coolant TOYOTA PRIUS 2014 3.G User Guide

500 5-2. Steps to take in an emergency
PRIUS_OM_OM47857U_DVD_(U)
Stop the vehicle immediately.The following warning indicates the possibility of damage to the vehi-
cle that may lead to an accident. Immediately stop the vehicle in a
safe place and contact your Toyota dealer.
Warning lightWarning light/Details
Charging system warning light Indicates a malfunction in the vehicle’s charging system
High coolant temperature warning light Indicates that the coolant temperature is too high
Changes from a flashing to a solid light when the engine
coolant temperature increases.

556
5-2. Steps to take in an emergency
PRIUS_OM_OM47857U_DVD_(U)
If your vehicle overheats
Correction procedures■ If the high coolant temperatur e warning light comes on or
flashes
Stop the vehicle in a safe place and turn off the air condition-
ing system, and then stop the hybrid system.
If you see steam: Carefully lift the hood after the steam subsides.
If you do not see steam: Carefully lift the hood.
After the hybrid system has
cooled down sufficiently, inspect
the hoses and radiator core
(radiator) for any leaks.
Radiator
Cooling fans
If a large amount of coolant leaks,
immediately contact your Toyota
dealer.
The following may indicate that your vehicle is overheating.
●The high coolant temperature warning light ( P. 500) comes on
or flashes, or a loss of hybrid system power is experienced. (For
example, the vehicle s peed does not increase.)
● “HYBRID SYSTEM OVERHEAT” ( P. 520) is shown on the
multi-informat ion display.
● Steam comes out from under the hood.
STEP 1
STEP 2
STEP 3

5
When trouble arises
557
5-2. Steps to take in an emergency
PRIUS_OM_OM47857U_DVD_(U)
The coolant level is satisfactory if
it is between the “FULL” and
“LOW” lines on the reservoir.
Reservoir
“FULL”
“LOW”
Add coolant if necessary.
Water can be used in an emer-
gency if coolant is unavailable.
Start the hybrid system and turn the air conditioning system
on to check that the radiator cooling fans operate and to
check for coolant leaks from the radiator or hoses.
The fans operate when the air conditioning system is turned on
immediately after a cold start. Conf irm that the fans are operating by
checking the fan sound and air flow. If it is difficult to check these,
turn the air conditioning system on and off repeatedly.
(The fans may not operate in freezing temperatures.)
If the fans are not operating:
Stop the hybrid system im mediately and contact your
Toyota dealer.
If the fans are operating: Have the vehicle inspected at the nearest Toyota dealer.
ITO43P111
STEP 4
ITO52P130
STEP 5
STEP 6
STEP7

558 5-2. Steps to take in an emergency
PRIUS_OM_OM47857U_DVD_(U)
■If “HYBRID SYSTEM OVERHEAT” is shown on the multi-infor-
mation display
Stop the vehicle in a safe place.
Stop the hybrid system and carefully lift the hood.
After the hybrid system has
cooled down, inspect the hoses
and radiator core (radiator) for
any leaks.
Radiator
Cooling fans
If a large amount of coolant leaks,
immediately contact your Toyota
dealer.
The coolant level is satisfactory if
it is between the “F” and “L” lines
on the reservoir.Reservoir
“F”
“L”
STEP 1
STEP 2
STEP 3
STEP 4

5
When trouble arises
559
5-2. Steps to take in an emergency
PRIUS_OM_OM47857U_DVD_(U)
Add coolant if necessary.
Water can be used in an emer-
gency if coolant is unavailable.
Start the hybrid system and check for the multi-information
display.
If the message does not disappear:
Stop the hybrid system and c ontact your Toyota dealer.
If the message is not displayed: Have the vehicle inspected at the nearest Toyota dealer.
STEP 5
STEP 6

560 5-2. Steps to take in an emergency
PRIUS_OM_OM47857U_DVD_(U)
CAUTION
■To prevent an accident or injury when inspecting under the hood of
your vehicle
● If steam is seen coming from under the hood, do not open the hood until
the steam has subsided. The engine compartment may be very hot, caus-
ing serious injuries such as burns.
● After the hybrid system has been turned off, check that the indicator on the
“POWER” switch and the “READY” indicator are off.
When the hybrid system is operating, the gasoline engine may automati-
cally start, or the cooling fans may suddenly operate even if the gasoline
engine stops. Do not touch or approach rotating parts such as the fans,
which may lead to fingers or clothing (especially a tie, a scarf or a muffler)
getting caught, resulting in serious injury.
● Do not loosen the coolant reservoir cap while the hybrid system and radia-
tor are hot.
Serious injury, such as burns, may result from hot coolant and steam
released under pressure.
NOTICE
■When adding engine/power control unit coolant
Wait until the hybrid system has cooled down before adding engine/power
control unit coolant.
When adding coolant, do so slowly. Adding cool coolant to a hot hybrid sys-
tem too quickly can cause damage to the hybrid system.
■ To prevent damage to the cooling system
Observe the following precautions:
●Avoid contaminating the coolant with foreign matter (such as sand or dust
etc.).
● Do not use any coolant additives.

