fuel TOYOTA TACOMA 2009 Warranties & Maintenance Guides (in English)

Basic Warranty
This warranty covers repairs and adjustments needed to correct defects
in materials or workmanship of any part supplied by Toyota, subject to
the exceptions indicated under “What Is Not Covered” on pages 11–12.
Coverage is for 36 months or 36,000 miles, whichever occurs first,
with the exception of wheel alignment and wheel balancing, which are
covered for 12 months or 20,000 miles, whichever occurs first.
Powertrain Warranty
This warranty covers repairs needed to correct defects in materials or
workmanship of any component listed in the next column and supplied
by Toyota, subject to the exceptions indicated under “What Is Not
Covered” on pages 11–12.
Coverage is for 60 months or 60,000 miles, whichever occurs first. Engine
Cylinder block and head and all internal parts, timing gears and gas-
kets, timing chain/belt and cover, flywheel, valve covers, oil pan, oil
pump, engine mounts, turbocharger housing and all internal parts,
supercharger housing and all internal parts, engine control computer,
water pump, fuel pump, seals and gaskets.
Transmission and Transaxle
Case and all internal parts, torque converter, clutch cover, transmission
mounts, transfer case and all internal parts, engine control computer,
seals and gaskets.
Front-Wheel-Drive System
Final drive housing and all internal parts, axle shafts, drive shafts,
constant velocity joints, front hub and bearings, seals and gaskets.
Rear-Wheel-Drive System
Axle housing and all internal parts, propeller shafts, U-joints, axle
shafts, drive shafts, bearings, supports, seals and gaskets.
WHAT IS COVERED AND HOW LONG
Your Warranties in Detail9
NEW VEHICLE LIMITED WARRANTY
09 Tacoma OWI-guts-b.cgla 4/9/08 9:18 PM Page 9

These warranty obligations do not apply to failures or noncompliance
caused by:
•The use of replacement parts not certified in accordance with
aftermarket parts certification regulations.
•The use of replacement parts not equivalent in quality or design
to original equipment parts.
Provisions under the “What Is Not Covered” section of the New Vehicle
Limited Warranty also apply to this warranty.
Air/Fuel Metering System
•
Air/fuel ratio feedback control system
•Cold-start enrichment system
•Deceleration control system
•Electronic fuel injection system components
– Airflow sensor
– Engine control module (8/80)
– Throttle body
– Other components
Air Induction System
•
Intake manifold and intake air surge tank
Catalyst System
•
Catalytic converter and protector (8/80)
•Constricted fuel filler neck
•Exhaust manifold
•Exhaust pipe (manifold to catalyst and/or catalyst to catalyst)
WHAT IS NOT COVERED WARRANTY PARTS LIST
Your Warranties in Detail15
FEDERAL EMISSION CONTROL WARRANTY
8/80 = Covered for eight years or 80,000 miles, whichever occurs first.
09 Tacoma OWI-guts-b.cgla 4/9/08 9:20 PM Page 15

Evaporative Control System
•
Charcoal canister
•Diaphragm valve
•Fuel filler cap
•Fuel tank
•Vapor liquid separator
Exhaust Gas Recirculation (EGR) System
•
EGR gas temperature sensor
•EGR valve
•Associated parts
Ignition System
•
Distributor and internal parts
•Ignition coil and ignitor
•Ignition wires
•Spark plugs*
Positive Crankcase Ventilation (PCV) System
•
Oil filler cap
•PCV valve or orifice
Other Parts Used in Above Systems
•
Data link connector (8/80)
•Hoses, clamps, fittings, tubing and mounting hardware
•Malfunction indicator light and bulb (8/80)
•Pulleys, belts and idlers
•Sealing gaskets and devices
•Sensors, solenoids, switches and valves
Your Warranties in Detail16
FEDERAL EMISSION CONTROL WARRANTY
*Warranted until first required maintenance under terms of the
California Emission Control Warranty.
8/80 = Covered for eight years or 80,000 miles, whichever occurs first.
09 Tacoma OWI-guts-b.cgla 4/9/08 9:21 PM Page 16

YOUR WARRANTY RIGHTS
AND OBLIGATIONS
Vehicles equipped with a California Certified Emission Control
System that are sold, registered and operated in California or
any state that adopts California emission warranty provisions
are covered by this warranty. Currently, Connecticut, Maine,
Massachusetts, New Jersey, Oregon, Pennsylvania, Rhode Island,
Vermont and Washington are the other states to which this war-
ranty applies. Vehicles covered by this warranty are also covered
by the Federal Emission Control Warranty (see page 14). The California Air Resources Board (CARB) and Toyota are pleased to
explain the emission control system warranty for your 2009 vehicle.
In California, new motor vehicles must be designed, built and equipped
to meet the state’s stringent anti-smog standards. CARB regulations
require that Toyota must warrant the emission control system on your
vehicle for the time periods indicated on the next page, provided there
has been no abuse, neglect or improper maintenance of your vehicle.
Your emission control system may include parts such as the fuel injec-
tion system, ignition system, catalytic converter and engine computer.
Also included may be hoses, belts, connectors and other emissions-
related assemblies.
Where a warrantable condition exists, Toyota will repair your vehicle at
no cost to you, including diagnosis, parts and labor.
Your Warranties in Detail20
CALIFORNIA EMISSION CONTROL WARRANTY
09 Tacoma OWI-guts-b.cgla 4/9/08 9:22 PM Page 20

WHAT IS NOT COVERED PARTS LIST: LONG-TERM EMISSION DEFECT WARRANTY
These warranty obligations do not apply to failures or noncompliance
caused by:
•The use of replacement parts not certified in accordance with
aftermarket parts certification regulations.
•The use of replacement parts not equivalent in quality or design
to original equipment parts.
Provisions under the “What Is Not Covered” section of the New Vehicle
Limited Warranty also apply to this warranty. The parts listed here are covered for seven years or 70,000 miles from
the vehicle’s in-service date, whichever occurs first.
Air/Fuel Metering System
•
Air pump on models equipped with 2TR-FE
•Engine control computer (engine control module)
•Throttle body
Air Induction System
•
Intake manifold and intake air surge tank
Catalyst System
•
Catalytic converter (warm-up three-way catalyst)
•Exhaust front pipe
•Exhaust front pipe no. 2 on models equipped with IGR-FE
•Exhaust manifold on models equipped with IGR-FE
Your Warranties in Detail22
CALIFORNIA EMISSION CONTROL WARRANTY
09 Tacoma OWI-guts-b.cgla 4/9/08 9:23 PM Page 22

Evaporative Control System
•
Fuel tank
Ignition System
•
Knock sensor on models equipped with IGR-FE You are responsible for performance of the required maintenance indi-
cated in the
Owner’s Manualand the Scheduled Maintenance Guide.
Toyota will not deny a warranty claim solely because you do not have
records to show that you maintained your vehicle. However, any failure
or noncompliance caused by lack of maintenance is not covered by this
warranty.
When maintenance and repairs are paid for by you, these services
may be performed by you or by any automotive service provider you
choose. Toyota will not deny a warranty claim solely because you
used a service provider other than a Toyota dealership for mainte-
nance and repairs. However, any failure or noncompliance caused by
improper maintenance or repairs is not covered by this warranty.
MAINTENANCE
Your Warranties in Detail23
CALIFORNIA EMISSION CONTROL WARRANTY
09 Tacoma OWI-guts-b.cgla 4/9/08 9:23 PM Page 23