key SUBARU FORESTER 2003 SG / 2.G Service Manual

11 - 4
Maintenance and service
the materials in the vehicle may be hazardous if
improperly used or handled, for example, bat-
tery acid.
Your vehicle should only be serviced by per-
sons fully competent to do so. Serious person-
al injury may result to persons not experienced
in servicing vehicles. Always use the proper tools and make certain
that they are well maintained. Never get under the vehicle supported only
by a jack. Always use a safety stands to sup-
port the vehicle. Never keep the engine running in a poorly
ventilated area, such as a garage or other
closed areas. Do not smoke or allow open flames around
the fuel or battery. This will cause a fire. Because the fuel system is under pressure,
replacement of the fuel filter should be per-
formed only by your SUBARU dealer. Wear adequate eye protection to guard
against getting oil or fluids in your eyes. If
something does get in your eyes, thoroughly
wash them out with clean water. Do not tamper with the wiring of the SRS air-
bag system or seatbelt pretensioner system, or
attempt to take its connectors apart, as that may activate the system or it can render it inop-
erative. The wiring and connectors of these
systems are yellow for easy identification. NEV-
ER use a circuit tester for these wiring.
If your SRS airbag or seatbelt pretensioner
needs service, consult your nearest SUBARU
dealer.
Before checking or servicing in the en-
gine compartment
Always stop the engine and set the parking
brake firmly to prevent the vehicle from mov-
ing. Always let the engine cool down. Engine
parts become very hot when the engine is run-
ning and remain hot for some time after the en-
gine is stopped. Do not spill engine oil, engine coolant, brake
fluid or any other fluid on hot engine compo-
nents. This may cause a fire. Always remove the key from the ignition
switch. When the ignition switch is in the “ON”
position, the cooling fan may operate suddenly

12-6
Specifications
Fuses and circuits
Fuse panel located behind the coin tray
1
23456
78 91011
12
13 14 15
16 17 18 19
20 21 22 23
HSC001BB
Fuse panelFuse ratingCircuit
115AHeater fan
215AHeater fan
315APower door lock
Remote keyless entry
420ACigarette lighter
Remote controlled rear
view mirrors
510ATail light
Parking light
615ASRS airbag
715AFog light
820AABS solenoid
915ARadio
10Empty
1115AEngine ignition system
SRS airbag
AT control system

14-2
Index
A
ABS ................................................................ 7-22
Warning light ...................................... 3-12, 7-23
Accessory power outlet .................................. 6-9
Active head restraint ....................................... 1-7
Air cleaner element ........................................ 11-19
Air filtration system ......................................... 4-18
Aluminum wheel ............................................. 11-44
Aluminum wheel Cleaning .............................. 10-3
Ambient temperature gauge ........................... 3-9
Antenna system ............................................. 5-2
Anti-lock brake warning light (ABS) ........ 3-12, 7-23
Arming the system .......................................... 2-14
Ashtray ........................................................... 6-14
Audio set ........................................................ 5-3
Auto-dimming mirror/compass ....................... 3-29
Automatic/Emergency Locking Retractor
(A/ELR) ....................................................... 1-14
Automatic climate control system .................... 4-10
Automatic transmission .................................. 7-14 Capacities .................................................. 12-4
Fluid ........................................................... 11-24
Selector lever ............................................. 7-15
Shift lock release ....................................... 7-18
Temperature warning (AT OIL TEMP) ....... 3-12 B
Battery ............................................................. 11-49
Jump starting .............................................. 9-9
Replacing (remote keyless entry) . .............. 2-9
Brake
Booster ....................................................... 11-32
Fluid ............................................................ 11-30
Pad and lining ............................................. 11-36
Parking ....................................................... 11-37
Pedal .......................................................... 11-33
System ....................................................... 7-21
Warning light .............................................. 3-13
Braking ............................................................ 7-21
Braking tips ..................................................... 7-21
Brake pedal ..................................................... 11-33 Free play .................................................... 11-33
Reserve distance ........................................ 11-33
Breaking-in of new brake pads and linings ..... 11-36 Bulb Chart ........................................................... 12-9
Replacing ................................................... 11-54
C
Capacities ....................................................... 12-4
Cargo area cover (if equipped) ....................... 6-16
Cargo area light ............................................... 6-2
Cargo tie-down hooks ..................................... 6-18

