power steering TOYOTA ECHO 2002 1.G User Guide

2001MY ECHO (U) L/O0008
1982002 ECHO (OM52463U)
Checking power steering fluid
SU72009Open
Close
Check the fluid level through the reser-
voir. If necessary, add automatic trans-
mission fluid DEXRON II or III.
If the vehicle has been driven around 80
km/h (50 mph) for 20 minutes (a little
more in frigid temperatures), the fluid is
hot (60 C—80 C or 140 F—175 F). You
may also check the level when the fluid
is cold (about room temperature,
10 C—30 C or 50 F—85 F) if the engine
has not been run for about five hours.
SU72010
If cold O.K.
If cold add
If hot O.K.
If hot add
a. Clean all dirt from outside of the reser-
voir tank.
b. Remove the rubber cap. c. Remove the reservoir cap by turning it counterclockwise and wipe the dipstick
clean.
d. Reinstall the reservoir cap.
e. Remove the reservoir cap again and look at the fluid level. If the fluid is
cold, the lever should be in the “COLD”
range on the dipstick. Similarly, if it is
hot, the fluid level should be in the
“HOT” range. If the level is at the low
side of either range, add automatic
transmission fluid DEXRON II or III to
bring the level within the range.

2002MY ECHO (U) L/O0109
1992002 ECHO (OM52463U)
f. After replacing the reservoir cap andrubber cap, visually check the steering
box case, vane pump and hose con-
nections for leaks or damage.
CAUTION
The reservoir tank may be hot so be
careful not to burn yourself.
NOTICE
Avoid overfilling, or the power steer-
ing could be damaged.
Checking tire pressure
SU72005
Keep your tire pressures at the proper
level.
The recommended cold tire pressures, tire
size and the vehicle capacity weight are
given in Section 8. They are also on the
tire pressure label as shown.
You should check the tire pressures every
two weeks, or at least once a month. And
do not forget the spare!
Incorrect tire pressure can reduce tire
life and make your vehicle less safe to
drive. Low tire pressure results in excessive
wear, poor handling, reduced fuel econo-
my, and the possibility of blowouts from
overheated tires. Also, low tire pressure
can cause poor sealing of the tire bead.
If the tire pressure is excessively low,
there is the possibility of w
heel deforma-
tion and/or tire separation.
High tire pressure produces a harsh ride,
handling problems, excessive wear at the
center of the tire tread, and a greater
possibility of tire damage from road haz-
ards.
If a tire frequently needs ref illing, have it
checked by your Toyota dealer.
The following instructions for checking
tire pressure should be observed:
The pressure should be checked only
when the tires are cold. If your ve-
hicle has been parked for at least 3
hours and has not been driven for
more than 1.5 km or 1 mile since, you
will get an accurate cold tire pressure
reading.
Always use a tire pressure gauge.
The appearance of a tire can be mis-
leading. Besides, tire pressures that
are even just a few pounds off can
degrade ride and handling.

2002MY ECHO (U) L/O0109
2172002 ECHO (OM52463U)
Service specifications
ENGINE
Valve clearance (engine cold), mm (in.):Intake 0.150.25 (0.0060.010)
Exhaust 0.250.35 (0.0100.014)
Spark plug type: DENSO K16RU
NGK BKR5EYA
Spark plug gap, mm(in.): 0.8 (0.031)
Drive belt tension measured with Bor-
roughs drive belt tension gauge No.
BT3373F (used belt), lbf: Generator belt 100 20
Power steering pump belt 65 10 ENGINE LUBRICATION
Oil capacity (drain and ref
ill), L (qt., Imp.
qt.):
With filter 3.7 (3.9, 3.3)
Without filter 3.4 (3.6, 3.0)
Oil grade: API grade SJ “EnergyConserving”, SL
“EnergyConserving” or ILSAC multi-
grade engine oil is recommended.
Recommended oil viscosity (SAE):
OIL05U
COOLING SYSTEM
Total capacity, L (qt., Imp. qt.): Manual transmission 4.4 (4.7, 3.9)
Automatic transmission 4.3 (4.5, 3.8)
Coolant type:
“TOYOTA Long Life Coolant” or equiva-
lent
With ethyleneglycol type coolant for a
proper corrosion protection of aluminum
components
Do not use alcohol type antifreeze or
plain water alone.
