air conditioning TATA SAFARI 2015 Owners Manual

51
COMFORT AND CONVENIENCE
• •• •
•Air conditioning and heating Air conditioning and heatingAir conditioning and heating Air conditioning and heating
Air conditioning and heating
• •• •
•Front windshield and door glass demister Front windshield and door glass demisterFront windshield and door glass demister Front windshield and door glass demister
Front windshield and door glass demister
• •• •
•Power windows Power windowsPower windows Power windows
Power windows
• •• •
•Front seat Front seatFront seat Front seat
Front seat
• •• •
•Headrestraint HeadrestraintHeadrestraint Headrestraint
Headrestraint
• •• •
•Middle seat Middle seatMiddle seat Middle seat
Middle seat
• •• •
•Armrest cum cup holder Armrest cum cup holderArmrest cum cup holder Armrest cum cup holder
Armrest cum cup holder
• •• •
•Jump seats (if fitted) Jump seats (if fitted)Jump seats (if fitted) Jump seats (if fitted)
Jump seats (if fitted)
• •• •
•Jack & tools Jack & toolsJack & tools Jack & tools
Jack & tools
• •• •
•Motorised rear view mirrors Motorised rear view mirrorsMotorised rear view mirrors Motorised rear view mirrors
Motorised rear view mirrors
• •• •
•Cigarette lighter and ash tray Cigarette lighter and ash trayCigarette lighter and ash tray Cigarette lighter and ash tray
Cigarette lighter and ash tray
• •• •
•Fuel filler flap Fuel filler flapFuel filler flap Fuel filler flap
Fuel filler flap
• •• •
•M MM M
M
echanic echanicechanic echanic
echanic
ally Op ally Opally Op ally Op
ally Op
er erer er
er
a aa a
a
t tt t
t
ed F ed Fed F ed F
ed F
uel uel uel uel
uel
T TT T
T
ank F ank Fank F ank F
ank F
lap laplap lap
lap
• •• •
•Glove box Glove boxGlove box Glove box
Glove box
• •• •
•Inside rear view mirror Inside rear view mirrorInside rear view mirror Inside rear view mirror
Inside rear view mirror
• •• •
•Sun visors Sun visorsSun visors Sun visors
Sun visors
• •• •
•Interior roof lights Interior roof lightsInterior roof lights Interior roof lights
Interior roof lights
• •• •
•Reverse guiding system Reverse guiding systemReverse guiding system Reverse guiding system
Reverse guiding system
• •• •
•Analog Clock Analog ClockAnalog Clock Analog Clock
Analog Clock
• •• •
•Music System Music SystemMusic System Music System
Music System
• •• •
•MP3 / DVD Player MP3 / DVD PlayerMP3 / DVD Player MP3 / DVD Player
MP3 / DVD Player
• •• •
•T TT T
T
ail Lamp ail Lampail Lamp ail Lamp
ail Lamp
• •• •
•High Mounted Stop Lamp High Mounted Stop LampHigh Mounted Stop Lamp High Mounted Stop Lamp
High Mounted Stop Lamp
This section gives you information on the different comfort
and convenience features provided in your vehicle.
There are many features as listed alongside in TATA SAFARI.
To get the maximum benefit from these features, please
read information in this section.
ProCarManuals.com

52
COMFORT AND CONVENIENCEAIR C AIR CAIR C AIR C
AIR C
ONDITIONING / HEA ONDITIONING / HEAONDITIONING / HEA ONDITIONING / HEA
ONDITIONING / HEA
TING TINGTING TING
TING
Air Conditioning / Heating Air Conditioning / HeatingAir Conditioning / Heating Air Conditioning / Heating
Air Conditioning / Heating
Your vehicle is fitted with heating and air conditioning system. The
controls are provided on dash board. For rear seat A.C. comfort direct
middle vents on the dash board to rear middle seat. The system controls
can be adjusted to mix air into various combinations. The air flow for
different locations is controlled by air flow direction control knob fitted
on RH side of A.C. control panel. The air flow switch has five positions
for air flow direction.
Face position -
Air flows to upper parts of body
Face / foot position -
Air flows to body and foot
Foot Position -
Air flows to foot only
Air to foot and windscreen -
recommended for clearing mist on
windscreen
Air to windscreen -
recommended for
clearing heavy fog or snow
A.C. Control Switches on Central Console A.C. Control Switches on Central ConsoleA.C. Control Switches on Central Console A.C. Control Switches on Central Console
A.C. Control Switches on Central Console
A AA A
A
B BB B
B
Air flow Direction
switchAir Temperature
switchBlower Switch
A. A.A. A.
A. Air recirculation switch
B. B.B. B.
B. Rear A.C. ON/OFF Switch
ProCarManuals.com

