flat tire TOYOTA AURIS 2015 (in English) Service Manual

5597-2. Steps to take in an emergency
Auris Touring Sports_EE (OM12G98E)
7
When trouble arises
If the tire is inflated to more than the specified air pressure
Ty p e A
Disconnect the hose from the valve.
Disconnect the hose from the valve, remove the air release cap from the
hose and then reconnect the hose.
Turn the compressor switch on and wait for several seconds, and then
turn it off. Check that the air pressure indicator shows the specified air
pressure.
If the air pressure is under the designated pressure, turn the compressor
switch on again and repeat the inflation procedure until the specified air
pressure is reached.
Ty p e B
Check that the air pressure indicator shows the specified air pressure.
If the air pressure is under the designated pressure, turn the compressor
switch on again and repeat the inflation procedure until the specified air
pressure is reached.
The valve of a tire that has been repaired
After a tire is repaired with the emergency tire puncture repair kit, the valve
should be replaced.Install the air release cap to the end of
the hose and push the protrusion on
the air release cap into the tire valve
to let some air out.
Press the button to let some air out.
1
2
3
4
1
2

5617-2. Steps to take in an emergency
Auris Touring Sports_EE (OM12G98E)
7
When trouble arises
CAUTION
Do not drive the vehicle with a flat tire
Do not continue driving with a flat tire.
Driving even a short distance with a flat tire can damage the tire and the
wheel beyond repair.
Driving with a flat tire may cause a circumferential groove on the side wall.
In such a case, the tire may explode when using a repair kit.
Caution while driving
The repair kit is exclusively only for your vehicle.
Do not use repair kit on other vehicles, which could lead to an accident
causing death or serious injury.
Do not use repair kit for tires that are different size than the original ones,
or for any other purpose. If the tires have not been completely repaired, it
could lead to an accident causing death or serious injury.
Precautions for use of the sealant
Ingesting the sealant is hazardous to your health. If you ingest sealant,
consume as much water as possible, and then immediately consult a doc-
tor.
If sealant gets in eyes or adheres to skin, immediately wash it off with
water. If discomfort persists, consult a doctor.
When fixing the flat tire
Stop your vehicle in a safe and flat area.
Do not touch the wheels or the area around the brakes immediately after
the vehicle has been driven.
After the vehicle has been driven, the wheels and the area around the
brakes may be extremely hot. Touching these areas with hands, feet or
other body parts may result in burns.
To avoid risk of burst or severe leakage, do not drop or damage the bottle.
Visually inspect the bottle before use. Do not use a bottle with shock,
crack, scratch, leakage or any other damage. In such case, immediately
replace.
Connect the valve and hose securely with the tire installed on the vehicle.
If the hose is not properly connected to the valve, air leakage may occur
as sealant may be sprayed out.
If the hose comes off the valve while inflating the tire, there is a risk that
the hose will move abruptly due to air pressure.

5627-2. Steps to take in an emergency
Auris Touring Sports_EE (OM12G98E)
CAUTION
When fixing the flat tire
After inflation of the tire has completed, the sealant may splatter when the
hose is disconnected or some air is let out of the tire.
Follow the operation procedure to repair the tire. If the procedures not fol-
lowed, the sealant may spray out.
Keep back from the tire while it is being repaired, as there is a chance of it
bursting while the repair operation is being performed. If you notice any
cracks or deformation of the tire, turn off the compressor switch and stop
the repair operation immediately.
The repair kit may overheat if operated for a long period of time. Do not
operate the repair kit continuously for more than 40 minutes.
Parts of the repair kit become hot during operation. Be careful when han-
dling the repair kit during and after operation. Do not touch the metal part
around the connecting area between the bottle and compressor. It will be
extremely hot.
Do not attach the vehicle speed warning sticker to an area other than the
one indicated. If the sticker is attached to an area where an SRS airbag is
located, such as the pad of the steering wheel, it may prevent the SRS air-
bag from operating properly.
Driving to spread the liquid sealant evenly
Observe the following precautions to reduce the risk of accidents.
Failing to do so may result in a loss of vehicle control and cause death or
serious injury.
Drive the vehicle carefully at a low speed. Be especially careful when turn-
ing and cornering.
If the vehicle does not drive straight or you feel a pull through the steering
wheel, stop the vehicle and check the following.
• Tire condition. The tire may have separated from the wheel.
• Tire inflation pressure. If the tire inflation pressure is 130 kPa (1.3
kgf/cm
2 or bar, 19 psi) or less, the tire may be severely damaged.

