main relay TOYOTA CAMRY 1994 XV10 / 4.G Wiring Diagrams Workshop Manual

32
ELECTRICAL WIRING ROUTING
Position of Parts in Instrument Panel
A 10 A/C Amplifier C 12 Combination SW
A 11 A/C Evaporator Temp. Sensor C 13 Combination SW
A 12 A/C SW C 14 Cooling Fan ECU
A 13 ABS ECU C 15 Cruise Control Clutch SW (M/T)
A 14 ABS ECU C 16 Cruise Control ECU
A 15 Airbag Squib (Steering Wheel Pad)
A 16 Air Inlet Control Servo Motor D 3 Data Lik Connector 2 (TDCL (Toyota Diagnostic
A 17 Air Vent Mode Control Servo Motor Communication Link))
A 18 Ashtray Illumination D 4 Daytime Running Light Relay (Main)
A 22 Airbag Squib (Front Passenger Airbag Assembly) D 5 Diode (for Cruise Control)
D 6 Diode (for Idle±Up)
B 3 Back Door Lock Control SW D 7 Diode (for Courtesy)
B 4 Blower Motor D 8 Door Lock Control Relay)
B 5 Blower Resistor D 24 Date Link Connector 3
B 6 Blower SW D 25 Diode (for Tension Reducer)
B 7 Buckle SW LH (w/ Power Seat)
B 8 Buckle SW LH (w/o Power Seat) E 6 Electronic Controlled Transmission Pattern Select SW
B 10 Buckle SW RH E 7 Engine Control Module (Engine and Electronic
Controlled Transmission ECU) (A/T)
C 3 Center Airbag Sensor Assembly E 8 Engine Control Module (Engine and Electronic
C 4 Cigarette Lighter Controlled Transmission ECU) (A/T)
C 5 Cigarette Lighter Illumination E 9 Engine Control Module (Engine and Electronic
C 6 ClockControlled Transmission ECU) (A/T)
C 7 Clutch Start SW (M/T) E 10 Engine Control Module (Engine and Electronic
C 8 Combination Meter Controlled Transmission ECU) (A/T)
C 9 Combination Meter E 11 Engine Control Module (Engine ECU) (M/T)
C 10 Combination Meter E 12 Engine Control Module (Engine ECU) (M/T)
C 11 Combination Meter E 14 Engine Control Module (Engine ECU) (M/T)

33
Position of Parts in Instrument Panel
G 3 Glove Box Light O 5 O/D Main SW and A/T Indicator Light (Shift Lever)
G 4 Glove Box Light SW
P 2 Parking Brake SW (for 1MZ±FE)
H 7 Hazard SW P 3 Parking Brake SW (for 5S±FE)
H 8 Heater Control SW (for Push Control SW Type) or Air P 4 Power Seat Control SW
Vent Mode Control SW (for Lever Control SW Type) P 5 Power Seat Motor (for Front Vertical Control)
H 9 Heated Oxygen Sensor (Bank 1 Sensor 2) P 6 Power Seat Motor (for Rear Vertical Control)
P 7 Power Seat Motor (for Reclining Control)
I 11 Ignition Key Cylinder Light P 8 Power Seat Motor (for Slide Control)
I 12 Ignition SW and Unlock Warning SW
I 13 Integration Relay R 2 Radio and Player (w/ CD Player)
R 3 Radio and Player (w/o CD Player)
J 1 Junction Connector R 4 Radio and Player (w/o CD Player)
J 2 Junction Connector R 5 Rear Window Defogger SW
J 3 Junction Connector R 6 Remote Control Mirror SW
J 4 Junction Connector (for SRS System) R 7 Rheostat
J 7 Junction Connector
S 5 Shift Lock ECU
K 3 Key Interlock Solenoid S 8 Stereo Component Amplifier
S 9 Stereo Component Amplifier
N 2 Noise Filter (for Stop Light) S 10 Stop Light SW
N 3 Noise Filter (for Stop Light)

