TOYOTA RAV4 2002 XA20 / 2.G Owners Manual

’02 Rav4_U (L/O 0108)
2622002 MY RAV4_U (OM42503U)
If you believe that your vehicle
has a defect which could cause a
crash or could cause injury or
death, you should immediately in-
form the National Highway Traffic
Safety Administration (NHTSA) in
addition to notifying Toyota Motor
Sales, U.S.A., Inc.
(Tollfree: 18003314331).
If NHTSA receives similar com-
plaints, it may open an investiga-
tion, and if it finds that a safety
defect exists in a group of ve-
hicles, it may order a recall and
remedy campaign. However,
NHTSA cannot become involved
in individual problems between
you, your dealer, or Toyota Motor
Sales, U.S.A., Inc.To contact NHTSA, you may ei-
ther call the Auto Safety Hotline
tollfree at 18004249393 (or
3660123 in Washington, D.C.
area) or write to: NHTSA, U.S.
Department of Transportation,
Washington, D.C. 20590. You can
also obtain other information about
motor vehicle safety from the Hot-
line.This information has been prepared in ac-
cordance with regulations issued by the
National Highway Traffic Safety Adminis-
tration of the U.S. Department of Trans-
portation. It provides the purchasers and/
or prospective purchasers of Toyota
vehicles with information on uniform tire
quality grading.
Your Toyota dealer will help answer any
questions you may have as you read this
information.
DOT quality grades—All passenger car
tires must conform to Federal Safety
Requirements in addition to these
grades. Quality grades can be found
where applicable on the tire sidewall
between tread shoulder and maximum
section width. For example: Treadwear
200 Traction AA Temperature A
Reporting safety defects for
U.S. owners
Uniform tire quality grading

’02 Rav4_U (L/O 0108)
2632002 MY RAV4_U (OM42503U)
Treadwear—The treadwear grade is a
comparative rating based on the wear rate
of the tire when tested under controlled
conditions on a specified government test
course. For example, a tire graded 150
would wear one and a half (11/2) times
as well on the government course as a
tire graded 100. The relative performance
of tires depends upon the actual condi-
tions of their use, however, and may de-
part significantly from the norm due to
variations in driving habits, service prac-
tices and differences in road characteris-
tics and climate. Traction AA, A, B, C—
The traction
grades, from highest to lowest, are AA, A,
B, and C, and they represent the tire’s
ability to stop on wet pavement as mea-
sured under controlled conditions on spe-
cified government test surfaces of asphalt
and concrete. A tire marked C may have
poor traction performance.
Warning: The traction grade assigned to
this tire is based on braking (straight
ahead) traction tests and does not include
cornering (turning) traction.
Temperature A, B, C— The temperature
grades are A (the highest), B, and C,
representing the tire’s resistance to the
generation of heat and its ability to dissi-
pate heat when tested under controlled
conditions on a specified indoor laboratory
test wheel. Sustained high temperature
can cause the material of the tire to de-
generate and reduce tire life, and exces-
sive temperature can lead to sudden tire
failure. The grade C corresponds to a lev-
el of performance which all passenger car
tires must meet under the Federal Motor
Vehicle Safety Standard No.109. Grades B
and A represent higher levels of perfor-
mance on the laboratory test wheel than
the minimum required by law. Warning: The temperature grades for this
tire are established for a tire that is prop-
erly inflated and not overloaded. Exces-
sive speed, underinflation, or excessive
loading, either separately or in combina-
tion, can cause heat buildup and possible
tire failure.

’02 Rav4_U (L/O 0108)
2642002 MY RAV4_U (OM42503U)

’02 Rav4_U (L/O 0108)
2652002 MY RAV4_U (OM42503U)
INDEX
SECTION 10

’02 Rav4_U (L/O 0108)
2662002 MY RAV4_U (OM42503U)
A
Adding washer fluid243
. . . . . . . . . . . . . . . . . .
Adjustment
Front seats 29
. . . . . . . . . . . . . . . . . . . . . . . . .