BATTERY
Open voltage
∗ at 20 C (68 F):
12.612.8 V Fully charged
12.212.4 V Half charged
11.812.0 V Discharged
∗: Voltage that is checked 20 minutes af-
ter the key is removed with all the lights
turned off
Charging rates: 5 A max.

2001MY ECHO (U) L/O0008
2182002 ECHO (OM52463U)
CLUTCH
Pedal free play, mm (in.):5—15 (0.2—0.6)
Fluid type: SAE J1703 or FMVSS No. 116 DOT 3
MANUAL TRANSAXLE
Oil capacity, L (qt., Imp. qt.): 1.9 (2.0, 1.7)
Oil type: Gear oil API GL4 or GL5
Recommended oil viscosity: SAE 75W90
AUTOMATIC TRANSAXLE Automatic transmission
Fluid capacity (drain and ref ill),
L (qt., Imp. qt.): 2.9 (3.1, 2.6)
Fluid type: Automatic transmission fluid Type
TIV
Change automatic transmission fluid only
as necessary. Generally, it is necessary to change
automatic transmission fluid only if your
vehicle is driven under one of the Special
Operating Conditions listed in your
“Scheduled Maintenance Guide” or
“Owner ’s Manual Supplement”. When
changing the automatic transmission fluid,
use only Toyota Genuine ATF Type TIV
(ATF JWS3309 or NWS6500) to aid in
assuring optimum transaxle performance.
Notice: Using automatic transmission
fluid other than Toyota Genuine ATF
Type TIV may cause deterioration in
shift quality, locking up of your trans-
mission accompanied by vibration, and
ultimately damage the automatic trans-
mission of your vehicle.
BRAKES
Minimum pedal clearance when depressed
with the pressure of 490 N (50 kgf, 110
lbf) with the engine running, mm (in.):
55 (2.2)
Pedal free play, mm (in.): 1—6 (0.04—0.24)
Pad wear limit, mm (in.): 1.0 (0.04)
Lining wear limit, mm (in.): 1.0 (0.04)
Parking brake adjustment when pulled with
the force of 196 N (20 kgf, 44 lbf): 6—9 clicks
Fluid type: SAE J1703 or FMVSS No. 116 DOT 3
STEERING
Wheel free play: Less than 30 mm (1.2 in.)
Power steering fluid type: Automatic transmission fluid DEXRON II
or III

2002MY ECHO (U) L/O0109
2272002 ECHO (OM52463U)
E
Economical drivingSaving money on both fuel
and repairs 153 . . . . . . . . . . . . . . . . . . . .
Electrical system Battery 206,207 . . . . . . . . . . . . . . . . . . . . . .
Fuse locations 187 . . . . . . . . . . . . . . . . . . .
Fuses 208 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 75 . . . . . . . . . . . .
Emergency, In case of Blown fuse 208 . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 75 . . . . . . . . . .
Flat tire 160 . . . . . . . . . . . . . . . . . . . . . . . . .
If you cannot shift automatic transmission selector lever 171 . . . . . .
If you lose your keys 172 . . . . . . . . . . . . . .
If your engine stalls while driving 159 . . . . . . . . . . . . . . . . . . .
If your vehicle needs to be towed 168 . . . . . . . . . . . . . . . . . . . .
If your vehicle will not start 156 . . . . . . . .
Jump starting 157 . . . . . . . . . . . . . . . . . . . .
Overheating 159 . . . . . . . . . . . . . . . . . . . . .
Towing 168 . . . . . . . . . . . . . . . . . . . . . . . . . .
Emissions inspection and maintenance (I/M) programs 184 . . . . . . .
Engine Before starting the engine 148 . . . . . . . . .
Checking the coolant level 196 . . . . . . . .
Emission control device 136 . . . . . . . . . . .
Engine compartment 186 . . . . . . . . . . . . . .
