CD player TOYOTA CAMRY 1994 XV10 / 4.G Wiring Diagrams Workshop Manual

33
Position of Parts in Instrument Panel
G 3 Glove Box Light O 5 O/D Main SW and A/T Indicator Light (Shift Lever)
G 4 Glove Box Light SW
P 2 Parking Brake SW (for 1MZ±FE)
H 7 Hazard SW P 3 Parking Brake SW (for 5S±FE)
H 8 Heater Control SW (for Push Control SW Type) or Air P 4 Power Seat Control SW
Vent Mode Control SW (for Lever Control SW Type) P 5 Power Seat Motor (for Front Vertical Control)
H 9 Heated Oxygen Sensor (Bank 1 Sensor 2) P 6 Power Seat Motor (for Rear Vertical Control)
P 7 Power Seat Motor (for Reclining Control)
I 11 Ignition Key Cylinder Light P 8 Power Seat Motor (for Slide Control)
I 12 Ignition SW and Unlock Warning SW
I 13 Integration Relay R 2 Radio and Player (w/ CD Player)
R 3 Radio and Player (w/o CD Player)
J 1 Junction Connector R 4 Radio and Player (w/o CD Player)
J 2 Junction Connector R 5 Rear Window Defogger SW
J 3 Junction Connector R 6 Remote Control Mirror SW
J 4 Junction Connector (for SRS System) R 7 Rheostat
J 7 Junction Connector
S 5 Shift Lock ECU
K 3 Key Interlock Solenoid S 8 Stereo Component Amplifier
S 9 Stereo Component Amplifier
N 2 Noise Filter (for Stop Light) S 10 Stop Light SW
N 3 Noise Filter (for Stop Light)

43
Connector Joining Wire Harness and Wire Harness
CODEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
IG1FLOOR NO. 1 WIRE AND INSTRUMENT PANEL WIRE (LEFT KICK PANEL)
IH1FRONT DOOR LH WIRE AND INSTRUMENT PANEL WIRE (LEFT KICK PANEL)IH2FRONT DOOR LH WIRE AND INSTRUMENT PANEL WIRE (LEFT KICK PANEL)
II1COWL WIRE AND INSTRUMENT PANEL WIRE (LEFT KICK PANEL)
II2INSTRUMENT PANEL WIRE AND COWL WIRE (BEHIND COMBINATION METER)
IJ1FLOOR NO. 1 WIRE AND COWL WIRE (LEFT KICK PANEL)
IK1COWL WIRE AND A/C SUB WIRE (NEAR THE RADIO AND PLAYER)
IL1COWL WIRE AND SERVO MOTOR SUB WIRE (BEHIND RADIO AND PLAYER)
IM1INSTRUMENT PANEL WIRE AND CONSOLE BOX WIRE (NEAR THE RADIO AND PLAYER)IM2INSTRUMENT PANEL WIRE AND CONSOLE BOX WIRE (NEAR THE RADIO AND PLAYER)
IN1INSTRUMENT PANEL WIRE AND SWITCH WIRE (UNDER THE INSTRUMENT PANEL CENTER)

60
POWER SOURCE (Current Flow Chart)
*Page Nos. of
Related Systems
Parts
Code or
Location
CB or Fuse
Location
156
* These are the page numbers of the first page on which the related system is shown.
The part indicated is located somewhere in the system, not necessarily on the page indicated here.


P13 P14 P15 P16 R1 R2 R3 R5 R6 R7 R8 R9156 156126
222
224
228
234126
190154120
124
Power Window Motor Front LH
Power Window Motor Front RH
Power Window Motor Rear LH
(EX. C/P)
Radiator Fan Motor (5S±FE)
Radio and Player (w/ CD Player)
Radio and Player (w/o CD Player)
Rear Window Defogger SW
Remote Control mirror SW
Rheostat
Stop Light LH
[Rear Comb. Light LH]
Taillight LH
[Rear Comb. Light LH]
Rear Turn Signal Light LH
[Rear Comb. Light LH]
Stop Light LH
[Rear Comb. Light LH]
40A AM1
15A CIG/RADIO
40A DEFOG
15A ECU±1G
10A GAUGE
7.5A IGN
10A MIR±HTR
30A POWER
7.5A SRS
15A STOP
15A TAIL
7.5A TURN
20A WIPER
30A AM2
7.5A ALT±S
30A CDS FAN
20A DOME
15A ECU±B
15A EFI
10A HAZ
15A HEAD (LWR±LH)
15A HEAD (LWR±RH)
15A HEAD (UPR±LH)
15A HEAD (UPR±RH)
15A HEAD LH
15A HEAD RH
10A HORN
40A MAIN
7.5A OBD
10A STARTER
10A A/C
40A HEATER
7.5A DRL
100A ALT
60A ABSR10 R11 R16 R17
Power Window Motor Rear RH
(EX. C/P)
Taillight LH
[Rear Comb. Light LH]
Back±up Light LH
[Rear Comb. Light LH]
Stop Light RH
[Rear Comb. Light RH]
Taillight RH
[Rear Comb. Light RH]
Rear Turn Signal Light RH
[Rear Comb. Light RH]
Taillight RH
[Rear Comb. Light RH]
Stop Light RH
[Rear Comb. Light RH]
Back±up Light RH
[Rear Comb. Light RH]
Rear Window Defogger (+)
(EX. W/G)
Rear Window Defogger (±)
(EX. W/G)
Rear Window Defogger (±)
(W/G)
156 242 126 126144
14811 4
148120
124144
148152120
124144
14811 4
11 8144
148120
124152 190 190 190
[LOCATION](1)
(7): J/B No. 1 (See page 20)
: R/B No. 7 (See page )(2)
(8): J/B No. 2 (See page 19)
: Fuse Box (F10, F17 See
on page )(3): R/B No. 1 (See page 23)
2022
25
27
28 29

