belt SUBARU OUTBACK 2004 4.G Owners Manual

11 - 4
2Maintenance and service
the materials in the vehicle may be hazardous if
improperly used or handled, for example, bat-tery acid. y
Your vehicle should only be serviced by per-
sons fully competent to do so. Serious person-
al injury may result to persons not experienced
in servicing vehicles. y Always use the proper tools and make certain
that they are well maintained. y Never get under the vehicle supported only
by a jack. Always use a safety stands to sup-
port the vehicle. y Never keep the engine running in a poorly
ventilated area, such as a garage or other
closed areas. y Do not smoke or allow open flames around
the fuel or battery. This will cause a fire. y Because the fuel system is under pressure,
replacement of the fuel filter should be per-
formed only by your SUBARU dealer.y Wear adequate eye protection to guard
against getting oil or fluids in your eyes. If
something does get in your eyes, thoroughly
wash them out with clean water. y Do not tamper with the wiring of the SRS air-
bag system or seatbelt pretensioner system, or
attempt to take its connectors apart, as that may activate the system or it can render it inop-
erative. The wiring and connectors of these
systems are yellow for easy identification. NEV-
ER use a circuit tester for these wiring.
If your SRS airbag or seatbelt pretensioner
needs service, consult your nearest SUBARU
dealer.
„ Before checking or servicing in the en-
gine compartment
yAlways stop the engine and set the parking
brake firmly to prevent the vehicle from mov-
ing. y Always let the engine cool down. Engine
parts become very hot when the engine is run-
ning and remain hot for some time after the en-
gine is stopped.y Do not spill engine oil, engine coolant, brake
fluid or any other fluid on hot engine compo-
nents. This may cause a fire.y Always remove the key from the ignition
switch. When the ignition switch is in the “ON”
position, the cooling fan may operate suddenly

11 - 5
2Maintenance and service
– CONTINUED –
even when the engine is stopped.
„ When you do checking or servicing in
the engine compartment while the en-
gine is running
A running engine can be dangerous. Keep your
fingers, hands, clothing, hair and tools away
from the cooling fan, belts and any other mov-
ing engine parts. Removing rings, watches and
ties is advisable.
Engine hood
To open the hood:
1. If the wiper blades are lifted off the windshield, re-
turn them to their original positions.
2. Pull the hood release knob under the instrument
panel.
UBB001BA

11 - 2 6
2Maintenance and service
Drive belts
The alternator, power steering pump, and air condi-
tioner compressor depend on drive belts. Satisfactory
performance requires that belt tension be correct. „
2.5 liter models
1) Power steering pump pulley
2) Air conditioner compressor pulley
3) Crank pulley in (mm)
To check belt tension, place a straightedge (ruler)
across two adjacent pulleys and apply a force of 22 lbs
(98 N, 10 kg) midway between the pulleys by using a
spring scale. Belt deflection should be the amount
specified. „ 3.0 liter models
It is unnecessary to check belt tension periodically be-
cause your engine is equipped with an automatic belt
tension adjuster. However, replacement of the belt
should be done according to the maintenance sched-
ule in the “Warranty and Maintenance Booklet”. Con-
sult your SUBARU dealer for replacement.
If a belt is loose, cracked, or worn, contact your SUBARU dealer.
2
3 A
B
1
HSB033BB
Deflection
New belt Used belt
A 0.28 – 0.35 (7.0 – 9.0) 0.35 – 0.43 (9.0 – 11.0)
B 0.30 – 0.33 (7.5 – 8.5) 0.35 – 0.40 (9.0 – 10.0)

11 -4 9
2Maintenance and service
– CONTINUED –
shown on the tire placard.
Using tires of a non-specified size detracts from con-
trollability, ride comfort, braking performance, speed-
ometer accuracy and odometer accuracy. It also cre-
ates incorrect body-to-tire clearances and inappropri-
ately changes the vehicle’s ground clearance.
All four tires must be the same in terms of manufactur-
er, brand (tread pattern), construction, and size. You
are advised to replace the tires with new ones that are
identical to those fitted as standard equipment.
For safe vehicle operation, SUBARU recommends re-
placing all four tires at the same time.
yAll four tires must be the same in terms of
manufacturer, brand (tread pattern), construc-
tion, degree of wear, speed symbol, load index
and size. Mixing tires of different types, sizes or
degrees of wear can result in damage to the ve-
hicle’s power train. Use of different types or siz-
es of tires can also dangerously reduce control-
lability and braking performance and can lead
to an accident. y Use only radial tires. Do not use radial tires
together with belted bias tires and/or bias-ply tires. Doing so can dangerously reduce control-
lability, resulting in an accident.
„ Wheel replacement
When replacing wheels due, for example, to damage,
make sure the replacement wheels match the specifi-
cations of the wheels that are fitted as standard equip-
ment. Replacement wheels are available from
SUBARU dealers.
Use only those wheels that are specified for
your vehicle. Wheels not meeting specifica-
tions could interfere with brake caliper opera-
tion and may cause the tires to rub against the
wheel well housing during turns. The resulting
loss of vehicle control could lead to an acci-
dent.