Exhaust gas caution 138 . . . . . . . . . . . . . . Hood release 19
. . . . . . . . . . . . . . . . . . . . .
Oil consumption 138 . . . . . . . . . . . . . . . . . .
Oil level 194 . . . . . . . . . . . . . . . . . . . . . . . . .
Overheating 159 . . . . . . . . . . . . . . . . . . . . .
Starting procedure 147 . . . . . . . . . . . . . . .
Threeway catalytic converter 136 . . . . .
Engine coolant
Temperature gauge 80 . . . . . . . . . . . . . . . .
Winter driving tips 150 . . . . . . . . . . . . . . . .
Engine coolant temperature gauge 80 . . . .
Engine oil Winter driving tips 150 . . . . . . . . . . . . . . . .
Exhaust gas caution 138 . . . . . . . . . . . . . . . .
F
Facts about engine oil
consumption 138 . . . . . . . . . . . . . . . . . . . . .
Flasher, Headlight 74 . . . . . . . . . . . . . . . . . . .
Flat tire After changing wheels 167 . . . . . . . . . . . .
Changing tires 165 . . . . . . . . . . . . . . . . . . .
If you have a flat tire 160 . . . . . . . . . . . . . .
Jack point 164 . . . . . . . . . . . . . . . . . . . . . . .
Jacking precautions 160 . . . . . . . . . . . . . .
Jacking up 164 . . . . . . . . . . . . . . . . . . . . . .
Loosening wheel nuts 164 . . . . . . . . . . . . .
Lowering vehicle 166 . . . . . . . . . . . . . . . . .
Reinstalling w heel ornament 167 . . . . . . .
Removing wheel ornament 164 . . . . . . . .
Wheel block 163 . . . . . . . . . . . . . . . . . . . . .
Wheel nuts 166 . . . . . . . . . . . . . . . . . . . . . .
Floor mat 131 . . . . . . . . . . . . . . . . . . . . . . . . . . Fluid level
Brake 197 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power steering 198 . . . . . . . . . . . . . . . . . . .
Washer fluid 209 . . . . . . . . . . . . . . . . . . . . .
Folddown rear seat 29 . . . . . . . . . . . . . . . . .
Foreign countries, Operation in 136 . . . . . .
Front passenger ’s seat 28 . . . . . . . . . . . . . .
Front seats 26,27 . . . . . . . . . . . . . . . . . . . . . .
Fuel Filler door o pener 22. . . . . . . . . . . . . . . . .
Fuel economy 153 . . . . . . . . . . . . . . . . . . . .
Fuel information 134 . . . . . . . . . . . . . . . . . .
Gauge 80 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operation in foreign countries 136 . . . . .
Tank cap 22 . . . . . . . . . . . . . . . . . . . . . . . . .
Fuse locations 187 . . . . . . . . . . . . . . . . . . . . .
Fuses Fuse box 208 . . . . . . . . . . . . . . . . . . . . . . . .
G
Gauge
Engine coolant temperature 80 . . . . . . . .
Fuel 80 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Glove box 130 . . . . . . . . . . . . . . . . . . . . . . . . .
Good driving practice Automatic transmission 89 . . . . . . . . . . . .
Manual transmission 93 . . . . . . . . . . . . . .
H
Hazard switch 75
. . . . . . . . . . . . . . . . . . . . . .
Head restraints 31
. . . . . . . . . . . . . . . . . . . . .
Headlight switch 74
. . . . . . . . . . . . . . . . . . . .

2002MY ECHO (U) L/O0109
2292002 ECHO (OM52463U)
Power steering198
. . . . . . . . . . . . . . . . . . .
Viscosity and grade 194,217
. . . . . . . . . .
Oil consumption 138
. . . . . . . . . . . . . . . . . . . .
Open door warning light 82
. . . . . . . . . . . . . .
Operating tips 123
. . . . . . . . . . . . . . . . . . . . .
Operation in foreign countries 136 . . . . . . .
Overdrive switch 89
. . . . . . . . . . . . . . . . . . . .
Overheating, Engine 159
. . . . . . . . . . . . . . . .
Overheating, Engine coolant 80
. . . . . . . . . .