5998-1. Specifications
Auris Touring Sports_EE (OM12G98E)
8
Vehicle specifications
Ty p e A
Ty p e B
*: 1AD-FTV engine
Tires and wheels
Tire size195/65R15 91H
Tire inflation pres-
sure
(Recommended
cold tire inflation
pressure)Vehicle speed
Front wheel
kPa (kgf/cm2
or bar, psi)
Rear wheel
kPa (kgf/cm2
or bar, psi)
More than 160
km/h (100 mph)260 (2.6, 38)260 (2.6, 38)
160 km/h (100
mph) or less230 (2.3, 33)230 (2.3, 33)
Wheel size15  6 J
Wheel nut torque103 N•m (10.5 kgf•m, 76 ft•lbf)
Tire size205/55R16 91V, 225/45R17 91W
Tire inflation pres-
sure
(Recommended
cold tire inflation
pressure)Vehicle speed
Front wheel
kPa (kgf/cm2
or bar, psi)
Rear wheel
kPa (kgf/cm2
or bar, psi)
More than 160
km/h (100 mph)270 (2.7, 39)*
260 (2.6, 38)260 (2.6, 38)
160 km/h (100
mph) or less240 (2.4, 35)*
230 (2.3, 33)230 (2.3, 33)
Wheel size16  6 1/2 J (205/55R16), 17  7 J (225/45R17)
Wheel nut torque103 N•m (10.5 kgf•m, 76 ft•lbf)

6008-1. Specifications
Auris Touring Sports_EE (OM12G98E)
Ty p e C
Compact spare tire
When towing a trailer
Add 20.0 kPa (0.2 kgf/cm
2 or bar, 3 psi) to the recommended tire inflation
pressure and drive at speeds below 100 km/h (62 mph).
Tire size215/45R17 87W
Tire inflation pres-
sure
(Recommended
cold tire inflation
pressure)Vehicle speed
Front wheel
kPa (kgf/cm2
or bar, psi)
Rear wheel
kPa (kgf/cm2
or bar, psi)
More than 160
km/h (100 mph)260 (2.6, 38)260 (2.6, 38)
160 km/h (100
mph) or less230 (2.3, 33)230 (2.3, 33)
Wheel size17  7 J
Wheel nut torque103 N•m (10.5 kgf•m, 76 ft•lbf)
Tire sizeT125/70D17 98M
Tire inflation pressure
(Recommended cold
tire inflation pressure)
420 kPa (4.2 kgf/cm2 or bar, 60 psi)
Wheel size17  4T
Wheel nut torque103 N•m (10.5 kgf•m, 76 ft•lbf)

609
Auris Touring Sports_EE (OM12G98E)
8
Vehicle specifications
8-3. Initialization
*: If equipped
Items to initialize
The following item must be initialized for normal system opera-
tion after such cases as the battery being reconnected, or main-
tenance being performed on the vehicle:
ItemWhen to initializeReference
Tire pressure warning sys-
tem
*
• When rotating front and rear
tires which have different tire
inflation pressures
• When changing the tire size
• When changing the tire infla-
tion pressure by changing
traveling speed or load
weight, etc.
P. 428

618What to do if... (Troubleshooting)
Auris Touring Sports_EE (OM12G98E)
Vehicles with a spare tire:
Stop the vehicle in a safe place and replace the flat tire with the
spare tire. (P. 527)
Vehicles with an emergency tire puncture repair kit:
Stop the vehicle in a safe place and repair the flat tire temporarily
with the emergency tire puncture repair kit. (P. 540)
Try the procedure for when the vehicle becomes stuck in mud, dirt,
or snow. (P. 581)
When a problem has occurred
If you have a flat tire
The vehicle becomes stuck

622Alphabetical index
Auris Touring Sports_EE (OM12G98E)
Emergency, in case of
If a warning buzzer
sounds ................................ 491
If a warning light turns on ...... 491
If a warning message is
displayed ............................ 507
If the battery is discharged .... 570
If the electronic key does
not operate properly ........... 567
If the engine will not start ...... 564
If the shift lever cannot be
shifted from P ..................... 566
If you have a flat tire...... 527, 540
If you run out of fuel and
the engine stalls.................. 580
If you think something is
wrong .................................. 489
If your vehicle becomes
stuck ................................... 581
If your vehicle has to be
stopped in an emergency ... 481
If your vehicle needs to be
towed .................................. 483
If your vehicle
overheats ............................ 577
Emergency brake signal ......... 276
Emergency flashers................. 480
Emergency tire puncture
repair kit ................................. 540Engine....................................... 588
ACCESSORY mode ............. 202
Compartment ........................ 409
Engine switch................ 195, 199
Hood ..................................... 405
How to start the
engine......................... 195, 199
Identification number ............ 587
If the engine will not start ...... 564
Ignition switch
(engine switch) ........... 195, 199
Overheating .......................... 577
Engine coolant ......................... 418
Capacity ................................ 595
Checking ............................... 418
Preparing and checking
before winter....................... 285
Engine coolant temperature
gauge.................................. 91, 95
Engine immobilizer system ...... 71
Engine oil ................................. 413
Capacity ................................ 591
Checking ............................... 413
Oil level warning light ............ 495
Oil level warning message .... 513
Oil pressure warning light ..... 492
Oil pressure warning
message ............................. 508
Preparing and checking
before winter....................... 285
Engine oil maintenance
data ......................................... 416
Engine switch .................. 195, 199
EPS (Electric Power
Steering)................................. 276
Function ................................ 276
Warning light ......................... 493

