radiator TOYOTA PRIUS 2009 2.G Owners Manual

273
3-4. Using the hands-free
system (for cellular phone)
3
Interior features
PRIUS_U_(OM47614U)
FCC WARNING:
Changes or modifications not expressly approved by the party responsible
for compliance could void the user’s authority to operate the equipment.
CAUTION:
Radio Frequency Radiation Exposure
This equipment complies with FCC radiation exposure limits set forth, for
uncontrolled equipment and meets the FCC radio frequency (RF) Exposure
Guidelines in Supplement C to OET65. This equipment has very low levels
of RF energy that it deemed to comply without maximum permissive expo-
sure evaluation (MPE). But it is desirable that it should be installed and oper-
ated with at least 7.9 in (20 cm) and more between the radiator and person’s
body (excluding extremities: hands, wrists, feet and legs).
Co-location:
This transmitter must not be co-located or operated in conjunction with any
other antenna or transmitter.
CAUTION
■Caution while driving
Do not use a cellular phone or connect the Bluetooth
® phone.
NOTICE
■When leaving the vehicle
Do not leave your mobile phone in the vehicle. The inside of the vehicle may
become hot, causing damage to the phone.

349
4-2. Maintenance
4
Maintenance and care
PRIUS_U_(OM47614U)
General maintenance
Engine compartment
Luggage compartment
ItemsCheck points
Brake fluid • At the correct level? ( P. 369)
Engine/inverter coolant • At the correct level? (P. 367)
Engine oil • At the correct level? (P. 361)
Exhaust system • No fumes or strange sounds?
Radiator/condenser/hoses • Not blocked with foreign matter?
(P. 369)
Washer fluid • At the correct level? (P. 374)
ItemsCheck points
12 volt battery • Maintenance-free (P. 371)
Listed below are the general maintenance items that should be per-
formed at the intervals specified in the “Scheduled Maintenance
Guide” or “Owner’s Manual Supp lement”. It is recommended that
any problem you notice should be brought to the attention of your
Toyota dealer or qualified service shop for advice.

354 4-3. Do-it-yourself maintenance
PRIUS_U_(OM47614U)
ItemsParts and tools
Engine oil level (P. 361)
• “Toyota Genuine Motor Oil” or
equivalent
• Rag or paper towel, funnel (used only for adding engine oil)
Fuses (P. 394)• Fuse with same amperage rating
as original
Radiator and condenser (P. 369)
Tire inflation pressure ( P. 384)• Tire pressure gauge
• Compressed air source
Washer fluid (P. 374)
• Water washer fluid containing anti-
freeze (for winter use)
• Funnel

355
4-3. Do-it-yourself maintenance
4
Maintenance and care
PRIUS_U_(OM47614U)
CAUTION
The engine compartment contains many mechanisms and fluids that may
move suddenly, become hot, or become electrically energized. To avoid death
or serious injury observe the following precautions.
■
When working on the engine compartment:
● Keep hands, clothing, and tools away from the moving fan and engine
drive belt.
● Be careful not to touch the engine, inverter, radiator, exhaust manifold, etc.
right after driving as they may be hot. Oil and other fluids may also be hot.
● Do not leave anything that may burn easily, such as paper or rags, in the
engine compartment.
● Do not smoke, cause sparks or expose an open flame to fuel or the 12 volt
battery. Fuel and 12 volt battery fumes are flammable.
● Be extremely cautious when working on the 12 volt battery. It contains poi-
sonous and corrosive sulfuric acid.
● Never touch, disassemble, remove or replace the high voltage parts,
cables and their connectors. It can cause severe burns or electric shock
that may result in death or serious injury.
● When the hybrid system is operating with the “READY” light on, the engine
may suddenly start in some cases. When you inspect the engine compart-
ment, be sure to turn off the hybrid system.
■ When working near the electric cooling fan or radiator grille
Be sure the “POWER” switch is OFF.
With the “POWER” switch in ON mode, the electric cooling fan may automat-
ically start to run if the air conditioning is on and/or the coolant temperature
is high. ( P. 369)
■ Safety glasses
Wear safety glasses to prevent flying or falling material, fluid spray, etc. from
getting in the eyes.

360
4-3. Do-it-yourself maintenance
PRIUS_U_(OM47614U)
Engine compar tment
■12 volt battery
 P. 371
Washer fluid tank
( P. 374)
Brake fluid reservoir ( P. 369)
Engine oil filler cap ( P. 363)
Engine coolant reservoir ( P. 367)Inverter coolant reservoir
( P. 367)
Fuse box ( P. 394)
Radiator ( P. 369)
Condenser ( P. 369)
Electric cooling fans
Engine oil level dipstick ( P. 361)

