charging TOYOTA AYGO 2013 Owners Manual (in English)

227 3-3. Using the audio system (Type B)
3
Interior features
AYGO_WE_99G80E
In “Random all”
play, not all of
the tracks/files
are played.In “Random all” play, the
system can only take into
account up to 999 tracks/
files.
With the
engine off, the
audio system
switches off
after a few min-
utes of use.When the engine is switched
off, the audio system operat-
ing time depends on the bat-
tery charge.
The switch-off is normal: the
audio system switches to
economy mode and
switches off to prevent dis-
charging the vehicle’s bat-
tery.Start the vehicle’s engine to
increase the battery charge.
The message
“the audio sys-
tem is over-
heated”
appears on the
display.In order to protect the instal-
lation if the surrounding tem-
perature is too high, the
audio system switches to an
automatic thermal protec-
tion mode leading to a
reduction of the volume or
stopping of the playing of the
CD.Switch the audio system off
for a few minutes to allow
the system to cool.
QuestionAnswerSolution

267 4-3. Do-it-yourself maintenance
4
Maintenance and care
AYGO_WE_99G80EBattery exterior
Make sure that the battery terminals are not corroded and that
there are no loose connections, cracks, or loose clamps.
Terminals
Hold-down clamp
Checking battery fluid
Check the battery condition by indicator color.
Green: Good condition
Dark: Charging is necessary.
Have the vehicle inspected by
any authorized Toyota dealer
or repairer, or another duly
qualified and equipped profes-
sional.
White: Not working properly.
Have the vehicle inspected by
any authorized Toyota dealer
or repairer, or another duly
qualified and equipped profes-
sional.

268 4-3. Do-it-yourself maintenance
AYGO_WE_99G80E
Before recharging
When recharging, the battery produces hydrogen gas which is flammable
and explosive. Therefore, observe the following before recharging:
If recharging with the battery installed on the vehicle, be sure to discon-
nect the ground cable.
Make sure the power switch on the charger is off when connecting and
disconnecting the charger cables to the battery.
CAUTION
Chemicals in the battery
Batteries contain poisonous and corrosive sulfuric acid and may produce
hydrogen gas which is flammable and explosive. To reduce the risk of death
or serious injury, take the following precautions while working on or near the
battery:
Do not cause sparks by touching the battery terminals with tools.
Do not smoke or light a match near the battery.
Avoid contact with eyes, skin and clothes.
Never inhale or swallow electrolyte.
Wear protective safety glasses when working near the battery.
Keep children away from the battery.
Where to safely charge the battery
Always charge the battery in an open area. Do not charge the battery in a
garage or closed room where there is insufficient ventilation.
How to recharge the battery
Only perform a slow charge (5 A or less). The battery may explode if
charged at a quicker rate.

269 4-3. Do-it-yourself maintenance
4
Maintenance and care
AYGO_WE_99G80E
Washer fluid
If any washer does not work, the
washer tank may be empty. Add
washer fluid.
CAUTION
Emergency measures regarding electrolyte
If electrolyte gets in your eyes
Flush your eyes with clean water for at least 15 minutes and get immedi-
ate medical attention. If possible, continue to apply water with a sponge or
cloth while traveling to the nearest medical facility.
If electrolyte gets on your skin
Wash the affected area thoroughly. If you feel pain or burning, get medical
attention immediately.
If electrolyte gets on your clothes
It can soak through clothing on to your skin. Immediately take off the cloth-
ing and follow the procedure above if necessary.
If you accidentally swallow electrolyte
Drink a large quantity of water or milk. Get emergency medical attention
immediately.
NOTICE
When recharging the battery
Never recharge the battery while the engine is running. Also, be sure all
accessories are turned off.

287 4-3. Do-it-yourself maintenance
4
Maintenance and care
AYGO_WE_99G80EEngine compartment (back side)
FuseAmpereCircuit
1 ALTERNATOR 120 ACharging system, EMPS, ABS,
VSC, RADIATOR, AM1, HTR,
PWR, D/L, DEF, TAIL, STOP, OBD,
ECU-B fuses

5
313 5-2. Steps to take in an emergency
When trouble arises
AYGO_WE_99G80E
Stop the vehicle immediately.
The following warnings indicate the possibility of damage to the
vehicle that may lead to an accident. Immediately stop the vehicle
in a safe place and contact any authorized Toyota dealer or
repairer, or another duly qualified and equipped professional.
Warning lightWarning light/Details
Charging system warning light
Indicates a malfunction in the vehicle’s charging system.
Low engine oil pressure warning light
Indicates that the engine oil pressure is too low.
High engine coolant temperature warning light
Indicates that the engine is almost overheating. (P. 336)
(Flashes)“STOP” warning light
Indicates a malfunction in:
• Engine oil pressure is too low; or
• Engine is almost overheating.

