main relay TOYOTA CAMRY 1994 XV10 / 4.G Wiring Diagrams User Guide

61
186
R18 R19 R20 R21 S3 S8 S9 S10 V1 V2 V3 V468
72182226
23080
90
98
Rear Wiper Motor (W/G)
Rear Wiper Relay (W/G)
Remote Control Mirror LH
Remote Control Mirror RH
Shift Lock ECU
Stereo Component Amplifier
Stereo Component Amplifier
Stop Light SW
VSV (for A/C Idle±Up)
VSV (for EGR System) (1MZ±FE)
VSV (for Fuel Pressure Up)
VSV (for Intake Air Control)
(1MZ±FE)
Vehicle Speed Sensor
(Speed Sensor)
Vanity Light LH
Vanity Light RH
Washer Motor
Water Temp. Sender
Diode
Noise Filter
Defogger Relay (Coil Side)
Power Main Relay (Coil Side)
S5 V5 V8 V9 W1 W2
Starter (1MZ±FE)
Defogger Relay (Point Side)
Power Main Relay (Point Side)
Taillight Relay (Coil Side)
Taillight Relay (Point Side)
Starter Relay (Point Side)
Starter Relay (Coil Side)
EFI Main Relay (Coil Side)
EFI Main Relay (Point Side)
Headlight Relay (Coil Side)
186 154 154226
230120
192
204182
198
210
21480
9080
90
9880 80
98
198 90
192
236130
134
138130
134
138184
186236130
134
138190 190 190156
160
168156
160
16811 2
12612668
7268
72 80
90
98
198
204 80
90
98
198
204106
(4): R/B No. 4 (See page 20)(5): R/B No. 5 (See page 19)(6)R/B No. 6 (See Page )
2526 26

62
POWER SOURCE (Current Flow Chart)
*Page Nos. of
Related Systems
Parts
Code or
Location
CB or Fuse
Location
* These are the page numbers of the first page on which the related system is shown.
The part indicated is located somewhere in the system, not necessarily on the page indicated here.


106
Horn Relay
Headlight Relay (Point Side)
Radiator Fan Relay (Point Side)
Turn Signal Flasher
Heater Relay (Point Side)
Radiator Fan Relay No. 2
(Coil Side)
A/C Magnetic Clutch Relay
(Coil Side)
Daytime Running Light Relay No. 3
(Coil Side)
40A AM1
15A CIG/RADIO
40A DEFOG
15A ECU±1G
10A GAUGE
7.5A IGN
10A MIR±HTR
30A POWER
7.5A SRS
15A STOP
15A TAIL
7.5A TURN
20A WIPER
30A AM2
7.5A ALT±S
30A CDS FAN
20A DOME
15A ECU±B
15A EFI
10A HAZ
15A HEAD (LWR±LH)
15A HEAD (LWR±RH)
15A HEAD (UPR±LH)
15A HEAD (UPR±RH)
15A HEAD LH
15A HEAD RH
10A HORN
40A MAIN
7.5A OBD
10A STARTER
10A A/C
40A HEATER
7.5A DRL
100A ALT
60A ABS
Radiator Fan Relay (Coil Side)
Heater Relay (Coil Side)
Radiator Fan Relay No. 2
(Point Side)
Radiator Fan Relay No. 3
(Point Side)
A/C Magnetic Clutch Relay
(Point Side)
Circuit Opening Relay (Coil Side)
Circuit Opening Relay (Coil Side)
Daytime Running Light Relay No. 4
(Coil Side)
106 173 106 242 24211 4
11 8246 246 242 242 242 246 24680
90
9880
90
98
[LOCATION](1)
(4): J/B No. 1 (See page 20)
: R/B No. 4 (See page )(2)
(5): J/B No. 2 (See page 19)
: R/B No. 5 (See page )(3)
(6): R/B No. 1 (See page 23)
: R/B No. 6 (See page )
(7): R/B No. 7 (See page 20)(8): Fuse Box (F10, F17 See
on page 19) 20 2225
25
28 2926 26
27

