overheating TOYOTA CAMRY HYBRID 2022 Owners Manual

1032. Instrument cluster
2
Instrument cluster
■Engine speed
On hybrid vehicles, engine speed is precisely controlled in order to help
improve fuel efficiency and reduce exhaust emissions etc.
There are times when the engine speed that is displayed may differ even
when vehicle operation and driving conditions are the same.
■Outside temperature display
In the following situations, the correct outside temperature may not be dis-
<0053004f0044005c00480047000f00030052005500030057004b004800030047004c00560053004f0044005c000300500044005c000300570044004e00480003004f00520051004a0048005500030057004b00440051000300510052005500500044004f00
030057005200030046004b00440051004a0048001d[
●When stopped, or driving at low speeds (less than 16 mph [25 km/h])
●When the outside temperature has changed suddenly (at the entrance/exit
of a garage, tunnel, etc.)
●When “” or “E” is displayed, the system may be malfunctioning.
Take your vehicle to your Toyota dealer.
■Fuel gauge and driving range display
The fuel gauge and driving range display are linked. If the fuel gauge and
driving range display do not update after refueling a small amount, they can
be updated by performing the following procedure:
Stop the vehicle on a level surface.
Wait until the fuel in the fuel tank stabilizes.
Press the ODO/TRIP switch to change the odometer and trip meter display
to the odometer.
Turn the power switch off.
While pressing and holding the ODO/TRIP switch, turn the power switch to
ON mode.
Continue holding the ODO/TRIP switch for approximately 5 seconds.
Release the switch when the odometer begins blinking.
Updating will be complete when the odometer blinks for approximately 5
seconds and then returns to the normal display.
NOTICE
■To prevent damage to the engine and its components
The engine may be overheating if the engine coolant temperature gauge is
in the red zone (H). In this case, immediately stop the vehicle in a safe
place, and check the engine after it has cooled completely. (P. 537)
1
2
3
4
5

1984-1. Before driving
WARNING
Observe the following precautions.
Failure to do so may result in death or serious injury.
■When the vehicle is parked
●Do not leave a door or window open if the curved glass is coated with a
metallized film such as a silver-colored one. Reflected sunlight may cause
the glass to act as a lens, causing a fire.
●Always apply the parking brake, shift the shift lever to P, stop the hybrid
system and lock the vehicle.
Do not leave the vehicle unattended while the “READY” indicator is illumi-
nated.
If the vehicle is parked with the shift lever in P but the parking brake is not
set, the vehicle may start to move, possibly leading to an accident.
●Do not touch the exhaust pipes while the “READY” indicator is illuminated
or immediately after turning the hybrid system off.
Doing so may cause burns.
■When taking a nap in the vehicle
Always turn the hybrid system off. Otherwise, if you accidentally move the
shift lever or depress the accelerator pedal, this could cause an accident or
fire due to hybrid system overheating. Additionally, if the vehicle is parked in
a poorly ventilated area, exhaust gases may collect and enter the vehicle,
leading to death or a serious health hazard.
■When braking
●When the brakes are wet, drive more cautiously.
Braking distance increases when the brakes are wet, and this may cause
one side of the vehicle to brake differently than the other side. Also, the
parking brake may not securely hold the vehicle.
●If the electronically controlled brake system does not operate, do not fol-
low other vehicles closely and avoid hills or sharp turns that require brak-
ing.
In this case, braking is still possible, but the brake pedal should be
depressed more firmly than usual. Also, the braking distance will increase.
Have your brakes fixed immediately.
●The brake system consists of 2 or more individual hydraulic systems; if
one of the systems fails, the other(s) will still operate. In this case, the
brake pedal should be depressed more firmly than usual and the braking
distance will increase. Have your brakes fixed immediately.

