wheel TOYOTA TUNDRA 2000 Repair Manual

TUNDRA (34413U)
247
CAUTION

Do not exceed 50 km/h (30 mph) or
the chain manufacturer 's recom-
mended speed limit, whichever is
lower.

Drive carefully avoiding bumps,
holes, and sharp turns, which may
cause the vehicle to bounce.

Avoid sharp turns or locked- wheel
braking, as use of chains may ad-
versely affect vehicle handling.
Replacing wheels
WHEN TO REPLACE YOUR WHEELS
If you have wheel damage such as
bending, cracks or heavy corrosion, the
wheel should be replaced.
If you fail to replace damaged wheels, the
tire may slip off the wheel or they may
cause loss of handling control.
WHEEL SELECTION
When replacing wheels, care should be
taken to ensure that the wheels are re-
placed by ones with the same load ca-
pacity, diameter, rim width, and offset.
Correct replacement wheels are available
at your Toyota dealer.
A wheel of a different size or type may
adversely affect handling, wheel and bear-
ing life, brake cooling, speedometer/odom-
eter calibration, stopping ability, headlight
aim, bumper height, vehicle ground clear-
ance, and tire or snow chain clearance to
the body and chassis. Replacement with used wheels is not rec-
ommended as they may have been sub-
jected to rough treatment or high mileage
and could fail without warning. Also, bent
wheels which have been straightened may
have structural damage and therefore
should not be used. Never use an inner
tube in a leaking wheel which is designed
for a tubeless tire.
ProCarManuals.com

TUNDRA (34413U)
248
Aluminum wheel precautions

After driving your vehicle the first 1600
km (1000 miles), check that the wheel
nuts are tight.

If you have rotated, repaired, or
changed your tires, check that the
wheel nuts are still tight after driving
1600 km (1000 miles).

When using tire chains, be careful not
to damage the aluminum wheels.

Use only the Toyota wheel nuts and
wrench designed for your aluminum
wheels.

When balancing your wheels, use only
Toyota balance weights or equivalent
and a plastic or rubber hammer.

As with any wheel, periodically check
your aluminum wheels for damage. If
damaged, replace immediately.
ProCarManuals.com

TUNDRA (34413U)
261
Part 8
SPECIFICATIONS

Dimensions

Payload

Engine

Fuel

Service specifications

Ti r es

Fuses
Dimensions
TWO- WHEEL DRIVE MODELS
Standard cab models Access cab models
Overall length mm (in.)
Overall height
* 5mm (in.)
Front tread mm (in.)
Rear tread mm (in.) Overall width mm (in.)
Wheelbase mm (in.)5405 (212.8)
*
1
5525 (217.5)*25525 (217.5)
1910 (75.2)
1940 (76.4)
*3
2015 (79.3)*4
1800 (70.9)*6
1805 (71.1)*7
1810 (71.3)*8
1815 (71.5)*9
3260 (128.3)
1680 (66.1)
1648 (64.9)
1648 (64.9) 1680 (66.1)
3260 (128.3) 1800 (70.9) 1910 (75.2)
*
1: Without rear bumper*2: With rear bumper*3: With wheel arch moulding*4: With over fender*5: Unladen vehicle*6: With 2UZ- FE engine and
without P265 tires
*7: With 5VZ- FE engine and
without P265 tires
*8: With 2UZ- FE engine and
with P265 tires
*9: With 5VZ- FE engine and
with P265 tires
ProCarManuals.com

TUNDRA (34413U)
262
FOUR- WHEEL DRIVE MODELSStandard cab models Access cab models
Overall length mm (in.)
Overall height
* 5mm (in.)
Overall width mm (in.)
5405 (212.8)
*
1
5525 (217.5)*25525 (217.5)
1910 (75.2)
1940 (76.4)
*3
2015 (79.3)*4
1820 (71.7)*6
1825 (71.9)*7
1830 (72.0)*8
1835 (72.2)*9
1815 (71.5) 1910 (75.2)
1940 (76.4)
*3
* 1
: Without rear bumper*2: With rear bumper*3: With wheel arch moulding*4: With over fender*5: Unladen vehicle*6: With 2UZ- FE engine and
without P265 tires
*7: With 5VZ- FE engine and
without P265 tires
Front tread mm (in.)
Rear tread mm (in.)
Wheelbase
mm (in.) 3260 (128.3)
1675 (65.9)
1648 (64.9)
1648 (64.9) 1675 (65.9)
3260 (128.3)
*
8: With 2UZ- FE engine and
with P265 tires
*9: With 5VZ- FE engine and
with P265 tires
ProCarManuals.com