14-3
Index
Center console ............................................... 6-5
Charge warning light ...................................... 3-11
CHECK ENGINE warning light/Malfunction
indicator lamp ............................................. 3-10
Child restraint systems ................................... 1-30 Installation with seatbelt ............................ 1-33
Top tether anchorages .............................. 1-38
Child safety locks ........................................... 2-20
Chime Key ............................................................ 3-3
Seat belt .............................................. 1-15, 3-9
Cigarette lighter socket ................................... 6-11
Clock .............................................................. 3-16
Clutch (MT)
Fluid ........................................................... 11-31
Pedal ......................................................... 11-34
Coat hook ....................................................... 6-16
Coil tray .......................................................... 6-7
Convenience net ............................................ 6-7
Coolant ........................................................... 11-15
Cooling system ............................................... 11-14
Corrosion protection ....................................... 10-4
Cruise control ................................................. 7-31
Cruise control indicator light ........................... 3-15
Cup holders ..................................................... 6-8 D
Dashboard storage compartment ................... 6-6
Daytime running light system ......................... 3-19
Differential gear oil
Front (AT vehicles) .................................... 11-26
Rear ........................................................... 11-27
Dimensions ..................................................... 12-2
Disarming the system ..................................... 2-16
Disc brake pad wear warning indicators ......... 7-22
Dome light ...................................................... 6-2
Door locks ...................................................... 2-3
Door open warning light ................................. 3-14
Drive belt ........................................................ 11-21
Driving in foreign country ................................ 8-5
Driving tips............................................... 7-13, 8-6 E
Electronic brake force distribution (EBD) system 7-25
Emergency locking retractor (ELR) ................ 1-14
Engine Compartment overview .............................. 11-8
Exhaust gas (carbon monoxide) ................ 8-3
Hood .......................................................... 11-5
Oil .............................................................. 11-9
Coolant ...................................................... 11-15
Overheating ............................................... 9-12
Starting ...................................................... 7-9

14-5
Index
J
Jack and jack handle ...................................... 9-19
Jump starting .................................................. 9-9 K
Key interlock release (AT vehicles) ................ 3-4
Keys ............................................................... 2-2 Key
Number ...................................................... 2-2
Reminder chime ........................................ 3-3
L
Leather seat materials .................................... 10-5
Light control switch ......................................... 3-17
Limited slip differential (LSD) .......................... 7-20
Loading your vehicle ...................................... 8-14
Lower and tether anchorages ......................... 1-35
Low fuel warning light ..................................... 3-14
LSD (limited slip differential) ........................... 7-20
Lumbar support .............................................. 1-5 M
Main fuse ........................................................ 11-53
Maintenance Precautions ................................................ 11-3
Schedule .................................................... 11-3 Seatbelt ..................................................... 1-26
Tools .......................................................... 9-19
Malfunction indicator lamp .............................. 3-10
Manual climate control system ........................ 4-4
Manual transmission ...................................... 7-11 Oil .............................................................. 11-22
Map light ......................................................... 6-3
Maximum load limits ....................................... 8-25
Meters and gears ........................................... 3-5
Mirrors ............................................................ 3-29
Moonroof ................................................ 2-26, 9-18 N
New vehicle break-in driving .......................... 8-2 O
Odometer/Trip meter ...................................... 3-5
Off road driving ............................................... 8-7
Oil pressure warning light ............................... 3-11
Oil filter ........................................................... 11-10
Oil level
Engine ....................................................... 11-9
Manual transmission .................................. 11-22
Rear differential ......................................... 11-27
Outside mirrors ............................................... 3-31
Overhead console .......................................... 6-6

14-6
Index
P
Parking brake ......................................... 7-27, 11-37
Stroke ........................................................ 11-37
Parking light switch ......................................... 3-21
Parking your vehicle ....................................... 7-27
Periodic inspections ....................................... 8-5Power Door locking switches ................................ 2-5
Steering ..................................................... 7-20
Steering fluid level ..................................... 11-29
Windows .................................................... 2-21
R
Rear Combination lights ..................................... 11-61
Differential gear oil level ............................ 11-27
Gate ................................................... 2-24, 9-17
Seats ......................................................... 1-9
Viscous limited slip differential (LSD) ........ 7-20
Rear Window Defogger switch ......................................... 3-27
Wiper and washer switch ........................... 3-25
Remote keyless entry system ........................ 2-6
Replacing Air cleaner element .................................... 11-19
Battery (remote keyless entry) ................... 2-9
Bulbs ......................................................... 11-54 Transmitters ............................................... 2-10
Rocking the vehicle ......................................... 8-13
Roof rail and crossbar ..................................... 8-17 S
Seatbelts ......................................................... 1-12
Seatbelt Maintenance ............................................... 1-26
Pretensioners ............................................. 1-27
Safety tips ................................................... 1-12
Warning light and chime ............................. 3-9
Seats
Fabric ......................................................... 10-5
Heater ......................................................... 1-8
Seat height adjustment (driver’s side) ............. 1-5
Security system ............................................... 2-14
Selector lever (AT vehicles) ............................ 7-15
Self-leveling rear suspension .......................... 7-34
Shift lock release ............................................. 7-18
Shift position indicator ..................................... 3-15
Shopping bag hook ......................................... 6-18
Snow tires ....................................................... 8-12
Snowy and icy roads ....................................... 8-11
Spark plugs ..................................................... 11-20
Specifications .................................................. 12-2
Speedometer ................................................... 3-5
SRS airbags .................................................... 1-39