engine oil TOYOTA PRIUS 2001 Service Repair Manual

2001 PRIUS (EWD414U)
B
[A]: Part Code
[B]: Part Name
[C]: Part Number
Toyota Part Number are indicated.
Not all of the above part numbers of the connector are established for the supply. In case of ordering a connector
or terminal with wire, please confirm in advance if there is supply for it using
ªParts Catalog Newsº (published by
Parts Engineering Administration Dept.).
A 5
90980±11194
L PART NUMBER OF CONNECTORS
Code Part Name Part NumberCode Part NamePart Number
A 1
A 2
A 4
A 6
A 7A/C Ambient Temp. Sensor
A/C Condenser Fan Motor
A/C Triple Pressure SW (A/C Dual and
Single Pressure SW)
A/T Oil Temp. Sensor
ABS Actuator
ABS Actuator90980±11070
90980±11237
90980±10943
90980±11413
90980±11151D 4
D 5
D 6
D 7
D 8
D 9
D10
D11Diode (Door Courtesy Light)
Diode (Key Off Operation)
Diode (Luggage Compartment Light)
Door Lock Control Relay
Door Courtesy Light LH
Door Courtesy Light RH
Door Courtesy SW LH
Door Courtesy SW RH90980±11608
90980±10962
90980±11608
90980±10848
90980±11148
90980±11097
A 8ABS Speed Sensor Front LH
90980±10941
A 9ABS Speed Sensor Front RH
90980±11856 A10Airbag Sensor Front LH
A11Airbag Sensor Front RHD12Door Courtesy SW Front LH
90980±11156 D13Door Courtesy SW Front RH
D14Door Courtesy SW Rear LH
Door Courtesy SW Rear RH
D15
[B] [C]
A12
Auto Antenna Motor90980±11194 A 3
A/C Condenser Fan Relay90980±10940
[A]
90980±11009
90980±11002
D16
D17Door Key Lock and Unlock SW LH
Door Key Lock and Unlock SW RH90980±11170

2001 PRIUS (EWD414U)
G ELECTRICAL WIRING ROUTING
Position of Parts in Engine Compartment
A 1 A/C Condenser Fan Motor
A 2 A/C Magnetic Clutch and Lock Sensor
A 3 A/C Triple Pressure SW
(A/C Dual and Single Pressure SW)
A 4 ABS Speed Sensor Front LH
A 5 ABS Speed Sensor Front RH
A 6 Ambient Temp. Sensor
B 1 Brake Actuator
B 2 Brake Actuator
B 3 Brake Actuator
B 4 Brake Fluid Level Warning SW
C 1 Camshaft Position Sensor
C 2 Camshaft Timing Oil Control Valve
C 3 Circuit Breaker Sensor
C 4 Converter
C 5 Converter
C 6 Crankshaft Position Sensor
D 1 DC Motor
E 1 Engine Coolant Temp. Sensor
E 2 Engine Hood Courtesy SWF 1 Front Airbag Sensor LH
F 2 Front Airbag Sensor RH
F 3 Front Parking Light LH
F 4 Front Parking Light RH
F 5 Front Side Marker Light LH
F 6 Front Side Marker Light RH
F 7 Front Turn Signal Light LH
F 8 Front Turn Signal Light RH
F 9 Front Wiper Motor
F 10 Fusible Link Block No.1
F 11 Fusible Link Block No.1
F 12 Fusible Link Block No.1
F 13 Fusible Link Block No.1
H 1 Headlight LH
H 2 Headlight RH
H 3 Heated Oxygen Sensor (Bank 1 Sensor1)
H 4 Horn
H 5 Hydraulic Booster
H 6 Hydraulic Booster