64

POWER SOURCE
5 512
3 W
W
W
W
W±R
B±R
W±B
W±R
W W
R±LW B±R L
W B60A ABS
100A ALT
DAYTIME RUNNING
LIGHT RELAY NO. 2(
CA NADA)
(
USA)
B
2H2
EC1 6
B
(
CANADA)
5
RW±B
FL MAIN
2. 0L
B
BATTERY
1
B
GENERATOR
(
ALTERNATOR) G1W
W
E14 : 1MZ±FE
E23 : 5S±FE
(
5S±FE)
(
1MZ±FE)
B 1A 1
D 1
C 1 E 1
TO AB S
ACTUATOR W±L
(
1MZ±FE)
(
5S±FE)
B F1 0 , F10
AC,F16
E F17D ,F18
FUSE B OX
W
(
5S±FE)(
5S±FE)
4 40A
HEATER
4 4
3 W
EF1 3IP37EF14
I2
E6
E14 : 1MZ±FE
E20 : 5S±FE
E14 : 1MZ±FE
E15 : 5S±FE
WW
W
W
WW
W
2 40A
AM1
1G 91E 1
1
3A 15
3C 16
2E2
2H215A HEAD(
RH)
15A HEAD(
LH)
15A HEAD(
UPR±RH)
15A HEAD(
UPR±LH)
2F 15
2 TER RELAY
2C2C
25
1
2E1 2G1 10A HAZ
20A DOME
AM2
15A EFI
40A MAIN
HEADLIGHT
RELAY
4
23
1 10A HORN 7. 5A ALT±S15A TEL
30A CDS FAN30A RDI FAN
543
W
2B6
2B2W±B
W±B 2G6
B±R
2H 1
15A ECU±B
ENGINE
MAIN RELAY 21
7. 5A OBD
30A
STAR3
B

65
E7 E6
21
7521
12 1E4
1E2
1G10
1G3
1G8 4
103
2
7
9 AM2 AM1ACC
IG1
ST1
IG2
ST2
EB IG 5
5 11M1
1C10 W
W
W
W±R
W±B
B±R
WB±R
B±R
WW
W
WW±B W
W
P±L
B±Y
B±O B±W
W
W±B
W±B
15A STOP
7. 5A SRS
15A TAIL
TAILLIGHT
RE LA Y
POWER MAIN
RELAY
DEFOGGER
RE LA Y
15A CIG/RADIO
15A ECU±IG
20A WIPER
10A GAUGE
7. 5A TURN
15A HEAD(
LW R±RH)
15A HEAD(
LWR±LH)
7. 5A DRL B±R
TO STARTER
3412 53
12
53
53
W±B
IGNITION SW I12
7 5R±W
R
W±R 1A7
EB11TO DOOR LOCK
CONTROL RELAY
10A MIR HTR
7. 5A IGN
10A STARTER
54 B±R
IP1172130A POWER
1240A DEFOG
E10 : 1MZ±FE
E20 : 5S±FE

