engine TOYOTA GT86 2017 1.G Owners Manual

363
6-1. Specifications
6
Vehicle specifications
Clutch
Brakes
*1: Minimum pedal clearance when depressed with a force of 110 lbf (490 N, 50
kgf) while the engine is running.
*2: Parking brake lever travel when pulled up with a force of 45.0 lbf (200 N,20.4 kgf).
Pedal free play 0.2 ⎯ 0.6 in. (5 ⎯ 15 mm)
Fluid type SAE J1703 or FMVSS No.116 DOT 3
Pedal clearance*12.16 in. (55 mm) Min.
Pedal free play0.020 ⎯ 0.106 in. (0.5 ⎯ 2.7 mm)
Brake pad wear limit0.06 in. (1.5 mm)
Parking brake lining wear limit 0.06 in. (1.5 mm)
Parking brake lever travel*27 ⎯ 8 clicks
Fluid type SAE J1703 or FMVSS No.116 DOT 3

366
6-1. Specifications
Fuel information
■Fuel tank opening for unleaded gasoline
To help prevent incorrect fueling, your Toyota has a fuel tank opening that
only accommodates the special nozzle on unleaded fuel pumps.
■ If your engine knocks
●Consult your Toyota dealer.
● You may occasionally notice light knocking for a short time while acceler-
ating or driving uphill. This is normal and there is no need for concern.
The engine is designed to operate at maximum performance using
unleaded gasoline with an octane ra ting of 93 (98 RON) or higher. If
an octane rating of 93 (98 RON) fuel is not readily available in your
area, unleaded gasoline with an octane rating of 91 (95 RON) may be
used with no detriment to engine dur ability or driveability. However,
you may notice a slight decrease in maximum engine performance
and you may hear some knocking (pin ging) of an engine while using
an octane rating of 91 (95 RON) fuel.
If the octane rating is less than 91, damage to the engine may occur
and may void the vehicle warranty.

367
6-1. Specifications
6
Vehicle specifications
■
Gasoline quality
In very few cases, driveability problems may be caused by the brand of gas-
oline you are using. If driveability problems persist, try changing the brand of
gasoline. If this does not correct the problem, consult your Toyota dealer.
■ Fuel octane rating
This octane rating is the average of the Research Octane and Motor Octane
numbers and is commonly referred to as the Anti Knock Index.
Using a gasoline with a lower octane rating can cause persistent and heavy
knocking, which can damage the engine. Do not be concerned if your vehi-
cle sometimes knocks lightly when you drive up a hill or when you acceler-
ate. Contact your Toyota dealer if you use a fuel with the specified octane
rating and your vehicle knocks heavily or persistently.
■ Gasoline for California-certified LEV
If your vehicle was certified to California’s low emission vehicle (LEV) stan-
dards as indicated on the underhood tune-up label, it is designed to optimize
engine and emission performance with gasoline that meets the clean burn-
ing low-sulfur California gasoline specifications. If you live in any other state
than California, your vehicle will operate on gasoline meeting Federal speci-
fications. Gasoline sold outside California is permitted to have higher sulfur
levels, which may affect the performance of your vehicle’s catalytic converter
and may produce a sulfur exhaust odor or smell. Toyota recommends that
you try a different brand of unleaded gasoline having lower sulfur to deter-
mine if the problem is fuel related before returning your vehicle to an autho-
rized dealer for service.