2001 PRIUS (EWD414U)
G
Position of Parts in Engine Compartment
I 1 Ignition Coil and Igniter No.1
I 2 Ignition Coil and Igniter No.2
I 3 Ignition Coil and Igniter No.3
I 4 Ignition Coil and Igniter No.4
I 5 Injector No.1
I 6 Injector No.2
I 7 Injector No.3
I 8 Injector No.4
I 9 Inverter
I 10 Inverter
I 11 Inverter
I 12 Inverter
I 13 Inverter
I 14 Inverter
K 1 Knock Sensor
M 1 Mass Air Flow Meter
M 2 Motor Generator No.1
M 3 Motor Generator No.2
M 4 Motor Generator No.2N 1 Noise Filter (Ignition)
O 1 Oil Pressure SW
R 1 Radiator Fan Motor
S 1 Steering Shaft Torque Sensor
T 1 Theft Deterrent Horn
T 2 Throttle Control Motor
T 3 Throttle Position Sensor
V 1 Vacuum Sensor (HC Adsorber and Catalyst System)
V 2 VSV (EVAP)
V 3 VSV (HC Adsorber and Catalyst System)
W 1 Washer Motor
W 2 Water Pump Motor (A/C)
W 3 Water Pump Motor (Inverter)
W 4 Water Temp. SW

2001 PRIUS (EWD414U)
E 4E 4E 4E 4
E 3E 3E 3
I 7 I 7 I 7
A 14 A 13 A 12 A 25 A 11E 4
2 1
B 5 A C
B B
D 9
B 3B9C25 B4A29
2 1
I 7 I 7B 22 B10 B19
I 71 2
I 7B 14 14 14 14 14
432
15 32 32 32 32
IGNITION COIL AND
IGNITER NO. 1 I 1
IGNITION COIL AND
IGNITER NO. 2 I 2
IGNITION COIL AND
IGNITER NO. 3 I 3
IGNITION COIL AND
IGNITER NO. 4 I 4
INJECTOR NO. 1 I 5 ENGINE COOLANT TEMP. SENSOR E 1 VSV (
EVAP) V 2
MASS AIR FLOW METER M 1JUNCTION
CONNECTORB J24 A , J25
B±R
W
B±R
G
B±R
Y
B±R
Y Y±G B±W
B±W
W± B
B±W
W± B
B±W
W± B
B±W
W± B
B±W (
*1) R±B
G
R
(
*1)
W R±LB G±R
G±RR±WB±W
B±WB
B±W B±W B±W B±W B±WB
B±W
B B G±R G±R
BR BR
B
B
(
*1) B B
B B
B
BR BRB±R
B±R B±R B±RW±B W± B W±B W± B W± B
THW EVG VG THA EVP1 +B MREL FC BATT IGSW IGT1 IGF IGT2 IGT3 IGT4 # 10
1B 12
O 1
OIL PRESSURE SWY±B
MOPS E10 , D C , E 9 AE 8, E 7 B
ENGINE CONTROL MODULE
* 1 : SHIELDEDB

2001 PRIUS (EWD414U)
IO1 6
I 7C 20 B 18
I 7IK1 7IK16 IE1 1IE12 D 1D12
IK1 1IE1 22D 7 D 11
I 6
A DD 16
B EBEBE A 41 2
A 23 A24 C10 C18 C19 C28 C27
1
422
IE1 12 2
431
L P Y BRO Y±R
W± GLG
W± G B±W B±W
P±L
W
BRBR BR
B
BR
BR
Y
G± YBR(
*1)
BR BR
B
BB
B(
*1)
(
*1)
P±L
W P±L
W
(
*1)
(
*1)
(
*1)CAMS HAFT TIMING OIL
CONTROL VALVE C 2 VSV (
HC ADSORBER AND
CATALYST SYSTEM) V 3
HEATED OXYGEN SENSOR
(
BANK 1 SENSOR 1) H 3
HEATED OXYGEN SENSOR
(
BANK 1 SENSOR 2) H 9 BJUNCTION
CONNECTORB J22 A , J23
HT1B OX1 B E11 OX1A HT1A HCC E2SPHV
13HTE± HTE+ ETH+ ETH± OCV± OC V+ FAN
FROM FAN NO. 1 AND
FAN NO. 2 RE LAY
(
*1)
(
*1)(
*1)
(
*1) * 1 : SHIELDED
E10 , D C , E 9 AE 8, E 7 B
ENGINE CONTROL MODULE
I 6
(
*1)
BR D 5
V±W
SPD
TO COMBI NATION
METER
SPDO HTE± HTE+ ETH+ ETH1
D 6D29 D19 D28 D27
C 21
G
GO GO
B 10
C 16
R±Y
ESTP ESTP
D 8D 1 HYBRID VEHICLE CONTROL ECUD H12 , H14
B15A
STOP FROM POWER SOURCE SYSTEM (
SEE PAGE 50)
2K 9
1 2 DBEA
STOP LIGHT SW S 3JUNCTION
CONNECTORB J14 A , J15 G± W
G± W R± B
STPG±W
IA2 9
G

