engine mount TOYOTA CAMRY 2000 Service Manual PDF

NEW FEATURES Ð 5S-FNE ENGINE 16
6. Fuel Filter
Mounted below the vehicle floor, the fuel filter re-
moves any moisture or oil from the fuel.
7. Fuel Pressure Regulator
The fuel pressure regulator regulates the fuel pressure by reducing the pressure of the compressed natural
gas from the fuel tank to the fuel injection pressure, which is 8 km/cm
2 (114 psi, 785 kPa).
Similar to the fuel shutoff valve for the fuel tank, a fuel shutoff valve is provided on the fuel inlet side
of the fuel pressure regulator to shut off the supply of fuel when the engine is stopped or during abnormal
conditions.
An oil separator that traps the moisture and oil in the fuel is provided on the low pressure side.
A built-in relief valve is provided to protect the parts located on the low pressure side.
While the fuel pressure is being reduced by the fuel pressure regulator, the Joule-Thomson effect associat-
ed with the expansion of the gas causes the fuel pressure regulator to be cooled excessively, exerting
unfavorable influence on the rubber parts such as diaphragms and fuel hoses.
Therefore, to raise the gas temperature, a water passage is provided in the fuel pressure regulator to
allow the engine coolant to warm the regulator.
Oil
Separator
Water Passage
Fuel
Shutoff
Valve
Relief Valve
167CN24 167CN25167CN10

NF
NEW FEATURES Ð 5S-FNE ENGINE17
8. Delivery Pipe
A delivery pipe with a wide passage that enables a large volume of gas to flow responsively has been
adopted to minimize the pressure loss.
A fuel pressure sensor and a fuel temperature sensor that help correct the fuel injection volume are mounted
on the delivery pipe.
Similar to the fuel shutoff valves for the fuel tank and the fuel pressure regulator, a fuel shutoff valve
is provided on the fuel inlet side of the delivery pipe to shut off the supply of fuel when the engine
is stopped or during abnormal conditions.
To discharge the fuel out of the delivery pipe during service, a discharge valve is provided.
Injector
167CN13
Discharge
ValveFuel Pressure Sensor
Fuel Temp. Sensor
Delivery Pipe
CNG
Fuel Shutoff
Valve
9. Injector
For the injection of fuel in the gaseous state, injectors that allow the flow of a large volume of fuel and
provide improved sealing performance have been adopted.
These injectors are actuated by the voltage (150V) that has been increased by the voltage booster circuit
provided in the ECM.
ECM
167CN14
167CN23
Rubber Sheet
12V
+B
Voltage
Booster
Circuit#10+
#10Injector

SCHEDULED MAINTENANCE LOGS22Engine Valves
Inspect for excessive lifter noise and engine vibration and adjust if
necessary. A qualified technician should perform this operation.
Exhaust Pipes and Mountings
Visually inspect the exhaust pipes, muffler and hangers for
cracks, deterioration and damage. Start the engine and listen
carefully for any exhaust gas leakage. Tighten connections or
replace parts as necessary.
Fuel Lines and Connections, Fuel Tank Band
and Fuel Tank Vapor Vent System Hoses
Visually inspect for corrosion, damage, cracks and loose or leaking
connections. Tighten connections or replace parts as necessary.
Fuel Tank Cap Gasket
Visually inspect for cracks, deterioration and damage and
replace if necessary.
Nuts and Bolts on Chassis and Body
Re- tighten the seat mounting bolts and front/rear suspension
member retaining bolts to specified torque.
Propeller Shaft
Lubricate the propeller shaft spiders and slide yokes with
lithium- base chassis grease and the double cardan joint with
molybdenum- disulfide lithium- base chassis grease, and re-
torque the flange bolts. Only a qualified technician should
re- torque the flange bolts.
Spark Plugs
Install new plugs of the same type as originally equipped. A
qualified technician should perform this operation.
Steering Gear Box
Inspect for signs of leakage. If you discover any leakage, have it
repaired immediately by a qualified technician.
Explanation of Maintenance Items

