stop start TOYOTA SIENNA HYBRID 2021 (in English) Repair Manual

4807-2. Steps to take in an emergency
ing the power switch to OFF with the
shift lever in any position other than
P.
Shift the shift lever to P.
■If “Shift Is in N Release Acceler-
ator Before Shifting” is shown
Message is displayed when the
accelerator pedal has been
depressed and the shift lever is in N.
Release the accelerator pedal and
shift the shift lever to D or R.
■If “Accelerator Pedal is
Pressed” is displayed
The accelerator pedal has been
depressed when the shift lever is in
P. Release the accelerator pedal.
■If “Press Brake When Vehicle Is
Stopped Hybrid System May
Overheat” is shown
Message is displayed when the
accelerator pedal is depressed to
maintain the vehicle position when
stopped on a upward slope, etc.
If this continues, the hybrid system
may overheat.
Release the accelerator pedal and
depress the brake pedal.
■If “Auto Power Off to Conserve
Battery” is shown
Power was turned off due to the
automatic power off function.
Next time when starting the hybrid
system, operate th e hybrid system
for approximatel y 5 minutes to
recharge the 12-volt battery.
■If “High Power Consumption
Power to Climate Temporarily
Limited” is displayed
Turn off unnecessary electronic
equipment to reduce power con-
sumption.
Please wait until th e power supply
returns to normal.
■If “Headlight System Malfunc-
tion Visit Your D ealer” is dis-
played
The following systems may be mal- functioning.
Have the vehicle inspected by your
Toyota dealer immediately.
●The LED headlight system
●Automatic High Beam
■If “Radar Cruise Control
Unavailable” is shown
The dynamic radar cruise control
with full-speed range system is sus-
pended temporarily or until the prob-
lem shown in the message is
resolved. (causes and coping meth-
ods: P.265)
■If a message that indicates the
malfunction of front camera is
displayed
The following systems may be sus-
pended until the problem shown in
the message is resolved. (P.265,
466)
●PCS (Pre-Collision System)
●LTA (Lane Tracing Assist)
●Automatic High Beam
●RSA (Road Sign Assist) (if
equipped)
●Dynamic radar cruise control with
full-speed range
■If “Oil Maintenance Required
Soon” is displayed
Indicates that the engine oil should
be scheduled to be changed.
Check the engine oil and change it if
necessary.
After changing the engine oil, make
sure to reset t he message.
(  P.418)
■If “Oil Maintenance Required
Visit Your Deale r” is displayed
Indicates that the engine oil should
be changed.
Check and change the engine oil
and oil filter by yo ur Toyota dealer.
After changing the engine oil, make
sure to reset t he message.
(  P.418)

5057-2. Steps to take in an emergency
7
When trouble arises
1Ensure that the shift lever is
in P and depress the brake
pedal.
2 Touch the electronic key to
the power switch as shown in
the illustration.
When the electronic key is
detected, a buzzer sounds and the
power switch will turn to ON.
When the smart key system is
deactivated in customization set-
ting, the power switch will turn to
ACC.
3Firmly depress the brake
pedal and check that is displayed on the multi-infor-
mation display.
4 Press the power switch
shortly and firmly.
In the event that t he hybrid system
still cannot be started, contact your
Toyota dealer.
■Stopping the hybrid system
Shift the shift lever to P, set the
parking brake and press the power
switch as you normally do when
stopping the hybrid system.
■Replacing the key battery
As the above proce dure is a tempo-
rary measure, it is recommended
that the electronic key battery be
replaced immediately when the bat-
tery is depleted. ( P.447)
■Changing power switch modes
Release the brake pedal and press
the power switch in step 3 above.
The hybrid system does not start
and modes will be changed each
time the switch is pressed.
(  P.234)
WARNING
■When using the mechanical
key and operating the power
windows or the moon roof (if
equipped)
Operate the power window or the
moon roof after checking to make
sure that there is n o possibility of
any passenger having any of their
body parts caught in the window
or the moon roof. Also, do not
allow children to operate the
mechanical key. It is possible for
children and other passengers to
get caught in the power window or
the moon roof.
Starting the hybrid sys-
tem