368 6-1. Specifications
■Toyota recommends the use of g asoline containing detergent additives
● Toyota recommends the use of gasoline that contains detergent additives
to avoid build-up of engine deposits.
● All gasoline sold in the U.S.A. contains minimum detergent additives to
clean and/or keep clean intake systems, per EPA’s lowest additives con-
centration program.
● Toyota strongly recommends the use of Top Tier Detergent Gasoline. For
more information on Top Tier Detergent Gasoline and a list of marketers,
please go to the official website www.toptiergas.com.
■ Toyota recommends the use of cleaner burning gasoline
Cleaner burning gasoline, including reformulated gasoline that contains oxy-
genates such as ethanol or MTBE (Methyl Tertiary Butyl Ether) is available in
many areas.
Toyota recommends the use of cleaner burning gasoline and appropriately
blended reformulated gasoline. These types of gasoline provide excellent
vehicle performance, reduce vehicle emissions and improve air quality.
■ Non-recommendation of the use of blended gasoline
●If you use gasohol in your vehicle, be sure that it has an octane rating no
lower than 93.
● Toyota DOES NOT recommend the use of gasoline containing methanol.
●Use only gasoline containing a maxi-
mum of 10% ethanol.
DO NOT use any flex-fuel or gasoline
that could contain more than 10% etha-
nol, including from any pump labeled
E15, E30, E50, E85 (which are only
some examples of fuel containing more
than 10% ethanol).DO NOT use gasoline
containing more than 10%
ethanol.
(15% ethanol)
(50% ethanol)
(85% ethanol)

369
6-1. Specifications
6
Vehicle specifications
■
Toyota does not recommend gasoline containing MMT
Some gasoline contains octane enhancing additive called MMT (Methylcy-
clopentadienyl Manganese Tricarbonyl).
Toyota DOES NOT recommend the use of gasoline that contains MMT. If
fuel containing MMT is used, your emission control system may be
adversely affected.
The malfunction indicator lamp on the instrument cluster may come on. If
this happens, contact your Toyota dealer for service.
NOTICE
■Notice on fuel quality
●Do not use improper fuels. If improper fuels are used the engine will be
damaged.
● Do not use leaded gasoline.
Leaded gasoline can cause damage to your vehicle’s three-way catalytic
converters causing the emission control system to malfunction.
● Do not use gasohol other than the type previously stated.
Other gasohol may cause fuel system damage or vehicle performance
problems.
● Using unleaded gasoline with an octane number or rating lower than the
level previously stated may cause persistent heavy knocking.
At worst, this may lead to engine damage and will void the vehicle war-
ranty.
■ Fuel-related poor driveability
If after using a different type of fuel, poor driveability is encountered (poor
hot starting, vaporization, engine knocking, etc.), discontinue the use of that
type of fuel.
■ When refueling with gasohol
Take care not to spill gasohol. It can damage your vehicle's paint.

376 6-1. Specifications
Warning: The temperature grades of a tire assume that it is properly
inflated and not overloaded.
Excessive speed, underinflation, or excessive loading, either sepa-
rately or in combination, can cause heat buildup and possible tire fail-
ure.
Glossary of tire terminology
Tire related termMeaning
Cold tire inflation
pressure Tire pressure when the vehicle has been
parked for three hours or more, or has not
been driven more than 1 mile or 1.5 km under
that condition
Maximum inflation
pressure The maximum cold inflated
pressure to which a
tire may be inflated, s hown on the sidewall of
the tire
Recommended
inflation pressure Cold tire inflation pressure recommended by a
manufacturer.
Accessory weight The combined weight (in excess of those stan-
dard items which may be replaced) of auto-
matic transmission, power steering, power
brakes, power windows, power seats, radio
and heater, to the extent that these items are
available as factory-installed equipment
(whether installed or not)
Curb weight The weight of a motor vehicle with standard
equipment, including the maximum capacity of
fuel, oil and coolant, and if so equipped, air
conditioning and additional weight optional
engine
Maximum loaded
vehicle weight The sum of:
(a) Curb weight
(b) Accessory weight
(c) Vehicle capacity weight
(d) Production options weight

384 6-2. Customization
Wireless
remote con-
trol
(
→P. 24)Door lock buzzer On Off
Trunk unlocking func-
tion
On Off
Trunk unlocking opera-
tion Push and hold
(short) Push and hold
(long)
One short push Two short pushes
Panic function OnOff
Vehicle finder function Off On
Automatic
light control
system
( →P. 172) Light sensor sensitivity ±0% -40% to +40%
Time elapsed before
headlights automati-
cally turn off after doors
are closed
30 seconds0 second
60 seconds
90 seconds
Illumination
(
→P. 220) Time elapsed before
lights turn off
15 seconds7.5 seconds
30 seconds
Operation when the
doors are unlocked On Off
Operation after the
engine switch is turned
off On Off
Interior light illumination On Off
ItemFunctionDefault settingCustomized setting