Overview
Engine compartment 186
. . . . . . . . . . . . . .
P
Parking brake
Operation 94 . . . . . . . . . . . . . . . . . . . . . . . .
Reminder light 94 . . . . . . . . . . . . . . . . . . . .
Parking brake reminder light 82 . . . . . . . . . .
Polishing 175 . . . . . . . . . . . . . . . . . . . . . . . . . .
Positioning the jack 190 . . . . . . . . . . . . . . . . .
Power outlet 129 . . . . . . . . . . . . . . . . . . . . . . .
Power steering Fluid level 198 . . . . . . . . . . . . . . . . . . . . . . .
Power window switches 15 . . . . . . . . . . . . . .
Preloaders (seat belt pretensioners) 38 . . . . . . . . . . .
Pretensioners
(seat belt pretensioners) 38 . . . . . . . . . . .
Protecting your Toyota from corrosion 174 . . . . . . . . . . . . . . . . . . .
R
Radiator
Coolant, Engine 196 . . . . . . . . . . . . . . . . . .
Rear seat Folddown 29 . . . . . . . . . . . . . . . . . . . . . . .
Rear view mirror remote
control 71 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear view mirror, Antiglare inside 71 . . . . . . . . . . . . . . . . . .
Rear view mirror, Remote controlled 71 . . . . . . . . . . . . . . . . .
Rear view mirrors, Outside 70 . . . . . . . . . . .
Rear window defogger switch 77 . . . . . . . . .
Reporting safety defects for U.S. owners 222 . . . . . . . . . . . . . . . . . .
S
Seat adjustment precautions
Front seats 26 . . . . . . . . . . . . . . . . . . . . . . .
Seat belt extender 37 . . . . . . . . . . . . . . . . . . .
Seat belt reminder buzzer 82 . . . . . . . . . . . .
Seat belt reminder light 82 . . . . . . . . . . . . . .
Seat belt pretensioner warning light 82 . . . . . . . . . . . . . . . . . . . . . .
Seat belts
Cleaning 177 . . . . . . . . . . . . . . . . . . . . . . . .
Seat belt precautions 32 . . . . . . . . . . . . . .
Seat belt pretensioners 38 . . . . . . . . . . . .
Seats 26 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Service and maintenance 180 . . . . . . . . . . .
Service reminder indicators 82 . . . . . . . . . .
Side door locks 9 . . . . . . . . . . . . . . . . . . . . . . Spare fuse 208
. . . . . . . . . . . . . . . . . . . . . . . .
Spare tire 162 . . . . . . . . . . . . . . . . . . . . . . . . .
Specifications 215 . . . . . . . . . . . . . . . . . . . . .
SRS airbag warning light 82 . . . . . . . . . . . . .
SRS driver and front passenger airbags 40
. . . . . . . . . . . .
SRS warning light 82
. . . . . . . . . . . . . . . . . . .
SRS side airbags 48
. . . . . . . . . . . . . . . . . . . .
Starting Cold weather 148
. . . . . . . . . . . . . . . . . . . .
Engine 147
. . . . . . . . . . . . . . . . . . . . . . . . . .
Jump starting 157
. . . . . . . . . . . . . . . . . . . .
Starting a flooded engine 156
. . . . . . . . . . . .
Steering Tilt steering wheel 69
. . . . . . . . . . . . . . . . .
Steering column
Column lock 88
. . . . . . . . . . . . . . . . . . . . . .
Suspension and chassis 145
. . . . . . . . . . . .
Switch
Emergency flasher 75
. . . . . . . . . . . . . . . .
Headlight, dimmer and turn signal 74
. . . . . . . . . . . . . . . . . . . . . .
Ignition 88
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Overdrive 89
. . . . . . . . . . . . . . . . . . . . . . . .
Rear window defogger 77
. . . . . . . . . . . . .
Power window 15
. . . . . . . . . . . . . . . . . . . .
Windshield wiper and washer 76 . . . . . . .
T
Theft deterrent system 20
. . . . . . . . . . . . . . .
Theft prevention labels 144
. . . . . . . . . . . . . .
Threeway catalytic converter 136 . . . . . . .