fuel TOYOTA tC 2006 Warranties & Maintenance Guides (in English)

Basic Warranty
This warranty covers repairs and adjustments needed to correct
defects in materials or workmanship of any part supplied by
Scion, subject to the exceptions indicated under “What Is Not
Covered” on pages 11–12.
Coverage is for 36 months or 36,000 miles, whichever occurs
first, with the exception of wheel alignment and wheel balanc-
ing, which are covered for 12 months or 20,000 miles, whichever
occurs first.
Powertrain Warranty
This warranty covers repairs needed to correct defects in
materials or workmanship of any component listed in the next
column and supplied by Scion, subject to the exceptions indi-
cated under “What Is Not Covered” on pages 11–12.
Coverage is for 60 months or 60,000 miles, whichever occurs
first.
Engine
Cylinder block and head and all internal parts, timing gears
and gaskets, timing chain/belt and cover, flywheel, valve covers,
oil pan, oil pump, engine mounts, turbocharger housing and
all internal parts, supercharger housing and all internal parts,
engine control computer, water pump, fuel pump, seals and
gaskets.
Transmission and Transaxle
Case and all internal parts, torque converter, clutch cover,
transmission mounts, transfer case and all internal parts,
engine control computer, seals and gaskets.
Front-Wheel-Drive System
Final drive housing and all internal parts, axle shafts, drive
shafts, constant velocity joints, front hub and bearings, seals
and gaskets.
Rear-Wheel-Drive System
Axle housing and all internal parts, propeller shafts, U-joints,
axle shafts, drive shafts, bearings, supports, seals and gaskets.
WHAT IS COVERED AND HOW LONG
Your Warranties in Detail9
New Vehicle Limited Warranty ‹‹

These warranty obligations do not apply to failures or non-
compliance caused by:
›The use of replacement parts not certified in accordance
with aftermarket parts certification regulations.
›The use of replacement parts not equivalent in quality or
design to original equipment parts.
Provisions under the “What Is Not Covered” section of the New
Vehicle Limited Warranty also apply to this warranty.Air/Fuel Metering System
›Air/fuel ratio feedback control system
›Cold-start enrichment system
›Deceleration control system
›Electronic fuel injection system components
— Airflow sensor
— Engine control module (8/80)
— Throttle body
— Other components
Air Induction System
›Intake manifold and intake air surge tank
Catalyst System
›Catalytic converter and protector (8/80)
›Constricted fuel filler neck
›Exhaust manifold
›Exhaust pipe (manifold to catalyst and/or catalyst to catalyst)
WHAT IS NOT COVERED WARRANTY PARTS LIST
Your Warranties in Detail15
Federal Emission Control Warranty ‹‹
8/80 = Covered for eight years or 80,000 miles, whichever occurs first.

Evaporative Control System
›Charcoal canister
›Diaphragm valve
›Fuel filler cap
›Fuel tank
›Vapor liquid separator
Exhaust Gas Recirculation (EGR) System
›EGR gas temperature sensor
›EGR valve
›Associated parts
Ignition System
›Distributor and internal parts
›Ignition coil and ignitor
›Ignition wires
›Spark plugs*
Positive Crankcase Ventilation (PCV) System
›Oil filler cap
›PCV valve or orifice
Other Parts Used in Above Systems
›Data link connector (8/80)
›Hoses, clamps, fittings, tubing and mounting hardware
›Malfunction indicator light and bulb (8/80)
›Pulleys, belts and idlers
›Sealing gaskets and devices
›Sensors, solenoids, switches and valves
Your Warranties in Detail 16
›› Federal Emission Control Warranty
*Warranted until first required maintenance under terms of the
California Emission Control Warranty.
8/80 = Covered for eight years or 80,000 miles, whichever occurs first.

The California Air Resources Board (CARB) and Scion are
pleased to explain the emission control system warranty for
your 2006 vehicle. In California, new motor vehicles must be
designed, built and equipped to meet the state’s stringent anti-
smog standards. CARB regulations require that Scion must
warrant the emission control system on your vehicle for the
time periods indicated on this page, provided there has been
no abuse, neglect or improper maintenance of your vehicle.
Your emission control system may include parts such as the
fuel injection system, ignition system, catalytic converter and
engine computer. Also included may be hoses, belts, connectors
and other emissions-related assemblies.
Where a warrantable condition exists, Scion will repair your
vehicle at no cost to you, including diagnosis, parts and labor.1) For three years or 50,000 miles, whichever occurs first:
›If your vehicle fails a smog-check test, all necessary
repairs and adjustments will be made by Scion to ensure
that your vehicle passes the test. This is your Emission
Control System Performance Warranty.
›If any emissions-related part on your vehicle is defective,
the part will be repaired or replaced by Scion. This is your
Short-Term Emission Control System Defect Warranty.
Covered parts are listed on pages 15–16. Specific compo-
nents may have longer coverage under the terms of the
Powertrain Warranty.
2) For seven years or 70,000 miles, whichever occurs first:
›If an emissions-related part listed on page 22 is defective,
the part will be repaired or replaced by Scion. This is your
Long-Term Emission Control System Defect Warranty.
Your Warranties in Detail 20
›› California Emission Control Warranty
YOUR WARRANTY RIGHTS AND OBLIGATIONS MANUFACTURER’S WARRANTY COVERAGE

The parts listed here are covered for seven years or 70,000
miles from the vehicle’s in-service date, whichever occurs first.
Air/Fuel Metering System
›Engine control computer (engine control module)
›Throttle body
Air Induction System
›Intake manifold
Catalyst System
›Catalytic converter (warm-up three-way catalyst)
›Exhaust center pipe on tC
›Exhaust front pipe on xA and xB
›Exhaust manifold on tC
Evaporative Control System
›Fuel tankYou are responsible for performance of the required mainte-
nance indicated in the
Owner’s Manualand the Scheduled
Maintenance Guide
. Scion will not deny a warranty claim solely
because you do not have records to show that you maintained
your vehicle. However, any failure or noncompliance caused by
lack of maintenance is not covered by this warranty.
When maintenance and repairs are paid for by you, these
services may be performed by you or by any automotive
service provider you choose. Scion will not deny a warranty
claim solely because you used a service provider other
than an Authorized Servicing Dealership for maintenance
and repairs.
However, any failure or noncompliance caused
by improper maintenance or repairs is not covered by this
warranty.
Your Warranties in Detail 22
›› California Emission Control Warranty
PARTS LIST: LONG-TERM EMISSION
DEFECT WARRANTYMAINTENANCE