5
333 5-2. Steps to take in an emergency
When trouble arises
AYGO_WE_99G80E
To prevent battery discharge
Turn off the headlights and the audio system while the engine is off.
Turn off any unnecessary electrical components when the vehicle is run-
ning at a low speed for an extended period, such as in heavy traffic.
Charging the battery
The electricity stored in the battery will discharge gradually even when the
vehicle is not in use, due to natural discharge and the draining effects of cer-
tain electrical appliances. If the vehicle is left for a long time, the battery may
discharge, and the engine may be unable to start. (The battery recharges
automatically during driving.)
Start the engine of the second vehicle. Increase the engine
speed slightly and maintain at that level for approximately 5
minutes to recharge the battery of your vehicle.
Maintain the engine speed of the second vehicle and turn
the engine switch to the “ON” position, then start the vehi-
cle’s engine.
Once the vehicle’s engine has started, remove the jumper
cables in the exact reverse order from which they were con-
nected.
Once the engine starts, have the vehicle inspected at any autho-
rized Toyota dealer or repairer, or another duly qualified and
equipped professional, as soon as possible.

353 6-1. Specifications
6
Vehicle specifications
AYGO_WE_99G80E
Ignition system
Electrical system
Manual transmission
Spark plug
Make
GapDENSO SK16HR11
1.1 mm (0.043 in.)
NOTICE
Iridium-tipped spark plugs
Use only iridium-tipped spark plugs. Do not adjust the spark plug gap.
Battery
Open voltage* at
20C (68F):12.6 12.8 V Fully charged
12.2 12.4 V Half charged
11 . 8 12.0 V Discharged
(
*: Voltage checked 20 minutes after
the engine and all the lights are
turned off)
Charging rates 5 A max.
Gear oil capacity (Reference) 1.7 L (1.8 qt., 1.5 Imp.qt.)
Gear oil typeUse either of the following:
• “TOYOTA Genuine Manual Transmission
Gear Oil LV”
• Other gear oil that meets API GL-4 and
SAE 75W specifications

368 Alphabetical index
AYGO_WE_99G80E
Tachometer .............................. 139
Tail lights
Replacing light bulbs ............. 292
Switch ................................... 144
Wattage................................. 356
Theft deterrent system
Engine immobilizer system ..... 73
Tire inflation pressure ............. 275
Tires
Chains ................................... 159
Checking ............................... 272
If you have a flat tire.............. 318
Inflation pressure .................. 275
Replacing .............................. 318
Rotating tires ......................... 272
Size ....................................... 355
Snow tires ............................. 159
Spare tire .............................. 318
Tools ......................................... 318
Total load capacity .................. 346
Towing
Emergency towing ................ 305
Trailer towing ........................ 163
Traction control ....................... 154
TRC ........................................... 154
Trip meter ................................. 139
Turn signal lights
Replacing light bulbs ............. 292
Switch ................................... 136
Wattage................................. 356USB memory ............................ 202
Vanity mirrors .......................... 232
Vehicle identification
number ................................... 346
Vehicle stability control .......... 154
VSC ........................................... 154
Warning buzzers
Electric power steering
system ................................ 315
Light reminder ....................... 147
Low fuel level ........................ 316
Multi-mode manual
transmission ....................... 313
Seat belt reminder ................ 316
Warning lights
Anti-lock brake system.......... 315
Brake assist system .............. 315
Brake system ........................ 312
Charging system ................... 313
Electric power steering
system ................................ 315
Electronic engine control
system ................................ 315
Engine oil pressure ............... 313
High engine coolant
temperature warning light ... 313
Low fuel level ........................ 316
Malfunction indicator lamp .... 315
Multi-mode manual
transmission ....................... 313
Pretensioners........................ 315
Seat belt reminder light ......... 316
SRS airbags.......................... 315
“STOP” warning light ............ 313
“VSC” warning light ............... 315TU
V
W

371 What to do if...
AYGO_WE_99G80EInstrument cluster
Warning lights
P. 3 1 2P. 315
P. 3 1 3P. 315
P. 3 1 3P. 315
P. 3 1 3P. 316
P. 3 1 3P. 316
P. 3 1 4P. 316
P. 3 1 4P. 316
P. 3 1 5
*: The light flashes to indicate a malfunction.
Brake system warning
lightSRS warning light*
Charging system warn-
ing lightABS warning light
Low engine oil pressure
warning lightElectric power steering
warning light
High engine coolant tempera-
ture warning light“VSC” warning light
“STOP” warning light*Low fuel level warning
light
Multi-mode manual transmis-
sion warning lightDriver’s seat belt
reminder light
Heat clutch warning
light
*
Front passenger’s seat belt
reminder light
Malfunction indicator
lamp