2001 PRIUS (EWD414U)
ENGINE CONTROL
This system utilizes an engine control module and maintains overall control of the engine, transmission and so on. An outline
of the engine control is explained here.
1. INPUT SIGNALS
(1) Engine coolant temp. signal circuit
The engine coolant temp. sensor detects the engine coolant temp. and has a built±in thermistor with a resistance which
varies according to the engine coolant temp. thus the engine coolant temp. is input in the form of a control signal into
TERMINAL THW of the engine control module.
(2) Intake air temp. signal circuit
The intake air temp. sensor is installed in the mass air flow meter and detects the intake air temp., which is input as a
control signal into TERMINAL THA of the engine control module.
(3) Oxygen sensor signal circuit
The oxygen density in the exhaust gases is detected and input as a control signal into TERMINALS OX1A and OX1B of
the engine control module.
(4) RPM signal circuit
Camshaft position and crankshaft position are detected by the camshaft position sensor and crankshaft position sensor.
Camshaft position is input as a control signal to TERMINAL G2 of the engine control module, and engine RPM is input
into TERMINAL NE+.
(5) Throttle signal circuit
The throttle position sensor detects the throttle valve opening angle, which is input as a control signal into TERMINALS
VTA and VTA2 of the engine control module.
(6) Vehicle speed signal circuit
The vehicle speed signal from brake ECU, detects the vehicle speed and inputs a control signal into TERMINAL SPD of
the engine control module via the combination meter.
(7) Battery signal circuit
Voltage is constantly applied to TERMINAL BATT of the engine control module. When the ignition SW is turned on, the
voltage for engine control module start±up power supply is applied to TERMINAL +B of the engine control module via
EFI relay.
(8) Engine knock signal circuit
Engine knocking is detected by knock sensor and the signal is input into TERMINAL KNK1 of the engine control module
as a control signal.
2. CONTROL SYSTEM
*SFI system
The SFI system monitors the engine condition through the signals, which are input from each sensor to the engine
control module. The best fuel injection volume is decided based on this data and the program memorized by the engine
control module, and the control signal is output to TERMINALS #10, #20, #30 and #40 of the engine control module to
operate the injector. (Inject the fuel). The SFI system produces control of fuel injection operation by the engine control
module in response to the driving conditions.
*ESA system
The ESA system monitors the engine condition through the signals, which are input to the engine control module from
each sensor. The best ignition timing is detected according to this data and the memorized data in the engine control
module, and the control signal is output to TERMINALS IGT1, IGT2, IGT3 and IGT4. This signal controls the ignition coil
and igniter to provide the best ignition timing for the driving conditions.
*Fuel pump control system
The engine control module operation outputs to TERMINAL FC and controls the CIR OPN relay. Thus controls the fuel
pump drive speed in response to conditions.
3. DIAGNOSIS SYSTEM
With the diagnosis system, when there is a malfunctioning in the engine control module signal system, the malfunction
system is recorded in the memory. The malfunctioning system can then be found by reading the display (Code) of the
malfunction indicator lamp.
4. FAIL±SAFE SYSTEM
When a malfunction occurs in any system, if there is a possibility of engine trouble being caused by continued control based
on the signals from that system, the fail±safe system either controls the system by using data (Standard values) recorded in
the engine control module memory or else stops the engine.
SYSTEM OUTLINE

