transmission TOYOTA RAIZE 2023 Service Manual

372
RAIZE_OM_General_BZ358E
7-2. Steps to take in an emergency
If your vehicle needs to be towed
If towing is necessary, we recomm end having your vehicle towed by
your Toyota dealer or commercial towing service, using a wheel-lift
type truck or flatbed truck.
Use a safety chain system for all towing, and abide by all state/pro-
vincial and local laws.
Situations when it is necessary to contact dealers before towing
The following may indicate a problem with your transmission.
Contact your Toyota dealer or commercial towing service before towing.
⚫The engine is running but the vehicle does not move.
⚫The vehicle makes an abnormal sound.
Towing with a wheel-lift type truck
▶From the front
Release the parking brake.▶From the rear
Use a towing dolly under the front
wheels.
KBRO720101KBRO720103
RAIZE_OM_General_BZ358E.book 372 ページ ２０２２年５月１７日　火曜日　午後１時５９分

3797-2. Steps to take in an emergency
RAIZE_OM_General_BZ358E ✽
: If equipped
When trouble arises
7
If a warning light turns on
If a warning light remains on or flashes, remain calm and take the
following actions. Even if the warn ing light lights up or flashes then
goes out, it is not a malfunction. However, if the same phenomenon
occurs again, have the vehicle inspected at your Toyota dealer.
Warning light/Warning buzzers list
Warning lightsWarning light name/Warning content/Action to take
Brake system warning light (warning buzzer *1)
⦁Low brake fluid level
⦁Malfunction in the brake system
➞ Immediately stop the vehicle in a safe place and contact your
Toyota dealer. Continuing to drive the vehicle is dangerous.
Charging system warning light✽
Malfunction in the vehicle’s charging system
➞ Immediately stop the vehicle in a safe place and contact your
Toyota dealer.
Low engine oil pressure warning light✽ (warning buzzer)
Abnormal engine oil pressure
➞ Immediately stop the vehicle in a safe place and contact your
Toyota dealer.
(Red light
flashing or lit)
High coolant temperature warning light
Abnormal engine coolant temperat ure (light changes from flash-
ing to lit as the temperature rises ➞P. 412.)
➞ Immediately stop the vehicle in a safe place and contact your
Toyota dealer.
Malfunction indicator lamp
⦁Malfunction in the electron ic engine control system
⦁Electronic control throttle error
➞ Have the vehicle inspected at your Toyota dealer immedi-
ately.
Continuously variable transmission warning light✽
Malfunction of the continuously variable transmission electronic
control system
➞ Have the vehicle inspected at your Toyota dealer immedi-
ately.
RAIZE_OM_General_BZ358E.book 379 ページ ２０２２年５月１７日　火曜日　午後１時５９分

3887-2. Steps to take in an emergency
RAIZE_OM_General_BZ358E ✽
: If equipped
“Engine Control Sys-
tem Malfunction Visit
Your Dealer”
Malfunction in the electronic engine control
system
Electronic control throttle error
➞ Have the vehicle inspected at your Toy-
ota dealer immediately.
“Transmission System
Malfunction Visit Your
Dealer”Malfunction in the e lectronic automatic
transmission control system
✽
➞ Have the vehicle inspected at your Toy-
ota dealer immediately.
“SRS Airbag Malfunc-
tion Visit Your Dealer”
Malfunction in the SRS airbag system
Malfunction in the seat belt pretensioner &
force limiter system
➞ Have the vehicle inspected at your Toy-
ota dealer immediately.
“ABS System Malfunc-
tion Visit Your Dealer”Malfunction in the ABS system
➞Have the vehicle inspected at your Toy-
ota dealer immediately.
“Power Steering Mal-
function Visit Your
Dealer”
(Red)
Malfunction in EPS (Electric Power Steering)
system
The warning buzzer will sound.
➞ Have the vehicle inspected at your Toy-
ota dealer immediately.
“Steering Performance
Is Reduced Steering
Power Low”
(Yellow)
Low battery voltage/Electric power steering
overheating
The warning buzzer will sound.
➞ Steering wheel operation becomes
heavy. Restrain from operating the
steering wheel for a short while. When
about 10 minutes has passed, it will
return to its usual weight.
“Smart Entry & Start
System Malfunction
Visit Your Dealer”Malfunction in th e key-free system
➞ Have the vehicle inspected at your Toy-
ota dealer immediately.
Warning messages
Indicators/
Warning lights
Warning content/Action to take
RAIZE_OM_General_BZ358E.book 388 ページ ２０２２年５月１７日　火曜日　午後１時５９分