572 6-1. Specifications
PRIUS_OM_OM47857U_DVD_(U)
Cooling system
Ignition system
Capacity
Gasoline
engine
Without an exhaust heat recovery system
6.9 qt. (6.5 L, 5.7 Imp.qt.)
With an exhaust heat recovery system
7.6 qt. (7.2 L, 6.3 Imp.qt.)
Power
control
unit2.2 qt. (2.1 L, 1.8 Imp.qt.)
Coolant type Use either of the following:
• “Toyota Super Long Life Coolant”
• Similar high-quality ethylene glycol-based non- silicate, non-amine, non-nitrite, and non-borate
coolant with long-life hybrid organic acid technol-
ogy
Do not use plain water alone.
Spark plug
Make DENSO SC20HR11
Gap 0.043 in. (1.1 mm)
NOTICE
■Iridium-tipped spark plugs
Use only iridium-tipped spark plugs. Do not adjust the spark plug gap.

588 6-1. Specifications
PRIUS_OM_OM47857U_DVD_(U)
Glossary of tire terminology
Tire related termMeaning
Cold tire inflation pres-
sure Tire pressure when the vehicle has been
parked for three hours or more, or has not
been driven more than 1 mile or 1.5 km under
that condition
Maximum inflation
pressure The maximum cold inflated
pressure to which a
tire may be inflated, s hown on the sidewall of
the tire
Recommended infla-
tion pressure Cold tire inflation pressure recommended by a
manufacturer
Accessory weight The combined weight (in excess of those stan-
dard items which may be replaced) of auto-
matic transmission, power steering, power
brakes, power windows, power seats, radio
and heater, to the extent that these items are
available as factory-installed equipment
(whether installed or not)
Curb weight The weight of a motor vehicle with standard
equipment, including the maximum capacity of
fuel, oil and coolant, and if so equipped, air
conditioning and additional weight optional
engine
Maximum loaded vehi-
cle weight The sum of:
(a) Curb weight
(b) Accessory weight
(c) Vehicle capacity weight
(d) Production options weight

627
Alphabetical index
PRIUS_OM_OM47857U_DVD_(U)
Eco drive mode switch ........... 206
Electric power steering........... 300
Electronic key
If the electronic key does not operate properly ................. 548
Replacing battery ................. 460
Emergency, in case of If a warning buzzer sounds ............................... 499
If a warning light turns on ..... 499
If the electronic key does not operate properly ................. 548
If the hybrid system will not start .................................... 545
If the 12-volt battery is
discharged ......................... 550
If you have a flat tire ............ 530
If you lose your keys............. 547
If you think something is wrong ................................. 498
If your vehicle becomes stuck................................... 561
If your vehicle has to be stopped in an
emergency ......................... 563
If your vehicle needs to be towed ................................. 491
If your vehicle overheats ...... 556
Emergency flashers Switch ................................... 490 Engine
Accessory mode....................196
Compartment ........................425
Hood......................................419
How to start the hybrid system ................................194
Identification number .............567
If the hybrid system will not start .....................................545
Ignition switch........................194
Overheating...........................556
“POWER” switch ...................194
Engine coolant Capacity ................................572
Checking ...............................430
Preparing and checking before winter .......................321
Engine/power control
unit coolantCapacity ................................572
Checking ...............................430
Preparing and checking before winter .......................321
Engine oil Capacity ................................569
Checking ...............................426
Preparing and checking before winter .......................321
Enhanced VSC .........................300
EPS ............................................300
EV drive mode switch ..............201
Event data recorder ...................25E

633
Alphabetical index
PRIUS_OM_OM47857U_DVD_(U)
Tonneau cover......................... 382
Tools......................................... 530
Touch tracer display ............... 217
Total load capacity .................. 320
Towing
Dinghy towing ....................... 327
Emergency towing ................ 492
Trailer towing ........................ 326
TRAC ........................................ 300
Traction control ....................... 300
Trailer towing........................... 326
Transmission
Hybrid transmission .............. 204
P position switch................... 207
Trip information....................... 231
Trip meter................................. 216
Turn signal lights Replacing light bulbs ............ 473
Switch ................................... 213
Wattage ................................ 576
USB port
*................................ 356
Vanity lights Vanity lights .......................... 369
Wattage ................................ 576
Vanity mirrors .......................... 369
Vehicle data recordings............ 24
Vehicle identification number................................... 567
Vehicle proximity notification system ..................................... 34
Vehicle stability control .......... 300
VSC ........................................... 300 Warning buzzers
Brake system ........................499
Open door ............................504
Seat belt reminder .................504
Warning lights Anti-lock brake system
(ABS) ..................................501
Automatic headlight leveling system ................................503
Brake system ................499, 502
Charging system .... ...............500
Cruise control ........................503
Electric power steering
system ................................501
High coolant temperature ......500
Hybrid system .......................501
Low fuel level ........................504
Low tire pressure...................505
Malfunction indicator lamp ....501
Open door .............................504
Pre-collision system ..............502
Radar cruise control. .............503
Seat belt warning light ...........504
Slip indicator..........................502
SRS airbags ..........................501
Tire pressure warning light ....505U
V
W
GW Refer to