Rear seats 30
. . . . . . . . . . . . . . . . . . . . . . . . .
Seat belt 40
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Air cleaner 230
. . . . . . . . . . . . . . . . . . . . . . . . . .
Air conditioning system 128
. . . . . . . . . . . . . . .
Airbags 50
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Aluminum wheel precautions 237
. . . . . . . . . .
Antiglare inside rear view mirror 76 . . . . . . .
Antilock brake system warning light 90 . . . .
Antitheft steering column lock 98
. . . . . . . . .
Appearance care
Cleaning the interior 209
. . . . . . . . . . . . . . . .
Protecting your Toyota from corrosion 206
. . . . . . . . . . . . . . . . . . .
Washing and waxing 207
. . . . . . . . . . . . . . . .
Automatic transmission
Driving with an automatic transmission 99
. . . . . . . . .
Shift lock override button 202
. . . . . . . . . . . .
Shift pattern 99
. . . . . . . . . . . . . . . . . . . . . . . .
Shifting speed 99
. . . . . . . . . . . . . . . . . . . . . .
Automatic transmission fluid temperature warning light 90
. . . . . . . . . . . .
Auxiliary boxes 141
. . . . . . . . . . . . . . . . . . . . . .
Auxiliary catch, Engine hood 22
. . . . . . . . . . .
B
Back door 21
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Back door lock 21
. . . . . . . . . . . . . . . . . . . . . . . . Battery
Checking battery condition 240
. . . . . . . . . .
Gas caution 240
. . . . . . . . . . . . . . . . . . . . . . .
Handling safety 240
. . . . . . . . . . . . . . . . . . . .
Recharging precautions 241
. . . . . . . . . . . . .
Winter driving tips 173
. . . . . . . . . . . . . . . . . .
Before starting the engine 170
. . . . . . . . . . . . .
Brake pad wear limit indicators 164 . . . . . . . .
Brake system 161
. . . . . . . . . . . . . . . . . . . . . . . .
Brake system warning light 90
. . . . . . . . . . . . .
Brakes
Fluid level 229
. . . . . . . . . . . . . . . . . . . . . . . . .
Pad wear limit indicators 164
. . . . . . . . . . . .
Parking 104
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Breakin tips 155
. . . . . . . . . . . . . . . . . . . . . . . .
Brightness control 82
. . . . . . . . . . . . . . . . . . . . .
C
Car audio system 110
. . . . . . . . . . . . . . . . . . . .
Carbon monoxide caution 159
. . . . . . . . . . . . .
Cassette player 110
. . . . . . . . . . . . . . . . . . . . . .
Checking and replacing fuses 242
. . . . . . . . .
Checking brake fluid 229
. . . . . . . . . . . . . . . . . .
Checking the engine oil level 226
. . . . . . . . . .
Checking the radiator and condenser 228
. . . . . . . . . . . . . . . . . . . . . . . . .
Child restraint
Child restraint system 58
. . . . . . . . . . . . . . .
Installation 60
. . . . . . . . . . . . . . . . . . . . . . . . .
Installation with ISOFIX rigid anchor 72
. . . . . . . . . . . . . . . . . . . . . .
Precautions 57
. . . . . . . . . . . . . . . . . . . . . . . . Types of child restraint system 59
. . . . . . . .
Using a top strap 69
. . . . . . . . . . . . . . . . . . . .
Cigarette lighter and ashtrays 136
. . . . . . . . .
Cleaning the interior 209
. . . . . . . . . . . . . . . . . .
Clock 136
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cold weather
Operation 173
. . . . . . . . . . . . . . . . . . . . . . . . .
Compact disc auto changer controller 110
. . . . . . . . . . . . . . . . . .
Compact disc player 110
. . . . . . . . . . . . . . . . . .
Condenser
Checking the condenser 228
. . . . . . . . . . . .
Controls, Instrument panel 2,4
. . . . . . . . . . . .
Cooling system
Coolant level 227
. . . . . . . . . . . . . . . . . . . . . .
Engine overheating 188
. . . . . . . . . . . . . . . . .