66
POWER SOURCE
TAILLIGHT RELAY5±3 : CLOSED WITH LIGHT CONTROL SW AT TAIL OR HEAD POSITION
CLOSED WITH ENGINE RUNNING AND PARKING BRAKE LEVER RELEASED (CANADA)
ENGINE MAIN RELAY4±5 : CLOSED WITH IGNITION SW AT ON OR ST POSITIONHEADLIGHT RELAY2±1 : CLOSED WITH LIGHT CONTROL SW AT HEAD POSITION OR DIMMER SW AT FLASH POSITION
CLOSED WITH ENGINE RUNNING AND PARKING BRAKE LEVER RELEASED (CANADA)
I12
IGNITION SW 4±3 : CLOSED WITH IGNITION KEY AT ACC OR ON POSITION
10±9, 4±2 : CLOSED WITH IGNITION KEY AT ON OR ST POSITION
: PARTS LOCATION
CODESEE PAGECODESEE PAGECODESEE PAGE
F10A28F17E28 (1MZ±FE), 30 (5S±FE)I 233F10B30F18D28 (1MZ±FE), 30 (5S±FE)
F16C28 (1MZ±FE), 30 (5S±FE)G 128 (1MZ±FE), 30 (5S±FE)
: RELAY BLOCKS
CODESEE PAGERELAY BLOCKS (RELAY BLOCK LOCATION)
125R/B NO. 4 (LEFT KICK PANEL)
425R/B NO. 4 (RIGHT KICK PANEL)
526R/B NO. 5 (ENGINE COMPARTMENT LEFT)
727R/B NO. 7 (NEAR THE BATTERY)
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
CODESEE PAGEJUNCTION BLOCK AND WIRE HARNESS (CONNECTOR LOCATION)
1A
1C
1E20COWL WIRE AND J/B NO. 1 (INSTRUMENT PANEL LEFT)
1G
20COWL WIRE AND J/B NO. 1 (INSTRUMENT PANEL LEFT)
1M
2B22ENGINE ROOM MAIN WIRE AND J/B NO. 2 (ENGINE COMPARTMENT LEFT)
2C22ENGINE WIRE AND J/B NO. 2 (ENGINE COMPARTMENT LEFT)
2E22ENGINE ROOM MAIN WIRE AND J/B NO. 2 (ENGINE COMPARTMENT LEFT)
2F22COWL WIRE AND J/B NO 2 (ENGINE COMPARTMENT LEFT)2G22COWL WIRE AND J/B NO. 2 (ENGINE COMPARTMENT LEFT)
2H22ENGINE WIRE AND J/B NO. 2 (ENGINE COMPARTMENT LEFT)
3A24COWL WIRE AND J/B NO 3 (BEHIND COMBINATION METER)3C24COWL WIRE AND J/B NO. 3 (BEHIND COMBINATION METER)
: CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS
CODESEE PAGEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
EB138 (1MZ±FE)ENGINE ROOM MAIN WIRE AND RELAY WIREEB140 (5S±FE)ENGINE ROOM MAIN WIRE AND RELAY WIRE
EC138 (1MZ±FE)ENGINE WIRE AND ENGINE ROOM MAIN WIREEC140 (5S±FE)ENGINE WIRE AND ENGINE ROOM MAIN WIRE
EF138 (1MZ±FE)EF140 (5S±FE)ENGINE WIRE AND COWL WIREIP144
ENGINE WIRE AND COWL WIRE
IP344
: GROUND POINTS
CODESEE PAGEGROUND POINTS LOCATION
EB38 (1MZ±FE)FRONT LEFT FENDEREB40 (5S±FE)FRONT LEFT FENDER
IG42INSTRUMENT PANEL BRACE LH
: SPLICE POINTS
CODESEE PAGEWIRE HARNESS WITH SPLICE POINTSCODESEE PAGEWIRE HARNESS WITH SPLICE POINTS
E638 (1MZ±FE)E1438 (1MZ±FE)E 640 (5S±FE)ENGINE ROOM MAIN WIREE15ENGINE WIRE
E738 (1MZ±FE)ENGINE ROOM MAIN WIREE2040 (5S±FE)ENGINE WIRE
E 740 (5S±FE)E23
40 (5S FE)
E1038 (1MZ±FE)ENGINE WIREI 244COWL WIRE
SERVICE HINTS

68
STARTING AND IGNITION (1MZ±FE)
A
AM1
AM2 104
7
9 ACC
IG1
ST1
IG2
ST2
EF1 3EF1 1 1 2G 1
1
2H 2
IG M
B 1
B1
B±RB±R
B±R B±O B±WB±O
B
BWW
W±RW
B±R B±R
W±B
B
B±W B
W±B W±B
B±W
IGNITION SW
52 31
B±W 100A ALT
FUSE BOX
30A
AM210A
STARTER
STARTER
RELAY
PARK/NEUTRAL POSITION SW
(
NE UTRA L START SW)
STARTER BATTERY FL MAIN
2. 0L
S3 , S4 I12
P1
AP
N5
6
B
A 1
B 1
B F10 , F16A
E10 17 2C52F12C2
TO CIRCUIT OPENING
RELAY TO ENGINE CO NTROL
MODULE(
ENGINE AND
ELECTRONIC CONTROLLED
TRANSMISSION ECU)B±W
B±W
5
4 40A
MAIN
IP1
B±W
1E 51G 6
1C 113C 6
1M 13C 18
3C 2
3D 2 3B 20
1G 9
1E 140A
AM1 2
1

72
STARTING AND IGNITION (5S±FE)
4
107
9 AM2 AM1ACC
IG1
ST1
IG2
ST2
30A
AM210A
STARTER 40A
MAIN
A 1
B 12C 52F12C2 1
1 2H 22G 1
B1A 1
IG EF1 1EF1 1
M 52 31
2 1
E20 EF1 3B±O
B±W
B±O
B±R
BB±W
W±RW
B±WB W
B±W B±W
B W±BB±R
B
B
B±W B±W
B± R(
M/T)
(
M/T)
(
A/T)
(
A/T)
(
M/T)
(
A/T) W±B
4 5
P
N
65
W
B B
W±BB±R
W±B
B±R
PARK/NEUTRAL POSITION SW
(
NE UTRA L START SW)
(
A/T) P1CLUTCH START
SW(
M/T) C7
STARTER
RELAY IGNITION SW I12
FL MAIN
2. 0L
BATTERY
TO CIRCUIT OPENING
RELAY TO ENGINE CONTROL
MODULE(
ENGINE AND
ELE CTRONIC CO NTROLLED
TRANSMISSION
ECU(
A/T)
,
ENGINE ECU(
M/T))
B S3 ,S4A
B F10 , F16A
STARTER
FUSE BOX100A ALT
IP 1 17
1G 6
1E 5
140A
AM1
1E 11G 9
2
3B 20 3D23C 2
3C 18
1M 13C 6
1C 11