2001 PRIUS (EWD414U)
With the ignition SW turned on, the current flows to TERMINAL 15 of the body ECU through GAUGE fuse.
Voltage is applied at all times to TERMINAL (A) 11 of the body ECU through the TAIL relay. Coil side, and to TERMINAL (A)
2 through the HEAD relay coil side (w/o daytime running light) or through the daytime running light relay (w/ daytime running
light).
1. NORMAL LIGHTING OPERATION

With the light control SW turned to TAIL position, a signal is input into TERMINAL (A) 18 of the body ECU. Due to this signal,
the current flowing to TERMINAL (A) 11 of the body ECU flows to TERMINAL (A) 18 to TERMINAL 14 of the light control SW
to TERMINAL 16 to GROUND, and taillight relay causes taillights to turn on.

With the light control SW turned to HEAD position, a signal is input into TERMINALS (A) 17 and (A) 18 of the body ECU. Due
to this signal, the current flowing to TERMINAL (A) 2 of the body ECU flows to TERMINAL (A) 17 to TERMINAL 13 of the
light control SW to TERMINAL 16 to GROUND in the headlight circuit, and causes taillight and HEAD relay to turn the lights
on. The taillight circuit is same as above.
2. LIGHT AUTO TURN OFF OPERATION
With light on and ignition SW turned off (Input signal goes to TERMINAL 15 of the body ECU), when the driver's door is
opened (Input signal goes to TERMINAL 3 of the body ECU), the ECU operates and the current is cut off which flows from
TERMINAL (A) 11 of the body ECU to TERMINAL (A) 18 in taillight circuit and from TERMINAL (A) 2 to TERMINAL (A) 17 in
headlight circuit.
As a result, all lights are turned off automatically.
HEAD RELAY
2±1 : Closed with the light control SW at HEAD position or the dimmer SW at FLASH position
Closed with the engine running and the parking brake lever released (Parking brake SW off) [w/ daytime running light]
TAIL RELAY
3±5 : Closed with the light control SW at TAIL or HEAD position
D6 DOOR COURTESY SW LH
1±GROUND : Continuity with the front LH door open
B8 (A), B9 (B) BODY ECU
15±GROUND : Approx. 12 volts with the ignition SW at ON position
3±GROUND : Continuity with the front LH door open
(B) 9±GROUND : Always approx. 12 volts
(A) 1±GROUND : Always continuity
(A) 2±GROUND : Continuity with the light control SW at HEAD position
(A)11±GROUND : Continuity with the light control SW at TAIL or HEAD position
: PARTS LOCATION
CodeSee PageCodeSee PageCodeSee Page
B9B36F13D34J2037
C1336F1838J24A37
D336J1137J25B37
D638J12A37J2737
F11B34J13B37U137
F12C34J1737
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
CodeSee PageJunction Block and Wire Harness (Connector Location)
1B27Engine Room Main Wire and Engine Room J/B (Engine Compartment Left)1F27Engine Room Main Wire and Engine Room J/B (Engine Compartment Left)
2C30Instrument Panel Wire and Instrument Panel J/B (Cowl Side Panel LH)2D30Instrument Panel Wire and Instrument Panel J/B (Cowl Side Panel LH)
2H31Engine Room Main Wire and Instrument Panel J/B (Cowl Side Panel LH)
2K31Cowl Wire and Instrument Panel J/B (Cowl Side Panel LH)
SYSTEM OUTLINE
SERVICE HINTS

