catalytic converter TOYOTA MR2 SPYDER 2002 W30 / 3.G Owners Manual

02 MY MR2 SMT(U) L/O 0108
123
01 06 12
2002 MR2 (OM17493U)
INFORMATION BEFORE DRIVING YOUR
TOYOTA
Breakin period124
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . .
Fuel 124
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . . . .
Fuel pump shut off system 126
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operation in foreign countries 126
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Threeway catalytic converter 126
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine exhaust cautions 127
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
Facts about engine oil consumption 128
. . . . . . . . . . . . . . . . . . . . . . . . . .
Iridiumtipped spark plugs 129
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake system 129
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . .
Brake pad wear limit indicators 132
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Luggage stowage precautions 132
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Limitedslip differential 133
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. .
Your Toyota’s identification 133
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Theft prevention labels 134
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. .
Suspension and chassis 135
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
Types of tires 135
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . .
SECTION 2

02 MY MR2 SMT(U) L/O 0108
124
01 06 12
2002 MR2 (OM17493U)
Breakin period
Drive gently and avoid high speeds.
Your vehicle does not need an elaborate
breakin. But following a few simple tips
for the first 1600 km (1000 miles) can add
to the future economy and long life of
your vehicle:
Do not drive over 88 km/h (55 mph).
Run the engine at moderate speed be-
tween 2000 and 4000 rpm.
Avoid fullthrottle starts.
Try to avoid hard stops during the first
300 km (200 miles).
Do not drive slowly with the transmis-
sion in a high gear.
Do not drive for a long time at any
single speed, either fast or slow.
Fuel
FUEL TYPE
Your new vehicle must use only
unleaded gasoline.
To help prevent gas station mixups, your
Toyota has a smaller fuel tank opening.
The special nozzle on pumps with un-
leaded fuel will fit it, but the larger stan-
dard nozzle on pumps with leaded gas will
not.
At a minimum, the gasoline you use
should meet specifications of ASTM
D4814 in the U.S.A.
NOTICE
Do not use leaded gasoline. Use of
leaded gasoline will cause the three
way catalytic converter to lose its ef-
fectiveness and the emission control
system to function improperly. Also,
this can increase maintenance costs.
OCTANE RATING
Select Octane Rating 87 (Research Oc-
tane Number 91) or higher.
Use of unleaded fuel with an octane num-
ber or rating lower than stated above will
cause persistent heavy knocking. If se-
vere, this will lead to engine damage.If your engine knocks...
If you detect heavy knocking even when
using the recommended fuel, or if you
hear steady knocking while holding a
steady speed on level roads, consult your
Toyota dealer.
However, now and then, you may notice
light knocking for a short time while accel-
erating or driving up hills. This is no need
of concern.
GASOLINES CONTAINING DETERGENT
ADDITIVES
Toyota recommends the use of gaso-
lines that contain detergent additives to
avoid buildup of engine deposits.
However, all gasoline sold in the U.S con-
tains detergent additives to keep clean
and/or clean intake systems.

02 MY MR2 SMT(U) L/O 0108
126
01 06 12
2002 MR2 (OM17493U)
Fuel pump shut off system
The fuel pump shut off system stops sup-
plying fuel to the engine to minimize the
risk of fuel leakage when the engine stalls
or an airbag inflates upon collision. To
restart the engine after the fuel pump shut
off system activates, turn the ignition
switch to “ACC” or “LOCK” once and start
it.
CAUTION
Inspect the ground under the vehicle
before restarting the engine. If you
find that liquid has leaked onto the
ground, it is the fuel system has
been damaged and it is in need of
repair. In this case, do not restart the
engine.
Operation in foreign countries
If you plan to drive your Toyota in
another country...
First, comply with the vehicle registration
laws.
Second, confirm the availability of the cor-
rect fuel (unleaded and minimum octane
number).
Threeway catalytic converter
SB21013
The threeway catalytic converter is an
emission control device installed in the
exhaust system.
Its purpose is to reduce pollutants in the
exhaust gas.
CAUTION
Keep people and combustible mate-
rials away from the exhaust pipe
while the engine is running. The
exhaust gas is very hot.
Do not drive, idle or park your ve-
hicle over anything that might burn
easily such as grass, leaves, paper
or rags.