Radiator and reservoir 227
. . . . . . . . . . . . . .
Radiator cap 188
. . . . . . . . . . . . . . . . . . . . . . .
Winter driving tips 173
. . . . . . . . . . . . . . . . . .
Corrosion prevention 206
. . . . . . . . . . . . . . . . .
Cruise control 105
. . . . . . . . . . . . . . . . . . . . . . .
Cup holder
Front 143
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear 143
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
D
Defogger
Out side rear view mirror 85 . . . . . . . . . . . . .
Rear window 85
. . . . . . . . . . . . . . . . . . . . . . . .
Differential, Limited slip 165
. . . . . . . . . . . . . . .
Dimmer switch, Headlight 80
. . . . . . . . . . . . . .
Dinghy towing 174,175
. . . . . . . . . . . . . . . . . . .
Directional signals 80
. . . . . . . . . . . . . . . . . . . .

’02 Rav4_U (L/O 0108)
2672002 MY RAV4_U (OM42503U)
Discharge warning light90
. . . . . . . . . . . . . . . .
Doityourself maintenance
Parts and tools 221
. . . . . . . . . . . . . . . . . . . . .
Service precautions 219
. . . . . . . . . . . . . . . .
Does your vehicle need repairing? 215 . . . . .
Doors
Side doors 12
. . . . . . . . . . . . . . . . . . . . . . . . .
Driver ’s seat belt reminder buzzer 90 . . . . . . .
Driver ’s seat belt reminder light 90
. . . . . . . . .
Driving
Automatic transmission 99
. . . . . . . . . . . . . .
Driving tips 170
. . . . . . . . . . . . . . . . . . . . . . . .
Manual transmission 103
. . . . . . . . . . . . . . .
Driving tips
Driving tips in various conditions 171 . . . . .
Driving with a manual transmission 103
. . . . . . . . . . . .
Driving with an automatic transmission 99
. . . . . . . . .
Economical driving 181
. . . . . . . . . . . . . . . . .
Good driving practice 99,103
. . . . . . . . . . . .
Winter driving tips 173
. . . . . . . . . . . . . . . . . .
During
Breakin 155
. . . . . . . . . . . . . . . . . . . . . . . . . .
E
Economical driving
Saving money on both fuel and repairs 181 . . . . . . . . . . . . . . . . . .
Electric moon roof 25 . . . . . . . . . . . . . . . . . . . . . Electrical system
Battery 240,241 . . . . . . . . . . . . . . . . . . . . . . . .
Fuse locations 219 . . . . . . . . . . . . . . . . . . . . .
Fuses 242 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 81 . . . . . . . . . . . . . .
Emergency, In case of
Blown fuse 242 . . . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 81 . . . . . . . . . . . .
Flat tire 189 . . . . . . . . . . . . . . . . . . . . . . . . . . .
If you cannot shift automatic transmission selector lever 202 . . . . . . . .
If you lose your keys 203 . . . . . . . . . . . . . . . .
If you lose your wireless remote control transmitter 203 . . . . . . . . . . . . . . . .
If your engine stalls while driving 188 . . . . .
If your vehicle needs to be towed 198 . . . . .
If your vehicle will not start 184 . . . . . . . . . .
Jump starting 185 . . . . . . . . . . . . . . . . . . . . . .
Overheating 188 . . . . . . . . . . . . . . . . . . . . . . .
Towing 198 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Emissions Inspection and Maintenance (I/M) programs 216 . . . . . . . . .
Engine
Air cleaner 230 . . . . . . . . . . . . . . . . . . . . . . . .
Before starting the engine 170 . . . . . . . . . . .
Checking the coolant level 227 . . . . . . . . . .
Emission control device 158 . . . . . . . . . . . . .
Engine compartment 218 . . . . . . . . . . . . . . .
Exhaust gas caution 159 . . . . . . . . . . . . . . . .
Hood release 22 . . . . . . . . . . . . . . . . . . . . . . .
Oil consumption 159 . . . . . . . . . . . . . . . . . . . .