623Alphabetical index
Auris Touring Sports_EE (OM12G98E)
Flat tire
Vehicles with a spare tire ...... 527
Vehicles without a spare
tire....................................... 540
Floor mats .................................. 30
Fluid
Brake..................................... 598
Clutch .................................... 597
Multidrive............................... 596
Washer.................................. 423
Fog lights.................................. 230
Replacing light bulbs ............. 463
Switch ................................... 230
Wattage................................. 601
Follow me home system ......... 222
Front fog lights ........................ 230
Replacing light bulbs ............. 463
Switch ................................... 230
Wattage................................. 601
Front personal lights ............... 357
Front position lights ................ 220
Light switch ........................... 220
Replacing light bulbs ............. 476
Front seats ............................... 153
Adjustment ............................ 153
Cleaning ................................ 396
Correct driving posture............ 32
Head restraints...................... 158
Seat heaters.......................... 384
Front turn signal lights............ 217
Replacing light bulbs ............. 476
Turn signal lever ................... 217
Wattage................................. 601Fuel ........................................... 238
Capacity ................................ 590
Fuel filter ....................... 424, 580
Fuel gauge ........................ 90, 95
Fuel pump shut off system.... 490
If you run out of fuel and
the engine stalls ................. 580
Information ............................ 602
Refueling............................... 238
Type .............................. 238, 590
Warning light ......................... 494
Fuel filler door.......................... 238
Refueling............................... 238
Fuel pump shut off system ..... 490
Fuses ........................................ 446
Gauges ................................. 90, 95
Gear Shift Indicator ................. 215
Glove box ................................. 360
Grocery bag hooks .................. 365
Hands-free system
(for cellular phone)*
Head restraints ........................ 158
Headlights ................................ 220
Adaptive Front-lighting
System (AFS) ..................... 223
Automatic High Beam
system ................................ 226
Discharge headlights
precautions ......................... 478
Follow me home system ....... 222
Light switch ........................... 220
Replacing light bulbs............. 463
Wattage ................................ 601
F
G
H
*: Refer to “Navigation and multimedia system Owner’s manual”.

628Alphabetical index
Auris Touring Sports_EE (OM12G98E)
Snow tires................................. 288
Spare tire .................................. 527
Inflation pressure .................. 600
Storage location .................... 528
Spark plug ................................ 595
Specifications .......................... 584
Speech command system*
Speed limiter ............................ 247
Speedometer ........................ 90, 95
Sport mode ............................... 210
Steering lock
Column lock release ..... 197, 206
Steering lock system
warning message ............... 524
Steering wheel ......................... 160
Adjustment ............................ 160
Audio switches ...................... 352
Stop & Start cancel switch...... 271
Stop & Start system................. 270
Stop & Start system
operation time.................... 92, 97
Stop & Start system total
operation time.................... 92, 97
Stop lights
Emergency brake signal ....... 276
Replacing light bulbs ............. 463
Wattage................................. 601
Storage feature ........................ 359
Stuck
If the vehicle becomes
stuck ................................... 581
Sun visors ................................ 377
Sunshade
Panoramic roof...................... 389Switches
“AFS OFF” switch ................. 223
Airbag manual on-off
switch ................................... 48
Audio remote control
switches.............................. 352
Cruise control switch............. 242
“DISP” button .................... 90, 96
Door lock switches ................ 146
Emergency flashers switch ... 480
Engine switch................ 195, 199
Fog light switch ..................... 230
Ignition switch ............... 195, 199
Light switches ....................... 220
Outside rear view mirror
switches.............................. 163
Paddle shift switches ............ 211
Panoramic roof shade
switch ................................. 389
Power door lock switch ......... 146
Power window switches ........ 166
Rear window and outside
rear view mirror defoggers
switch ................................. 314
Seat heater switches ............ 384
Simple-IPA switch ................. 257
Speed limiter switch .............. 247
Sport mode switch ................ 210
Stop & Start cancel switch .... 270
Talk switch*
Telephone switches*
Tire pressure warning reset
switch ................................. 428
Toyota parking assist-sensor
switch ................................. 250
VSC OFF switch ................... 277
Window lock switch............... 166
Windshield wiper and
washer switch ............. 232, 236