engine TOYOTA CAMRY 2009 XV40 / 8.G Warranty And Maintenance Guide
[x] Cancel search | Manufacturer: TOYOTA, Model Year: 2009, Model line: CAMRY, Model: TOYOTA CAMRY 2009 XV40 / 8.GPages: 34, PDF Size: 0.57 MB
Page 10 of 34
Basic Warranty
This warranty covers repairs and adjustments needed to correct defects
in materials or workmanship of any part supplied by Toyota, subject to
the exceptions indicated under “What Is Not Covered” on pages 11–12.
Coverage is for 36 months or 36,000 miles, whichever occurs first,
with the exception of wheel alignment and wheel balancing, which are
covered for 12 months or 20,000 miles, whichever occurs first.
Powertrain Warranty
This warranty covers repairs needed to correct defects in materials or
workmanship of any component listed in the next column and supplied
by Toyota, subject to the exceptions indicated under “What Is Not
Covered” on pages 11–12.
Coverage is for 60 months or 60,000 miles, whichever occurs first. Engine
Cylinder block and head and all internal parts, timing gears and gas-
kets, timing chain/belt and cover, flywheel, valve covers, oil pan, oil
pump, engine mounts, turbocharger housing and all internal parts,
supercharger housing and all internal parts, engine control computer,
water pump, fuel pump, seals and gaskets.
Transmission and Transaxle
Case and all internal parts, torque converter, clutch cover, transmission
mounts, transfer case and all internal parts, engine control computer,
seals and gaskets.
Front-Wheel-Drive System
Final drive housing and all internal parts, axle shafts, drive shafts,
constant velocity joints, front hub and bearings, seals and gaskets.
Rear-Wheel-Drive System
Axle housing and all internal parts, propeller shafts, U-joints, axle
shafts, drive shafts, bearings, supports, seals and gaskets.
WHAT IS COVERED AND HOW LONG
Your Warranties in Detail9
NEW VEHICLE LIMITED WARRANTY
117510.Text.cgla 12/14/07 12:10 AM Page 9
Page 12 of 34
This warranty does not cover damage or failures resulting directly or
indirectly from any of the following:
•Fire, accidents or theft
•Abuse or negligence
•Misuse — for example, racing or overloading
•Improper repairs
•Alteration or tampering, including installation of non-Genuine
Toyota Accessories
•Lack of or improper maintenance, including use of fluids other
than those specified in the
Owner’s Manual
•Installation of non-Genuine Toyota Parts
•Airborne chemicals, tree sap, road debris (including stone chips),
rail dust, salt, hail, floods, wind storms, lightning and other
environmental conditions
•Water contamination This warranty also does not cover the following:
Tires
Tires are covered by a separate warranty provided by the tire manufac-
turer. See page 26.
Normal Wear and Tear
Noise, vibration, cosmetic conditions and other deterioration caused
by normal wear and tear.
Maintenance Expense
Normal maintenance services such as:
•Engine tune-ups
•Replacement of fluids and filters
•Lubrication
•Cleaning and polishing
•Replacement of spark plugs and fuses
•Replacement of worn wiper blades, brake pads/linings and
clutch linings
WHAT IS NOT COVERED
Your Warranties in Detail11
NEW VEHICLE LIMITED WARRANTY
117510.Text.cgla 12/14/07 12:10 AM Page 11
Page 16 of 34
These warranty obligations do not apply to failures or noncompliance
caused by:
•The use of replacement parts not certified in accordance with
aftermarket parts certification regulations.
•The use of replacement parts not equivalent in quality or design
to original equipment parts.
Provisions under the “What Is Not Covered” section of the New Vehicle
Limited Warranty also apply to this warranty.
Air/Fuel Metering System
•
Air/fuel ratio feedback control system
•Cold-start enrichment system
•Deceleration control system
•Electronic fuel injection system components
– Airflow sensor
– Engine control module (8/80)
– Throttle body
– Other components
Air Induction System
•
Intake manifold and intake air surge tank
Catalyst System
•
Catalytic converter and protector (8/80)
•Constricted fuel filler neck
•Exhaust manifold
•Exhaust pipe (manifold to catalyst and/or catalyst to catalyst)
WHAT IS NOT COVERED WARRANTY PARTS LIST
Your Warranties in Detail15
FEDERAL EMISSION CONTROL WARRANTY
8/80 = Covered for eight years or 80,000 miles, whichever occurs first.
117510.Text.cgla 12/14/07 12:10 AM Page 15
Page 21 of 34
YOUR WARRANTY RIGHTS
AND OBLIGATIONS
Vehicles equipped with a California Certified Emission Control
System that are sold, registered and operated in California or any
state that adopts California emission warranty provisions are cov-
ered by this warranty. Currently, Connecticut, Maine, Massachusetts,
New Jersey, Or egon, Pennsylvania, Rhode Island, Vermont and
Washington are the other states to which this warranty applies.
Vehicles covered by this warranty are also covered by the Federal
Emission Control Warranty (see page 14). Note: Camry PZEV
models sold, registered and operated in California, Connecticut,
Maine, Massachusetts, New Hampshire, New Jersey, New York,
Oregon, Rhode Island and Vermont are also covered by the
California Emission Control Warranty. For these vehicles, all emis-
sions components are covered for 15 years or 150,000 miles,
whichever occurs first, for performance and defect. The California Air Resources Board (CARB) and Toyota are pleased to
explain the emission control system warranty for your 2009 vehicle.
In California, new motor vehicles must be designed, built and equipped
to meet the state’s stringent anti-smog standards. CARB regulations
require that Toyota must warrant the emission control system on your
vehicle for the time periods indicated on the next page, provided there
has been no abuse, neglect or improper maintenance of your vehicle.
Your emission control system may include parts such as the fuel injec-
tion system, ignition system, catalytic converter and engine computer.
Also included may be hoses, belts, connectors and other emissions-
related assemblies.
Where a warrantable condition exists, Toyota will repair your vehicle at
no cost to you, including diagnosis, parts and labor.
Your Warranties in Detail20
CALIFORNIA EMISSION CONTROL WARRANTY
117510.Text.cgla 12/14/07 12:10 AM Page 20
Page 23 of 34
WHAT IS NOT COVERED PARTS LIST: LONG-TERM EMISSION DEFECT WARRANTY
These warranty obligations do not apply to failures or noncompliance
caused by:
•The use of replacement parts not certified in accordance with
aftermarket parts certification regulations.
•The use of replacement parts not equivalent in quality or design
to original equipment parts.
Provisions under the “What Is Not Covered” section of the New Vehicle
Limited Warranty also apply to this warranty. The parts listed here are covered for seven years or 70,000 miles from
the vehicle’s in-service date, whichever occurs first.*
Air/Fuel Metering System
•
Engine control computer (engine control module)
•Throttle body
Air Induction System
•
Intake manifold and intake air surge tank
Your Warranties in Detail22
CALIFORNIA EMISSION CONTROL WARRANTY
*For Camry 4-cylinder models certified as partial zero-emission vehicles (PZEV)
that are sold, registered and operated in California, Connecticut, Maine,
Massachusetts, New Hampshire, New Jersey, New York, Oregon, Rhode Island
or Vermont, all emissions components are covered for 15 years or 150,000 miles,
whichever occurs first, for performance and defect.
117510.Text.cgla 12/14/07 12:10 AM Page 22