02 MY MR2 SMT(U) L/O 0108
127
01 06 12
2002 MR2 (OM17493U)
NOTICE
A large amount of unburned gases
flowing into the threeway catalytic
converter may cause it to overheat
and create a fire hazard. To prevent
this and other damage, observe the
following precautions:
Use only unleaded gasoline.
 Do not drive with an extremely low
fuel level; running out of fuel could
cause the engine to misfire, creat-
ing an excessive load on the three
way catalytic converter.
 Do not allow the engine to run at
idle speed for more than 20 min-
utes.
 Avoid racing the engine.
 Do not pushstart or pullstart your
vehicle.
 Do not turn off the ignition while
the vehicle is moving.
 Keep your engine in good running
order. Malfunctions in the engine
electrical system, electronic ignition
system/distributor ignition system
or fuel system could cause an ex-
tremely high threeway catalytic
converter temperature.
If the engine becomes difficult to
start or stalls frequently, take your
vehicle in for a checkup as soon
as possible. Remember, your Toyota
dealer knows your vehicle and its
threeway catalytic converter sys-
tem best.
 To ensure that the threeway cata-
lytic converter and the entire emis-
sion control system operate proper-
ly, your vehicle must receive the
periodic inspections required by the
Toyota Maintenance Schedule. For
scheduled maintenance information,
refer to the “Scheduled Maintenance
Guide” or “Owner ’s Manual
Supplement”.
Engine exhaust cautions
CAUTION
Avoid inhaling the engine exhaust.
It contains carbon monoxide, which
is a colorless and odorless gas. It
can cause unconsciousness or even
death.
Make sure the exhaust system has
no holes or loose connections. The
system should be checked from
time to time. If you hit something,
or notice a change in the sound of
the exhaust, have the system
checked immediately.
Do not run the engine in a garage
or enclosed area except for the
time needed to drive the vehicle in
or out. The exhaust gases cannot
escape, making this a particularly
dangerous situation.
Do not remain for a long time in a
parked vehicle with the engine run-
ning. If it is unavoidable, however,
do so only in an unconfined area
and adjust the heating or cooling
system to force outside air into the
vehicle.

02 MY MR2 SMT(U) L/O 0108
146
01 06 12
2002 MR2 (OM17493U)
Before making these checks, make sure
you have followed the correct starting
procedure given in “How to start the
engine” on page 138 in Section 3 and that
you have sufficient fuel. Also check
whether the other keys will start the
engine. If they work, your key may be
broken. Have the key checked at your
Toyota dealer. If none of your keys work,
the engine immobiliser system is possibly
broken. Call your Toyota dealer. (See
“Keys” on page 8 in Section 12.)
If the engine is not turning over or is
turning over too slowly—1. Check that the battery terminals are tight and clean.
2. If the battery terminals are O.K., switch on the interior light.
3. If the light is out, dim or goes out when the starter is cranked, the battery
is discharged. You may try jump start-
ing. See “(c) Jump starting” on page
147 for further instructions.
If the light is O.K., but the engine still will
not start, it needs adjustment or repair.
Call a Toyota dealer or qualified repair
shop.NOTICE
 Sequential manual transmission
only: Your vehicle cannot be pull
or pushstarted.
 Do not pull or pushstart the ve-
hicle. It may damage the vehicle or
cause a collision when the engine
starts. Also the threeway catalytic
converter may overheat and become
a fire hazard.
If the engine turns over at its normal
speed but will not start—
1. The engine may be flooded because of repeated cranking. See “(b) Starting a
flooded engine” on page 146 for further
instructions.
2. If the engine still will not start, it needs adjustment or repair. Call a Toyota
dealer or qualified repair shop.
(b) Starting a flooded engine
If the engine will not start, your engine
may be flooded because of repeated
cranking.
Sequential manual transmission: If this
happens, turn the key to “START” with the
accelerator pedal and brake pedal held
down. Keep the key, accelerator pedal and
brake pedal in these positions for 15 sec-
onds and release them. Then release the
accelerator pedal, and try cranking the
engine with the brake pedal depressed.
Manual transmission: If this happens,
turn the key to “START” with the accelera-
tor pedal held down. Keep the key and
accelerator pedal in these positions for 15
seconds and release them. Then try start-
ing the engine with your foot off the accel-
erator pedal.
If the engine does not start after 15 sec-
onds of cranking, release the key, wait a
few minutes and try again.
If the engine still will not start, it needs
adjustment or repair. Call a Toyota dealer
or qualified repair shop for assistance.
NOTICE
Do not crank for more than 30 sec-
onds at a time. This may overheat the
starter and wiring systems.
If your vehicle will not start—
(a) Simple checks

