gas type TOYOTA MIRAI 2019 Owners Manual (in English)

2135-4. Refueling
5
Driving
MIRAI_OM_USA_OM62054U(18MY)_O
M62048U(19MY)
Opening the fuel door
●Close the all the doors and windows.
● Set the parking brake.
● Shift the shift position to P.
● Turn the power switch off.
● Turn off the headlights.
■Fuel Type
Compressed hydrogen gas
■ Notes on fueling
●Fueling will not be possible if the pressure inside the vehicle ’s hydrogen tanks
is higher than the supply pressure of the hydrogen station. If the hydrogen
tanks are more than half full, the vehicle will be unable to fu el at a H35 dis-
penser.
A hydrogen station with a H70 dispenser (supply pressure of 101 50 psi
[70 MPa, 714 kgf/cm
2, 700 bar] is necessary to completely fill hydrogen tanks.
● If the fueling cannot be completed due to trouble with the station equipment,
call the number indicated on the equipment.
● Fuel with compressed hydrogen g as only at hydrogen stations.
● Fuel at hydrogen stations confor ming with the Society of Automo-
tive Engineers (SAE) J2601 fueling protocol or laws that may
supersede such SAE protocols.
●
Refer to the Mirai Station Finder Application in Entune,
www.toyota.com
(for U.S. owners) or www.toyota.ca (for
Canadian owners), or call 1-800-331-4331 (for U.S. owners)
or 1-888-869-6828 (for Canadian owners).
● Observe any notic es or instructions show n at hydrogen stations.
● The filling time and amount of fuel may depend on outside tem-
perature and the equipment at that hydrogen station.
● Vehicles with expired hydrogen tanks must not be used. ( P. 94)
Consult your Toyota dealer.
Before filling

3587-1. Maintenance and care
MIRAI_OM_USA_OM62054U(18MY)_O
M62048U(19MY)
NOTICE
■Cleaning detergents
● Do not use the following types of detergent, as they may discol or the vehi-
cle interior or cause streaks or damage to painted surfaces:
• Non-seat portions: Organic substances such as benzene or gasol ine,
alkaline or acidic solutions, dye, and bleach
• Seats: Alkaline or acidic solutions, such as thinner, benzene, and alco-
hol
● Do not use a polish wax or polish cleaner. The instrument panel’s or other
interior part’s painted surface may be damaged.
■ Preventing damage to leather surfaces
Observe the following precautions to avoid damage to and deterioration of
leather surfaces:
● Remove any dust or dirt from leather surfaces immediately.
● Do not expose the vehicle to direct sunlight for extended perio ds of time.
Park the vehicle in the shade, especially during summer.
● Do not place items made of vinyl, plastic, or containing wax on the uphol-
stery, as they may stick to the leather surface if the vehicle interior heats
up significantly.
■ Water on the floor
Do not wash the vehicle floor with water.
Vehicle systems such as the audio system may be damaged if wate r comes
into contact with electrical components such as the audio syste m above or
under the floor of the vehicle. Water may also cause the body to rust.
■ When cleaning the inside of the windshield
Do not allow glass cleaner to contact the lens. Also, do not to uch the lens.
( P. 219)
■ Cleaning the inside of the rear window
● Do not use glass cleaner to clean the rear window, as this may cause
damage to the rear window defogger heater wires or antenna. Use a cloth
dampened with lukewarm water to gently wipe the window clean. Wipe the
window in strokes running parallel to the heater wires or antenna.
● Be careful not to scratch or damage the heater wires or antenna .

4558-2. Steps to take in an emergency
MIRAI_OM_USA_OM62054U(18MY)_O
M62048U(19MY)
8
When trouble arises
●When the 12-volt battery is reconnected, start the fuel cell sy stem, depress
the brake pedal, and confirm that it is possible to shift into each shift posi-
tion.
● If the battery is removed or the terminals disconnected without operating the
water release function during cold weather, the vehicle may not start due to
the fuel cell system being frozen. To prevent this, operate the water release
function before removing the battery or disconnecting the terminals.
( P. 190)
■ When exchanging the 12-volt battery
Use a Central Degassing type 12-volt battery (Japanese Industri al Stan-
dards). Also, use 12-volt batteries with case sizes similar to one prior the
exchange and an equivalent 20 hour rate capacity (20HR) or grea ter.
• If the sizes differ, the 12-volt battery cannot be properly se cured.
• If the 20 hour rate capacity is low, even if the time period w here the vehicle
is not used is a short time, the 12-volt battery may discharge and fuel cell
system may not be able to start.
For details, consult your Toyota dealer.
WARNING
■ Avoiding 12-volt batte ry fires or explosions
Observe the following precautions to prevent accidentally ignit ing the flam-
mable gas that may be emitted from the 12-volt battery:
● Make sure each jumper cable is connected to the correct terminal and that
it is not unintentionally in contact with any other than the in tended terminal.
● Do not allow the other end of the jumper cable connected to the “+” termi-
nal to come into contact with any other parts or metal surfaces in the area,
such as brackets or unpainted metal.
● Do not allow the + and - clamps of the jumper cables to come in to contact
with each other.
● Do not smoke, use matches, cigarette lighters or allow open fla me near
the 12-volt battery.