39
Connector Joining Wire Harness and Wire Harness
CODEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
EB1ENGINE ROOM MAIN WIRE AND RELAY WIRE (UNDER THE R/B NO. 5)
EC1ENGINE WIRE AND ENGINE ROOM MAIN WIRE (UNDER THE J/B NO. 1)
ED1COWL WIRE AND ENGINE ROOM MAIN WIRE (UNDER THE J/B NO. 1)
EE1SENSOR WIRE AND ENGINE WIRE (SIDE OF FRONT CYLINDER HEAD)
EF1ENGINE WIRE AND COWL WIRE (NEAR THE BRAKE MASTER CYLINDER)

41
Connector Joining Wire Harness and Wire Harness
CODEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
EA1ENGINE ROOM MAIN WIRE AND ENGINE ROOM NO. 3 WIRE (RADIATOR FAN SHROUD)
EB1ENGINE ROOM MAIN WIRE AND RELAY WIRE (UNDER THE R/B NO. 5)
EC1ENGINE WIRE AND ENGINE ROOM MAIN WIRE (UNDER THE J/B NO. 1)
ED1COWL WIRE AND ENGINE ROOM MAIN WIRE (UNDER THE J/B NO. 1)
EF1ENGINE WIRE AND COWL WIRE (NEAR THE BRAKE MASTER CYLINDER)

52
POWER SOURCE (Current Flow Chart)
The chart below shows the route by which current flows from the battery to each electrical source (Fusible Link,
Circuit Breaker, Fuse, etc.) and other parts.
The next page and following pages show the parts to which each electrical source outputs current.
Starter Battery
FL MAIN 2.0L30A AM2Ignition SW
(AM2)
Headlight Relay
(Point Side)
40A DEFOG 100A ALTGenerator
(Alternator) 7.5A SRS
Taillight Relay
(Coil Side) 40A MAIN
(Canada) 7.5A OBD
7.5A ALT±S
10A HAZ
10A HORN
15A ECU±B
15A EFI
20A DOMEHeadlight Relay
(Coil Side)
60A ABS 15A STOP
40A HEATER
Taillight Relay
(Point Side)
Engine Main
Relay (Point Side)
15A TEL
Daytime Running
Light Relay No. 2
(Coil Side)
Daytime Running
Light Relay No. 2
(Point Side)Starter Relay
(Point Side)
(5S±FE)
30A POWER
40A AM1
Daytime Running
Light Relay (Main)
15A HEAD (UPR±LH)
15A HEAD (UPR±RH)
[LOCATION](1): J/B No. 1 (See page 20)(2): J/B No. 2 (See page 19)
(3): R/B No. 1 (See page 20)(7): R/B No. 7 (See page 19) 2022
25
27

53
Integration Relay 7.5A IGN
Daytime Running
Light Relay (Main)
Ignition SW
(AM1)(USA)
Starter Relay
(Coil Side) 10A MIR HTRABS Actuator
Light Control SW
[Comb. SW]15A HEAD (LH)
10A A/CABS ECU ABS Actuator
and ECU(TMM Made)
ABS Relay
Integration
Relay
Defogger Relay
(Point Side)
Heater Relay
(Point Side)
15A TAIL
Power Main Relay
(Point Side)Clutch Start
SW Light Control SW
[Comb. SW]
* These are the page numbers of the first page on which the related
system is shown.
The part indicated is located somewhere in the system, not
necessarily on the page indicated here.
(Canada)
Dimmer SW
[Comb. SW]
30A RDI FAN
30A CDS FAN15A HEAD (RH)
7.5A DRL
15A HEAD (LWR±LH)
15A HEAD (LWR±RH)
(Canada)
10A STARTER
Starter
(M/T)
(A/T)
Park/Neutral
Position SW
(Neutral Start SW)
Engine Control
Module (Engine and
Electronic Controlled
Transmission ECU)
7.5A TURN
10A GAUGE
15A ECU±IG
15A CIG/RADIO
20A WIPER (TMC Made) ABS Relay
(4): R/B No. 4 (See page 20)(5): R/B No. 5 (See page 19)(6)R/B No. 6 (See Page )
2526 26