02 MY MR2 SMT(U) L/O 0108
229
01 06 12
2002 MR2 (OM17493U)
E
Economical drivingSaving money on both fuel
and repairs 142 . . . . . . . . . . . . . . . . . . . .
Electrical system Battery 200,201 . . . . . . . . . . . . . . . . . . . . . .
Fuse locations 182 . . . . . . . . . . . . . . . . . . .
Fuses 202 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 63 . . . . . . . . . . . .
Emergency, In case of Blown fuse 202 . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 63 . . . . . . . . . .
Flat tire 151 . . . . . . . . . . . . . . . . . . . . . . . . .
If you cannot increase the engine speed 149 . . . . . . . . . . . . . . . . . .
If you cannot shift the sequential manual transmission
selector lever 164 . . . . . . . . . . . . . . . . . .
If you lose your keys 164 . . . . . . . . . . . . . .
If your engine stalls while driving 149 . . . . . . . . . . . . . . . . . . .
If your vehicle needs to be towed 160 . . . . . . . . . . . . . . . . . . . .
If your vehicle will not start 146 . . . . . . . .
Jump starting 147 . . . . . . . . . . . . . . . . . . . .
Overheating 150 . . . . . . . . . . . . . . . . . . . . .
Towing 160 . . . . . . . . . . . . . . . . . . . . . . . . . .
Emissions Inspection and Maintenance (I/M) programs 178 . . . . . . .
Engine Before starting the engine 138 . . . . . . . . .
Checking the coolant level 189 . . . . . . . . Emission control device 126
. . . . . . . . . . .
Engine compartment 180 . . . . . . . . . . . . . .
Exhaust gas caution 127 . . . . . . . . . . . . . .
Hood release 16 . . . . . . . . . . . . . . . . . . . . .
Oil consumption 128 . . . . . . . . . . . . . . . . . .
Oil level 188 . . . . . . . . . . . . . . . . . . . . . . . . .
Overheating 150 . . . . . . . . . . . . . . . . . . . . .
Starting procedure 137 . . . . . . . . . . . . . . .
Threeway catalytic converter 126 . . . . .
Engine coolant
Temperature gauge 68 . . . . . . . . . . . . . . . .
Winter driving tips 140 . . . . . . . . . . . . . . . .
Engine coolant temperature gauge 68 . . . .
Engine immobiliser system 10 . . . . . . . . . . .
Engine oil Winter driving tips 140 . . . . . . . . . . . . . . . .
Exhaust gas cautions 127 . . . . . . . . . . . . . . .
F
Facts about engine oil
consumption 128 . . . . . . . . . . . . . . . . . . . . .
Flasher, Headlight 62 . . . . . . . . . . . . . . . . . . .
Flat tire
After changing wheels 158 . . . . . . . . . . . .
Changing tire 157 . . . . . . . . . . . . . . . . . . . .
If you have a flat tire 151 . . . . . . . . . . . . . .
Jack point 156 . . . . . . . . . . . . . . . . . . . . . . .
Jacking precautions 151 . . . . . . . . . . . . . .
Jacking up 156 . . . . . . . . . . . . . . . . . . . . . .
Loosening wheel nuts 155 . . . . . . . . . . . . .
Lowering vehicle 158 . . . . . . . . . . . . . . . . .
Wheel block 155 . . . . . . . . . . . . . . . . . . . . . Wheel nuts 157
. . . . . . . . . . . . . . . . . . . . . .
Floor mat 121 . . . . . . . . . . . . . . . . . . . . . . . . . .
Fluid level Brake 191 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power steering 191 . . . . . . . . . . . . . . . . . . .
Washer fluid 203 . . . . . . . . . . . . . . . . . . . . .
Foreign countries, Operation in 126 . . . . . .
Front box 117 . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Filler door o pener 18. . . . . . . . . . . . . . . . .
Fuel economy 142 . . . . . . . . . . . . . . . . . . . .
Fuel pump shut off system 126 . . . . . . . . .
Gauge 68 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operation in foreign countries 126 . . . . .
Tank cap 18 . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel information 124 . . . . . . . . . . . . . . . . . . . .
Fuel pump shut off system 126 . . . . . . . . . .
Fuses Fuse box 202 . . . . . . . . . . . . . . . . . . . . . . . .
Fuse locations 182 . . . . . . . . . . . . . . . . . . . . .
G
Gauge
Engine temperature 68 . . . . . . . . . . . . . . .
Fuel 68 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
General maintenance 175 . . . . . . . . . . . . . . .
Glove box 117 . . . . . . . . . . . . . . . . . . . . . . . . .
Good driving practice Manual transmission 88 . . . . . . . . . . . . . .