TUNDRA (34413U)
263
Payload*
U.S.A.kg (lb.)
Standard cab
5VZ- FE engineTwo- wheel drive modelsManual transmissionStandard grade773 (1705)
Automatic transmissionStandard grade753 (1661)
Four- wheel drive modelsManual transmissionSR5 grade651 (1436)
Automatic transmissionSR5 grade631 (1392)
2UZ- FE engineFour- wheel drive modelsAutomatic transmissionSR5 grade879 (1938)
Access cab5VZ- FE engineTwo- wheel drive modelsManual transmissionSR5 grade731 (1612)
Automatic transmissionSR5 grade710 (1567)
Limited grade653 (1441)
Four- wheel drive modelsManual transmissionSR5 grade762 (1680)
Automatic transmissionSR5 grade736 (1624)
Limited grade679 (1499)
2UZ- FE engineTwo- wheel drive modelsAutomatic transmissionSR5 grade872 (1924)
Limited grade815 (1798)
Four- wheel drive modelsAutomatic transmissionSR5 grade694 (1532)
Limited grade637 (1406)
ProCarManuals.com

TUNDRA (34413U)
264
Canadakg (lb.)
Standard cab
5VZ- FE engineTwo- wheel drive modelsManual transmissionStandard grade763 (1683)
Automatic transmissionStandard grade743 (1639)
Four- wheel drive modelsManual transmissionStandard grade653 (1440)
Automatic transmissionStandard grade633 (1396)
Access cab5VZ- FE engineTwo- wheel drive modelsAutomatic transmissionSR5 grade700 (1545)
Four- wheel drive modelsManual transmissionSR5 grade746 (1646)
Automatic transmissionSR5 grade726 (1602)
2UZ- FE engineTwo- wheel drive modelsAutomatic transmissionSR5 grade862 (1902)
Four- wheel drive modelsAutomatic transmissionSR5 grade684 (1509)
*: Occupants + luggage
ProCarManuals.com

TUNDRA (34413U)
266
Drive belt tension measured with Bor-
roughs drive belt tension gauge
No.BT- 33- 73F (used belt), lbf:5VZ- FE engineGenerator belt 100  20
Air conditioning compressor belt
100
+20
-10
Power steering pump belt100+20
-15
ENGINE LUBRICATION
Oil capacity (drain and ref ill), L (qt., Imp.
qt.):
5VZ- FE engineWith filter 5.2 (5.5, 4.6)
Without filter 4.9 (5.2, 4.3)
2UZ- FE engine With filter 6.1 (6.4, 5.4)
Without filter 5.7 (6.0, 5.0)
Oil grade: API grade SJ, Energy- Conservingº or
ILSAC multigrade engine oil is recom-
mended. Recommended oil viscosity (SAE):
COOLING SYSTEM
Total capacity, L (qt., Imp. qt.):
With manual transmission 10.0 (10.6, 8.8)
With automatic transmission 5VZ- FE engine 9.9 (10.5, 8.7)
2UZ- FE engine 11.6 (12.3, 10.2)
Coolant type: TOYOTA Long Life Coolantº or equiva-
lent
With ethylene- glycol type coolant for a
proper corrosion protection of aluminum
components
Do not use alcohol type antifreeze or
plain water alone. BATTERY
Open voltage
* at 20
5C (68 5F):
12.6Ð12.8 V Fully charged
12.2Ð12.4 V Half charged
11.8Ð12.0 V Discharged
*: Voltage that is checked 20 minutes af- ter the key is removed with all the
lights turned off
Charging rates: 5 A max.
CLUTCH
Pedal freeplay, mm (in.): 5Ð15 (0.2Ð0.6)
Fluid type: SAE J1703 or FMVSS No.116 DOT 3
MANUAL TRANSMISSION
Oil capacity, L (qt., Imp. qt.): Two- wheel drive models 2.6 (2.7, 2.3)
Four- wheel drive models 2.2 (2.3, 1.9)
Oil type: Gear oil API GL-4 or GL-5
Recommended oil viscosity: SAE 75W- 90
ProCarManuals.com