Oil level 226 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Overheating 188 . . . . . . . . . . . . . . . . . . . . . . . Starting procedure 170
. . . . . . . . . . . . . . . . .
Threeway catalytic converter 158 . . . . . . .
Engine coolant
Temperature gauge 88 . . . . . . . . . . . . . . . . . .
Winter driving tips 173 . . . . . . . . . . . . . . . . . .
Engine coolant temperature gauge 88 . . . . . .
Engine immobiliser system 11 . . . . . . . . . . . . .
Engine oil
Winter driving tips 173 . . . . . . . . . . . . . . . . . .
Exhaust gas caution 159 . . . . . . . . . . . . . . . . . .
F
Facts about engine oil consumption 159 . . . .
Flasher, Headlight 80 . . . . . . . . . . . . . . . . . . . . .
Flat tire
After changing wheels 197 . . . . . . . . . . . . . .
Changing tire 194 . . . . . . . . . . . . . . . . . . . . . .
If you have a flat tire 189 . . . . . . . . . . . . . . . .
Jack point 193 . . . . . . . . . . . . . . . . . . . . . . . . .
Jacking precautions 189 . . . . . . . . . . . . . . . .
Jacking up 193 . . . . . . . . . . . . . . . . . . . . . . . .
Loosening wheel nuts 193 . . . . . . . . . . . . . . .
Lowering vehicle 195 . . . . . . . . . . . . . . . . . . .
Stowing flat tire 196 . . . . . . . . . . . . . . . . . . . .
Wheel block 192 . . . . . . . . . . . . . . . . . . . . . . .
Wheel nuts 195 . . . . . . . . . . . . . . . . . . . . . . . .
Floor mat 151 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fluid level
Brake 229 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power steering 229 . . . . . . . . . . . . . . . . . . . . .
Washer fluid 243 . . . . . . . . . . . . . . . . . . . . . . .
Fog light switch, Front 82 . . . . . . . . . . . . . . . . .
Foreign countries, Operation in 157 . . . . . . . .

’02 Rav4_U (L/O 0108)
2682002 MY RAV4_U (OM42503U)
Front cup holder143
. . . . . . . . . . . . . . . . . . . . .
Front fog light switch 82
. . . . . . . . . . . . . . . . . .
Front passenger ’s seat belt reminder light 90
. . . . . . . . . . . . . . . . . . . . . . .
Front seat
Seatback flattening 38
. . . . . . . . . . . . . . . . . .
Front seats 28,29
. . . . . . . . . . . . . . . . . . . . . . . .
Fuel
Filler door o pener 24
. . . . . . . . . . . . . . . . . . .
Fuel economy 181
. . . . . . . . . . . . . . . . . . . . .
Fuel pump shut off system 157
. . . . . . . . . .
Gauge 88
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operation in foreign countries 157 . . . . . . .
Tank cap 24
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel information 155
. . . . . . . . . . . . . . . . . . . . .
Fuel pump shut off system 157
. . . . . . . . . . . .
Fuse
Fuse box 242
. . . . . . . . . . . . . . . . . . . . . . . . . .
Fuse locations 219
. . . . . . . . . . . . . . . . . . . . . . .
G
Garage door opener box 138
. . . . . . . . . . . . . .
Gauge
Engine coolant temperature 88
. . . . . . . . . .
Fuel 88
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Glove box 138
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Good driving practice 99,103
. . . . . . . . . . . . . .
Grocery bag hooks 145
. . . . . . . . . . . . . . . . . . .
H
Hazard switch 81
. . . . . . . . . . . . . . . . . . . . . . . .
Head restraints 39
. . . . . . . . . . . . . . . . . . . . . . .
Headlight switch 80
. . . . . . . . . . . . . . . . . . . . . .
High speed operation
During breakin 155
. . . . . . . . . . . . . . . . . . . .
Hood release, Engine 22
. . . . . . . . . . . . . . . . . .
How to start the engine 170
. . . . . . . . . . . . . . .
I
I/M test 216
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Identification
Engine 166
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Vehicle 165
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ignition switch 98
. . . . . . . . . . . . . . . . . . . . . . . .
