coolant level TOYOTA C_HR HYBRID 2016 Owners Manual

5217-2. Maintenance
C-HR_HV_OM_Europe_OM10538E
7
Maintenance and care
■Where to go for maintenance service?
In order to maintain your vehicle in the best possible condition, Toyota recom-
mends that maintenance service operations as well as other inspections and
repairs be carried out by authorized Toyota retailers or repairers or other duly
qualified and equipped professionals. For repairs and services covered by
your warranty, please visit an authorized Toyota retailers or repairer, who will
use genuine Toyota parts in repairing any difficulties you may encounter.
There can also be advantages in utilizing authorized Toyota retailers or
repairers for non-warranty repairs and services, as members of the Toyota
network will be able to expertly assist you with any difficulties you may
encounter.
Your authorized Toyota retailer or Toyo ta authorized repairer, or any reliable
repairer will perform all of the scheduled maintenance on your vehicle reliably
and economically due to their experience with Toyota vehicles.
■ Does your vehicle need repairs?
Be on the alert for changes in performance and sounds, and visual tip-offs
that indicate service is needed. Some important clues are:
● Engine misses, stumbling or pinging
● Appreciable loss of power
● Strange engine noises
● A fluid leak under the vehicle (However, water dripping from the air condi-
tioning system after use is normal.)
● Change in exhaust sound (This may indicate a dangerous carbon monoxide
leak. Drive with the windows open and have the exhaust system checked
immediately.)
● Flat-looking tires, excessive tire squeal when cornering, uneven tire wear
● Vehicle pulls to one side when driven straight on a level road
● Strange noises related to suspension movement
● Loss of brake effectiveness, spongy feeling brake pedal, pedal almost
touches the floor, vehicle pulls to one side when braking
● Engine coolant temperature continually higher than normal (P. 600, 657)
If you notice any of these clues, take your vehicle to any authorized Toyota
retailer or Toyota authorized repairer, or any reliable repairer as soon as pos-
sible. Your vehicle may need adjustment or repair.

5237-3. Do-it-yourself maintenance
C-HR_HV_OM_Europe_OM10538E
7
Maintenance and care
Do-it-yourself service precautions
If you perform maintenance by yourself, be sure to follow the
correct procedure as given in these sections.
ItemsParts and tools
12-volt battery
condition
( P. 536)
• Warm water • Baking soda • Grease
• Conventional wrench (for terminal clamp bolts)
Engine/power
control unit
coolant level
( P. 533)
• “Toyota Super Long Life Coolant” or a similar high
quality ethylene glycol-based non-silicate, non-
amine, non-nitrite and non-borate coolant with long-
life hybrid organic acid technology
“Toyota Super Long Life Coolant” is pre-mixed with
50% coolant and 50% deionized water.
• Funnel (used only for adding coolant)
Engine oil level
( P. 530)
• “Toyota Genuine Motor Oil” or equivalent
• Rag or paper towel
• Funnel (used only for adding engine oil)
Fuses (P. 5 6 4 )• Fuse with same amperage rating as original
Light bulbs
( P. 568)
• Bulb with same number and wattage rating as origi-
nal
• Phillips-head screwdriver
• Flathead screwdriver•Wrench
Radiator and
condenser
( P. 535)

Tire inflation
pressure
( P. 553)
• Tire pressure gauge
• Compressed air source
Washer fluid
( P. 539)
• Water or washer fluid containing antifreeze (for win-
ter use)
• Funnel (used only for adding water or washer fluid)

5297-3. Do-it-yourself maintenance
C-HR_HV_OM_Europe_OM10538E
7
Maintenance and care
Engine compartment
Washer fluid tank (P. 539)
Engine coolant reservoir
( P. 533)
Fuse boxes ( P. 564)
Engine oil level dipstick
( P. 530)
Engine oil filler cap ( P. 531)
Power control unit coolant
reservoir ( P. 533)
12-volt battery ( P. 536)
Radiator ( P. 535)
Condenser ( P. 535)
Electric cooling fans
1
2
3
4
5
6
7
8
9
10