76
CHARGING
A
IG L S B
IC RE GULATOR2C 6
B 2B1B3 8
E9
E
IP3 10 IP 3 2GE 64)
A 1 7. 5A
ALT±S
R±LY
W
R±L
YB±O
W B
W
W
GENERATOR
(
ALTERNATOR)
BATTERY FL MAIN
2. 0L
100A ALT
CHARGE WARNING LIGHT
[COMB. METER]
JUNCTION
CONNECTOR
Y
J1
G1 , G2
C9
B FUSE BOX
FROM DAYTIME RUNNING
LIGHT RELAY(
MAIN)
Y E
(
CANADA)
R±L R±L
TO BA CK± UP SW(
M/T)
TO PARK/NEUTRAL POSITION
SW(
NEUTRAL START SW)(
A/T)
TO VEHICLE SPEED SENSOR
(
SPEED SENSOR) B 1A 1
C 1(
1MZ±FE)
(
5S±FE)
B F10 , F10AC,F16
I18
1D 61D37. 5A
IGN 10A
GAUGE
FROM POWER SOURCE SYSTEM(
SEE PA

78
ENGINE CONTROL (1MZ±FE)
THIS SYSTEM UTILIZES AN ENGINE CONTROL MODULE (ENGINE AND ELECTRONIC CONTROLLED TRANSMISSION ECU) AND
MAINTAINS OVERALL CONTROL OF THE ENGINE, TRANSMISSION AND SO ON. AN OUTLINE OF THE ENGINE CONTROL IS
EXPLAINED HERE.
1. INPUT SIGNALS
(1) ENGINE COOLANT TEMP. (WATER TEMP.) SIGNAL CIRCUIT
THE ENGINE COOLANT TEMP. SENSOR (WATER TEMP. SENSOR) DETECTS THE ENGINE COOLANT TEMP. AND HAS A
BUILT±IN THERMISTOR WITH A RESISTANCE WHICH VARIES ACCORDING TO THE WATER TEMP. IS INPUT INTO TERMINAL
THW OF ENGINE CONTROL MODULE (ECU) AS A CONTROL SIGNAL.
(2) INTAKE AIR TEMP. SIGNAL CIRCUIT
THE INTAKE AIR TEMP. SENSOR IS INSTALLED IN THE MASS AIR FLOW (AIR FLOW METER) AND DETECTS THE INTAKE AIR
TEMP., WHICH IS INPUT AS A CONTROL SIGNAL TO TERMINAL THA OF ENGINE CONTROL MODULE (ECU).
(3) OXYGEN SENSOR SIGNAL SYSTEM
THE OXYGEN DENSITY IN THE EXHAUST GASES IS DETECTED AND INPUT AS A CONTROL SIGNAL TO TERMINAL OXL, OXR
AND OXS OF THE ENGINE CONTROL MODULE (ECU). TO MAINTAIN STABLE DETECTION PERFORMANCE BY THE OXYGEN
SENSOR, A HEATER IS USED FOR WARMING THE SENSOR. THE HEATER IS ALSO CONTROLLED BY THE ENGINE CONTROL
MODULE (ECU) (HTL, HTR AND HTS).
(4) RPM SIGNAL SYSTEM
CAMSHAFT POSITION AND CRANKSHAFT POSITION ARE DETECTED BY THE CAMSHAFT POSITION SENSOR AND
CRANKSHAFT POSITION SENSOR. CRANKSHAFT POSITION IS INPUT AS A CONTROL SIGNAL TO TERMINAL G22+ OF THE
ENGINE CONTROL MODULE (ECU), AND ENGINE RPM IS INPUT TO TERMINAL NE+.
(5) THROTTLE SIGNAL CIRCUIT
THE THROTTLE POSITION SENSOR DETECTS THE THROTTLE VALVE OPENING ANGLE AS A CONTROL SIGNAL, WHICH IS
INPUT INTO TERMINAL VTA OF THE ENGINE CONTROL MODULE (ECU). WHEN THE VALVE IS COMPLETELY CLOSED, THE
CONTROL SIGNAL IS INPUT INTO TERMINAL IDL.
