wiring diagram TOYOTA PRIUS 2001 Service Repair Manual

NOTICE
When handling supplemental restraint system components (removal,
installation or inspection, etc.), always follow the direction given in the repair
manuals listed above to prevent accidents and supplemental restraint
system malfunction.
CAUTION
When repairing the hybrid vehicle (HV), always follow the direction given in
the repair manual listed above to prevent electrical shock, leakage or
explosion.
2001 PRIUS (EWD414U)
FOREWORD
This wiring diagram manual has been prepared to provide
information on the electrical system of the 2001 PRIUS.
Applicable models: NHW11 Series
For service specifications and repair procedures of the above
models other than those listed in this manual, refer to the
following manuals;
Manual Name
Pub. No.

2001 PRIUS Repair Manual
Volume 1
Volume 2

2001 PRUIS New Car Features
RM778U1
RM778U2
NCF182U
All information in this manual is based on the latest product
information at the time of publication. However, specifications
and procedures are subject to change without notice.

2001 PRIUS (EWD414U)
A INTRODUCTION
This manual consists of the following 13 sections:
No.
SectionDescription
A
INDEXIndex of the contents of this manual.
A
INTRODUCTIONBrief explanation of each section.
BHOW TO USE THIS
MANUALInstructions on how to use this manual.
CTROUBLE±
SHOOTINGDescribes the basic inspection procedures for electrical circuits.
DABBREVIATIONSDefines the abbreviations used in this manual.
E
GLOSSARY OF
TERMS AND
SYMBOLS
Defines the symbols and functions of major parts.
FRELAY LOCATIONSShows position of the Electronic Control Unit, Relays, Relay Block, etc.
This section is closely related to the system circuit.
GELECTRICAL
WIRING ROUTINGDescribes position of Parts Connectors, Splice points, Ground points, etc.
This section is closely related to the system circuit.
INDEXIndex of the system circuits.
H
SYSTEM CIRCUITS
Electrical circuits of each system are shown from the power supply through ground
points. Wiring connections and their positions are shown and classified by code
according to the connection method. (Refer to the section, ºHow to use this manualº).
The ºSystem Outlineº and ºService Hintsº useful for troubleshooting are also contained
in this section.
IGROUND POINTShows ground positions of all parts described in this manual.
JPOWER SOURCE
(Current Flow Chart)Describes power distribution from the power supply to various electrical loads.
KCONNECTOR LISTDescribes the form of the connectors for the parts appeared in this book.
This section is closely related to the system circuit.
LPART NUMBER OF
CONNECTORSIndicates the part number of the connectors used in this manual.
M
OVERALL
ELECTRICAL
WIRING DIAGRAM
Provides circuit diagrams showing the circuit connections.

2001 PRIUS (EWD414U)
HOW TO USE THIS MANUAL B
This manual provides information on the electrical circuits installed on vehicles by
dividing them into a circuit for each system.
The actual wiring of each system circuit is shown from the point where the power
source is received from the battery as far as each ground point. (All circuit
diagrams are shown with the switches in the OFF position.)
When troubleshooting any problem, first understand the operation of the circuit
where the problem was detected (see System Circuit section), the power source
supplying power to that circuit (see Power Source section), and the ground points
(see Ground Point section). See the System Outline to understand the circuit
operation.
When the circuit operation is understood, begin troubleshooting of the problem
circuit to isolate the cause. Use Relay Location and Electrical Wiring Routing
sections to find each part, junction block and wiring harness connectors, wiring
harness and wiring harness connectors, splice points, and ground points of each
system circuit. Internal wiring for each junction block is also provided for better
understanding of connection within a junction block.
Wiring related to each system is indicated in each system circuit by arrows
(from__, to__). When overall connections are required, see the Overall Electrical
Wiring Diagram at the end of this manual.

