automatic transmission fluid TOYOTA CAMRY 2000 Service User Guide

'99camry U
205
Tire surface and wheel nuts
Check the tires carefully for cuts, damage
or excessive wear. See Chapter 7±2 for
additional information. When checking the
tires, make sure no nuts are missing, and
check the nuts for looseness. Tighten
them if necessary.
Tire rotation
Rotate the tires every 12000 km (7500
miles). See Chapter 7±2 for additional in-
formation.
Fluid leaks
Check underneath for leaking fuel, oil, wa-
ter or other fluid after the vehicle has
been parked for a while. If you smell fuel
fumes or notice any leak, have the cause
found and corrected immediately.
Doors and engine hood
Check that all doors including trunk lid
operate smoothly and all latches lock se-
curely. Make sure the engine hood sec-
ondary latch secures the hood from open-
ing when the primary latch is released.
INSIDE THE VEHICLE
Items listed below should be checked
regularly, e.g. while performing periodic
services, cleaning the vehicle, etc.Lights
Make sure the headlights, stop lights, tail
lights, turn signal lights, and other lights
are all working. Check headlight aim.
Service reminder indicators and warning
buzzers
Check that all service reminder indicators
and warning buzzers function properly.
Steering wheel
Be alert for changes in steering condition,
such as hard steering or strange noise.
Seats
Check that all front seat controls such as
seat adjusters, seatback recliner, etc. op-
erate smoothly and that all latches lock
securely in any position. Check that the
head restraints move up and down
smoothly and that the locks hold securely
in any latched position. For folding±down
rear seatbacks, check that the latches
lock securely.
Seat belts
Check that the seat belt system such as
buckles, retractors and anchors operate
properly and smoothly. Make sure that the
belt webbings not cut, frayed, worn or
damaged.Accelerator pedal
Check the pedal for smooth operation and
uneven pedal effort or catching.
Clutch pedal
Check the pedal for smooth operation.
Brake pedal
Check the pedal for smooth operation and
that the pedal has the proper clearance.
Check the brake booster function.
Brakes
At a safe place, check that the brakes do
not pull to one side when applied.
Parking brake
Check that the lever has the proper travel
and that, on a safe incline, your vehicle
is held securely with only the parking
brake applied.
Automatic transmission ºParkº mecha-
nism
Check the lock release button of the se-
lector lever for proper and smooth opera-
tion. On a safe incline, check that your
vehicle is held securely with the selector
lever in ºPº position and all brakes re-
leased.

'99camry U
241
ENGINE LUBRICATION
Oil capacity (drain and refill), L (qt., Imp.
qt.):
5S±FE engine
With filter 3.6 (3.8, 3.2)
Without filter 3.4 (3.6, 3.0)
1MZ±FE engine
With filter 4.7 (5.0, 4.1)
Without filter 4.5 (4.8, 4.0)
Oil grade:
API grade SJ, ºEnergy±Conservingº or
ILSAC multigrade engine oil is recom-
mended.
Recommended oil viscosity (SAE):COOLING SYSTEM
Total capacity, L (qt., Imp. qt.):
5S±FE engine 6.9 (7.3, 6.1)
1MZ±FE engine 9.1 (9.6, 8.4)
Coolant type:
ºToyota Long Life Coolantº or equivalent
With ethylene±glycol type coolant for a
proper corrosion protection of aluminum
components
Do not use alcohol type antifreeze or
plain water alone.
BATTERY
Open voltage
* at 20C (68F):
12.6Ð12.8V Fully charged
12.2Ð12.4V Half charged
11.8Ð12.0V Discharged
*: Voltage that is checked 20 minutes after
the key is removed with all the lights
turned off
Charging rates:
5 A max.CLUTCH
Pedal freeplay, mm (in.):
5Ð15 (0.2Ð0.6)
Fluid type:
SAE J1703 or FMVSS No.116 DOT 3
MANUAL TRANSAXLE
Oil capacity, L (qt., Imp. qt.):
5S±FE engine 2.2 (2.3, 1.9)
1MZ±FE engine 4.2 (4.4, 3.7)
Oil type:
Gear oil API GL±4 or GL±5
Recommended oil viscosity:
SAE 75W±90
AUTOMATIC TRANSAXLE
1MZ±FE engine
Fluid capacity (drain and refill),
L (qt., Imp. qt.):
Up to 4.75 (5.0, 4.2)
Fluid type:
Automatic transmission fluid D±ll or
DEXRONIIl (DEXRONII)