13-4
Consumer information and Reporting safety defects
(2) Tire Size
(3) Tire Type Code (4) Date of Manufacture
The first two figures identify the week, starting
with “01” to represent the first full week of the cal-
endar year; the second two figures represent the
year. For example, 0101 means the 1st week of
2001. T
Other markings
The following makings are also placed on the
sidewall. V Maximum permissible inflation pressure
The maximum cold inflation pressure to which
this tire may be inflated. For example, “300 kpa
(44 PSI) MAX. PRESS” V Maximum load rating
The load rating at the maximum permissible
weight load for this tire. For example, “MAX.
LOAD 730 kg (1609 LBS) @ 300 kpa (44 PSI) MAX. PRESS.”
Maximum load rating applies only to the
tire, not to the vehicle. Putting a load rated
tire on any car does not mean the car can
be loaded up to the tire’s rated load.
V Construction type
Applicable construction of this tire.
For example, “TUBELESS STEEL BELTED RA-
DIAL” V Construction
The generic name of each cord material used in
the plies (both sidewall and tread area) of this
tire.
For example, “PLIES: TREAD 2 STEEL + 2
POLYESTER + 1 NYLON SIDEWALL 2 POLY-
ESTER” V Uniform Tire Quality Grading (UTQG)
For details, refer to “Uniform tire quality grading
standards” in this chapter.

14-3
Index
Center
Console ..................................................................... 6-6
Ventilators ................................................................. 4-2
Changing
Flat tire ....................................................................... 9-5
Oil and oil filter ........................................................ 11-12
Charge warning light .................................................. 3-12
CHECK ENGINE warning light/ Malfunction indicator lamp ..................................3-11
Checking
Brake pedal free play ........................................... 11-39
Brake pedal reserve distance ...........................11-40
Clutch function ........................................................ 11-40
Clutch pedal free play .......................................... 11-41
Engine oil level ....................................................... 11-11
Fluid level ....................... 11-28, 11-35, 11-36, 11-38
Gear oil level ................................ 11-27, 11-30, 11-32
Child restraint systems ............................................... 1-37
Installation with seatbelt .....................................1-41
Lower and tether anchorages ..........................1-48
Child safety .................................................................... 5
Locks .......................................................................... 2-22
Chime
Key .............................................................................. 3-5
Seatbelt ........................................................... 1-20, 3-10
Cigarette lighter socket ............................................. 6-10Cleaning
Aluminum wheels .................................................. 10-4
I n te rior .. ... .. ... .. ... ... .. ... ... .. ... .. ... ... .. ... ... .. ... .. ... ... .. ... ... .. .. 10 -7
Ventilator grille ........................................................ 4-19
Climate control system Manual ....................................................................... 4-5
Automatic ................................................................. 4-11
Clock ................................................................................. 3-18
Clutch fluid ...................................................................... 11-38
Clutch pedal ................................................................... 11-40
Coat hook ....................................................................... 6-20
Coin compartment ....................................................... 6-7
Convenience hook ...................................................... 6-20
Convenient tie-down hooks .....................................6-24
Cooling system ............................................................. 11-17
Corrosion protection ......................................... 8-13, 10-5
Cruise control ................................................................ 7-42
Set indicator light ................................................... 3-18
Cup holder ...................................................................... 6-8
D
Daytime running light system .................................3-21
Differential gear oil Front ............................................................................ 11-30
Rear ............................................................................ 11-32
Dimensions .................................................................... 12-2
Disarming the system ................................................ 2-17

14-4
Index
Disc brake pad wear warning indicators
............7-31
Dome light ............................................................ 6-2, 11-76
Door locks ....................................................................... 2-3
Door open warning lights .........................................3-15
Drive belts ....................................................................... 11-26
Driving Drinking ..................................................................... 7
Drugs .......................................................................... 7
Foreign countries .................................................. 8-6
Car/Mobile phone .................................................. 8
Pets ............................................................................. 9
Tips ............................................. 7-14, 7-19, 7-28, 8-6
Tired or sleepy ........................................................ 8
Snowy and icy roads ............................................ 8-12
E
Electrical system .......................................................... 12-3
Emergency Locking Retractor (ELR) ..................1-19
Engine
Compartment overview .......................................11-8
Coolant ...................................................................... 11-18
Exhaust gas (Carbon monoxide) ....................6, 8-3
Hood ........................................................................... 11-5
Oil ................................................................................. 11-11
Overheating ............................................................. 9-19
Starting ...................................................................... 7-10
Stopping .................................................................... 7-12Exterior care
................................................................... 10-2
F
Flat tires ............................................................................ 9-5
Floor mat .......................................................................... 6-21
Fluid level
Automatic transmission .......................................11-28
Brake ... .. ... .. ... ... .. ... .. ... ... .. ... ... .. ... .. ... ... .. ... ... .. ... .. ... ... .. .. 1 1 -3 6
Clutch .......................................................................... 11-38
Power steering ........................................................ 11-35
Fog light switch ............................................................. 3-24
Folding down the rear seat .......................................1-14
Front Differential gear oil ................................................. 11-30
Fog light ..................................................................... 11-69
Seatbelt pretensioners ........................................1-34
Seats ........................................................................... 1-2
Turn signal light, parking light and
marker light ............................................................ 11-69
Front-wheel drive warning light ..............................3-15
Fuel .................................................................................... 7-2
Economy hints ......................................................... 8-2
Filler lid and cap ..................................................... 7-4
Gauge ......................................................................... 3-8
Requirements .......................................................... 7-2
Fuses ................................................................................. 11-59
Fuses and circuits ........................................................ 12-6