2001 PRIUS (EWD414U)
E
RELAY
Basically, an electrically operated
switch which may be normally
closed (1) or open (2).
Current flow through a small coil
creates a magnetic field which either
opens or closes an attached switch.
1. NORMALLY
CLOSED
2. NORMALLY
OPEN
SWITCH, MANUAL
Opens and closes
iitth b
SPEAKER
An electromechanical device which
creates sound waves from current
flow.
RELAY, DOUBLE THROW
A relay which passes current
through one set of contacts or the
other.
circuits, thereby
stopping (1) or
allowing (2) current
flow.1. NORMALLY
OPEN
2. NORMALLY
CLOSED
RESISTOR
An electrical component with a fixed
resistance, placed in a circuit to
reduce voltage to a specific value.SWITCH, DOUBLE THROW
A switch which continuously passes
current through one set of contacts
or the other.
RESISTOR, TAPPED
A resistor which supplies two or
more different non adjustable
resistance values.SWITCH, IGNITION
A key operated switch with several
positions which allows various
circuits, particularly the primary
ignition circuit, to become
operational.
RESISTOR, VARIABLE or RHEOSTAT
A controllable resistor with a variable
rate of resistance.
Also called a potentiometer or
rheostat.
SENSOR (Thermistor)
A resistor which varies its resistance
with temperature.SWITCH, WIPER PARK
Automatically returns wipers to the
stop position when the wiper switch
is turned off.
(Reed Switch Type)
SENSOR, SPEED
Uses magnetic impulses to open
and close a switch to create a signal
for activation of other components.TRANSISTOR
A solidstate device typically used as
an electronic relay; stops or passes
current depending on the voltage
applied at ºbaseº.
SHORT PIN
Used to provide an unbroken
connection within a junction block.WIRES
Wires are always drawn as
straight lines on wiring
diagrams.
Crossed wires (1) without a
black dot at the junction are
tj i d
(1) NOT
CONNECTED
SOLENOID
An electromagnetic coil which forms
a magnetic field when current flows,
to move a plunger, etc.
j
not joined;
crossed wires (2) with a
black dot or octagonal ( )
mark at the junction are
spliced (joined)
connections.
(2) SPLICED

M OVERALL ELECTRICAL WIRING DIAGRAM
2001 PRIUS (EWD414U)

M
2001 PRIUS (EWD414U)
[A]: System Title
[B]: Indicates the wiring color.
Wire colors are indicated by an alphabetical code.
B = Black W = White BR = Brown
L = Blue V = Violet SB = Sky Blue
R = Red O = Orange LG = Light Green
P = Pink Y = Yellow GR = Gray
G = Green
The first letter indicates the basic wire color and the
second letter indicates the color of the stripe.
Example: L ± Y
L
(Blue)Y
(Yellow)
[C]: The position of the parts is the same as shown in
the wiring diagram and wire routing.
[D]: Indicates the pin number of the connector.
The numbering system is different for female
and male connectors.
Example :
Numbered in order
from upper left to
lower rightNumbered in order
from upper right to
lower left
Female Male
The numbering system for the overall wiring
diagram is the same as above
[E]: Indicates a Relay Block. No shading is used and
only the Relay Block No. is shown to distinguish
it from the J/B.
Example : Indicates Relay Block No.1
[F]: Junction Block (The number in the circle is the
J/B No. and the connector code is shown beside
it). Junction Blocks are shaded to clearly
separate them from other parts.
3C indicates
that it is inside
Junction Block
No.3 Example:

[G]: Indicates related system.
[H]: Indicates the wiring harness and wiring harness
connector. The wiring harness with male
terminal is shown with arrows (
).
Outside numerals are pin numbers.
Female Male ( )
[I]: ( ) is used to indicate different wiring and
connector, etc. when the vehicle model, engine
type, or specification is different.
[J]: Indicates a shielded cable.
[K]: Indicates and located on ground point.
[L]: The same code occuring on the next page
indicates that the wire harness is continuous.