127
A15
3A
C
IF I14 I16
I14
I164 2
1 2 II2 16
II2 12 B 16
B 6B4 A 6A14C 2
A 13A 8
B 7A
B
B 5
CAAAA
13
B A
21
CCC
C
B2
B2 1 1 2
B
BB
BG
G G
G
G
G G G
G
G
G
G G±WB BB B B
B
W±BW±B W±BB
G
BBJUNCTION CONNECTOR
JUNCTION CONNECTOR
COMBINATION METER
BLOWER SW
RADIO AND PLAYER
A/T INDICATOR LIGHT
[COMB. METER]
ELECTRONIC CONTROLLED
TRANSMISSION PATTERN
SELECT SWA/T INDICATOR LIGHT
(
SHIFT LEVER)
RHEOSTAT
GLOVE BOX LIGHT(
PUSH SW TYPE)
(
LEVER SW TYPE)
GLOVE BOX SW
JUNCTION
CONNECTOR J2 J2 J2
R7
G4 G3E6O5 C11 C8 , C9
B6B
B A
R2 ,R3 ,R4B A12
B
IN1 2
IN1 1
BG
IM2 10
A 10
C 9
IM1 5
(
W/O CD PLAYER)
(
W/ CD PLAYER)G W±G B(
W/ CD PLAYER) (
W/O CD PLAYER)
(
W/ CD PLAYER)(
W/O CD PLAYER)
G
(
W/ CD PLAYER) (
PUSH SW TYPE)
(
LEVER SW TYPE) H8AA/C SW
HEATER CONTROL SW
I17 G
(
W/ CD PLAYER) G
G
1D 11 1B4 1D 10
1L7
1D 11L8 1D 21B5

222
AUTO ANTENNA (S/D, C/P)*
1 : 6 SPEAKER
* 2 : 4 SPEAKER
W±B
AUTO ANTENNA MOTOR
AND CONTROL RELAY
BM A2 1M 145786 256431
R
2G 2
IU1 3 A A
R R R
JUNCTION
CONNECTOR J33
8
1OFF
B±R
L±R
RA DIO AND PLA YER(
*1)
RADIO SW
PLAYER
SW ON
B±R
P±L
II2 9 II2 13
IU1 1IU12
IU1 9IU110IM28
3
8
9OFF RADIO SW
PLAYER
SW ON 9
BB B
L±RB±R
L±R B±R
L±R
GR
W P±L B±R L±R B±R
P±L B±RGRR B±R FROM POWER S OURCE SY STE M(
SEE PAGE 64)
ACC
J UNCTION
CONNECTORSTEREO COMPONENT
AMPLIFIER
RA DIO AND PLA YER(
*2)
(
*2) (
*2)
(
*1) (
*1)
J3S8
R2
R3
L±Y
Y
R±G
B
R±W
W±B
23
LB 20A
DOME
W±B IM2 9 II2 3
R
1L 11L9 15A
ECU±IG15A
CIG/RADIO
1K 121C 1

