fuel TOYOTA AVENSIS 2002 Repair Manual

73094±02
±
THEFT DETERRENT & DOOR LOCK FUEL LID OPENER SYSTEM
73±29
AVENSIS REPAIR MANUAL (RM1018E)
PROBLEM SYMPTOMS TABLE
SymptomSuspected AreaSee Page
Fuel lid opener does not operate.
1. FUEL OPN fuse
2. Fuel lid opener switch
3. Fuel lid lock control assy
4. Wire harness68±1
73±30
73±30

73095±02
B68828
Fuel Lid Opener Switch
B68829
Shaft Strokes
Open 73±30
± THEFT DETERRENT & DOOR LOCKFUEL LID OPENER SYSTEM
AVENSIS REPAIR MANUAL (RM1018E)
INSPECTION
1. INSPECT FUEL LID OPENER SWITCH
(a) Check the switch resistance.
Standard:
Tester ConnectionSwitch PositionSpecified Condition
23OFF10 k
or higher2 ± 3ONBelow 1

If the result is not as specified, replace the switch.
2. INSPECT FUEL LID LOCK CONTROL ASSY
(a) Apply battery voltage to the lock control and check the
motor operates in the direction.
Standard:
Measurement ConditionSpecified Condition
Battery positive (+)
Terminal 2
Battery negative (±)
Terminal 1Open direction
If the result is not as specified, replace the lock control assy.
(b) Check the shaft strokes.
Standard: 18.0 mm (0.709 in.) or more

700TI±01
B68929
B68929
±
WINDSHIELD/WINDOWGLASS/MIRROR OUTER REAR VIEW MIRROR ASSY LH
70±65
AVENSIS REPAIR MANUAL (RM1018E)
OUTER REAR VIEW MIRROR ASSY LH
REPLACEMENT
HINT:

The installation is in the reverse order of the removal. However, when there is a special point concern-
ing the installation, it is indicated.

Use the same procedures on the RH side as on the LH side.
1.REMOVE FRONT DOOR HOLE COVER SUB±ASSY NO.1 LH (See page 75±8)
(a) Remove the front door lower frame bracket garnish.
(b) Remove the front door trim base.
(c) Only driver side: Remove the fuel lid opener switch.
(d) w/ Power window: Remove the power window regulator switch.
(e) Remove the front door trim board sub.
(f) Remove the front door inside handle.
(g) remove the front service hole cover No. 1.
2. REMOVE OUTER REAR VIEW MIRROR ASSY LH
(a) Disconnect the connector.
(b) Remove the 3 screws and mirror .
3. INSTALL OUTER REAR VIEW MIRROR ASSY LH
(a) Install the mirror with the 3 screws.Torque: 10 N
m (102 kgf
cm, 7 ft
lbf)
(b) Connect the connector.

I35138
LHD:
FUSE
1. ±
2. DEF I/ UP 7.5A
3. ST 7.5A
4. MIR HTR 7.5A
5. RAD No.2 15A6. DOME 7.5A
7. ECU±B2 7.5A
8. PWR SEAT 30A
9. ±
10. P±RR P/W 20A11. P±FR P/W 20A
12. D±RR P/W 20A
13. D±FR P/W 20A
14. ECU±B1 7.5A
15. FUEL OPN 10A
16. FR DIC 20A
RELAY
A. ST
B. FR FOG
C. P/POINT
D. FR DEICER
A
B
13 14 15 934567
8
C
D
16 11 1 2 10 12
Fuse Block Assy
Drive Side Relay Block Assy 68±6
± WIRINGPOWER SOURCE
AVENSIS REPAIR MANUAL (RM1018E)

I35137
AB
CD
13 14 15 93 456 7
8
16 10 1211 12
RHD:
Fuse Block Assy
FUSE
1. ±
2. DEF I/ UP 7.5A
3. ST 7.5A
4. MIR HTR 10A
5. RAD No.2 15A6. DOME 7.5A
7. ECU±B2 7.5A
8. PWR SEAT 30A
9. ±
10. P±RR P/W 20A11. D±FR P/W 20A
12. P±RR P/W 20A
13. P±FR P/W 20A
14. ECU±B1 7.5A
15. FUEL OPN 10A
16. FR DIC 20A
Passenger Side Relay Block Assy
RELAY
A. P/POINT
B. FR FOG
C. ST
D. FR DEICER
± WIRINGPOWER SOURCE
68±7
AVENSIS REPAIR MANUAL (RM1018E)