103
MAINTENANCE
• •• •
•Engine Compartment Engine CompartmentEngine Compartment Engine Compartment
Engine Compartment
• •• •
•Air filter Air filterAir filter Air filter
Air filter
• •• •
•Cooling system Cooling systemCooling system Cooling system
Cooling system
• •• •
•Engine oil & oil filter Engine oil & oil filterEngine oil & oil filter Engine oil & oil filter
Engine oil & oil filter
• •• •
•Changing fuel filter Changing fuel filterChanging fuel filter Changing fuel filter
Changing fuel filter
• •• •
•Changing gear box oil Changing gear box oilChanging gear box oil Changing gear box oil
Changing gear box oil
• •• •
•Changing transfer case oil Changing transfer case oilChanging transfer case oil Changing transfer case oil
Changing transfer case oil
• •• •
•Changing front axle & rear axle oil Changing front axle & rear axle oilChanging front axle & rear axle oil Changing front axle & rear axle oil
Changing front axle & rear axle oil
• •• •
•Head lamp & head lamp focus adjustment Head lamp & head lamp focus adjustmentHead lamp & head lamp focus adjustment Head lamp & head lamp focus adjustment
Head lamp & head lamp focus adjustment
• •• •
•Clutch & brake fluid Clutch & brake fluidClutch & brake fluid Clutch & brake fluid
Clutch & brake fluid
• •• •
•Power steering Power steeringPower steering Power steering
Power steering
• •• •
•L LL L
L
CR CRCR CR
CR
V (if fitt V (if fittV (if fitt V (if fitt
V (if fitt
ed) ed)ed) ed)
ed)
• •• •
•Battery BatteryBattery Battery
Battery
• •• •
•Starting the engine with jump leads Starting the engine with jump leadsStarting the engine with jump leads Starting the engine with jump leads
Starting the engine with jump leads
• •• •
•Wheels & tyres Wheels & tyresWheels & tyres Wheels & tyres
Wheels & tyres
• •• •
•V VV V
V
ehicle c ehicle cehicle c ehicle c
ehicle c
ar arar ar
ar
e ee e
e
• •• •
•Fuses & Relays Fuses & RelaysFuses & Relays Fuses & Relays
Fuses & Relays
• •• •
•Catalytic Converter Catalytic ConverterCatalytic Converter Catalytic Converter
Catalytic Converter
• •• •
•EGR system EGR systemEGR system EGR system
EGR system
• •• •
•T TT T
T
urb urburb urb
urb
o oo o
o
char charchar char
char
ger gerger ger
ger
• •• •
•Air Conditioning Air ConditioningAir Conditioning Air Conditioning
Air Conditioning
• •• •
•Belts tension Belts tensionBelts tension Belts tension
Belts tension
Your TATA SAFARI is designed to give you long trouble free service for
thousands of kilometres/miles. However with proper maintenance
care you can get optimum performance from your vehicle. We have
indicated some of the important maintenance operations to be
carried out on the vehicle. Please read the procedure carefully and
get it attended at Authorised Workshop.
ProCarManuals.com

134
AIR CONDITIONING AIR CONDITIONING AIR CONDITIONING AIR CONDITIONING
AIR CONDITIONING
Air Conditioning Air ConditioningAir Conditioning Air Conditioning
Air Conditioning
The Air Conditioning is a sealed system. Any major maintenance
should be done by Authorised Workshop.
There are couple of things which can be done by you to ensure proper
working of Air conditioning / Heating.
Periodically check the engine’s radiator and air conditioning
condensers for leaves, insects and dirt stuck in front surface.
These block the air flow and reduce the cooling efficiency. Use a light
water spray from a hose or a soft brush to remove them.
NO NONO NO
NO
TICE TICETICE TICE
TICE
Use only low pressure spray or soft bristle brush to clean condenser
and radiator fins.
Run the air conditioning at least once a week during winter season.
Run it at least for ten minutes with vehicle at steady speed and engine
at normal operating condition. This circulates lubrication oil in the
compressor.
For any complaint on A.C. and Heating get it attended at Authorised
Workshop.
NO NONO NO
NO
TICE TICETICE TICE
TICE
The system is charged with R 134 (a) - ‘Non C.F.C.’ refrigerant. Do
not top up with any other refrigerant.
M A I N T E N A N C E
ProCarManuals.com