5127-2. Steps to take in an emergency
“LOW” line
5 Add coolant if necessary.
Water can be us ed in an emer-
gency if engine coolant is unavail-
able.
6 Start the hybrid system and
turn the air conditioning sys-
tem on to check that the radi-
ator cooling fan operates and
to check for coolant leaks
from the radiator or hoses.
The fan operates when the air con-
ditioning system is turned on imme-
diately after a cold start. Confirm
that the fan is op erating by check-
ing the fan sound and air flow. If it is
difficult to check th ese, turn the air
conditioning system on and off
repeatedly. (The f an may not oper-
ate in freezing temperatures.)
7 If the fan is not operating:
Stop the hybrid system
immediately and contact your
Toyota dealer.
If the fan is operating:
Have the vehicle inspected at
the nearest Toyota dealer.
8 Check if “Engine Coolant
Temp High Stop in a Safe
Place See Owner’s Manual”
is shown on the multi-infor-
mation display.
If the message does not disappear:
Stop the hybrid system and contact
your Toyota dealer.
If the message is not displayed:
Have the vehicle inspected at the
nearest Toyota dealer.
■If “Hybrid System Over-
heated Output Power
Reduced” is shown on the
multi-information display
1 Stop the vehicle in a safe
place.
2 Stop the hybrid system and
carefully lift the hood.
3 After the hybrid system has
cooled down, inspect the
hoses and radiator core (radi-
ator) for any leaks.
Radiator
Cooling fan
If a large amount of coolant leaks,
immediately contact your Toyota
dealer.
4The coolant level is satisfac-
tory if it is between the
C
A
B

5137-2. Steps to take in an emergency
7
When trouble arises
“FULL” and “LOW” lines on
the reservoir.
Reservoir
“FULL” line
“LOW” line
5 Add coolant if necessary.
Water can be used in an emer-
gency if power control unit coolant
is unavailable.
6After stopping the hybrid sys-
tem and waiting for 5 minutes
or more, start the hybrid sys-
tem again and check for the
multi-information display.
If the message does not disappear:
Stop the hybrid system and contact
your Toyota dealer.
If the message is not displayed:
The hybrid system temperature has
dropped and the vehicle may be
driven normally.
However, if the message appears
again frequently, contact your Toyota dealer.
A
B
C
WARNING
■When inspecting under the
hood of your vehicle
Observe the following precau-
tions.
Failure to do so may result in seri-
ous injury such as burns.
●If steam is seen coming from
under the hood, do not open the
hood until the steam has sub-
sided. The engine compart-
ment may be very hot.
●After the hybrid system has
been turned off , check that the
“READY” indicator is off.
When the hybrid system is oper-
ating, the gasoline engine may
automatically start, or the cool-
ing fan may suddenly operate
even if the gasoline engine
stops. Do not touch or approach
rotating parts such as the fan,
which may lead to fingers or
clothing (especially a tie, a scarf
or a muffler) getting caught,
resulting in serious injury.
●Do not loosen the coolant reser-
voir cap while the hybrid system
and radiator are hot.
High temperature steam or
coolant could spray out.
NOTICE
■When adding engine/power
control unit coolant
Add coolant slowly after the
hybrid system has cooled down
sufficiently. Adding cool coolant to
a hot hybrid system too quickly
can cause damage to the hybrid
system.

5147-2. Steps to take in an emergency
1Stop the hybrid system. Set
the parking brake and shift
the shift lever to P.
2 Remove the mud, snow or
sand from around the stuck
tire.
3 Place wood, stones or some
other material to help provide
traction under the tires.
4 Restart the hybrid system
5 Shift the shift lever to D or R
and release the parking
brake. Then, while exercising
caution, depress the acceler-
ator pedal.
■When it is difficult to free the
vehicle
Press to turn off TRAC.
(  P.336)
NOTICE
■To prevent damage to the
cooling system
Observe the following precau-
tions:
●Avoid contaminating the coolant
with foreign matter (such as
sand or dust, etc.).
●Do not use any coolant additive.
If the vehicle becomes
stuck
Carry out the following pro-
cedures if the tires spin or
the vehicle becomes stuck
in mud, dirt or snow:
Recovering procedure