368 4-3. Do-it-yourself maintenance
PRIUS_U_(OM47614U)
■If the coolant level drops within a short time after replenishing
Visually check the radiator, hoses, engine coolant filler cap, radiator cap,
drain cock and water pump.
If you cannot find a leak, have your Toyota dealer pressure test the cap and
check for leaks in the cooling system.
■ Coolant selection
Only use “Toyota Super Long Life Coolant” or similar high quality ethylene
glycol based non-silicate, non-amine, non-nitrite, and non-borate coolant
with long-life hybrid organic acid technology.
U.S.A.: “Toyota Super Long Life Coolant” is a mixture of 50% coolant and 50% deionized water. (Enabled: -31 F [-35 C])
Canada: “Toyota Super Long Life Coolant” is a mixture of 55% coolant and 45% deionized water. (Enabled: -44 F [-42C])
For more details about engine coolant, contact your Toyota dealer.
CAUTION
■ When the coolant is hot
Do not remove the coolant reservoir cap.
The cooling system may be under pressure and may spray hot coolant if the
cap is removed, causing burns or other injuries.
NOTICE
■When adding the coolant
Coolant is neither plain water not straight antifreeze. The correct mixture of
water and anti freeze must be used to provide proper lubrication, corrosion
protection and cooling. Be sure to read the antifreeze or coolant label.
■ If you spill coolant
Be sure to wash it off with water to prevent it damage to parts or paint.

369
4-3. Do-it-yourself maintenance
4
Maintenance and care
PRIUS_U_(OM47614U)
Radiator and condenser
Check the radiator and condenser and clear any foreign objects.
If either of the above parts are extremely dirty or you are not sure of
their condition, have your vehicl e checked by your Toyota dealer.
Brake fluid
■ Checking fluid level
The brake fluid level should be
between the “MAX” and “MIN”
lines on the tank.
Make sure to check the fluid type and prepare the necessary items.
■ Adding fluid
CAUTION
■When the engine is hot
Do not touch the radiator or condenser, as they may be hot and you may be
burned.
Fluid typeFMVSS No.116 DOT 3 or SAE J1703 brake fluid
ItemsClean funnel

5
When trouble arises
455
5-2. Steps to take in an emergency
PRIUS_U_(OM47614U)
After the hybrid system has
cooled down sufficiently, check
the coolant level and inspect the
radiator core (radiator) for any
leaks.
Add coolant if required.
Water can be used in an emer-
gency measure if coolant is
unavailable. (
P. 465)
Have the vehicle checked at your nearest Toyota dealer as soon as
possible.
ITY52P018
STEP5
ITY52P019
STEP6
■Overheating
In the following situations, your vehicle may be overheating.
● High coolant temperature warning light is displayed on the touch screen.
● Steam is coming from under the hood.

456 5-2. Steps to take in an emergency
PRIUS_U_(OM47614U)
CAUTION
■To prevent an accident or injury when inspecting under the hood of
your vehicle
● If steam is seen coming from under the hood, do not open the hood until
the steam has subsided. The engine compartment may be very hot, caus-
ing serious injury such as burns.
● Keep hands and clothing away from the fan and engine drive belt while the
hybrid system is operating.
● Do not loosen the radiator cap while the hybrid system and radiator are
hot.
Serious injury, such as burns, may result from hot coolant and steam
released under pressure.
NOTICE
■When adding engine coolant
Wait until the hybrid system has cooled down before adding engine/inverter
coolant.
When adding coolant, do so slowly. Adding cool coolant to a hot hybrid sys-
tem too quickly can cause damage to the hybrid system.

501
Alphabetical index
PRIUS_U_(OM47614U)
Interior lights
Interior lights ......................... 317
Switch ................................... 317
Wattage ................................ 469
Jack Positioning a floor jack ......... 358
Vehicle-equipped jack .......... 436
Jack handle.............................. 436
Keys Electronic key ......................... 49
If you lose your keys............. 447
If your electronic key ............ 448
Key number plate ................... 35
Keyless entry .......................... 36
Keys ....................................... 34
“POWER” switch .................. 132
Mechanical key....................... 34
Wireless remote control key ... 49
Light bulbs Replacing ............................. 403
Wattage ................................ 469
Lights
Emergency flasher switch .... 412
Fog light switch..................... 155
Hazard light switch ............... 412
Headlights switch ................. 152
Interior lights list ................... 315
Replacing light bulbs ............ 403
Turn signal lever ................... 142
Vanity lights .......................... 327
Wattage ................................ 469
Load capacity .......................... 172
Maintenance Do-it-yourself maintenance ...................... 353
General maintenance ........... 349 Maintenance data..................460
Maintenance
requirements .......................347
Meter Instrument panel light control .................................146
Meters ...................................145
Mirrors Inside rear view mirror.............72
Side mirror heater .................213
Side mirrors .............................74
Vanity mirrors ........................327
MP3 disc ...................................250
Odometer ..................................145
Oil Engine oil ..............................361
Opener Fuel filler door .........................79
Hood......................................357
Back door ................................54
Outside rear view mirrors Adjusting and folding ...............74
Outside temperature
display ....................................185
Overheating, Hybrid system ....................................454
Parking brake ...........................143
Parking lights Replacing light bulbs .............403
Switch....................................152
Wattage .................................469
Personal lights .........................317
Power outlet .............................329
Power windows ..........................76
Radiator ....................................369
Radio .........................................221
RDS (Radio Data System) .......223
J
K
L
M
O
P
R