54
POWER SOURCE (Current Flow Chart)
40A AM1
15A CIG/RADIO
40A DEFOG
15A ECU±1G
10A GAUGE
7.5A IGN
10A MIR±HTR
30A POWER
7.5A SRS
15A STOP
15A TAIL
7.5A TURN
20A WIPER
30A AM2
7.5A ALT±S
30A CDS FAN
20A DOME
15A ECU±B
15A EFI
10A HAZ
15A HEAD (LWR±LH)
15A HEAD (LWR±RH)
15A HEAD (UPR±LH)
15A HEAD (UPR±RH)
15A HEAD LH
15A HEAD RH
10A HORN
40A MAIN
7.5A OBD
10A STARTER
10A A/C
40A HEATER
7.5A DRL
100A ALT
60A ABS
A/C Condenser Fan Motor (5S±FE)
242
A4 A5 A11 A1*Page Nos. of
Related Systems
Parts
Code or
Location
CB or Fuse
LocationA2 A3
* These are the page numbers of the first page on which the related system is shown.
The part indicated is located somewhere in the system, not necessarily on the page indicated here.


A12 A6 A7 A13 A17 A18A14 A16 A21 B1 B2 B3 B4 B5 B6 B7 B9 B10 214 252126
252210 210 246246
252126222
224152 236 166246
252246
252126
246
252160
166 220 220
A/C Triple Pressure SW (A/C Dual
and Single Pressure SW)
A/C Magnetic Clutch and Lock
Sensor
ABS Actuator and ECU
(TMM Made)
ABS Actuator (TMC Made)
ABS Actuator and ECU
(TMM Made)
ABS Relay
A/C Amplifier
A/C SW
ABS ECU (TMC Made)
Air Inlet Control Servo Motor
Air Vent Mode Control Servo Motor
Ashtray Illumination
Auto Antenna Motor and Relay
Back±Up Light SW (M/T)
Brake Fluid Level SW
Back Door Lock Control SW
Blower Motor
Blower Resistor
Blower SW
Buckle SW LH
Back Door Lock Motor (W/G)
Buckle SW RH
A10246
252 210 210 210 214 246
252 242
246
252
ABS ECU (TMC Made)A/C Evaporator Temp. Sensor ABS Relay
[LOCATION](1)
(7): J/B No. 1 (See page 20)
: R/B No. 7 (See page )(2)
(8): J/B No. 2 (See page 19)
: Fuse Box (F10, F17 See
on page )(3): R/B No. 1 (See page 23)
2022
25
27
28 29

55
192 17711 4
11 8
Cruise Control Actuator
C2 C5 C10 C11 C13 D8C12 C3 C4 C6 C8 C9 C14 C16 D1 D3 D4 D6 D7
Center Airbag Sensor Assembly
Cigarette Lighter
Cigarette Lighter Illumination
Clock
Combination Meter
(Turn Signal Indicator Light)Combination Meter
(Cruise Control Indicator Light)
Combination Meter
Combination Meter
(Meter Illmination)
Combination Meter
(Open Door Warning Light)
Combination Meter
(Seat Belt Warning Light)
Combination Meter
(Charge Warning Light)
Combination Meter
(High Beam Indicator Light)
Combination Meter
(Rear Light Warning Light)
Combination Meter
Combination Meter
(SRS Warning Light)
Combination Meter
(A/T Indicator Light)
Combination SW (Horn SW)
Combination SW
(Turn Signal SW)
Combination SW
(Light Control SW)
Combination SW
Front Wiper and Washer SW)
Cooling Fan ECU (1MZ±FE)
Cruise Control ECU
Data Link Connector 1
(Check Connector)
Data Link Connector 2
(TDCL (Toyota Diagnostic
Communication Link))
Daytime Running Light Relay
(Main) (CANADA)
Diode (for Idle±Up)
Diode (for Courtesy) (W/G) Door Lock Control Relay
18912618968
72192236210
21476 130
134
138
140 126120
124
144
148236126
198
204104
11 2
144244 80
90
98
214 90
192
214106
23680
90
98130
134
138
140156
140 104
106
D9 C717080
90
98177 17311 4
11 8106
126
148184
186192 98
204134
140
Diode (for Courtesy) Combination Meter
(Malfunction Indicator Light) Combination Meter
(ABS Warning Light) Clutch Start SW (M/T)
(4): R/B No. 4 (See page 20)(5): R/B No. 5 (See page 19)(6)R/B No. 6 (See Page )
2526 26

58
POWER SOURCE (Current Flow Chart)
*Page Nos. of
Related Systems
Parts
Code or
Location
CB or Fuse
Location
* These are the page numbers of the first page on which the related system is shown.
The part indicated is located somewhere in the system, not necessarily on the page indicated here.