2001 PRIUS (EWD414U)
BUZZERB 3A132B 7
2A 6A GAG B GBG
114
4 11
GR± LV±W V±W V±W
GR±L GR ±B GR
LV±W
MPX+ MPD1 MPD2
MP2+
C11 , A C10 B
COMBINATION METERA/C AMPLIFIER A 7
GATEWAY ECU G 1
JUNCTION
CONNECTORB J27 , J28AFROM HYBRID VEHICLE
CONTROL ECU
FROM ENGINE CONTROL MODULE
FROM NAVIGATION ECU
CHARGEOIL SEAT BELT
(
FRONT
PASSENGER' S SEAT) SEAT BELT
(
DRIVER' S SEAT) BRAKEHEAD DOOR
GA
FROM MULTI DISPLAY
V±W

2001 PRIUS (EWD414U)
I GROUND POINT
IGCT RELAY
A/C TRIPLE
PRESSURE SW
HYDRAULIC BOOSTER
WATER PUMP MOTOR
(
A/C)
FRONT PARKING
LIGHT LH
FRONT PARKING
LIGHT RHIG2 RELAY
ENGINE HOOD
COURTESY SW
FRONT WI PER MOTOR
FRONT TURN
SIGNAL LIGHT LH
RADIATOR FAN MOTOR
ABS SOL
RELAY
INVERTER
(
GND1)
(
GND2)
PTC HEATER
BLOWER MOTOR
LINEAR CONTROLLER
(
E1)
(
SG)
(
E01)
(
E02) FRONT SIDE MARKER
LIGHT LH
FRONT SIDE MARKER
LIGHT RH
FRONT TURN
SIGNAL LIGHT RH
BRAKE FLUID LEVEL
WARNING SW
WATER TEMP. SW
DRL RELAY
IGNITION COIL AND
IGNITER NO. 1
IGNITION COIL AND
IGNITER NO. 2
IGNITION COIL AND
IGNITER NO. 3
IGNITION COIL AND
IGNITER NO. 4
ENGINE CONTROL
MODULE1K3
E 5
E 5
E 5
E 5 E 5
E 5
E 5
E 5 (
±S)
E 5
E 5
3HYDRAULIC BOOSTER E 5 E 5 (
CUT±)
E 1
E 1
E 1
E 1
E 1
E 1
3W±B
W±B
W±B
W±B
W±B
W±B
W±B
W±B
W±B
W±B
W±B
W±B
W±B
W±B
W± BW±B
W±B W±B W±B
W±B
W±B
W±B
W±B
W±B
W±B W±B W±B W± B W±B W± B W±B W±B W±B W±B
W±B W±B W±B W±B W±B
A
AA
(
*1)IE ECW± B
W± B
W± B
W± B
W± B
W± B W±BA
AA
A
AJUNCTION
CONNECTOR J 7
J 1
JUNCTION
CONNECTOR
W±B
A
BRAKE ECU
EAE 3 E 3 E 3
EBID214
IO114 A A
B A JUNCTION
CONNECTORB J 8 , J 9A W±B
W±B
W±B
W±B
W±B
W±BBR
BR
W±B
W±BBR BR
W±B W±B W±B
BR
ENGINE CONTROL
MODULE
ENGINE CONTROL
MODULE
(
ME01)
(
E03)DATA LINK
CONNECTOR 3 HTR RELAY
NAVIGATION ECU
RADIO AND PLAYER
IFIJ121
BR
BR
BR BR
MULTI DISPLAY (
*2)(
*2)
AIRBAG SENSOR
ASSEMBLY
COMBINATION
METER(
E1)
(
ES)
IH W±B
2B6 7
LBR
2A WATER PUMP
MOTOR (
INVERTER)
2W±B
FAN NO. 2
RELAY
AEFI RELAY