2104-2. Driving procedures
■When the steering lock cannot be released
■Steering lock motor overheating prevention
To prevent the steering lock motor from overheating, the motor may be sus-
pended if the hybrid system is turned on and off repeatedly in a short period
of time. In this case, refrain from operating the hybrid system. After about 10
seconds, the steering lock motor will resume functioning.
■When a message requesting the smart key system be inspected is dis-
played on the multi-information display
The system may be malfunctioning. Have the vehicle inspected by your
Toyota dealer immediately.
■When “Check Fuel Cap” is displayed on the multi-information display
P. 245
■If the “READY” indicator does not come on
In the event that the “READY” indicator does not come on even after perform-
ing the proper procedures for starting the vehicle, contact your Toyota dealer
immediately.
■If the hybrid system is malfunctioning
P. 83
■If the electronic key battery is depleted
P. 470
■Operation of the power switch
●If the switch is not pressed shortly and firmly, the power switch mode may
not change or the hybrid system may not start.
●If attempting to restart the hybrid system immediately after turning the power
switch off, the hybrid system may not start in some cases. After turning the
power switch off, wait a few seconds before restarting the hybrid system.
■If the smart key system has been deactivated in a customized setting
P. 527 A message informing the driver that the
steering wheel is locked will be displayed
on the multi-information display.
Check that the shift lever is set in P. Press
the power switch while turning the steer-
ing wheel left and right.

2254-2. Driving procedures
4
Driving
■Parking the vehicle
P. 192
■Parking brake operation
●When the power switch is not in ON mode, the parking brake cannot be
released using the parking brake switch.
●When the power switch is not in ON mode, automatic mode (automatic
brake setting and releasing) is not available.
■Automatic release function
The parking brake is automatically released when slowly depress the acceler-
ator pedal.
The parking brake will be released automatically under the following condi-
tions:
●The driver’s door is closed.
●The driver’s seatbelt is fastened.
●Shift the shift lever is in a forward or reverse position.
●The malfunction indicator lamp or brake system warning light is not illumi-
nated.
If the automatic release function does not operate, manually release the park-
ing brake.
■If “Parking Brake Temporarily Unavailable” is displayed on the multi-
information display
If the parking brake is operated repeatedly over a short period of time, the
system may restrict operation to prevent overheating. If this happens, refrain
from operating the parking brake. Normal operation will return after about 1
minute.
■If “Parking Brake Unavailable” is displayed on the multi-information dis-
play
Operate the parking brake switch. If the message does not disappear after
operating the switch several times, the system may be malfunctioning. Have
the vehicle inspected by your Toyota dealer immediately.
■Parking brake operation sound
When the parking brake operates, a motor sound (whirring sound) may be
heard. This does not indicate a malfunction.
■Parking brake indicator light and parking brake light
●Depending on the power switch mode, the parking brake indicator light and
<005300440055004e004c0051004a0003004500550044004e00480003004f004c004a004b00570003005a004c004f004f0003005700580055005100030052005100030044005100470003005600570044005c00030052005100030044005600030047004800
5600460055004c004500480047000300450048004f0052005a[:
ON mode: Comes on until the parking brake is released.
Not in ON mode: Stays on for approximately 15 seconds.
●When the power switch is turned off with the parking brake set, the parking
brake indicator light and parking brake light will stay on for about 15 sec-
onds. This does not indicate a malfunction.

2264-2. Driving procedures
■Parking brake engaged warning buzzer
A buzzer will sound if the vehicle is driven with the parking brake engaged.
“Release Parking Brake” is displayed on the multi-information display.
■Warning messages and buzzers
Warning messages and buzzers are used to indicate a system malfunction or
to inform the driver of the need for caution. If a warning message is shown on
the multi-information display, read the message and follow the instructions.
■If the brake system warning light comes on
P. 497
■Usage in winter time
P. 360
WARNING
■When parking the vehicle
Do not leave a child in the vehicle alone. The parking brake may be
released unintentionally and there is the danger of the vehicle moving that
may lead to an accident resulting in death or serious injury.
■Parking brake switch
Do not set any objects near the parking brake switch. Objects may interfere
with the switch and may lead the parking brake to unexpectedly operate.
NOTICE
■When parking the vehicle
Before you leave the vehicle, shift the shift lever to P, set the parking brake
and make sure that the vehicle does not move.
■When the system malfunctions
<003600570052005300030057004b0048000300590048004b004c0046004f00480003004c0051000300440003005600440049004800030053004f004400460048000300440051004700030046004b00480046004e00030057004b00480003005a0044005500
51004c0051004a000300500048005600560044004a00480056[.
■When the parking brake cannot be released due to a malfunction
Driving the vehicle with the parking brake set will lead to brake components
overheating, which may affect braking performance and increase brake
wear. Contact your Toyota dealer immediately if this occurs.