(6) VEHICLE SPEED SIGNAL SYSTEM
THE VEHICLE SPEED SENSOR (SPEED SENSOR), INSTALLED INSIDE THE COMBINATION METER, DETECTS THE VEHICLE
SPEED AND INPUTS A CONTROL SIGNAL TO TERMINAL SP1 OF THE ENGINE CONTROL MODULE (ECU).
(7) PARK/NEUTRAL POSITION SW (NEUTRAL START SW) SIGNAL SYSTEM
THE PARK/NEUTRAL POSITION SW (NEUTRAL START SW) DETECTS WHETHER THE SHIFT POSITION IS IN NEUTRAL OR
PARKING OR NOT, AND INPUTS A CONTROL SIGNAL TO TERMINAL NSW OF THE ENGINE CONTROL MODULE (ECU).
(8) A/C SW SIGNAL SYSTEM
THE A/C AMPLIFIER INPUTS THE A/C OPERATIONS TO TEMRINAL A/C OF THE ENGINE CONTROL MODULE (ECU) AS A
CONTROL SIGNAL.
(9) BATTERY SIGNAL CIRCUIT
VOLTAGE IS CONSTANTLY APPLIED TO TERMINAL BATT OF THE ENGINE CONTROL MODULE (ECU). WHEN THE IGNITION SW
TURNED ON, VOLTAGE FOR ENGINE CONTROL MODULE (ECU) START±UP POWER SUPPLY IS APPLIED TO TERMINALS +B
AND +B1 OF ENGINE CONTROL MODULE (ECU) VIA EFI MAIN RELAY.
(10) INTAKE AIR VOLUME SIGNAL CIRCUIT
INTAKE AIR VOLUME IS DETECTED BY THE MASS AIR FLOW (AIR FLOW METER) AND THE SIGNAL IS INPUT TO TERMINAL VG
OF THE ENGINE CONTROL MODULE (ECU). AS A CONTROL SIGNAL.
(11) STA SIGNAL CIRCUIT
TO CONFIRM WHETHER THE ENGINE IS CRANKING, THE VOLTAGE APPLIED TO THE STARTER MOTOR DURING CRANKING IS
DETECTED AND THE SIGNAL IS INPUT INTO TERMINAL STA OF THE ENGINE CONTROL MODULE (ECU) AS A CONTROL
SIGNAL.
(12) ENGINE KNOCK SIGNAL CIRCUIT
ENGINE KNOCKING IS DETECTED BY THE KNOCK SENSOR NO. 1 AND NO. 2 AND THE SIGNALS ARE INPUT INTO TERMINALS
KNKR AND KNKL AS A CONTROL SIGNAL.
SYSTEM OUTLINE

80
ENGINE CONTROL (1MZ±FE)
AM1
AM2 104
7
9 ST1
IG2
2G 1
IG 1 2
1 2
1 2
1 2
1 2
1 2 I20
E12 I18 E12 I18
BX1 4IJ1 16 EF1 3IP1 9IP1 16
IP3 15 66
666 641 32 2H 2
L±B
G±R
Y
R
L
GR
G
W B±OL±B B±W
B±WB±O
B±O B±O B±O
BB±O
BWW
BW
W±R
B±O
B±O B±O B±O
B±O
B±O
B±O
B±O
B±O Y RL GRG W
W±B W±B W±B
L±B L±BG±R
L±BB± O
B±W
B±W
BATTERY FL MAIN
2. 0LI18
B±O B±O 100A ALT
10A
STARTER
30A
AM2
FUSE BOX
IGNITION SW
CIRCUIT
OPENING
RELAY
INJECTOR NO. 1
INJECTOR NO. 6
INJECTOR NO. 3
INJECTOR NO. 4
INJECTOR NO. 5
INJECTOR NO. 2 I4
I9
I6
I7
I8
I5
I12
L±B
A 1
B 1B F10 , F16A
FROM POWER SOURCE
SYSTEM(
SEE PAGE 64)
1 B±O
B±W B±W
B±O
IP14
B±O 4
1G 9
1E 140A
AM1 2
1
1G 8
1A 67. 5A
IGN 1D 9
3B 20
3D 23C 2
3A 13
1C 113C 18
1M 1