Maintenance Log.
. Cars & Sienna
SCHEDULED MAINTENANCE LOGS25
15,000 Miles or 12 Months
❑Replace engine oil and oil filter
❑Rotate tires
❑Re-torque drive shaft flange bolts (Sienna)
❑Inspect the following:__
Automatic transmission fluid__
Drive shaft boots
__
Ball joints and dust covers__
Exhaust pipes and mountings
__
Brake lines and hoses__
Steering gear box
__
Brake linings/drums and brake pads/discs__
Steering linkage
__
Differential oil
Additional Maintenance Items for Special Operating Conditions:*
❑Inspect engine air filter
❑Inspect nuts and bolts on chassis and body
❑Replace automatic transmission fluid
❑Replace differential oil
Date: __________________
Mileage: _______________
15,000 Miles or 12 Months
15,000 Miles or 12 Months
DEALER SERVICE VERIFICATION

Maintenance Log.
. Cars & Sienna
SCHEDULED MAINTENANCE LOGS27
30,000 Miles or 24 Months
❑Replace engine air filter❑Replace engine coolant
❑Replace engine oil and oil filter❑Rotate tires
❑Replace non-platinum spark plugs (Corolla, Paseo, Tercel)1
❑Repack front wheel bearings (Paseo, Tercel)
❑Re-torque drive shaft flange bolts (Sienna)
❑Inspect the following:__
Ball joints and dust covers__
Drive shaft boots
__
Brake lines and hoses__
Exhaust pipes and mountings
__
Brake linings/drums and brake pads/discs__
Fuel tank cap gasket
__
Differential oil__
Steering gear box
__
Drive belts (non-ribbed)__
Steering linkage
__
Fuel lines and connections, fuel tank band__
Transmission fluid or oil
and fuel tank vapor vent system hoses
Additional Maintenance Items for Special Operating Conditions:*
❑Inspect nuts and bolts on body and chassis
❑Replace differential oil
❑Replace transmission fluid or oil
Date: __________________
Mileage: _______________
30,000 Miles or 24 Months
30,000 Miles or 24 Months
DEALER SERVICE VERIFICATION
1Required under the terms of the Emission Control Warranty.

Maintenance Log.
. Cars & Sienna
SCHEDULED MAINTENANCE LOGS29
45,000 Miles or 36 Months
❑Replace engine oil and oil filter
❑Rotate tires
❑Re-torque drive shaft flange bolts (Sienna)
❑Inspect the following:__
Automatic transmission fluid__
Drive shaft boots
__
Ball joints and dust covers__
Exhaust pipes and mountings
__
Brake lines and hoses__
Steering gear box
__
Brake linings/drums and brake pads/discs__
Steering linkage
__
Differential oil
Additional Maintenance Items for Special Operating Conditions: *
❑Inspect engine air filter
❑Inspect nuts and bolts on chassis and body
❑Replace differential oil
❑Replace automatic transmission fluid
Date: __________________
Mileage: _______________
45,000 Miles or 36 Months
45,000 Miles or 36 Months
DEALER SERVICE VERIFICATION