5337-3. Do-it-yourself maintenance
C-HR_HV_OM_Europe_OM10538E
7
Maintenance and care
The coolant level is satisfactory if it is between the “FULL” and “LOW”
lines on the reservoir when the hybrid system is cold.
■Engine coolant reservoir
Reservoir cap
“FULL” line
“LOW” line
If the level is on or below the
“LOW” line, add coolant up to
the “FULL” line. ( P. 657)
■Power control unit coolant reservoir
Reservoir cap
“FULL” line
“LOW” line
If the level is on or below the
“LOW” line, add coolant up to
the “FULL” line. ( P. 657)
■Coolant selection
Only use “Toyota Super Long Life Coolant” or a similar high quality ethylene
glycol based non-silicate, non-amine, non- nitrite, and non-borate coolant with
long-life hybrid organic acid technology.
“Toyota Super Long Life Coolant” is a mixture of 50% coolant and 50% deion-
ized water. (Minimum temperature: -35 C [-31F])
For more details about coolant, contact any authorized Toyota retailer or Toy-
ota authorized repairer, or any reliable repairer.
■ If the coolant level drops within a short time of replenishing
Visually check the radiator, hoses, engine/power control unit coolant reservoir
caps, drain cock and water pump.
If you cannot find a leak, have any authorized Toyota retailer or Toyota autho-
rized repairer, or any reli able repairer test the cap and check for leaks in the
cooling system.
Coolant
1
2
3
1
2
3

5948-2. Steps to take in an emergency
C-HR_HV_OM_Europe_OM10538E
If you think something is wrong
●Fluid leaks under the vehicle
(Water dripping from the air conditioning after use is normal.)
● Flat-looking tires or uneven tire wear
● Engine coolant temperature gauge needle continually points higher
than normal
● Changes in exhaust sound
● Excessive tire squeal when cornering
● Strange noises related to the suspension system
● Pinging or other noises related to the hybrid system
● Engine misses, stumbling or running roughly
● Appreciable loss of power
● Vehicle pulls heavily to one side when braking
● Vehicle pulls heavily to one side when driving on a level road
● Loss of brake effectiveness, spongy feeling, pedal almost touches
the floor
If you notice any of the following symptoms, your vehicle proba-
bly needs adjustment or repair. Contact any authorized Toyota
retailer or Toyota authorized repairer, or any reliable repairer as
soon as possible.
Visible symptoms
Audible symptoms
Operational symptoms

6588-2. Steps to take in an emergency
C-HR_HV_OM_Europe_OM10538E
The coolant level is satisfactory if it is between the “FULL” and
“LOW” lines on the reservoir.
Reservoir
“FULL” line
“LOW” line
Add coolant if necessary.
Water can be used in an emer-
gency if coolant is unavailable.
Start the hybrid system and turn the air conditioning system on to
check that the radiator cooling fans operate and to check for
coolant leaks from the radiator or hoses.
The fans operate when the air condi tioning system is turned on immedi-
ately after a cold start. Confirm that the fans are operating by checking
the fan sound and air flow. If it is difficult to check these, turn the air con-
ditioning system on and off repeatedly. (The fans may not operate in
freezing temperatures.)
If the fans are not operating:
Stop the hybrid system immediately and contact any authorized
Toyota retailer or Toyota authorized repairer, or any reliable
repairer.
If the fans are operating:
Have the vehicle inspected at the nearest any authorized Toyota
retailer or Toyota authorized repairer, or any reliable repairer.
4
1
2
3
5
6
7