TUNDRA (34413U)
267
AUTOMATIC TRANSMISSION
Fluid capacity (drain and refill), L (qt.,
Imp. qt.):
Up to 2.0 (2.1, 1.8)
Fluid type: Automatic transmission fluid D- II or
DEXRON III (DEXRON II)
TRANSFER
Oil capacity, L (qt., Imp. qt.): 1.0 (1.1, 0.9)
Oil type: Gear oil API GL-4 or GL-5
Recommended oil viscosity: SAE 75W- 90
DIFFERENTIAL
Oil capacity, L (qt., Imp. qt.): Front 1.15 (1.2, 1.0)
RearTwo- wheel drive models 3.80 (4.0, 3.3)
Four- wheel drive models 3.50 (3.7, 3.1)Oil type:
Hypoid gear oil API GL- 5
Recommended oil viscosity:
Front SAE 75W- 90
Rear Above -18 5C (0 5F)
SAE 90
Below -18 5C (0 5F)
SAE 80W or 80W- 90
CHASSIS LUBRICATION
Propeller shafts: Spiders and slide yokesLithium base chassis grease, NLGI
No.2
Double cardan joint Molybdenum- disulfide lithium base
chassis grease, NLGI No.2
BRAKES
Minimum pedal clearance when depressed
with the pressure of 490 N (50 kgf, 110
lbf) with the engine running, mm (in.): 95 (3.7)
Pedal freeplay, mm (in.): 1Ð6 (0.04Ð0.24)
Pad wear limit, mm (in.): 1.0 (0.04) Lining wear limit, mm (in.):
1.0 (0.04)
Parking brake adjustment: Pedal typeÐwhen depressed with the
pressure of 294 N (30 kgf, 66.1 lbf)5Ð8 clicks
Lever typeÐwhen pulled with the force
of 196 N (20 kgf, 44 lbf) 4Ð12 clicks
Fluid type: SAE J1703 or FMVSS No.116 DOT 3
STEERING
Wheel freeplay: Less than 30 mm (1.2 in.)
Power steering fluid type: Automatic transmission fluid DEXRON II
or III
ProCarManuals.com

TUNDRA (34413U)
268
Tires
Tire size and pressure:
STANDARD CAB MODELS
Two- wheel drive modelsTire size
Tire pressure
kPa (kgf/cm2 or bar, psi)Wheel sizeTire size
FrontRear
Wheel size
P245/70R16180 (1.8, 26)240 (2.4, 35)16
7JJ
Four- wheel drive models
Tire size
Tire pressure
kPa (kgf/cm2 or bar, psi)Wheel sizeTire size
FrontRear
Wheel size
P245/70R16180 (1.8, 26)240 (2.4, 35)16
7JJ (J)
P265/70R16180 (1.8, 26)200 (2.0, 29)16
7JJ (J)
ProCarManuals.com

TUNDRA (34413U)
269
ACCESS CAB MODELS
Two- wheel drive modelsTire size
Tire pressure
kPa (kgf/cm2 or bar, psi)Wheel sizeTire size
FrontRear
Wheel size
P245/70R16180 (1.8, 26)240 (2.4, 35)16
7JJ (J)
P265/70R16180 (1.8, 26)200 (2.0, 29)16
7JJ (J)
Four- wheel drive models
Tire size
Tire pressure
kPa (kgf/cm2 or bar, psi)Wheel sizeTire size
FrontRear
Wheel size
P245/70R16180 (1.8, 26)240 (2.4, 35)16
7JJ (J)
P265/70R16180 (1.8, 26)200 (2.0, 29)16
7JJ (J)
P265/70R16
Off- road package180 (1.8, 26)200 (2.0, 29)16
7JJ
Wheel nut torque, N´m (kgf´m, ft´lbf):
110 (11.5, 83.2)
ProCarManuals.com