02 MY MR2 SMT(U) L/O 0108
232
01 06 12
2002 MR2 (OM17493U)
Power rear view mirror control 58. . . . . .
Power window 13 . . . . . . . . . . . . . . . . . . . .
Windshield wiper and washer 64 . . . . . . .
T
Tachometer 69
. . . . . . . . . . . . . . . . . . . . . . . . .
Theft prevention labels 134
. . . . . . . . . . . . . .
Threeway catalytic converter 126 . . . . . . .
Tilt steering wheel 57
. . . . . . . . . . . . . . . . . . .
Tires Changing 151
. . . . . . . . . . . . . . . . . . . . . . . .
Flat tire 151
. . . . . . . . . . . . . . . . . . . . . . . . .
Rotation 194
. . . . . . . . . . . . . . . . . . . . . . . . .
Spare 153
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Tire information 192,193,195
. . . . . . . . . .
Tools 153
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
To w i n g
Dinghy 141
. . . . . . . . . . . . . . . . . . . . . . . . . .
Emergency towing 161
. . . . . . . . . . . . . . . .
If your vehicle needs
to be towed 160
. . . . . . . . . . . . . . . . . . . .
Trailer 142
. . . . . . . . . . . . . . . . . . . . . . . . . .
Trailer towing 142
. . . . . . . . . . . . . . . . . . . . . .
Trip meter 69
. . . . . . . . . . . . . . . . . . . . . . . . . .
Trunk lid (front) 14
. . . . . . . . . . . . . . . . . . . . .
Trunk room (front) overview 181
. . . . . . . . .
Turn signals 62
. . . . . . . . . . . . . . . . . . . . . . . .
Types of tires 135
. . . . . . . . . . . . . . . . . . . . . .
U
Uniform tire quality grading 225
. . . . . . . . . .
W
Warning buzzer 70
. . . . . . . . . . . . . . . . . . . . .
Washer fluid
Adding washer fluid 203
. . . . . . . . . . . . . . .
Washing and waxing 167
. . . . . . . . . . . . . . . .
Wheels
Aluminum wheel 197
. . . . . . . . . . . . . . . . .
Windshield wiper and washer switch 64
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Winter driving tips 140
. . . . . . . . . . . . . . . . . .