14-5
Index
G
GAWR (Gross Axle Weight Rating)
.....................8-19
Glove box ........................................................................ 6-6
GVWR (Gross Vehicle Weight Rating ) .............8-19
H
Hazard warning flasher ............................................. 3-6
Headlights ......................................................... 3-19, 11-65
Headrest adjustment (Wagon) ..............................1-13
Head restraint adjustment (Front) .......................1-7
Heater operation .......................................................... 4-7
High beam indicator light ..........................................3-18
High mount stop light ................................................. 11-79
Horn ................................................................................... 3-36
Hose and connections ............................................... 11-18
IIgnition switch ..... ... .. ... .. ... ... .. ... .. ... ... .. ... ... .. ... .. ... ... .. ... ... . 3-3
Illuminated entry ........................................................... 2-9
Illumination brightness control ...............................3-22
Indicator light
High beam ................................................................ 3-18
Selector lever position ......................................... 3-17
Turn signal ................................................................ 3-17
Inside mirror ................................................................... 3-31
Internal trunk lid release handle ............................2-28J
Jack and jack handle
................................................. 9-32
Jump starting ................................................................. 9-15
KKey Interlock release .................................................... 3-5
Number ...................................................................... 2-2
Reminder chime ..................................................... 3-5
Keys .................................................................................. 2-2
LLe ath er s e at materi als ... ... .. ... ... .. ... ... .. ... .. ... ... .. ... ... .. .. 10 -7
Light control switch ..................................................... 3-19
Limited slip differential (LSD) .................................7-29
Loading your vehicle .................................................. 8-17
LSD (Limited slip differential) .................................7-29
Luggage cover .............................................................. 6-22
M
Main fuse ........................................................................ 11-61
Maintenance Precautions .............................................................. 11-3
Schedule ................................................................... 11-3
Seatbelt ..................................................................... 1-31
Tools ........................................................................... 9-31

14-7
Index
Recommended
Automatic transmission fluid .............................11-30
Brake fluid ................................................................. 11-37
Clutch fluid ................................................................ 11-38
OIL grade and viscosity .........11-15, 11-16, 11-27
11-31, 11-34
Power steering fluid .............................................. 11-35
Spark plugs .............................................................. 11-25
Remote keyless entry system ................................2-7
Replacement
Brake pad and lining ............................................ 11-41
Wiper blades ........................................................... 11-52
Replacing
Air cleaner element ............................................... 11-22
Battery (remote keyless entry system) .........2-10
Lost transmitters (keyless entry system) .....2-11
Replacing bulbs ............................................................ 11-63
Dome light ................................................................ 11-76
Front fog light .......................................................... 11-69
Front turn signal light ........................................... 11-69
Headlight ................................................................... 11-65
High mount stop light ........................................... 11-79
License plate light ................................................. 11-76
Luggage compartment light ..............................11-76
Map light .................................................................... 11-76
Parking light ............................................................. 11-69
Rear combination light ........................................11-71Trunk light
................................................................. 11-79
Rocking the vehicle .................................................... 8-16
Roof rail and crossbar ............................................... 8-20
S Seat Fabric
... ... .. ... .. ... ... .. ... ... .. ... .. ... ... .. ... ... .. ... .. ... ... .. ... ... .. .. 10 -7
Heater ........................................................................ 1-9
Seatbelt ............................................................................ 4
Maintenance ............................................................ 1-31
Pretensioners .......................................................... 1-34
Safety tips ................................................................. 1-18
Warning light and chime ...........................1-20, 3-10
Seatbelts ......................................................................... 1-18
Security system ............................................................ 2-15
Selector lever ...................................................... 7-16, 7-22
Position indicator ......................................................... 3-17
Shift lock release ............................................... 7-20, 7-28
Snow tires ....................................................................... 8-14
Sounding a panic alarm ............................................ 2-9
Spark plugs .................................................................... 11-25
Specifications ................................................................ 12-2
Speedometer ................................................................. 3-7
SRS airbag (Supplemental Restraint
Syst em a irbag) ... .. ... ... .. ... .. ... ... .. ... ... .. ... .. ... ... .. ... ... . 4, 1-5 7
SRS airbag system warning light ..........................3-10
S R S fr on tal a ir ba g ... ... ... .. ... .. ... ... .. ... ... .. ... .. ... ... .. ... ... .. .. 1-62