4689-1. Specifications
MIRAI_OM_USA_OM62054U(18MY)_O
M62048U(19MY)*: This is the maximum possible fill amount. The actual fuel amount achieved
at hydrogen stations may be lower due to station capacity or station set-
tings.
Fuel
Fuel type Compressed hydrogen gas
Nominal working
pressure10150 psi (70 MPa, 714 kgf/cm2, 700 bar)
Hydrogen tanks’ fuel
capacity
(Reference)32.3 gal. (122.4 L, 26.9 Imp.gal.)
(Approximately 11.0 lb. [5 kg]
*)
Electric motor (traction motor)
Type
Permanent magnet synchronous motor
Maximum output 113 kW
Maximum torque 247 ft•lbf (335 N•m, 34.2 kgf•m)
Traction battery
TypeNickel-metal hydride battery
Voltage7.2 V/module
Capacity 6.5 Ah (3HR)
Quantity 34 modules
Overall voltage 244.8 V

518Alphabetical index
MIRAI_OM_USA_OM62054U(18MY)_O
M62048U(19MY)
Fuel cell stack ............................ 94
Fuel cell stack coolantCapacity ................................ 469
Checking ............................... 370
Fuel cell system
Characteristics ........................ 86
Cold temperatures ................ 189
Coolant type.......................... 469
Indicators .............................. 109
Multi-information display ....... 117
Precautions ............................. 90
Starting the system ............... 186
Stopping the system ............. 187
Warning lights ....................... 107
Fuel cell system indicator....... 120
Fuel cell vehicles Characteristics ........................ 86
Charging the traction
battery .................................. 89
Driving advice ....................... 102
Emergency shut off system .... 92
Emergency start function ...... 448
Emergency stops .................. 409
Fuel ....................................... 468
Handling hydrogen gas ........... 98
High-voltage components ....... 91
Hydrogen gas ......................... 97
Hydrogen-related
components .......................... 90
If the 12-volt battery is
discharged .......................... 452
If the fuel cell system will not start ........................ 447
Maintenance, repair, recycling, and disposal ......... 89 Opening the fuel door ........... 213
Overheating .......................... 457
Power output restriction .......... 96
Power switch ........................ 186
Precautions............................. 90
Regenerative braking ............. 89
Road accident cautions ........ 100
Running out of fuel ................. 93
Service plugs .......................... 99
Sounds and vibrations ............ 88
Starting the system ............... 186
Traction battery air intake
vent ...................................... 93
Vehicle proximity notification
system .......... ..................... ... 92
Warning message................. 426
Water release ....................... 187
Fuel consumption ........... 121, 122
Fuel door .................................. 213 Refueling .............................. 213
Fuses ........................................ 402
Garage door opener ................ 343
Gauges ..................................... 111
Glove box ................................. 321
Grocery bag hooks.................. 325
G

528
MIRAI_OM_USA_OM62054U(18MY)_O
M62048U(19MY)
HYDROGEN STATION INFORMATION
Auxiliary catch leverTrunk openerFuel door
P. 366 P. 138P. 215
Hood lock release
leverFuel door openerTire inflation pressure
P. 366 P. 215P. 471
Hydrogen tanks’ fuel
capacity (Reference)32.3 gal. (122.4 L, 26.9 Imp.gal.)
(Approximately 11.0 lb. [5 kg]
*)
*: This is the maximum possible fill amount. The
actual fuel amount achieved at hydrogen sta-
tions may be lower due to station capacity or
station settings.
Fuel type Compressed hydrogen gas P. 213, 468
Cold tire inflation
pressure P. 4 7 1