Indicator symbols 5
. . . . . . . . . . . . . . . . . . . . . .
Instrument panel
Brightness control 82
. . . . . . . . . . . . . . . . . . .
Cigarette lighter and ashtrays 136 . . . . . . .
Clock 136
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel gauge 88
. . . . . . . . . . . . . . . . . . . . . . . . .
Indicator symbols 5
. . . . . . . . . . . . . . . . . . . .
Odometer 89
. . . . . . . . . . . . . . . . . . . . . . . . . .
Tachometer 89
. . . . . . . . . . . . . . . . . . . . . . . . .
Trip meter 89
. . . . . . . . . . . . . . . . . . . . . . . . . .
Instrument panel light control 82
. . . . . . . . . . .
Instrument panel overview 2,4
. . . . . . . . . . . .
Interior light 82
. . . . . . . . . . . . . . . . . . . . . . . . . .
J
Jack
Location 190 . . . . . . . . . . . . . . . . . . . . . . . . . .
Jump starting 185 . . . . . . . . . . . . . . . . . . . . . . . .
K
Key reminder buzzer 90
. . . . . . . . . . . . . . . . . .
Keys 8,203
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
L
Light bulbs
Backup lights 249 . . . . . . . . . . . . . . . . . . . . .
Front fog lights 246 . . . . . . . . . . . . . . . . . . . . .
Front side marker lights 248 . . . . . . . . . . . . .
Front turn signal lights 248,249 . . . . . . . . . .
Headlights 245 . . . . . . . . . . . . . . . . . . . . . . . .
High mounted stoplight 250 . . . . . . . . . . . . .
License plate lights 251 . . . . . . . . . . . . . . . . .
Parking lights 248 . . . . . . . . . . . . . . . . . . . . . .
Rear side marker lights 249 . . . . . . . . . . . . .
Rear turn signal lights 249 . . . . . . . . . . . . . .
Stop/tail lights 249 . . . . . . . . . . . . . . . . . . . . .
Light bulbs, Replacing 244 . . . . . . . . . . . . . . . .
Light reminder buzzer 90 . . . . . . . . . . . . . . . . .
Limited slip differential 165 . . . . . . . . . . . . . . . .
Lock
Back door 21 . . . . . . . . . . . . . . . . . . . . . . . . . .
Side doors 12 . . . . . . . . . . . . . . . . . . . . . . . . .
Steering column 98 . . . . . . . . . . . . . . . . . . . .
Low engine oil pressure warning light 90 . . . .
Low fuel level warning light 90 . . . . . . . . . . . . .

’02 Rav4_U (L/O 0108)
2692002 MY RAV4_U (OM42503U)
Low windshield washer fluid level warning light 90 . . . . . . . . . . . . . . . . . . . . . . . .
Luggage cover 146 . . . . . . . . . . . . . . . . . . . . . . .
Luggage stowage precautions 164 . . . . . . . . .
M
Maintenance
Doityourself maintenance 219 . . . . . . . . .
Does your vehicle need repairing? 215 . . . . . . . . . . . . . . . . . .
General maintenance 213 . . . . . . . . . . . . . . .
Maintenance requirements 212 . . . . . . . . . .
Parts and tools 221 . . . . . . . . . . . . . . . . . . . . .
Where to go for service 212 . . . . . . . . . . . . .
Malfunction indicator lamp 90,216 . . . . . . . . .
Manual transmission
Driving with a manual transmission 103 . . . . . . . . . . . .
Shift pattern 103
. . . . . . . . . . . . . . . . . . . . . . .
Shifting speed 103
. . . . . . . . . . . . . . . . . . . . .
Maximum allowable speed
Automatic transmission 99
. . . . . . . . . . . . . .
Manual transmission 103
. . . . . . . . . . . . . . .
Mirror
Antiglare inside rear view 76
. . . . . . . . . . .
Mirrors
Folding rear view 75
. . . . . . . . . . . . . . . . . . . .
Outside rear view 74
. . . . . . . . . . . . . . . . . . .