I5 I6 I7 I8 I9 I11 I12
I13I14 I16 I17 I18
I19 8068
72
80 130
134
138
140106
120
130
144
76
11 4
130
170
214
246
177
Injector No. 2
Injector No. 3
Injector No. 4
Injector No. 5 (1MZ±FE)
Injector No. 6 (1MZ±FE)
Injector Key Cylinder Light
Ignition SW and Unlock Warning
SW
Integration Relay
Interior Light
Ignition Coil No. 1 (1MZ±FE)
Ignition Coil No. 2 (1MZ±FE)
Ignition Coil No. 3 (1MZ±FE)
Ignition Coil No. 4 (1MZ±FE)
40A AM1
15A CIG/RADIO
40A DEFOG
15A ECU±1G
10A GAUGE
7.5A IGN
10A MIR±HTR
30A POWER
7.5A SRS
15A STOP
15A TAIL
7.5A TURN
20A WIPER
30A AM2
7.5A ALT±S
30A CDS FAN
20A DOME
15A ECU±B
15A EFI
10A HAZ
15A HEAD (LWR±LH)
15A HEAD (LWR±RH)
15A HEAD (UPR±LH)
15A HEAD (UPR±RH)
15A HEAD LH
15A HEAD RH
10A HORN
40A MAIN
7.5A OBD
10A STARTER
10A A/C
40A HEATER
7.5A DRL
100A ALT
60A ABS
Ignition Coil No. 5 (1MZ±FE)
Ignition Coil No. 6 (1MZ±FE)
Junction Connector
Junction Connector
Junction Connector
Junction Connector (for Airbag
System)
I20 I21 J1 J2 J3 J4 80 80 80 8011 2
126
140
17068
8068
8068
8068
8068
8068
80
90
11 8
134
192
224
252 98
120
138
210 80
154
182
190
204126
156
189
198
236130
156
182
214
226
234134
160
198
222
228
236154
168
204
224
230130
134
138
140130
134
138
140
[LOCATION](1)
(7): J/B No. 1 (See page 20)
: R/B No. 7 (See page )(2)
(8): J/B No. 2 (See page 19)
: Fuse Box (F10, F17 See
on page )(3): R/B No. 1 (See page 23)
2022
25
27
28 29

59
11 8
180
186
22480
J5 J6 K3
120
124
144
148168 198130
138
168168120
124
182
192198
204
210
214236
Junction Connector (W/G)
Junction Connector (1MZ±FE)
Key Interlock Solenoid
License Plate Light
Light Failure Sensor
Luggage Compartment Light
Luggage Compartment Light SW
Moon Roof Control RelayMoon Roof Control SW and Personal
Light (w/ Moon Roof) (EX. W/G)Moon Roof Limit SW (EX. W/G)
Moon Roof Motor (EX. W/G)
Mass Air Flow (Air Flow Meter)
(1MZ±FE)
Noise Filter (for Ignition System)
Oil Pressure SW
O/D Main SW and A/T Indicator
Light (Shift Lever)
Park/Neutral Position SW
(Neutral Start SW) (A/T)
Parking Brake SW (for 1MZ±FE)
Parking Brake SW (for 5S±FE)
J7 L1 L2 L4L3 M2 M3 M5M4 M6 N1 N2 N3 O1 O5 P1 P2 P3 P4 P5 P6 P7 P8 P9 P10 P11 P12
Junction Connector (1MZ±FE)
Noise Filter (for Stop Light)
Noise Filter (for Stop Light)
Power Seat Control SW
Power Seat Motor
(for Front Vertical Control)
Power Seat Motor
(for Rear Vertical Control)
Power Seat Motor
(for Slide control)
Power Seat Motor
(for Reclining Control)
Power Window Control SW Front
RH
Power Window Control SW Rear
LH (EX. C/P)
Power Window Control SW Rear
RH (EX. C/P)
Power Window Master SW and
Door Lock control SW LH
182 144130
134
138
140130
134
138
140168 80 80120
124
182
192198
204
210
214126
198
204 68
72
152
198
204236 236 180 180 180 180 180 156 156 156156
160
(4): R/B No. 4 (See page 20)(5): R/B No. 5 (See page 19)(6)R/B No. 6 (See Page )
2526 26