'99camry U
242
5S±FE engine
Automatic transmission
Fluid capacity (drain and refill),
L (qt., Imp. qt.):
Up to 2.5 (2.6, 2.2)
Fluid type:
Automatic transmission fluid D±ll or
DEXRONIIl (DEXRONII)
Differential
Fluid capacity L (qt., Imp. qt.):
1.6 (1.7, 1.4)
Fluid type:
Automatic transmission fluid D±II or
DEXRONIII (DEXRONII)
BRAKES
Minimum pedal clearance when depressed
with the pressure of 490 N (50 kgf, 110 lbf)
with the engine running, mm (in.):
70 (2.8)
Pedal freeplay, mm (in.):
1Ð6 (0.04Ð0.24)
Pad wear limit, mm (in.):
1.0 (0.04)
Lining wear limit, mm (in.):
1.0 (0.04)
Parking brake adjustment when pulled with
the force of 196 N (20 kgf, 44 lbf):
5Ð8 clicksFluid type:
SAE J1703 or FMVSS No.116 DOT 3
STEERING
Wheel freeplay:
Less than 30 mm (1.2 in.)
Power steering fluid type:
Automatic transmission fluid DEXRONII
or III

NF
NEW FEATURES Ð A140E AUTOMATIC TRANSAXLE AND BRAKES
A140E AUTOMATIC TRANSAXLE
DESCRIPTION
As in the 5S-FE engine model, the A140E automatic transaxle is used on the 5S-FNE engine model.
The gear ratio of the differential has been lowered to accommodate the performance of the 5S-FNE engine
and to ensure fuel economy.

Specifications 
Item
5S-FNE Engine5S-FE Engine
1st2.810
2nd1.549
Gear Ratio3rd1.000
Overdrive0.706
Reverse2.296
Counter Gear Ratio0.945
Differential Gear Ratio4.1763.944
Fluid Capacity litersTransmission5.6 (5.9, 4.9)Fluid Capacity liters
(US qts, Imp. qts)Differential1.6 (1.7, 1.4)
Fluid TypeATF D-II or
DEXRONIII (DEXRONII)
BRAKES
DESCRIPTION
The front brake size has been changed.

Specifications 
Item
5S-FNE Engine Model5S-FE Engine Model
TypeVentilated Disc
Caliper TypePE60PE57
Front BrakeWheel Cylinder Diameter
mm (in.)60.33 (2.38)57.22 (2.25)
Rotor Size (D
T)*
mm (in.)275
28
(10.83
1.10)255
28
(10.04
1.10)
*: D : Outer Diameter, T : Thickness

SCHEDULED MAINTENANCE LOGS20
The following descriptions are provided to give you a better
understanding of the maintenance items that should be per-
formed on your vehicle. The Scheduled Maintenance Log
indicates at which mileage/time intervals each item should be
performed. Please note that many maintenance items should be
performed only by a qualified technician.
For further information on maintenance items you can per-
form yourself, see the “General Maintenance and Care” and
“Do- It-Yourself Maintenance” sections of your
Owner’s Manual.
Automatic Transmission Fluid
or Manual Transmission Oil
Inspect each component for signs of leakage. If you discover any
leakage, have it repaired by a qualified technician immediately.
Ball Joints and Dust Covers
Check the suspension and steering linkage ball joints for loose-
ness and damage. Check all dust covers for deterioration and
damage. A qualified technician should perform these inspections.
Brake Lines and Hoses
Visually inspect for proper installation. Check for chafing,
cracks, deterioration and evidence of leaking. Replace any deteri-
orated or damaged parts immediately. A qualified technician
should perform these operations.
Explanation of Maintenance Items

Maintenance Log.
. Cars & Sienna
SCHEDULED MAINTENANCE LOGS25
15,000 Miles or 12 Months
❑Replace engine oil and oil filter
❑Rotate tires
❑Re-torque drive shaft flange bolts (Sienna)
❑Inspect the following:__
Automatic transmission fluid__
Drive shaft boots
__
Ball joints and dust covers__
Exhaust pipes and mountings
__
Brake lines and hoses__
Steering gear box
__
Brake linings/drums and brake pads/discs__
Steering linkage
__
Differential oil
Additional Maintenance Items for Special Operating Conditions:*
❑Inspect engine air filter
❑Inspect nuts and bolts on chassis and body
❑Replace automatic transmission fluid
❑Replace differential oil
Date: __________________
Mileage: _______________
15,000 Miles or 12 Months
15,000 Miles or 12 Months
DEALER SERVICE VERIFICATION

