Transmission TOYOTA COROLLA 2015 11.G Repair Manual

5308-2. Steps to take in an emergency
COROLLA_TMMMS_TMMC_U (OM12F00U)
■Stopping the engine
Shift the shift lever to P (continuously variable transmission) or N (manual
transmission) and press the engine switch as you normally do when stopping
the engine.
■ Replacing the key battery
As the above procedure is a temporary measure, it is recommended that the
electronic key battery be replaced immediately when the battery is depleted.
(P. 463)
■ Changing engine switch modes
Release the brake pedal (continuously variable transmission) or clutch pedal
(manual transmission) and press the engine switch in step above.
The engine does not start and modes will be changed each time the switch is
pressed. ( P. 166)
■ When the electronic key does not work properly
●Make sure that the smart key system has not been deactivated in the cus-
tomization setting. If it is off, turn the function on.
(Customizable features P. 570)
● Check if battery-saving mode is set. If it is set, cancel the function.
(P. 114)
3

5408-2. Steps to take in an emergency
COROLLA_TMMMS_TMMC_U (OM12F00U)
Stop the engine. Set the parking brake and shift the shift lever to P
(automatic transmission or continuously variable transmission) or N
(manual transmission).
Remove the mud, snow or sand from around the front wheels.
Place wood, stones or some othe r material under the front wheels
to help provide traction.
Restart the engine.
Shift the shift lever to D or R (automatic transmission or continu-
ously variable transmission) or 1 or R (manual transmission) and
release the parking brake. Then, while exercising caution, depress
the accelerator pedal.
If the vehicle becomes stuck
Carry out the following procedures if the tires spin or the vehicle
becomes stuck in mud, dirt or snow:
1
2
3
4
5

5499-1. Specifications
9
Vehicle specifications
COROLLA_TMMMS_TMMC_U (OM12F00U)
Electrical system
Battery
Open voltage at
68F (20 C):
12.6  12.8 V Fully charged
12.2  12.4 V Half charged
11 . 8  12.0 V Discharged
(Voltage checked 20 minutes after the engine
and all the lights turned off)
Charging rates5 A max.
Manual transaxle
Gear oil capacity
(Reference)2.5 qt. (2.4 L, 2.1 Imp. qt.)
Gear oil type
Use either of the following:
• “TOYOTA Genuine Manual Transmission Gear Oil LV”
• Other gear oil that meets API GL-4 and SAE
75W specifications
NOTICE
■Manual transmission gear oil
Please be aware that depending on the particular characteristics of the gear
oil used or the operating conditions, idle sound, shift feeling and/or fuel effi-
ciency may be different or affected. Toyota recommends to use “TOYOTA
Genuine Manual Transmission Gear Oil LV” to achieve optimal perfor-
mance.

5509-1. Specifications
COROLLA_TMMMS_TMMC_U (OM12F00U)
*: The fluid capacity is a reference quantity.If replacement is necessary, contact your Toyota dealer.
Automatic transaxle
Fluid capacity (Reference) 6.9 qt. (6.5 L, 5.7 Imp. qt.)
Fluid type Toyota Genuine ATF WS
NOTICE
■Automatic transmission fluid type
Using automatic transmission fluid other than “Toyota Genuine ATF WS”
may cause deterioration in shift quality, locking up of your transmission
accompanied by vibration, and ultimately damage the transmission of your
vehicle.
Continuously variable transaxle
Fluid capacity*7.9 qt. (7.5 L, 6.6 Imp. qt.)
Fluid typeToyota Genuine CVTF FE
NOTICE
■Continuously variable transaxle fluid type
Using continuously variable transaxle fluid other than “Toyota Genuine
CVTF FE” may cause deterioration in shift quality, locking up of the trans-
mission accompanied by vibration and, ultimately, damage to the vehicle’s
transmission.
Clutch
Pedal free play 0.2 0.6 in. (5  15 mm)
Fluid type SAE J1703 or FMVSS No.116 DOT 3