569What to do if... (Troubleshooting)
weak or depleted?
In this case, the hybrid sys-
tem can be started in a tem-
porary way. (P.505)
 Is the 12-volt battery dis-
charged? ( P.506)
 Is the power switch in ON?
If you cannot release the shift
lever by depressing the brake
pedal with the power switch in
ON ( P.240)
 It is locked automatically to
prevent theft of the vehicle.
( P.232)
 Is the window lock switch
pressed?
The power window except for
the one at the driver’s seat
cannot be operated if the win-
dow lock switch is pressed.
( P.203)
 The auto power off function
will be operated if the vehicle is left in ACC or ON (the
hybrid system is not operat-
ing) for a period of time.
(
P.235)
 The seat belt reminder light is
flashing
Are the driver and the passengers
wearing the seat belts? (
P.473)
The parking brake indicator is
on
Is the parking br ake released?
( 
P.243)
Depending on the situation,
other types of warning buzzer
may also sound. ( P.466, 477)
 Did anyone inside the vehicle
open a door during setting the
alarm?
The sensor detects it and the
alarm sounds. ( P.89)
To stop the alarm, turn the power
switch to ON or start the hybrid sys-
tem.
 Is the message displayed on
the multi-information display?
Check the message on the
The shift lever cannot be
shifted from P even if you
depress the brake pedal
The steering wheel can-
not be turned after the
hybrid system is stopped
The windows do not open
or close by operating the
power window switches
The power switch is
turned off automatically
A warning buzzer sounds
during driving
An alarm is activated and
the horn sounds (if
equipped)
A warning buzzer sounds
when leaving the vehicle

574Alphabetical Index
tion display ........................... 110
Dynamic radar cruise control with full-speed rangeFunction ............................... 288
Warning message ................ 477
E
ECB (Electronically Controlled Brake System) ...................... 335
Eco drive mode ...................... 333
EDR (Event data recorder)......... 8
E-Four (Electronic On-Demand AWD system) ........................ 336
Elapsed time ........................... 111
Electric motor Location.................................. 79
Specification ......................... 520
Electric Power Steering (EPS) Function ............................... 336
Warning light ........................ 468
Electronically Controlled Brake System (ECB) ....................... 335
Electronic key Battery-saving function......... 165
If the electronic key does not operate properly ................. 504
Replacing the battery ........... 447
Emergency, in case of If a warning buzzer sounds .. 466
If a warning light turns on ..... 466
If a warning message is dis-played................................. 477
If the 12-volt battery is dis- charged .............................. 506
If the electronic key does not operate properly ................. 504
If the fuel filler door cannot be opened ............................... 503
If the hybrid sy stem will not start
........................................... 501
If the vehicle is trapped in rising water .................................. 460 If you have a flat tire .....481, 491
If you lose your keys.............502
If you think something is wrong
...........................................465
If your vehicle becomes stuck ...........................................514
If your vehicle has to be stopped in an emergency .................459
If your vehicle needs to be towed ...........................................462
If your vehicle ove rheats ......511
Emergency flashers ...............458
Energy monitor .......................122
Engine Compartment........................416
Hood .....................................413
Identification number ............520
Engine coolant Capacity ...............................522
Checking ..............................419
Preparing and checking before winter ..................................343
Warning light ........................467
Engine coolant temperature gauge ...............................97, 101
Engine oil Capacity ...............................521
Checking ..............................416
Preparing and checking before winter ..................................343
Warning light ........................467
Engine oil maintenance data .418
Enhanced Vehicle Stability Con- trol (Enhanced VSC ) .............335
Enhanced VSC (Enhanced Vehi- cle Stability Control).............335
EPS (Electric Po wer Steering)
Function................................336
Warning light ........................468
EV drive mode.........................236
Event data recorder (EDR) .........8
EV indicator...............................80