223
A21 AUTO ANTENNA MOTOR AND RELAY
9±GROUND : APPROX. 12 VOLTS WITH IGNITION SW AT ON POSITION
5±GROUND : APPROX. 12 VOLTS WITH IGNITION SW AT ACC OR ON POSITION
7±GROUND : ALWAYS APPROX. 12 VOLTS
8±GROUND : APPROX. 12 VOLTS WITH IGNITION SW AT ACC OR ON POSITION AND RADIO SW ON
3±GROUND : CONTINUITY (UPPER LIMIT SW ON) UNLESS ANTENNA AT UP STOP
2±GROUND : CONTINUITY (DOWN LIMIT SW ON) UNLESS ANTENNA AT DOWN STOP
4±3 : CLOSED WITH IGNITION SW AT ACC OR ON POSITION AND RADIO SW ON AND PLAYER SW OFF UNTIL ANTENNA AT
UPPERMOST POSITION
1±2 : CLOSED WITH IGNITION SW AT ACC OR ON POSITION AND RADIO SW OFF AND PLAYER SW OFF UNTIL ANTENNA AT
LOWERMOST POSITION
1±2: CLOSED WITH IGNITION SW OFF UNTIL ANTENNA AT LOWERMOST POSITION
: PARTS LOCATION
CODESEE PAGECODESEE PAGECODESEE PAGE
A2134 (S/D), 35 (C/P)R 233S 833
J 333R 333
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
CODESEE PAGEJUNCTION BLOCK AND WIRE HARNESS (CONNECTOR LOCATION)
1C
1K20COWL WIRE AND J/B NO. 1 (INSTRUMENT PANEL LEFT)
1L
20COWL WIRE AND J/B NO. 1 (INSTRUMENT PANEL LEFT)
2G22COWL WIRE AND J/B NO. 2 (ENGINE COMPARTMENT LEFT)
: CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS
CODESEE PAGEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
II242INSTRUMENT PANEL WIRE AND COWL WIRE
IM242INSTRUMENT PANEL WIRE AND CONSOLE BOX WIRE
IU144FLOOR NO. 2 WIRE AND INSTRUMENT PANEL WIRE
: GROUND POINTS
CODESEE PAGEGROUND POINTS LOCATION
BM46 (S/D)UNDER THE LEFT QUARTER PILLARBM48 (C/P)UNDER THE LEFT QUARTER PILLAR
12
34 56B B A A
AABBBB
3
8X3
89
X
X9 A21 J 3 R 2 R 3
S8BLUE
1
(
HINT : SEE PAGE 7)
SERVICE HINTS

224
AUTO ANTENNA (W/G)*
1 : 8 SPEAKER
* 2 : 6 SPEAKER
W±B
AUTO ANTENNA MOTOR
AND RELAY
BL A2 1
M 145786 256431
RR R
3
8
1OFF
B±R
L±R
RADIO A ND P LAY ER(
*1)
RADIO S W
PLAYER
SW ON
B±R
P±L
II2 9 II2 13
IG1 1IG12
IG1 9IG110IM28
3
8
9OFF RADIO S W
PLAYER
SW ON 9
BB B
L±RB±R
L±R B±R
L±R
GR
W P±L B±R L±R B±R
P±L B±RGR RB±R ACC
JUNCTION
CONNE CTORSTEREO COMPONENT
AMPLIFIER
RADIO A ND P LAY ER(
*2)
(
*2) (
*2)
(
*1) (
*1)
J3S8
R2
R3
L±Y
Y
R±G
B
R±W
W±B
23
LBW±B IM2 9
C C
JUNCTION
CONNECTOR J5
1H 61C 1
2G 21L11L9 FROM POWER SOURCE SYSTEM(
SEE PAGE 64)
15A
ECU±IG15A
CIG/RA DIO 20A
DOME

