cooling TOYOTA VENZA 2013 Owners Manual (in English)

356 4-3. Do-it-yourself maintenance
VENZA_OM_OM73010U_(U)
CAUTION
■When working near the electric cooling fan or radiator grille
Vehicles with smart key system
Be sure the “ENGINE START STOP” switch is off. With the “ENGINE
START STOP” switch in IGNITION ON mode, the electric cooling fan may
automatically start to run if the air conditioning is on and/or if the coolant
temperature is high. ( P. 369)
Vehicles without smart key system
Be sure the engine switch is in the “LOCK” position. With the engine
switch in the “ON” position, the electric cooling fan may automati\
cally
start to run if the air conditioning is on and/or if the coolant temperature is
high. ( P. 369)
■ When working on or under the vehicle
Do not get under the vehicle with just the jack supporting it.
Always use automotive jack stands or other solid supports.
■ Safety glasses
Wear safety glasses to prevent flying or falling material, fluid spray, etc. from
getting in your eyes.
NOTICE
■If you remove the air cleaner filter
Driving with the air cleaner filter removed may cause excessive engine wear
due to dirt in the air. Also a backfire could cause a fire in the engine compart-
ment.

361
4-3. Do-it-yourself maintenance
4
Maintenance and care
VENZA_OM_OM73010U_(U)
Engine compar tment
2GR-FE engine
Engine coolant reservoir( P. 367)
Engine oil filler cap ( P. 365)
Engine oil level dipstick ( P. 363)
Brake fluid reservoir ( P. 370)Battery ( P. 372)
Fuse box ( P. 397)
Electric cooling fans
Condenser ( P. 369)
Radiator ( P. 369)
Washer fluid tank ( P. 375)

362 4-3. Do-it-yourself maintenance
VENZA_OM_OM73010U_(U)
1AR-FE engine
Engine coolant reservoir( P. 367)
Engine oil filler cap ( P. 365)
Engine oil level dipstick ( P. 363)
Brake fluid reservoir ( P. 370)Battery ( P. 372)
Fuse box ( P. 397)
Electric cooling fans
Condenser ( P. 369)
Radiator ( P. 369)
Washer fluid tank ( P. 375)

368 4-3. Do-it-yourself maintenance
VENZA_OM_OM73010U_(U)
■If the coolant level drops within a short time after replenishing
Visually check the radiator, hoses, reservoir cap, radiator cap, drain cock
and water pump.
If you cannot find a leak, have your Toyota dealer pressure test the cap and
check for leaks in the cooling system.
■ Coolant selection
Only use “Toyota Super Long Life Coolant” or similar high quality ethylene
glycol based non-silicate, non-amine, non-nitrite, and non-borate coolant
with long-life hybrid organic acid technology.
U.S.A.: “Toyota Super Long Life Coolant” is a mixture of 50% coolant and 50% deionized water. (Enabled: -31 F [-35 C])
Canada: “Toyota Super Long Life Coolant” is a mixture of 55% coolant and 45% deionized water. (Enabled: -44 F [-42 C])
For more details about engine coolant, contact your Toyota dealer.
CAUTION
■ When the engine is hot
Do not remove the radiator cap.
The cooling system may be under pressure and may spray hot coolant if the
cap is removed, causing serious injuries, such as burns.

369
4-3. Do-it-yourself maintenance
4
Maintenance and care
VENZA_OM_OM73010U_(U)
Radiator and condenser
Check the radiator and condenser and clear any foreign objects.
If either of the above parts are extremely dirty or you are not sure of
their condition, have your vehicl e checked by your Toyota dealer.
NOTICE
■When adding the engine coolant
Coolant is neither plain water nor stra ight antifreeze. The correct mixture of
water and antifreeze must be used to provide proper lubrication, corrosion
protection and cooling. Be sure to read the antifreeze or coolant label.
■ If you spill coolant
Be sure to wash it off with water to prevent it damage to parts or paint.
CAUTION
■When the engine is hot
Do not touch the radiator or condenser as they may be hot and cause seri-
ous injuries, such as burns.