Power rear view 75
. . . . . . . . . . . . . . . . . . . . .
Vanity 77
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Moon roof 25
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
N
New vehicle breakin 155
. . . . . . . . . . . . . . . . .
O
Odometer 89
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Offroad driving precautions 172
. . . . . . . . . .
Offroad vehicle precautions 154
. . . . . . . . . .
Oil
Consumption 159
. . . . . . . . . . . . . . . . . . . . . .
Power steering 229
. . . . . . . . . . . . . . . . . . . . .
Viscosity and grade 226
. . . . . . . . . . . . . . . .
Oil consumption 159
. . . . . . . . . . . . . . . . . . . . .
Open door warning light 90
. . . . . . . . . . . . . . . .
Operation in foreign countries 157
. . . . . . . . .
Overdrive switch 99
. . . . . . . . . . . . . . . . . . . . . .
Overheating, Engine 188
. . . . . . . . . . . . . . . . . .
Overheating, Engine coolant 88
. . . . . . . . . . .
Overview
Engine compartment 218
. . . . . . . . . . . . . . .
P
Parking brake
Operation 104 . . . . . . . . . . . . . . . . . . . . . . . . .
Reminder light 104 . . . . . . . . . . . . . . . . . . . . .
Personal light 83 . . . . . . . . . . . . . . . . . . . . . . . . .
Polishing 207 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Positioning the jack 222 . . . . . . . . . . . . . . . . . .
Power outlet 137 . . . . . . . . . . . . . . . . . . . . . . . . .
Power rear view mirror control 75 . . . . . . . . . .
Power steering
Fluid level 229 . . . . . . . . . . . . . . . . . . . . . . . . .
Power window switches 19 . . . . . . . . . . . . . . . . Preloaders (seat belt pretensioners) 48
. . . . .
Pretensioners (seat belt pretensioners) 48 . . . . . . . . . . . . .
R
Radiator
Checking the radiator 228 . . . . . . . . . . . . . . .
Coolant, Engine 227 . . . . . . . . . . . . . . . . . . . .
Radio 110 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear cup holder 143 . . . . . . . . . . . . . . . . . . . . . .
Rear seats 30 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear view mirror
Antiglare inside 76 . . . . . . . . . . . . . . . . . . . .
Rear view mirrors
Folding 75 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Outside 74 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power 75 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear window and outside rear view mirror defogger switch 85 . . . . . . . . . . . . . . .
Rear window wiper and washer switch 84 . . . . . . . . . . . . . . . . . . . . . .
Reporting safety defects for U.S. owners 262 . . . . . . . . . . . . . . . . . . . . . . .
Roof luggage carrier 150 . . . . . . . . . . . . . . . . . .
S
Seat adjustment precautions
Front seats 28 . . . . . . . . . . . . . . . . . . . . . . . . .
Seat belt extender 46 . . . . . . . . . . . . . . . . . . . . .
Seat belts
Cleaning 209 . . . . . . . . . . . . . . . . . . . . . . . . . .
Fastening 40 . . . . . . . . . . . . . . . . . . . . . . . . . .

’02 Rav4_U (L/O 0108)
2702002 MY RAV4_U (OM42503U)
Seat belt precautions40
. . . . . . . . . . . . . . . .
Seat belt pretensioners 48
. . . . . . . . . . . . . .
Seats 28
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Separation net 147
. . . . . . . . . . . . . . . . . . . . . . .
Service and maintenance 212
. . . . . . . . . . . . .
Side door locks 12
. . . . . . . . . . . . . . . . . . . . . . .
Side doors 12
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Side vents 134
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Spare fuse 242
. . . . . . . . . . . . . . . . . . . . . . . . . .
Spare tire 190
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Spark plugs
Iridiumtipped spark plugs 160
. . . . . . . . . .
Specifications 254
. . . . . . . . . . . . . . . . . . . . . . .
SRS driver airbag and front passenger airbag 50
. . . . . . . . . . . . . . . . . . .