417
Alphabetical index
Child safety
Airbag precautions ................. 97
Battery precautions ...... 267, 343
Child restraint system ........... 112
How your child should
wear the seat belt................. 44
Installing child restraints ....... 116
Power window lock switch ...... 54
Power window precautions .......................... 56
Removed key battery
precautions ........................ 288
Seat belt guide ....................... 43
Seat belt precautions.............. 46
Trunk precautions................... 32
Cleaning Aluminum wheels ................. 237
Exterior ................................. 236
Interior .................................. 240
Seat belts ............................. 241
Clock ........................................ 229
Condenser ............................... 263
Console tray ............................ 225
Coolant Capacity ............................... 360
Checking .............................. 261
Cooling system Engine overheating .............. 345
Cruise control .......................... 179 Cup holders ..............................225
Curtain shield airbags ...............66
Customizable features.............383
Daytime running light
system ....................................173
Defogger
Rear window .........................215
Side mirror.............................215
Dimension.................................354
Dinghy towing ..........................205
Display Multi-information display .......165
Trip information .....................166
Do-it-yourself main tenance.....250
Doors
Door lock ...........................24, 27
Door windows..........................54
Side mirrors .............................51
Driver's seat belt reminder light.........................320
Driving
Break-in tips ..........................131
Correct posture .......................64
Procedures ............................128
Winter drive tips ....................200
D

418 Alphabetical index
Electric power steering ........... 184
Emergency flashersSwitch.................................... 306
Emergency, in case of If the engine will not start ...... 338
If the shift lever cannot
be shifted from P................. 339
If the vehicle has a
discharged battery .............. 341
If the warning buzzer sounds ................................ 317
If the warning light turns on ............................... 317
If you have a flat tire ............. 327
If you lose your keys ............. 340
If you think something is wrong .................................. 315
If your vehicle becomes stuck ................................... 348
If your vehicle has to be
stopped in an
emergency .......................... 350
If your vehicle needs to
be towed ............................. 307
If your vehicle overheats ....... 345 Engine
Compartment ........................ 257
Engine switch ........................ 142
Hood ..................................... 253
How to start the engine ......... 142
Identification number............. 355
If the engine will not start ...... 338
Ignition switch ....................... 142
Overheating .......................... 345
Engine coolant Capacity ................................ 360
Checking ............................... 261
Engine coolan t temperature
gauge ...................................... 158
Engine immobilizer system ...... 61
Engine oil Capacity ................................ 358
Checking ............................... 258
Preparing and checking before winter ....................... 200
Engine switch........................... 142
Engine switch light .................. 220
EPS............................................ 184
Event data recorder ................... 18E

419
Alphabetical index
Floor mat .................................. 232
Fluid
Brake .................................... 263
Washer ................................. 268
Front passenger occupant
classification system............ 104
Front passenger's seat belt reminder light ........................ 320
Front seats Adjustment ............................. 35
Front side marker light
Replacing light bulbs ............ 298
Wattage ................................ 365
Front turn signal lights
Switch ................................... 155
Fuel Capacity ............................... 357
Fuel gauge ........................... 158
Fuel pump shut off system ... 316
Gas station information ........ 428
Information ........................... 366
Refueling ................................ 57
Fuel door .................................... 57
Fuel filler door ........................... 57
Fuel pump shut off system .... 316
Fuses ........................................ 290 Gauges ......................................158
Glove box..................................223
Hazard lights
Switch....................................306
Head restraints Adjusting ................................40
Headlights Automatic headlight leveling................................174
Switch....................................172
Heaters Side mirror.............................215
Hill-start assist control ............191
Hood ..........................................253
Horn...........................................157
I/M test.......................................249
Identification Engine ...................................355
Vehicle ..................................355
Ignition switch ..........................142
Ignition switch light Ignition switch light ................220
Illuminated entry system .........220
Immobilizer system....................61
Indicator lights .........................161
Inside rear view mirror ..............50
Interior light Interior light ...........................221
Switch....................................221
Wattage .................................365FG
H
I