400 4-3. Do-it-yourself maintenance
VENZA_OM_OM73010U_(U)
FuseAmpereCircuit
1MIRROR10 AOutside rear view mirrors
(driving position memory)
2DEICER20 AWindshield wiper de-icer
3INJ NO.115 A
Multiport fuel injection system/
sequential multiport fuel injection
system
4INJ NO.215 AIgniter system
5EFI NO.215 A
Multiport fuel injection system/
sequential multiport fuel injection
system
6EFI NO.310 A
Multiport fuel injection system/
sequential multiport fuel injection
system
7HEATER50 AAir conditioning system
8VSC NO.150 AAnti-lock brake system, vehicle
stability control system
9FA N M A I N*150 AElectric cooling fan
10VSC NO.230 AAnti-lock brake system, vehicle
stability control system
11CDS FAN*230 AElectric cooling fan
12RDI FAN*230 AElectric cooling fan
13LG/CLOSER30 APower back door
14RR DEF30 ARear window defogger
15ALT
140 A*3
or
120 A
*3
Charging system, HEATER,
ABS NO.1, FAN MAIN, ABS
NO.2, PBD, RR DEF, MIR HTR,
DEICER
16EPS80 AElectric power steering
17ST30 AStarting system
18BI-XENON10 ADischarge headlights
(high beam control)
19DOOR NO.120 APower door lock system
20STRG LOCK20 ASteering lock system
21SEC HORN7.5 ASEC HORN
22AM27.5 AMultiplex communication sys-
tem, starting system
23ALT-S7.5 ACharging system

470 5-2. Steps to take in an emergency
VENZA_OM_OM73010U_(U)
CAUTION
■Battery precautions
The battery contains poisonous and corrosive acidic electrolyte, while
related parts contain lead and lead compounds. Observe the following pre-
cautions when handling the battery:
● When working with the battery, always wear safety glasses and take care
not to allow any battery fluids (acid) to come into contact with skin, clothing
or the vehicle body.
● Do not lean over the battery.
● If the battery fluid comes into contact with the skin or eyes, immediately
wash the affected area with water and seek medical attention.
Place a wet sponge or cloth over the affected area until medical attention
can be received.
● Always wash your hands after handling the battery support, terminals, and
other battery-related parts.
● Do not allow children near the battery.
NOTICE
■When handling jumper cables
Be careful that the jumper cables do not become tangled in the cooling fan
or any of the belts when connecting or disconnecting them.

5
When trouble arises
471
5-2. Steps to take in an emergency
VENZA_OM_OM73010U_(U)
If your vehicle overheats
If your engine overheats:Stop the vehicle in a safe place and turn off the air condi-
tioning system.
Check to see if steam is coming out from under the hood.
If you see steam: Stop the engine. Carefully lift the hood after the steam
subsides and then restart the engine.
If you do not see steam: Leave the engine running and carefully lift the hood.
Check to see if the cooling fan is operating.
If the fan is operating: Wait until the engine coolant temperature gauge begins
to fall and then stop the engine.
If the fan is not operating: Stop the engine immediately and call your local Toyota
dealer.
STEP1
STEP2
STEP3

486 6-1. Specifications
VENZA_OM_OM73010U_(U)
Cooling system
Capacity
2GR-FE engineWith towing package: 10.9 qt. (10.3 L, 9.1 Imp.qt.)
Without towing package: 10.7 qt. (10.1 L, 8.9 Imp.qt.)
1AR-FE engine7.5 qt. (7.1 L, 6.2 Imp.qt.)
Coolant type
Use either of the following:• “Toyota Super Long Life Coolant”
• Similar high-quality ethylene glycol-based non-silicate, non-amine, non-nitrite, and non-borate
coolant with long-life hybrid organic acid technol-
ogy
Do not use plain water alone.

545
Alphabetical index
VENZA_OM_OM73010U_(U)
Care
Exterior ................................. 340
Interior .................................. 343
Seat belts ............................. 344
Cargo capacity ........................ 244
Cargo hooks ............................ 324
CD player
*
Chains ...................................... 253
Child-protectors ........................ 52
Child restraint system Booster seats, definition ....... 138
Booster seats, installation .... 144
Convertible seats, definition............................. 138
Convertible seats,
installation .......................... 144
Front passenger occupant classification system .......... 132
Infant seats, definition .......... 138
Infant seats, installation ........ 144
Installing child restraint system with lower
anchorages ........................ 145
Installing child restraint system with seatbelts ......... 148
Installing child restraint system with top straps ....... 153 Child safety
Airbag precautions ................126
Back door precautions ............61
Battery precautions .......374, 396
Child-protectors .......................52
Child restraint system............138
How your child should wear the seat belt ..........................82
Installing child restraints ........144
Moon roof precautions ..........101
Power window lock switch.......95
Power window precautions .....98
Removed key battery
precautions .........................396
Seat belt extender
precautions ...........................86
Seat belt precautions ..............83
Seat heater precautions ........319
Cleaning Exterior ..................................340
Interior ...................................343
Seat belts ..............................344
Clock .................................192, 204
Compass ...................................333
Condenser ................................369
Console box .............................305
Cooling system Engine overheating ...............471
Cruise control...........................227
Cup holders ..............................308
Curtain shield airbags .............117
Customizable features.............513
C
*: Refer to the “Navigation System Owner’s Manual” or “Display Audio System Owner’s Manual”.