6598-2. Steps to take in an emergency
C-HR_HV_OM_Europe_OM10538E
8
When trouble arises
■If “Hybrid System Overheated Reduced Output Power.” is
shown on the multi-information display
Stop the vehicle in a safe place.
Stop the hybrid system and carefully lift the hood.
After the hybrid system has cooled down, inspect the hoses and
radiator core (radiator) for any leaks.
Radiator
Cooling fans
If a large amount of coolant
leaks, immediately contact
any authorized Toyota retailer
or Toyota authorized repairer,
or any reliable repairer.
The coolant level is satisfactory if it is between the “FULL” and
“LOW” lines on the reservoir.
Reservoir
“FULL” line
“LOW” line
Add coolant if necessary.
Water can be used in an emer-
gency if coolant is unavailable.
If water was added in an emer-
gency, have the vehicle
inspected at any authorized
Toyota retailer or Toyota autho-
rized repairer, or any reliable
repairer as soon as possible.
1
2
3
1
2
4
1
2
3
5

702Alphabetical index
C-HR_HV_OM_Europe_OM10538E
Hands-free system
(for cellular phone)*.............. 467
Head restraints......................... 182
Headlight cleaners ................... 256
Headlights ................................ 244
Automatic headlight
leveling ............................... 248
Automatic High Beam ........... 249
Follow me home system ....... 245
Light switch ........................... 244
Manual headlight
leveling dial......................... 246
Replacing light bulbs ............. 570
Wattage................................. 676
Heated steering wheel ............. 488
Heaters
Automatic air conditioning
system ................................ 478
Heated steering wheel .......... 488
Outside rear view mirrors ...... 482
Seat heaters.......................... 488
High coolant temperature
warning light .......................... 600
High mounted stoplight
Replacing .............................. 582
Hill-start assist control ............ 403
Hood.......................................... 526
Hooks
Cargo hooks ......................... 497
Grocery bag hook ................. 497
Retaining hooks (floor mat)..... 34
Horn .......................................... 186
Hybrid battery (traction battery)
Location .................................. 92
Specification ......................... 669
Hybrid battery
(traction battery) air intake
vent ........................................... 93
Hybrid system ............................ 87
Brake Override System......... 202
Drive-Start Control ................ 202
Emergency shut off system .... 93
Energy monitor/consumption
screen................................. 138
EV drive mode ...................... 228
High voltage components ....... 92
Hybrid System Indicator........ 127
Hybrid system precautions ..... 92
Hybrid vehicle driving tips ..... 409
If the hybrid system will not
start .................................... 646
Overheating .......................... 657
Power switch......................... 221
Regenerative braking.............. 89
Starting the hybrid system .... 221
Hybrid System Indicator ......... 127
Hybrid transmission ................ 231
H

710Alphabetical index
C-HR_HV_OM_Europe_OM10538E
Warning buzzers
Blind Spot Monitor (BSM) ..... 335
Brake system ........................ 595
Lane departure alert.............. 290
Open back door .................... 158
Open door ............................. 155
Pre-collision warning ............. 275
Radar cruise control .............. 316
RSA (Road Sign Assist) ........ 301
Seat belt reminder................. 599
Toyota parking assist
sensors ............................... 353
Warning lights .......................... 117
ABS ....................................... 596
Brake Override System ......... 600
Brake system ........................ 595
Charging system ................... 595
Electric parking brake ... 597, 598
Electric power steering.......... 596
High coolant temperature...... 600
LDA system........................... 600
Low engine oil pressure ........ 595
Low fuel level ........................ 598
Malfunction indicator lamp .... 596
Master warning light .............. 600
PCS....................................... 598
Seat belt reminder light ......... 599
Slip indicator ......................... 597
SRS....................................... 596
Tire pressure ......................... 599
Warning messages .................. 606
Washer
Checking ............................... 539
Preparing and checking
before winter....................... 412
Switch ........................... 256, 259
Washing and waxing ............... 512
What to do if...
(Troubleshooting) ................. 692
Wheels ...................................... 555
Replacing wheels.................. 555
Size ....................................... 674
Window glasses....................... 193
Window lock switch ................ 193
Windows
Power windows ..................... 193
Rear window defogger .......... 482
Washer ......................... 256, 259
Windshield wipers ................... 256
Rain-sensing windshield
wipers ................................. 256
Winter driving tips ................... 412
Wireless remote control
key .......................................... 144
Locking/Unlocking......... 144, 150
Replacing the battery ............ 561
WMA disc ................................. 426
W