Maintenance Log.
. Cars & Sienna
SCHEDULED MAINTENANCE LOGS31
60,000 Miles or 48 Months
❑Replace engine air filter❑Replace engine coolant
❑Replace engine oil and oil filter❑Rotate tires
❑Replace platinum spark plugs1
❑Replace non-platinum spark plugs (Corolla, Paseo, Tercel)1
❑Repack front wheel bearings (Paseo, Tercel)
❑Re-torque drive shaft flange bolts (Sienna)
❑Inspect the following:__
Ball joints and dust covers__
Drive shaft boots
__
Brake lines and hoses__
Engine valves
__
Brake linings/drums and brake pads/discs__
Exhaust pipes and mountings
__
Charcoal canister
2__
Fuel tank cap gasket
__
Differential oil__
Steering gear box
__
Drive belts__
Steering linkage
__
Fuel lines and connections, fuel tank band__
Transmission fluid or oil
and fuel tank vapor vent system hoses
Additional Maintenance Items for Special Operating Conditions:*❑Inspect nuts and bolts on body and chassis❑Replace differential oil❑Replace transmission fluid or oil
Date: __________________
Mileage: _______________
60,000 Miles or 48 Months
60,000 Miles or 48 Months
DEALER SERVICE VERIFICATION
1Required under the terms of the Emission Control Warranty.2Inspect at 60,000 miles or 72 months, whichever comes first, for Avalon, 6-cyl. Camry,
6-cyl. Camry Solara, Paseo, Sienna and Tercel. Required only for vehicles in California,
Massachusetts and New York.

Maintenance Log.
. Cars & Sienna
SCHEDULED MAINTENANCE LOGS33
75,000 Miles or 60 Months
❑Replace engine oil and oil filter
❑Rotate tires
❑Re-torque drive shaft flange bolts (Sienna)
❑Inspect the following:__
Automatic transmission fluid__
Drive belts
__
Ball joints and dust covers__
Drive shaft boots
__
Brake lines and hoses__
Exhaust pipes and mountings
__
Brake linings/drums and brake pads/discs__
Steering gear box
__
Differential oil__
Steering linkage
Additional Maintenance Items for Special Operating Conditions: *
❑Inspect engine air filter
❑Inspect nuts and bolts on chassis and body
❑Replace differential oil
❑Replace automatic transmission fluid
Date: __________________
Mileage: _______________
75,000 Miles or 60 Months
75,000 Miles or 60 Months
DEALER SERVICE VERIFICATION

Maintenance Log.
. Cars & Sienna
SCHEDULED MAINTENANCE LOGS35
90,000 Miles or 72 Months
❑Replace engine air filter❑Replace engine coolant
❑Replace engine oil and oil filter❑Rotate tires
❑Replace non-platinum spark plugs (Corolla, Paseo, Tercel)1
❑Repack front wheel bearings (Paseo, Tercel)
❑Re-torque drive shaft flange bolts (Sienna)
❑Replace timing belt (except Corolla)
❑Inspect the following:__
Ball joints and dust covers__
Drive shaft boots
__
Brake lines and hoses__
Exhaust pipes and mountings
__
Brake linings/drums and brake pads/discs__
Fuel tank cap gasket
__
Differential oil__
Steering gear box
__
Drive belts (non-ribbed)__
Steering linkage
__
Fuel lines and connections, fuel tank band__
Transmission fluid or oil
and fuel tank vapor vent system hoses
Additional Maintenance Items for Special Operating Conditions:*
❑Inspect nuts and bolts on body and chassis
❑Replace differential oil
❑Replace transmission fluid or oil
Date: __________________
Mileage: _______________
90,000 Miles or 72 Months
90,000 Miles or 72 Months
DEALER SERVICE VERIFICATION
1Required under the terms of the Emission Control Warranty.

Maintenance Log.
. Cars & Sienna
SCHEDULED MAINTENANCE LOGS37
105,000 Miles or 84 Months
❑Replace engine oil and oil filter
❑Rotate tires
❑Re-torque drive shaft flange bolts (Sienna)
❑Inspect the following:__
Automatic transmission fluid__
Drive belts
__
Ball joints and dust covers__
Drive shaft boots
__
Brake lines and hoses__
Exhaust pipes and mountings
__
Brake linings/drums and brake pads/discs__
Steering gear box
__
Differential oil__
Steering linkage
Additional Maintenance Items for Special Operating Conditions: *
❑Inspect engine air filter
❑Inspect nuts and bolts on chassis and body
❑Replace differential oil
❑Replace automatic transmission fluid
Date: __________________
Mileage: _______________
105,000 Miles or 84 Months
105,000 Miles or 84 Months
DEALER SERVICE VERIFICATION