3967-2. Steps to take in an emergency
RAIZE_OM_General_BZ358E
If you have a flat tire
Replace the flat tire with the supplied spare tire.
(See P. 327 for more information about tires)
WARNING
⬛If you have a flat tire
Do not drive with a flat tire.
Even over short distances, the tires an d wheels can be irreparably damaged or
cause an accident.
Before lifting the vehicle with a jack
⚫Move the vehicle to a hard, flat, safe location
⚫Apply the parking brake
⚫For continuously variable transmission vehicles, set the shift lever to P
⚫For vehicles with manual transmission, set the shift lever to R
⚫Stop the engine
⚫Turn the emergency flashers on
RAIZE_OM_General_BZ358E.book 396 ページ ２０２２年５月１７日　火曜日　午後１時５９分

4067-2. Steps to take in an emergency
RAIZE_OM_General_BZ358E
If the electronic key does not work properly
(vehicles with key-free system)
The key-free system and wireless remote control cannot be used
when communication between the electronic key and vehicle is
blocked (➞P. 125) or when the electronic key battery is dead. In such
cases, you can open the doors or start the engine by following the
steps below.
Locking and unloc king the doors
Using the emergency key ( ➞P. 118),
you can:
a Lock all doors
b Unlock all doors
If set, the alarm will sound. ( ➞P. 73)
Starting the engine
a Continuously variable transmission vehicles: Step on the brake pedal
with the shift lever placed in P
Manual transmission vehicles: Step on the clutch pedal with the shift
lever placed in N
b Touch the electronic key to the
engine switch, as shown in the
illustration
⦁The indicator of the engine switch
lights up in green.
⦁ The alarm will shut off. (➞ P. 73)
cPress the engine switch
If you are still unable to start the engine after following the above steps,
contact your Toyota dealer.
12
KBRO720801E
KBRO820801E
RAIZE_OM_General_BZ358E.book 406 ページ ２０２２年５月１７日　火曜日　午後１時５９分

4077-2. Steps to take in an emergency
RAIZE_OM_General_BZ358E
When trouble arises
7
⬛Stopping the engine
As you usually would when stopping the engine, set the shift lever to P for con-
tinuously variable transmission vehicles , and set it to N for manual transmis-
sion vehicles, then press the engine switch.
⬛Replacing the battery
The method to start the engine descri bed here is a temporary workaround. We
recommend that you replace dead batteries immediately. ( ➞P. 344)
⬛Changing the engine switch mode
In step c of “Starting the engine ”, if you press the engine switch by releasing
your foot from the clutch pedal for manual transmission vehicles and from the
brake pedal for continuously variable tr ansmission vehicles, the engine will not
start. Instead, the mode changes each time you press the switch. (➞P. 185)
⬛If the electronic key does not work properly
Check whether the electronic key is set to battery-saving mode. If the mode is
set, cancel it ( ➞P. 125)
RAIZE_OM_General_BZ358E.book 407 ページ ２０２２年５月１７日　火曜日　午後１時５９分

4157-2. Steps to take in an emergency
RAIZE_OM_General_BZ358E
When trouble arises
7
If the vehicle has become stuck
Carry out the following procedures if the tires spin or the vehicle has
become stuck in mud, sand or snow:
a Make sure that the parking brake is applied. For continuously variable
transmission vehicles, set the shift lever to P, and for the manual trans-
mission vehicles, set it to N, then stop the engine
b Remove the dirt and snow from around the wheels
c Place wood, stones or some other material under the rear wheels to
help provide traction
d Restart the engine
e For continuously variable transmission vehicles, set the shift lever to D
or R. For the manual transmission ve hicles, make sure to set the gear
to 1 or R. Then, step on the accelerator pedal while exercising caution
If VSC/TRC is making it difficult to extricate the vehicle, turn off TRC or VSC/TRC.
( ➞ P. 233)
WARNING
⬛When attempting to free a stuck vehicle
If you choose to push the vehicle back an d forth to free it, make sure the sur-
rounding area is clear to avoid striking other vehicles, objects or people.
The vehicle may also lunge forward or lu nge back suddenly as it becomes free.
Use extreme caution.
⬛When shifting the shift lever
Be careful not to shift the shift lever with the accelerator pedal depressed.
This may lead to unexpected rapid acceleration of the vehicle that may cause
an accident resulting in death or serious injury.
⬛To avoid damage to the transmission and other components
⚫Avoid spinning the wheels and depre ssing the accelerator pedal more than
necessary to race the engine. The tr ansmission or other parts may be dam-
aged, which may lead to an accident.
⚫Do not spin the wheels at high speed. The tires may rupture or overheat,
which may lead to an accident.
RAIZE_OM_General_BZ358E.book 415 ページ ２０２２年５月１７日　火曜日　午後１時５９分