SRS warning light 90
. . . . . . . . . . . . . . . . . . . . .
Starting
Cold weather 170
. . . . . . . . . . . . . . . . . . . . . .
Engine 170
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Jump starting 185
. . . . . . . . . . . . . . . . . . . . . .
Steering
Tilt steering wheel 74
. . . . . . . . . . . . . . . . . . .
Steering column
Column lock 98
. . . . . . . . . . . . . . . . . . . . . . . .
Sun visors 76
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Suspension and chassis 167
. . . . . . . . . . . . . .
Switch
Emergency flasher 81
. . . . . . . . . . . . . . . . . .
Headlight, dimmer and turn signal 80 . . . . .
Ignition 98
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Outside rear view mirror defogger 85 . . . . .
Overdrive 99
. . . . . . . . . . . . . . . . . . . . . . . . . .
Rear window defogger 85
. . . . . . . . . . . . . . .
Rear window wiper and washer 84 . . . . . . .
Windshield wiper and washer 84
. . . . . . . . . T
Tachometer 89
. . . . . . . . . . . . . . . . . . . . . . . . . .
Theft prevention labels 167
. . . . . . . . . . . . . . .
Threeway catalytic converter 158
. . . . . . . . .
Tiedown hooks 145
. . . . . . . . . . . . . . . . . . . . .
Tilt steering wheel 74
. . . . . . . . . . . . . . . . . . . . .
Tires
Changing 189
. . . . . . . . . . . . . . . . . . . . . . . . . .
Flat tire 189
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Rotation 234
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Spare 190
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tire information 231,232,234,236 . . . . . . . .
Tools 190
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
To w i n g
Dinghy towing 174,175
. . . . . . . . . . . . . . . . .
Emergency towing 200
. . . . . . . . . . . . . . . . .
Emergency towing eyelet precautions 201
. . . . . . . . . . . . . . . .
If your vehicle needs to be towed 198 . . . . .
Tips for towing a stuck vehicle 202 . . . . . . .
Trailer 176
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Trailer towing 176
. . . . . . . . . . . . . . . . . . . . . . . .
Trip meter 89
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Turn signals 80
. . . . . . . . . . . . . . . . . . . . . . . . . .
Types of tires 167
. . . . . . . . . . . . . . . . . . . . . . . .
U
Uniform tire quality grading 262
. . . . . . . . . . . .
V
Vanity mirrors 77
. . . . . . . . . . . . . . . . . . . . . . . . .
W
Washer fluid
Adding washer fluid 243 . . . . . . . . . . . . . . . .
Washing and waxing 207 . . . . . . . . . . . . . . . . . .
Wheels
Aluminum wheel 237 . . . . . . . . . . . . . . . . . . .
Windshield wiper and washer switch 84 . . . . .
Winter driving tips 173 . . . . . . . . . . . . . . . . . . . .
Wireless remote control 15,203 . . . . . . . . . . . .

’02 Rav4_U (L/O 0108)
2002 MY RAV4_U (OM42503U)
Publication No. OM42503U
Part No. 01999-42503
Printed in Japan 01-0108-00
I

( U)
Quick index
If a service reminder indicator or warning buzzer comes on 90 . . . . . . . . .
 If your vehicle will not start 184 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. .
 If your engine stalls while driving 188 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
 If your vehicle overheats 188 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . .
 If you have a flat tire 189 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . . .
 If your vehicle needs to be towed 198 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
 Tips for driving during breakin period 155 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
 How to start the engine 170 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . .
 General maintenance 213 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . . . .
 Complete index 265 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . . . . . . . . .
Gas station information
Fuel type:
UNLEADED gasoline, Octane Rating 87 (Research Octane Number 91)
or higher
See page 155 for detailed information.
Fuel tank capacity:
56 L (14.8 gal., 12.3 lmp. gal.)
Engine oil:
API grade SJ “EnergyConserving”, SL “EnergyConserving” or ILSAC
multigrade engine oil is recommended.
See page 226 for detailed information.
Tire information: See pages 231 through 237.
Tire pressure: See page 257.
\fU8