142
SR. NO. SR. NO.SR. NO. SR. NO.
SR. NO.
PROBLEM OBSERVED PROBLEM OBSERVEDPROBLEM OBSERVED PROBLEM OBSERVED
PROBLEM OBSERVED
PROBABLE CAUSE PROBABLE CAUSEPROBABLE CAUSE PROBABLE CAUSE
PROBABLE CAUSE
A AA A
A
CTION CTION CTION CTION
CTION
T TT T
T
O BE O BE O BE O BE
O BE
T TT T
T
AKEN AKENAKEN AKEN
AKEN
AIR CONDITIONING AIR CONDITIONINGAIR CONDITIONING AIR CONDITIONING
AIR CONDITIONING
1. Fan motor does not operate Blown fuse • Replace fuse and correct any
wiring short
Faulty connection • Properly connect poor
connections
Faulty motor •Replace motor if no conductance
Faulty or poor •Replace resistor block if defective
connection at resistor
Faulty fan switch • Replace switch
2. Motor operates but air flowObstruction at •Clean evaporator
is minimumevaporator inlet
Air leak • Correctly seal
Faulty thermostat •Adjust or replace thermostat
3. Insufficient cooling, Air flowIncorrect refrigerant quantity or •Get the defect rectified at
normal and compressordefect in system aggregates nearest authorised service
operatingcentre
PRELIMINAR PRELIMINARPRELIMINAR PRELIMINAR
PRELIMINAR
Y Y Y Y
Y
TR TRTR TR
TR
OUBLE SHOO OUBLE SHOOOUBLE SHOO OUBLE SHOO
OUBLE SHOO
TING TINGTING TING
TINGPRELIMINARY TROUBLE SHOOTING
ProCarManuals.com

154
AC ACAC AC
AC
Air Conditioning Air ConditioningAir Conditioning Air Conditioning
Air Conditioning
ACC ACCACC ACC
ACC
Accessories AccessoriesAccessories Accessories
Accessories
Amp AmpAmp Amp
Amp
Ampere AmpereAmpere Ampere
Ampere
Br BrBr Br
Br
Branch BranchBranch Branch
Branch
Brg BrgBrg Brg
Brg
Bearing BearingBearing Bearing
Bearing
cc cccc cc
cc
Cubic Centimeters Cubic CentimetersCubic Centimeters Cubic Centimeters
Cubic Centimeters
Cm CmCm Cm
Cm
Centimeter CentimeterCentimeter Centimeter
Centimeter
Dia DiaDia Dia
Dia
Diameter DiameterDiameter Diameter
Diameter
EGR EGREGR EGR
EGR
Exhaust Gas Recirculation Exhaust Gas RecirculationExhaust Gas Recirculation Exhaust Gas Recirculation
Exhaust Gas Recirculation
F FF F
F
A AA A
A
W
WW W
W
Front Axle Weight Front Axle WeightFront Axle Weight Front Axle Weight
Front Axle Weight
Fig FigFig Fig
Fig
Figure FigureFigure Figure
Figure
FIP FIPFIP FIP
FIP
Fuel Injection Pump Fuel Injection PumpFuel Injection Pump Fuel Injection Pump
Fuel Injection Pump
gm gmgm gm
gm
Gram GramGram Gram
Gram
GVW GVWGVW GVW
GVW
Gross Vehicle Weight Gross Vehicle WeightGross Vehicle Weight Gross Vehicle Weight
Gross Vehicle Weight
IGN IGNIGN IGN
IGN
Ignition IgnitionIgnition Ignition
Ignition
Kg KgKg Kg
Kg
Kilogram KilogramKilogram Kilogram
Kilogram
Km KmKm Km
Km
Kilometer KilometerKilometer Kilometer
Kilometer
Km/h Km/hKm/h Km/h
Km/h
Kilometer per hour Kilometer per hourKilometer per hour Kilometer per hour
Kilometer per hour
LH LHLH LH
LH
Left Hand Left HandLeft Hand Left Hand
Left Hand
Max Max
Max Max
Max
Maximum MaximumMaximum Maximum
MaximumMD MDMD MD
MD
Main Dealer Main DealerMain Dealer Main Dealer
Main Dealer
Min MinMin Min
Min
Minimum MinimumMinimum Minimum
Minimum
mkg mkgmkg mkg
mkg
Meter per Kilogram Meter per KilogramMeter per Kilogram Meter per Kilogram
Meter per Kilogram
mm mmmm mm
mm
Millimeter MillimeterMillimeter Millimeter
Millimeter
Mtg MtgMtg Mtg
Mtg
Mounting MountingMounting Mounting
Mounting
No NoNo No
No
Number NumberNumber Number
Number
PCBU PCBUPCBU PCBU
PCBU
Passenger Car Business Unit Passenger Car Business UnitPassenger Car Business Unit Passenger Car Business Unit
Passenger Car Business Unit
PDI PDIPDI PDI
PDI
Pre-delivery Inspection Pre-delivery InspectionPre-delivery Inspection Pre-delivery Inspection
Pre-delivery Inspection
PSI PSIPSI PSI
PSI
Pounds per Square Inch Pounds per Square InchPounds per Square Inch Pounds per Square Inch
Pounds per Square Inch
PUC PUCPUC
PUC
PUC
Pollution Under Control Pollution Under ControlPollution Under Control Pollution Under Control
Pollution Under Control
R RR R
R
A AA A
A
W WW W
W
Rear Axle Weight Rear Axle WeightRear Axle Weight Rear Axle Weight
Rear Axle Weight
RCSM RCSMRCSM RCSM
RCSM
Regional Customer Support Manager Regional Customer Support ManagerRegional Customer Support Manager Regional Customer Support Manager
Regional Customer Support Manager
RH RHRH RH
RH
Right Hand Right HandRight Hand Right Hand
Right Hand
RM RMRM RM
RM
Regional Manager Regional ManagerRegional Manager Regional Manager
Regional Manager
RPM RPMRPM RPM
RPM
Revolution Per Minute Revolution Per MinuteRevolution Per Minute Revolution Per Minute
Revolution Per Minute
Sec SecSec Sec
Sec
Seconds SecondsSeconds Seconds
Seconds
Sq.cm. Sq.cm.Sq.cm. Sq.cm.
Sq.cm.
Square Centimeter Square CentimeterSquare Centimeter Square Centimeter
Square Centimeter
T TT T
T
ASC ASCASC ASC
ASC
T TT T
T
a aa a
a
ta M ta Mta M ta M
ta M
ot otot ot
ot
ors A ors Aors A ors A
ors A
uthor uthoruthor uthor
uthor
ised S ised Sised S ised S
ised S
er erer er
er
vic vicvic vic
vic
e C e Ce C e C
e C
en enen en
en
tr trtr tr
tr
e ee e
e
T TT T
T
ASP ASPASP ASP
ASP
T TT T
T
a aa a
a
ta M ta Mta M ta M
ta M
ot otot ot
ot
ors A ors Aors A ors A
ors A
uthor uthoruthor uthor
uthor
ised S ised Sised S ised S
ised S
er erer er
er
vic vicvic vic
vic
e P e Pe P e P
e P
oin oinoin oin
oin
t tt t
t
V VV V
V
V VV V
V
olts oltsolts olts
olts
W WW W
W
Watts WattsWatts Watts
Watts
ABBRE ABBREABBRE ABBRE
ABBRE
VIA VIAVIA VIA
VIA
TIONS TIONSTIONS TIONS
TIONSA B B R E V I A T I O N S
ProCarManuals.com