4258-1. List of specifications
RAIZE_OM_General_BZ358E
Vehicle information
8
Cooling system
*1Except for hot area
*2For hot area
*3For vehicles without heater
*4For vehicles with heater
Ignition system
NOTICE
⬛Iridium-tipped spark plugs
Use only iridium-tipped spark plugs. Do not adjust the spark plug gap.
WA-VE engine1KR-VET engine
Capacity
(Reference)
▶Continuously variable trans-
mission
4.1 L (4.3 qt., 3.6 Imp.qt.)*
1, 3
4.6 L (4.9 qt., 4.0 Imp.qt.)*1, 4
4.2 L (4.4 qt., 3.7 Imp.qt.)*2, 3
4.7 L (5.0 qt., 4.1 Imp.qt.)*2, 4
▶Manual transmission
3.9 L (4.1 qt., 3.4 Imp.qt.)*
1, 3
4.5 L (4.8 qt., 4.0 Imp.qt.)*1, 4
4.0 L (4.2 qt., 3.5 Imp.qt.)*2, 3
4.6 L (4.9 qt., 4.0 Imp.qt.)*2, 4
▶Continuously variable trans-
mission
4.6 L (4.9 qt., 4.0 Imp.qt.)*
1, 3
4.8 L (5.1 qt., 4.2 Imp.qt.)*1, 4
4.7 L (5.0 qt., 4.1 Imp.qt.)*2, 3
5.0 L (5.3 qt., 4.4 Imp.qt.)*2, 4
▶Manual transmission
4.4 L (4.6 qt., 3.9 Imp.qt.)*
1, 3
4.7 L (5.0 qt., 4.1 Imp.qt.)*1, 4
4.6 L (4.9 qt., 4.0 Imp.qt.)*2, 3
4.8 L (5.1 qt., 4.2 Imp.qt.)*2, 4
Coolant type
Use either of the following:
⚫“Toyota Super Long Life Coolant”
⚫A similar high-quality ethylene glycol-based non-silicate, non-
amine, non-nitrite, and non-borate coolant with long-life hybrid
organic acid technology
Do not use plain water alone.
Spark plug
Make▶WA-VE engine
DENSO FC20HR-Q8
▶1KR-VET engine
NGK SILKAR7G8G
Gap0.8 mm (0.031 in.)
RAIZE_OM_General_BZ358E.book 425 ページ ２０２２年５月１７日　火曜日　午後１時５９分

4268-1. List of specifications
RAIZE_OM_General_BZ358E
Electrical system
Continuously variable transmission
*The fluid capacity is a reference quantity. If replacement is necessary, contact
your Toyota dealer.
NOTICE
⬛Continuously variable tr ansmission fluid type
Using continuously variable transmission fluid other than “TOYOTA GENUINE
CVT FLUID FE” may cause malfunction.
Manual transmission
Battery
Model
Specific gravity
reading at 20°C
(68°F):34B19L
1.250 - 1.290 Fully charged
1.200 - 1.240 Half charged
1.170 or less Discharged
Charging rates
Quick charge
Slow charge20 A max.
3 A max.
Fluid capacity*6.0 L (6.3 qt., 5.3 Imp.qt.)
Fluid typeTOYOTA GENUINE CVT FLUID FE
Gear oil capacity
(Reference)1.4 L (1.5 qt., 1.2 Imp.qt.)
Gear oil typeGear oil API GL-4
Recommended
gear oil viscositySAE 80W
RAIZE_OM_General_BZ358E.book 426 ページ ２０２２年５月１７日　火曜日　午後１時５９分

437What to do if... (Troubleshooting)
RAIZE_OM_General_BZ358E
If you think something is wrong
The engine does not start (vehicles without key-free system)
⚫Continuously variable transmission vehicles
Is the shift lever in P? (➞P. 180)
⚫Manual transmission vehicles
Did you turn the engine switch while firmly depressing the clutch pedal?
(➞ P. 1 8 0 )
⚫Isn’t the steering wheel locked? ( ➞P. 182)
⚫Isn’t the battery discharged? ( ➞P. 408)
The engine does not start (vehicles with key-free system)
⚫Continuously variable transmission vehicles
Did you press the engine switch while firmly depressing the brake
pedal? ( ➞P. 184)
⚫Manual transmission vehicles
Did you press the engine switch wh ile firmly stepping on the clutch
pedal? ( ➞P. 184)
⚫Continuously variable transmission vehicles
Is the shift lever in P? ( ➞P. 184)
⚫Is the key anywhere detectable inside the vehicle? ( ➞P. 122)
⚫Isn’t the steering wheel locked? ( ➞P. 187)
⚫Is the key battery weak or depleted?
In this case, the engine can be started in a temporary way. ( ➞P. 406)
⚫Isn’t the battery discharged? ( ➞P. 408)
RAIZE_OM_General_BZ358E.book 437 ページ ２０２２年５月１７日　火曜日　午後１時５９分