5649-1. Specifications
COROLLA_TMMMS_TMMC_U (OM12F00U)
Glossary of tire terminology
Tire related termMeaning
Cold tire inflation pres-
sure
Tire pressure when the vehicle has been
parked for three hours or more, or has not
been driven more than 1 mile or 1.5 km under
that condition
Maximum inflation
pressureThe maximum cold inflated pressure to which
a tire may be inflated, shown on the sidewall
of the tire
Recommended infla-
tion pressureCold tire inflation pressure recommended by a
manufacturer
Accessory weight
The combined weight (in excess of those stan-
dard items which may be replaced) of auto-
matic transmission, power steering, power
brakes, power windows, power seats, radio
and heater, to the extent that these items are
available as factory-installed equipment
(whether installed or not)
Curb weight
The weight of a motor vehicle with standard
equipment, including the maximum capacity of
fuel, oil and coolant, and if so equipped, air
conditioning and additional weight optional
engine
Maximum loaded vehi-
cle weight
The sum of:
(a) Curb weight
(b) Accessory weight
(c) Vehicle capacity weight
(d) Production options weight
Normal occupant
weight150 lb. (68 kg) times the number of occupants
specified in the second column of Table 1
*
that follows
Occupant distributionDistribution of occupants in a vehicle as speci-
fied in the third column of Table 1
* below

5769-2. Customization
COROLLA_TMMMS_TMMC_U (OM12F00U)
■Vehicle customization
When the doors remain closed after unlocking the doors and the timer acti-
vated automatic door lock function activates, signals will be generated \
in
accordance with the operational signal (Emergency flashers) function set-
tings.
■ When customizing usi ng the navigation system
Stop the vehicle in a safe place, apply the parking brake, and shift the shift
lever to P (automatic transmission or c ontinuously variable transmission) or N
(manual transmission). Also, to prevent battery discharge, leave the engine
running while customizing the features.
CAUTION
■ During customization
As the engine needs to be running during customization, ensure that the
vehicle is parked in a place with adequate ventilation. In a closed area such
as a garage, exhaust gases including harmful carbon monoxide (CO) may
collect and enter the vehicle. This may lead to death or a serious health
hazard.
NOTICE
■During customization
To prevent battery discharge, ensure that the engine is running while cus-
tomizing features.

596What to do if... (Troubleshooting)
COROLLA_TMMMS_TMMC_U (OM12F00U)
●Vehicles with a manual transmission:
Do you turn the key with the clutch pedal depressed firmly?
(P. 161)
●Except vehicles with a manual transmission:
Is the shift lever in P? ( P. 161)
●Is the steering wheel unlocked? ( P. 161)
●Is the battery discharged? (P. 531)
●Except vehicles with a manual transmission:
Did you press the engine switch while firmly depressing the brake pedal?
(P. 164)
●Vehicles with a manual transmission:
Did you press the engine switch while firmly depressing the clutch pedal?
(P. 164)
●Except vehicles with a manual transmission:
Is the shift lever in P? ( P. 169)
●Is the electronic key anywhere detectable inside the vehicle?
(P. 112)
●Is the steering wheel unlocked? ( P. 169)
●Is the electronic key battery weak or depleted?
In this case, the engine can be started in a temporary way.
(P. 529)
●Is the battery discharged? ( P. 531)
If you think something is wrong
The engine does not start
(vehicles without a smart key system)
The engine does not start
(vehicles with a smart key system)

597What to do if... (Troubleshooting)
COROLLA_TMMMS_TMMC_U (OM12F00U)
●Vehicles without a smart key system:
Is the engine switch in the “ON” position?
If you cannot release the shift lever by depressing the brake pedal with the
engine switch in the “ON” position. (P. 527)
●Vehicles with a smart key system:
Is the engine switch in IGNITION ON mode?
If you cannot release the shift lever by depressing the brake pedal with the
engine switch in IGNITION ON mode. ( P. 527)
●Vehicles without a smart key system:
It is locked to prevent theft of the vehicle if the key is pulled from the engine
switch. (P. 162)
●Vehicles with a smart key system:
It is locked automatically to prevent theft of the vehicle. ( P. 169)
●Is the window lock switch pressed?
The power window except for the one at the driver’s seat cannot be oper-
ated if the window lock switch is pressed. (P. 133)
The shift lever cannot be shifted from P even if you
depress the brake pedal (vehicles with an automatic
transmission or continuously variable transmission)
The steering wheel cannot be turned after the engine is
stopped
The windows do not open or cl ose by operating the power
window switches