576Alphabetical Index
Heated steering wheel ........... 361
HeatersFront automatic air conditioning system ................................ 348
Heated steering wheel ......... 361
Outside rear view mirrors ..... 350
Rear automatic air conditioning system ................................ 358
Seat heaters ......................... 361
High mounted stoplight Replacing light bulbs ............ 451
Hill-start assist control .......... 335
Hood ........................................ 413
Hooks Cargo hooks ......................... 372
Coat hooks ........................... 388
Grocery bag hooks ............... 387
Retaining hooks (floor mat) .... 32
Horn ......................................... 186
Hybrid battery (tr action battery)
Location.................................. 83
Specification ......................... 521
Hybrid battery (traction battery) air intake vents ............... 85, 443
Hybrid battery (traction battery) air intake vents and filters ... 443
Hybrid battery air vent ............. 85
Hybrid system .......................... 79 ACC...................................... 234
Acoustic Vehicle Alerting System............................................. 81
Emergency shut off system .... 86
Energy monitor/consumption screen ................................ 122
EV drive mode...................... 236
High voltage components....... 83
How to start the hybrid system ........................................... 231
Hybrid battery (traction battery) air vents.............................. 443
Hybrid System In dicator . 97, 101
Hybrid system precautions ..... 83 Hybrid vehicle dri
ving tips .....341
If the hybrid sys tem will not start
...........................................501
If your vehicle has to be stopped in an emergency .................459
Ignition switch (power switch) ...........................................231
Overheating ..........................511
Power (ignition) switch .........231
Regenerative braking .............80
Starting the hybrid system ....231
Hybrid System Indicator ..................98, 102, 121
Hybrid transmissio n ...............238
S mode .................................241
I
I/M test .....................................410
Identification Engine ..................................520
Vehicle..................................519
Ignition switch (power switch) ...............................................231Auto power off fun ction.........235
Changing the power switch modes.................................234
If your vehicle has to be stopped in an emergency .................459
Starting the hybrid system ....231
Immobilizer system ..................88
Indicators ..................................95
Initialization Items to initialize ...................554
Oil maintenance ...................418
Tire pressure warning system...........................................430
Inside rear view m irror ...186, 188
Instrument panel light control .............................99, 103
Interior lights...........................363 Switch ...................................364
Wattage ................................526

Alphabetical Index581
Digital Rear-view Mirror........ 192
Inside rear view mirror.......... 187
Intuitive parking assist .......... 308
LTA (Lane Tracing Assist).... 275
Parking Support Brake function (rear-crossing vehicles) ...... 301
Parking Support Brake function (static objects) .................... 308
Rain-sensing windshield wipers ........................................... 256
RCTA ................................... 301
Toyota Safety Sense ............ 262
Service plug .............................. 83
Shift lever ................................ 238 If the shift lever cannot be shifted from P................................. 240
Shift lock system .................... 240
Shopping bag hooks .............. 387
Side airbags .............................. 41
Side auxiliary box ................... 372
Side marker lights Light switch .......................... 248
Replacing light bulbs ............ 451
Side mirrors ............................ 198 Adjustment ........................... 198
BSM (Blind Spot Monitor)..... 300
Folding ................................. 199
Heaters................................. 350
Linked mirror function when reversing ............................ 199
Side turn signal lights Replacing light bulbs ............ 451
Turn signal lever................... 242
Side windows ...... ................... 201
Sliding doors Canceling the power sliding door system ................................ 148
Hands Free Power Sliding doors
........................................... 141
Keyless entry........................ 138
Power sliding doors .............. 137
Sliding door child -protectors. 142 Wireless remote control........139
Smart key system ...................164 Antenna location...................164
Entry functions......132, 138, 151
Starting the hybrid system ....231
Warning message . ...............477
Snow tires ...............................343
Spare tire Storage location ...................492
Specifications .........................518
Speedometer .....................97, 101
Sport mode..............................333
Steering lock Column lock releas e .............232
Steering lock system warning message .............................232
Steering wheel Adjustment ...........................185
Heated steering wheel..........361
Meter control switches..........105
Stop lights Replacing light bulbs ............451
Storage feature .. .....................366
Storage precaution s ...............367
Stuck If the vehicle becomes stuck 514
Suggestion functi on ...............117
Sunglass holder.... ..................370
Sunshade ........................204, 385
Sunshades ..............................385
Sun visors ...............................374
Switches “ODO TRIP”switch ..........99, 103
“SOS” button ..........................75
Automatic High Beam switch 250
Brake hold switch .................246
BSM (Blind Spot M onitor) .....301
Digital Rear-view Mirror control switches..............................188
Door lock switch ...................135
Driving mode select switch ...333
Driving position memory