225
A21 AUTO ANTENNA MOTOR AND RELAY
9±GROUND : APPROX. 12 VOLTS WITH IGNITION SW AT ON POSITION
5±GROUND : APPROX. 12 VOLTS WITH IGNITION SW AT ACC OR ON POSITION
7±GROUND : ALWAYS APPROX. 12 VOLTS
8±GROUND : APPROX. 12 VOLTS WITH IGNITION SW AT ACC OR ON POSITION AND RADIO SW ON
3±GROUND : CONTINUITY (UPPER LIMIT SW ON) UNLESS ANTENNA AT UP STOP
2±GROUND : CONTINUITY (DOWN LIMIT SW ON) UNLESS ANTENNA AT DOWN STOP
4±3 : CLOSED WITH IGNITION SW AT ACC OR ON POSITION AND RADIO SW ON AND PLAYER SW OFF UNTIL ANTENNA
AT UPPERMOST POSITION
1±2 : CLOSED WITH IGNITION SW AT ACC OR ON POSITION AND RADIO SW OFF AND PLAYER SW OFF UNTIL ANTENNA
AT LOWERMOST POSITION
1±2 : CLOSED WITH IGNITION SW OFF UNTIL ANTENNA AT LOWERMOST POSITION
: PARTS LOCATION
CODESEE PAGECODESEE PAGECODESEE PAGE
A2136 (W/G)J 536 (W/G)R 333
J 333R 233S 833
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
CODESEE PAGEJUNCTION BLOCK AND WIRE HARNESS (CONNECTOR LOCATION)
1C20COWL WIRE AND J/B NO. 1 (INSTRUMENT PANEL LEFT)
1H20FLOOR NO. 1 WIRE J/B NO. 1 (INSTRUMENT PANEL LEFT)
1L20COWL WIRE AND J/B NO. 1 (INSTRUMENT PANEL LEFT)
2G22COWL WIRE AND J/B NO. 2 (ENGINE COMPARTMENT LEFT)
: CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS
CODESEE PAGEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
II242INSTRUMENT PANEL WIRE AND COWL WIRE
IM242INSTRUMENT PANEL WIRE AND CONSOLE BOX WIRE
IG142FLOOR NO. 1 WIRE AND INSTRUMENT PANEL WIRE
: GROUND POINTS
CODESEE PAGEGROUND POINTS LOCATION
46 (S/D)
BL48 (C/P)UNDER THE LEFT QUARTER PILLARBL
50 (W/G)
UNDER THE LEFT QUARTER PILLAR
12
345 6
3
8X
3
89X
X9 A21R2
R3 S8BLUECC CC
CC C C CCJ5
BB BBJ3
B B
(
HINT : SEE PAGE 7)1
(
HINT : SEE PAGE 7)
SERVICE HINTS

226
RADIO AND PLAYER (S/D, C/P 6 SPEAKER)
A
B 10 A7
B 5 B 1 B 6 B 2 B 7B8B9B3B4
IM2 2IM2IM12IM16IM11IM13IM2 6IM2 5
1111
1 12222
2 2 II2 9 II2 3
AB
B A
IH
R R R
L±R L±Y
GR BR
P
V
B
Y
R
W
LG
L L LGWRY B V
P P
V
LG
L BR
FROM POWER SOURCE S
E FL+ FL± RL+ RL± RR+ RR± FR+ FR±BACC
L±R JUNCTION
CONNECTOR
FRONT DOOR
SPEAKER LH FRONT TWEETER
(
SPEAKER)
LHFRONT TWEETER
(
SPEAKER)
RH REAR SPEAKER
LHREAR SPEAKER
RH
FRONT DOOR
SPEAKER RH F1 0 F12
R12 R13 F13
F1 1
J3
S8 , S9B
STEREO COMPONENT AMPLIFIER
IH1 8IH113 IG18IG118 IG17IG117 IT24IT29
L LGWRY B V
P
IM2 7A 3A9A10 A11 A12 A4A6A5A14 A13 4311 12135761514
IM2 4IM23
L±Y
GR
(
SHIELDED) (
SHIELDED)
(
SHIELDED)
B ACC GND SGND BEEP MUTE FR FL RR RL
B
W
BR
W
R
BR
B
L
G
Y
ANTIU1 9
8
B±R B±R
TO AUTO ANTENNA M OTOR
AND RELAY
RADIO AND PLAYER R2
1 I15 B ACC GND SGND BEEP MUTE FR FL RR RL
A 11
AMP
R
AMP
I15 IM2 9
RP±L
R TO AUTO ANTENNA MOTOR
AND RELAYIM2 8
B±R
1L 915A
CIG/RADIO YSTEM(
SEE PAGE 64)
1K 121C 1
2G 220A
DOME

228
RADIO AND PLAYER (S/D, C/P 4 SPEAKER)
B
B 8B9B4B3
B 5 B 1 B 6 B 2 B 7A2A6A1A3
IH1 8IH113 IG18IG118 IG17IG117 IT24IT29
111 1222 2II2 9 II2 3
AB
B A
IHIU1 10 IU1 9
R R R
L±R L±YP±L B±R
GRP±L B±R BR
P
V
B
Y
R
W
LG
L L LGWRY B V P BR
FROM POWER SOURCE SYSTEM
E FL+ FL± RL+ RL± RR+ RR± FR+ FR±ANT ANP B ACC
L±R
RADIO AND PLAYER JUNCTION
CONNECTOR TO AUTO ANTENNA MOTOR
AND RELAY
FRONT DOOR
SPEAKER LHREAR SPEAKER
LHREAR SPEAKER
RHFRONT DOOR
SPEAKER RH F1 0
R12 R13 F11J3
R3 , R4A
1K 121C 1
1L 915A
CIG/RA DIO (
SEE PAGE 64)2G 220A
DOME