600
COROLLA_TMMMS_TMMC_U (OM12F00U)
Alphabetical index
Alphabetical index
A/C .................................... 380, 386Air conditioning filter ............. 461
ABS (Anti-lock Brake System)...... 211 Function ................................ 211
Warning light ......................... 492
Air conditioning filter .............. 461
Air conditioning system ............................ 380, 386 Air conditioning filter ............. 461
Airbags ....................................... 34
Airbag operating conditions .... 41
Airbag precautions for your child .............................. 36
Airbag warning light .............. 492
Correct driving posture ........... 26
Curtain shield airbag operating conditions ............................. 41
Curtain shield airbag precautions ........................... 39
General airbag precautions .... 36
Locations of airbags................ 34
Modification and disposal of airbags ............... 40
Side airbag operating conditions ............................. 41
Side airbag precautions .......... 36
Side and curtain shield airbags
operating conditions ............. 41
Side and curtain shield airbags
precautions ........................... 36
SRS airbags............................ 34
Alarm .......................................... 68
Anchor brackets ........................ 57 Antennas
(smart key system) ............... 111
Anti-lock Brake System (ABS) ...................................... 211 Function ................................ 211
Warning light......................... 492
Assist grips .............................. 406
Audio input ..................... 227, 286
Audio system ........................... 222 Antenna ................................ 231
Audio input............................ 227
AUX port/USB port ..................................... 227
Bluetooth
® audio .................. 255
CD player.............................. 232
iPod ...................................... 241
MP3/WMA disc ..................... 232
Optimal use .......................... 228
Portable music player ........... 227
Radio .................................... 230
Steering wheel audio switch ................................. 226
USB memory ........................ 248
Automatic light control system.................................... 186
Automatic transmission ......... 172 If the shift lever
cannot be shifted from P .... 527
AUX port ........................... 227, 286
A

602Alphabetical index
COROLLA_TMMMS_TMMC_U (OM12F00U)
Child safety ................................ 52Airbag precautions .................. 36
Battery precautions ....... 445, 535
Child restraint system ............. 53
How your child should wear
the seat belt .......................... 30
Installing child restraints ......... 57
Moon roof precautions .......... 140
Power window lock switch .... 133
Power window precautions ... 136
Rear door child-protectors .... 101
Removed electronic key battery precautions ............. 465
Seat belt extender
precautions ........................... 33
Seat belt precautions .............. 32
Seat heater precautions........ 411
Trunk precautions ................. 109
Child-protectors....................... 101
Cleaning ........................... 414, 417 Aluminum wheels.................. 415
Exterior ................................. 414
Interior................................... 417
Seat belts .............................. 418
Clock ......................................... 403
Condenser ................................ 442
Compass .................................. 407
Console box ............................. 399
Continuously variable transmission .................. 174, 176
If the shift lever cannot be shifted from P ..................... 527
M mode ................................. 178
Cooling system ........................ 440 Engine overheating ............... 536
Cruise control .......................... 197
Cup holders.............................. 401
Curtain shield airbags ............... 34
Customizable features ............ 570 Daytime running light
system.................................... 188
Defogger Outside rear view mirrors ........................ 381, 389
Rear window ................. 381, 389
Dimensions .............................. 544
Dinghy towing.................. 158, 159
Display Drive monitor display .............. 77
Multi-information display ......... 82
Trip information................. 79, 84
Warning message ................ 503
Do-it-yourself maintenance .... 428
Door lock
Doors ...................................... 97
Smart key system ................... 97
Wireless remote control .......... 97
Key ......................................... 98
Doors .......................................... 97
Automatic door locking and unlocking systems ....... 102
Door lock .............................. 100
Door windows ....................... 133
Open door warning buzzer ... 112
Open door warning light ....... 493
Outside rear view mirrors ..... 131
Rear door child-protector ...... 101
Drive monitor display................ 77
Driving ...................................... 142 Break-in tips.......................... 145
Correct posture ....................... 26
Procedures ........................... 142
Winter drive tips .................... 216D