155
A L P H A B E T I C A L I N D E X ALPHABETIC INDEX ALPHABETIC INDEX ALPHABETIC INDEX ALPHABETIC INDEX
ALPHABETIC INDEX
A AA A
A
Air Bags 2 2
Aggregate Numbers-Location 1 2
Air Conditioning52, 134
Air Filter & Filter Element 105
Analog Clock 66
Anti Lock Brake System 7 9
Ashtray 6 1
Audio Warning 2 1
Automatic Hub Lock 8 2
B BB B
B
Battery 118
Belt Tension 135
Bonnet Opening / Closing 7 0
Brake Fluid 115
Brakes 7 9
Branded Lubricants 9 5
C CC C
C
Catalytic Converter 132
Central Locking System 13
Child Lock 20
Cigarette Lighter 60
Clutch Fluid 115
Collapsible Steering column 2 1
Combi-Switch 33
Coolants 9 4
D DD D
D
Door Locks 20
Driving Controls 28
Driving in adverse conditions 85
Driving Safety 89
E
ECU 1 1 7
EGR System 132
Engine Compartment 104
Engine Coolant 73
Engine Cooling System 106
Engine oil 72
Engine Oil & Oil Filter 108
Environment Protection 8
F FF F
F
Flat tyre replacement 120
Follow Me Home Headlamp 64
Front & Rear Fog Lights 38
Front / Rear Axle Oil 112
Front Seat 56
Front Windshield / Door Glass Demister 5 4
Fuel 92
Fuel Economy 84
Fuel Gauge 50
Fuel level 72
Fuel Tank Flap Switch 38
Fuel Tank Flap 61
Fuses 130
G GG G
G
Gauges 4 7
Gear Box 78
Gear Box Oil 1 1 0
Gear Shift Lever 32
Glove Box 62
H HH H
H
Hazard Warning 39
Head Lamps & Headlamp Adjustment 113
Headlamp Leveling Switch 40
Headrest 57
Headrest adjustment 1 8
High mounted stop lamp 67
I II I
I
Ignition Switch 29
Immobiliser- Anti Theft Security System 31
Important Information 6,7
Indicators 43
Instrument Cluster 42
J JJ J
J
Jack & Tools 59
Jump Seats 59
ProCarManuals.com