004702c80076007502c9004700970096009a0090009b00900096009500530047009b008f008c0047009e0088009900
9500900095008e004700930090008e008f009b004700900095> the indicator display blinks for 6
seconds, however, the chime buzzer does not sound.
The seat belt warning light goes off and the chime buzzer in the ICM box stops when turning
the ignition switch to “OFF” position.
The chime buzzer stops and the seat belt warning light stays on for the specified duration (6
seconds) when fastening the seat belt during the warning operation.
The seat belt warning light comes on and the chime buzzer sounds for 6 seconds again when
unfastening the seat belt during fastening operation. 1.
2.
3.
4.

02-238710-01
6) Parking Brake Warning
The parking brake warning light comes on for approx. 4 seconds (T4) when turning the ignition
<0092008c00a00047008d009900960094004702c80076006d006d02c90047009b0096004702c80076007502c9004700970096009a0090009b00900096009500470099008c008e00880099008b0093008c009a009a00470096008d0047009b008f008c004700
9d008c008f0090008a0093008c0047009a0097008c008c008b> and parking brake switch
position.
The warning light comes on when the parking brake switch is turned on while the vehicle speed
is below 10 km/h (V1).
The warning light goes off when turning off the parking brake switch under step 2.
The warning light blinks and the chime buzzer in the ICM box sounds for 2.85 seconds and
stops for 1.5 seconds when the vehicle speed is over 10 km/h (V1) for more than 2 seconds
while the parking brake switch is turned on.
The warning light goes off and the chime buzzer stops when turning off the parking brake
switch under step 4.
The warning light comes on and the chime buzzer stops when the vehicle speed goes down
below 7 km/h (V2) under step 4.
<007b008f0090009a0047008d009c0095008a009b00900096009500470090009a004700950096009b00470088009d008800900093008800890093008c0047009e008f008c00950047009b008f008c00470090008e00950090009b0090009600950047009200
8c00a000470090009a0047009b009c00990095008c008b0047>to “OFF” position. 1.
2.
3.
4.
5.
6.
7.

02-58810-03
2. OPERATION
1) Air Bag
▶Air bag inflates when:
<0070009500470099008c009a009700960095009a008c0047009b0096004700880047009a008c009d008c0099008c0047008d009900960095009b0088009300470090009400970088008a009b00530047009b008f008c0047008b00990090009d008c009902
c5009a004700880095008b0047008d009900960095009b0047>passenger’s air bags deploy
at the same time to supplement the seat belts to prevent or reduce any personal injuries. ·


▶Air bag can inflate when:
Underbody impact from the road surface; impact against the curb at a very high speed;
dropping impact onto the road surface with a large angle ·
▶Air bag does not inflate when:
Rollover, side impact or rear impact
If the severity of impact to the vehicle is not significant and the seat belts are enough to
protect occupants. ·
·
Air bag seldom inflates when: ▶
Oblique impact, rollover
Weak impact in which the sensor is unable to detect (under the inflation requirements)
Impact against narrow objects such as a utility pole or a tree
The vehicle falls into a drainage or a puddle
The front of the vehicle crashes into a high impact point yyvehicle such as a truck
Impact on the hood by falling stones
The air bag warning light is on
<00740096008b008c00990088009b008c0047009600990047009a008c009d008c0099008c00470090009400970088008a009b0047009b00960047009b008f008c004700940090008b008b0093008c00470096008d0047009b008f008c0047009d008c008f00
90008a0093008c004700890096008b00a002c5009a0047009a>ide structure. In that case,
only the side curtain air bags deploy. ·
·
·
·
·
·
·
·