Maintenance Log.
. Cars & Sienna
SCHEDULED MAINTENANCE LOGS29
45,000 Miles or 36 Months
❑Replace engine oil and oil filter
❑Rotate tires
❑Re-torque drive shaft flange bolts (Sienna)
❑Inspect the following:__
Automatic transmission fluid__
Drive shaft boots
__
Ball joints and dust covers__
Exhaust pipes and mountings
__
Brake lines and hoses__
Steering gear box
__
Brake linings/drums and brake pads/discs__
Steering linkage
__
Differential oil
Additional Maintenance Items for Special Operating Conditions: *
❑Inspect engine air filter
❑Inspect nuts and bolts on chassis and body
❑Replace differential oil
❑Replace automatic transmission fluid
Date: __________________
Mileage: _______________
45,000 Miles or 36 Months
45,000 Miles or 36 Months
DEALER SERVICE VERIFICATION

Maintenance Log.
. Cars & Sienna
SCHEDULED MAINTENANCE LOGS33
75,000 Miles or 60 Months
❑Replace engine oil and oil filter
❑Rotate tires
❑Re-torque drive shaft flange bolts (Sienna)
❑Inspect the following:__
Automatic transmission fluid__
Drive belts
__
Ball joints and dust covers__
Drive shaft boots
__
Brake lines and hoses__
Exhaust pipes and mountings
__
Brake linings/drums and brake pads/discs__
Steering gear box
__
Differential oil__
Steering linkage
Additional Maintenance Items for Special Operating Conditions: *
❑Inspect engine air filter
❑Inspect nuts and bolts on chassis and body
❑Replace differential oil
❑Replace automatic transmission fluid
Date: __________________
Mileage: _______________
75,000 Miles or 60 Months
75,000 Miles or 60 Months
DEALER SERVICE VERIFICATION

Maintenance Log.
. Cars & Sienna
SCHEDULED MAINTENANCE LOGS37
105,000 Miles or 84 Months
❑Replace engine oil and oil filter
❑Rotate tires
❑Re-torque drive shaft flange bolts (Sienna)
❑Inspect the following:__
Automatic transmission fluid__
Drive belts
__
Ball joints and dust covers__
Drive shaft boots
__
Brake lines and hoses__
Exhaust pipes and mountings
__
Brake linings/drums and brake pads/discs__
Steering gear box
__
Differential oil__
Steering linkage
Additional Maintenance Items for Special Operating Conditions: *
❑Inspect engine air filter
❑Inspect nuts and bolts on chassis and body
❑Replace differential oil
❑Replace automatic transmission fluid
Date: __________________
Mileage: _______________
105,000 Miles or 84 Months
105,000 Miles or 84 Months
DEALER SERVICE VERIFICATION

Maintenance Log.
. SUVs & Tacoma
SCHEDULED MAINTENANCE LOGS41
15,000 Miles or 12 Months
❑Replace engine oil and oil filter
❑Rotate tires
❑Lubricate propeller shaft and re-torque bolts (all 4WD except RAV4)
❑Re-torque drive shaft flange bolts (all 4WD except Land Cruiser)
❑Inspect the following:__
Automatic transmission fluid__
Differential oil
__
Ball joints and dust covers__
Drive shaft boots
__
Brake lines and hoses__
Exhaust pipes and mountings
__
Brake linings/drums and brake pads/discs__
Steering gear box
__
Limited-slip differential oil__
Steering linkage
(Land Cruiser, 4WD RAV4)
1
Additional Maintenance Items for Special Operating Conditions:*
❑Inspect engine air filter
❑Inspect nuts and bolts on chassis and body
❑Replace automatic transmission fluid
❑Replace differential oil (including limited-slip)
Date: __________________
Mileage: _______________
15,000 Miles or 12 Months
15,000 Miles or 12 Months
DEALER SERVICE VERIFICATION
1If vehicle is equipped with limited-slip differential.