3074-5. Using the driving support systems
4
Driving
■Automatic reactivation of TRAC and VSC systems
After turning the TRAC and VSC systems off, the systems will be automati-
cally re-enabled in the following situations:
●When the power switch is turned off
●If only the TRAC system is turned off, the TRAC will turn on when vehicle
speed increases
If both the TRAC and VSC systems are turned off, automatic re-enabling will
not occur when vehicle speed increases
■Secondary Collision Brake operating conditions
The system operates when the SRS airbag sensor detects a collision while
the vehicle is in motion.
However, the system does not operate in any of the following situations.
●The vehicle speed is below 6 mph (10 km/h)
●Components are damaged
■Secondary Collision Brake automatic cancellation
The Secondary Collision Brake is automatically canceled in the following situ-
ations:
●The vehicle speed drops below approximately 6 mph (10 km/h)
●A certain amount of time elapses during operation
●The accelerator pedal is depressed a large amount
■Reduced effectiveness of the EPS system
The effectiveness of the EPS system is reduced to prevent the system from
overheating when there is frequent steering input over an extended period of
time. The steering wheel may feel heavy as a result. Should this occur, refrain
from excessive steering input or stop the vehicle and turn the hybrid system
off. The EPS system should return to normal within 10 minutes.

5377-2. Steps to take in an emergency
7
When trouble arises
■If the needle of the engine coolant temperature gauge enters
the red zone or “Engine Coolant Temp High Stop in a Safe
Place See Owner’s Manual” is shown on the multi-information
display
Stop the vehicle in a safe place and turn off the air conditioning sys-
tem, and then stop the hybrid system.
If you see steam:
Carefully lift the hood after the steam subsides.
If you do not see steam:
Carefully lift the hood.
After the hybrid system has
cooled down sufficiently,
inspect the hoses and radiator
core (radiator) for any leaks.
Radiator
Cooling fan
If a large amount of coolant leaks,
immediately contact your Toyota
dealer.
If your vehicle overheats
The following may indicate that your vehicle is overheating.
●The needle of the engine coolant temperature gauge (P. 100)
enters the red zone or a loss of hybrid system power is experi-
enced. (For example, the vehicle speed does not increase.)
●“Engine Coolant Temp High Stop in a Safe Place See Owner’s
Manual” or “Hybrid System Overheated Output Power Reduced”
is shown on the multi-information display
●Steam comes out from under the hood.
Correction procedures
1
2
3
1
2

600Alphabetical index
Coolant
Capacity ................................ 548
Checking ............................... 436
Preparing and checking
before winter....................... 360
Cooling system ........................ 436
Hybrid system
overheating......................... 537
Cruise control
Dynamic radar cruise control
with full-speed range .......... 287
Cup holders.............................. 384
Curtain shield airbags ............... 35
Customizable features ............ 569
Daytime running light
system .................................... 232
Defogger
Outside rear view
mirrors ................................ 370
Rear window ......................... 370
Windshield ............................ 370
Dimensions .............................. 544
Dinghy towing .......................... 205
Display
Dynamic radar cruise control
with full-speed range .......... 287
LTA (Lane Tracing Assist) .... 267
Multi-information
display ........................ 104, 117
Warning messages ............... 507Do-it-yourself maintenance .... 427
Door courtesy lights
Location ................................ 378
Wattage ................................ 552
Door lock
Doors .................................... 154
Key ....................................... 527
Smart key system ................. 154
Wireless remote control ........ 154
Doors ........................................ 154
Automatic door locking
and unlocking systems ....... 157
Door lock .............................. 156
Outside rear view mirrors ..... 181
Rear door child-protector ...... 157
Side doors ............................ 154
Side windows........................ 183
Drive information..................... 107
Drive-Start Control (DSC) ....... 193
Sudden start restraint
control ................................ 193
Driving
Break-in tips.......................... 194
Correct posture ....................... 26
Hybrid vehicle driving tips ..... 357
Procedures ........................... 192
Winter drive tips .................... 360
DSC (Drive-Start Control) ....... 193
Sudden start restraint
control ................................ 193
Dynamic radar cruise control
with full-speed range ............ 287
D