L PART NUMBER OF CONNECTORS
Code Part Name Part NumberCodePart Name Part Number
Note : Not all of the above part numbers of the connector are established for the supply.
2001 PRIUS (EWD414U) A 1
A/C Condenser Fan Motor90980±11237
A 2A/C Magnetic Clutch and Lock Sensor90980±10942
A 3A/C Triple Pressure SW (A/C Dual and
Single Pressure SW)90980±10943
A 4ABS Speed Sensor Front LH90980±11003A 5ABS Speed Sensor Front RH90980±11003
A 6Ambient Temp. Sensor90980±11070
A 7A/C Amplifier90980±11911
A 8A/C Amplifier90980±11913
A 9A/C Amplifier90980±11927
A10A/C Room Temp. Sensor
A11A/C Solar Sensor90980±11919
A12A/C Thermistor
A13Accel Position Sensor90980±11144
A14Air Inlet Control Servo Motor90980±11921
A15Air Mix Control Servo Motor90980±11909A16Air Vent Mode Control Servo Motor90980±11909
A17Airbag Sensor Assembly90980±11869
A18Airbag Sensor Assembly90980±11872
A19Airbag Sensor Assembly90980±11867
A20Airbag Squib (Front Passenger Airbag
Assembly)90980±11884
A21Airbag Squib (Steering Wheel Pad)90980±10850
A22Ashtray Illumination90980±12111
A23ABS Speed Sensor Rear LH90980±11060A24ABS Speed Sensor Rear RH90980±11060
B 1Brake Actuator90980±11087
B 2Brake Actuator90980±11161
B 3Brake Actuator90980±11698
B 4Brake Fluid Level Warning SW90980±11207
B 5Back±Up Light Relay82660±20340
B 6Blower Motor90980±10214
B 7Blower Motor Linear Controller90980±11676
B 8Body ECU90980±11971
B 9Body ECU90980±11973
B10Brake ECU90980±11935
B11Brake ECU90980±11476
B12Brake ECU90980±11637
B13Brake ECU90980±11638
B14Brake Warning Buzzer90980±10906
B15Battery Blower Motor82824±47130
B16Battery Blower Motor Controller90980±11676
B17Battery ECU90980±11392
B18Battery ECU90980±11424
B19Battery Fan Relay82660±20340
B20Buckle SW and Tension Reducer LH
B21Buckle SW RH and Seat Belt Warning
Occupant Detection Sensor90980±11471
C 1Camshaft Position Sensor90980±10947
C 2Camshaft Timing Oil Control Valve90980±11162
C 3Circuit Breaker Sensor90980±11898
C 4Converter90980±10942
C 5Converter90980±11963
C 6Crankshaft Position Sensor90980±12028
C 7Center Cluster SW90980±10801
C 8Cigarette Lighter90980±10760
C 9Cigarette Lighter Illumination90980±11148
C10Combination Meter90980±11927
C11Combination Meter90980±11923
C12Combination SW90980±11594
C13Combination SW90980±11672
C14Combination SW90980±11616
D 1DC Motor90980±10838
D 2Data Link Connector 390980±11665
D 3Daytime Running Light Relay90980±12034
D 4Diode (Door Courtesy)90980±11251
D 5Diode (Daytime Running Light)90980±10962
D 6Door Courtesy SW Front LH
D 7Door Courtesy SW Front RH90980±10871D 8Door Courtesy SW Rear LH90980±10871
D 9Door Courtesy SW Rear RH
D10Door Lock Control SW Front RH90980±10797
D11Door Lock Motor and Door Unlock
Detection SW Rear LH
90980±11150
D12Door Lock Motor and Door Unlock
Detection SW Rear RH90980±11 150
D13Door Lock Motor, Door Key Lock and
Unlock SW and Door Unlock Detection SW
Front LH
90980±11858
D14Door Lock Motor, Door Key Lock and
Unlock SW and Door Unlock Detection SW
Front RH90980±11 858
E 1Engine Coolant Temp. Sensor90980±10737
E 2Engine Hood Courtesy SW90980±11189
E 3EMPS ECU90980±12012
E 4EMPS ECU90980±11579
E 5EMPS ECU90980±12120
E 6EMPS ECU90980±11923
E 7Engine Control Module90980±11421
E 8Engine Control Module90980±11476
E 9Engine Control Module90980±11637