SYSTEM INDEX
M OVERALL ELECTRICAL WIRING DIAGRAM
2001 PRIUS (EWD414U)
SYSTEMS LOCATION SYSTEMS LOCATION
ABS 19±3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Air Conditioning 24±2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Back±Up Light 6±2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cigarette Lighter 11±4. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Combination Meter 23±2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Door Lock Control 15±2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Electric Tension Reducer 13±4. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
EMPS 20±3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine Control 2±3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Gateway System 14±8. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Headlight (w/ Daytime Running Light) 4±2. . . . . . . . . . . . . . . . . . . . . . . . . .
Headlight (w/o Daytime Running Light) 3±2. . . . . . . . . . . . . . . . . . . . . . . . .
Horn 12±2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hybrid Vehicle Immobiliser System 2±16. . . . . . . . . . . . . . . . . . . . . . . . . . .
Illumination 8±2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Interior Light 10±3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Key Reminder and Light Reminder Buzzer 9±2. . . . . . . . . . . . . . . . . . . . . .
Light Auto Turn Off 9±3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Navigation System 14±5. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power Source 1~24±1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power Window 18±2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Radiator Fan and Condenser Fan 22±3. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Radio and Player 14±2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear Window Defogger 22±2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Remote Control Mirror 11±2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Seat Belt Warning 9±4. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Shift Lock 13±3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SRS 21±2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Stop Light 3±4. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Taillight 7±2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Theft Deterrent 17±2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
TOYOTA Hybrid System 1±2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
* Charging
* Cruise Control
* Regenerative Brake
Turn Signal and Hazard Warning Light 5±2. . . . . . . . . . . . . . . . . . . . . . . . . .
Wiper and Washer 12±3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wireless Door Lock Control 16±2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

2001 PRIUS (EWD414U)
M
1
234
1 PRIUS ELECTRICAL WIRING DIAGRAM(
Cont. next page)
1C1B 2 1J 82C 2
2G 1W± R
B±GW± R
BATTERY 120A
MAI N 5A
DC/ DC±S1B 2A1F 11
1B 11J 9
F1 7 F18,
FUSI BL E LI NK
BLOCK NO. 2AB15 A AM2
10A BATT FAN
20A HV
C B
A
B
BB± R
G±Y
L±R
Power SourceTOYOTA Hybrid System
L±R
G± Y
B±R
2
7ACC
IG1
ST1
IG2
ST2 AM1 4
6
8 AM2
71J15A DOME
2A 5 2B 3
2 1
3 5 2D 6
5A AM1 10A GAUGE
2K 82D8
IDCowl side
panel LH
CHARGE OUT PUT CONTROLCRUI SE
IHRight kick panel 2B 62A 7 22 A 21 A
14 A 3 B2BF
G
I 114 14
A13
11
4 B± W
R± WB±Y W± G
LGR± BR± WB± W
W± B GR L±R G±YB± R
GR
LBR GR±B GR± L GR
GR± B
W± B
W± B
B±Y W± G
W±G
I15
IGNITION SW
L±Y
2G 2
2A 4L
L±Y
F10 F1 2,
FUSIBLE LINK BLOCK NO. 1ACF13, D
J11
JUNCTI ON
CONNECTORMPX + MPD1MPX ±
MPX ± MPX +
MPX 2
MPD2
MP2 +E10
ENGINE
CONTROL
MODULE
G 1
GATEWAY
ECU
A 7
A/C
AMPLIFIER C10 C1 1,
COMBINATION METERAB 100A
DC/DCIG1
RE LAYB 8
BODY ECU
16 15
1
D2 1
3 51A 2
1A 11K3
1BD W
1A2H 1 14 IK1
1J 3
2G 112B 5
W± B
H E W± B
1 2 B± W B± W
W
W
W±B
W±B B±W B±W W± B
W 3
WATER PUMP MOTOR
(
Inverter)
B± W W±BWW
B± W
F11 , B IG2 RELAY