601Alphabetical index
ECO Accelerator Guidance..... 123
Eco drive mode ........................ 355
Eco-friendly driving
information ............................ 121
Eco guide ................................. 123
Eco score ................................. 123
EDR (Event data recorder) .......... 9
Electric motor
(traction motor) ....................... 78
Electric Power Steering
(EPS)....................................... 304
Warning light ......................... 498
Electronic key .......................... 150
Battery-saving function ......... 166
If the electronic key does not
operate properly ................. 527
Replacing the battery ............ 470
Emergency flashers ................ 490Emergency, in case of
If a warning buzzer
sounds................................ 497
If a warning light turns on ..... 497
If a warning message is
displayed ............................ 507
If the 12-volt battery is
discharged.......................... 530
If the electronic key does not
operate properly ................. 527
If the hybrid system
will not start ........................ 525
If the vehicle is submerged
or water on the road is
rising................................... 492
If you have a flat tire ............. 513
If you lose your keys ............. 151
If you think something is
wrong ................................. 496
If your vehicle becomes
stuck ................................... 541
If your vehicle has to be
stopped in an emergency ... 491
If your vehicle needs to be
towed.................................. 493
If your vehicle overheats....... 537
Engine
ACCESSORY mode ............. 208
Compartment ........................ 432
Engine switch ....................... 206
Hood ..................................... 429
How to start the hybrid
system ................................ 206
Identification number ............ 545
If your vehicle has to be
stopped in an
emergency ......................... 491
Ignition switch
(power switch) .................... 206
Overheating .......................... 537
Power switch ........................ 206
E

603Alphabetical index
Heated steering wheel............. 376
Heaters
Automatic air
conditioning system ............ 366
Heated steering wheel .......... 376
Outside rear view mirrors...... 370
Seat heaters ......................... 375
Seat ventilators ..................... 375
High mounted stoplight
Replacing .............................. 486
High voltage components......... 82
Hill-start assist control............ 304
Hood ......................................... 429
Hooks
Coat hooks............................ 402
Grocery bag hooks ............... 387
Retaining hooks (floor mat)..... 24
Horn .......................................... 177
HUD (Head-up display)............ 136
Hybrid battery
(traction battery)...................... 82
Hybrid battery
(traction battery) air
intake vent ....................... 83, 465
Hybrid system ............................ 78
Acoustic Vehicle Alerting
System ................................. 79
Emergency shut off system .... 83
Energy monitor/
consumption screen ........... 142
EV drive mode ...................... 213
High voltage components ....... 82
Hybrid System Indicator........ 102
Hybrid system precautions ..... 82
Hybrid vehicle driving tips ..... 357
If the hybrid system
will not start ........................ 525
Overheating .......................... 537
Power (ignition) switch .......... 206
Starting the hybrid system .... 206Hybrid System Indicator ......... 102
Hybrid transmission................ 216
If the shift lever cannot be
shifted from P ..................... 220
Identification
Engine .................................. 545
Vehicle .................................. 545
Ignition switch
(power switch) ....................... 206
Illuminated entry system ........ 380
Immobilizer system ................... 89
I/M test ...................................... 426
Indicators ................................... 97
Initialization
Items to initialize ................... 577
Parking Support Brake ......... 345
Tire pressure
warning system .................. 446
Inside rear view mirror ............ 179
Instrument panel light
control .................................... 101
Interior lights ........................... 378
Switch ................................... 379
Intuitive parking assist ........... 317
Jack
Positioning the jack............... 431
Vehicle-equipped jack .......... 513
Jack handle .............................. 513
Jam protection function
Moon roof ............................. 187
Power window ...................... 183
I
J
*: Refer to the “NAVIGATION AND MULTIMEDIA SYSTEM OWNER’S
MANUAL”.