2001 PRIUS (EWD414U)
M OVERALL ELECTRICAL WIRING DIAGRAM
5
678
1 PRIUS (
Cont' d)(
Cont. next page)
6E 7E 2D
CA CA
BB
6ID1B A
16 D
AB AB
AA AAAB 31 D 24 D
IGCowl si de
panel RH1D 13D 14D 12D 23D 15D 22D 15E 13E 23E 22E 14E 12E 11E 21E
AB
AA AA5EG±Y
L±R
G
TOYOTA Hybrid System
B± WB±Y L W± B
W± B G± WY GL B WR
W± BW± B
W±B
B± WW±B W±B W±B
W± B L±R L±WL±B LG±RR± BWB R (
*1)
* 1 : Shielded
4
5
653421 25674 983E
A4E
A ST 2 I GSW ST1 ± CCS GND1 GND2 STP VCP1 VPA1 EP1 VCP2 VPA2 EP2 P N D B R VSFT SFT GSFT EOMH10 H11,
HYBRI D VE HI CLE CONTROL E CUCA
J18 J19,
J UNCTI ON
CONNECTORABJ24 J25,
J UNCTI ON
CONNECTORAB
(
*1)
J24 J25,
JUNCTI ON
CONNECTORABJUNCTI ON
CONNECTORB A J22 J23,
From Stop
Light SW
< 3±4>J21
JUNCTI ON
CONNE CTOR
J17
JUNCTION
CONNECTORA13
ACCEL POSI TI ON SENSORP 1
PARK / NEUTRAL
POSITION SW
C1 4
CRUI SE CONTROL SW
[COMB. SW]
H12 , B E, H13 D, H14
3
S 3
STOP L I GH T S WW±B W±B W± B W± B
W± B
W± B
A
B
C
HF
G
W±B R± W B±WL±R G± Y
B±R
R±W
B± W
B± W
CCS
CRUI SE
RES/ ACC
SET/ COAST
CANCEL
W±B
IW
D
W±B
E
D W
F W± B ECCVCP1 VPA1 EP1 VCP2 VPA2 EP2
E W± BC B± RDB
EA EA
1
W±B
W±B

2001 PRIUS (EWD414U)
M OVERALL ELECTRICAL WIRING DIAGRAM
15 16
14 13
(
Cont. next page)
1 PRIUS (
Cont' d)
A
BG± Y
L±R
21 A 13 A
7C 4DA 11
5D D3 6A A4
1D D2 5A A26
6D C1 16 A A7
3C C4 17 A A20
5C C2 25 A A19
1B B3 8A
4B 18 A
2B 28 A
4A 12 A
5A 23 A
3A 3A
2A 2A
1A 1A
6A 27 A
8C 14 A
7B 15 A
8B 24 AA
B G±Y
L±R
6B4E
10 IF1
4IH1
6C 1E 1FD
E
TOYOTA Hybrid System
GYL G (
*1)
R WB B WGR
Y B WGR YL G WR
B B GB OO V±RV±R
W±B
O(
*2)
O(
*2) 1
2
(
*1)(
*1)(
*1)
I17
INTERLOCK SW H1 0 H11, CAB E, H13 , H12 D, H14
HYB RI D VE HI CL E CONTROL E CU
I 9 I10,
I NVERTERDC MSI V MS DN MI T MWU MU U MVU MI VG MI VA MI VB MI WB V B MI WA GI VA GI VB GI WB GI WA GS DN GI T GWU GVU GUU GI VG MFI V GS I V GFI V I LK
I11 , A* 2 : High Voltage(
273. 6V)
I12 , B
HW1B
W
I13 , E I14, F* 1 : Shielded
C
D
E
F(
*1) (
*1) (
*1) (
*1)
W±B
IB±R
GD 5 D 4
IA1 13 IA1 12+B 1 +B 2
W± G W± G
W± G W± G
W±G
1A 5B4A 4B
IH11
2IH13A 2A
14 IE1 W±G W±G
YB±RY
L±O L±OW±G W± G
C
F W± G
W±R W± G
W±G
NODD
To A/C Amplifier
< 24±6> C 4 C 5,
CONV ERTE RABI GCT M± SI NV M±SD OWN M±I N VT M± WU M± UU M±VU M±GI NV M± I VA M± I VB M±I WB V B M±I WA G±I V A G±I VB G±I WB G±I WA G± SDOWN G± I NV T G±WU G± VU G±U U G±GI NV M±FI N V G±SI N V G± FI NV CVRSW CBI CEI
GND NODD IGCT
IDH AMD S