radiator TOYOTA xB 2009 Owners Manual (in English)

199
4. Start your engine in the normal way.After starting, run it at about 2000 rpm
for several minutes with the accelerator
pedal lightly depressed.
5. Carefully disconnect the cables in the exact reverse order: the negative cable
and then the positive cable.
If the cause of your battery discharging is
not apparent (for example, lights left on),
you should have it checked at your Scion
dealer.
If the first start attempt is not success-
ful...
Check that the clamp on the jumper
cables are tight. Recharge the discharged
battery with the jumper cables connected
for several minutes and restart your en-
gine in the normal way.
If the another attempt is not successful,
the battery may be depleted. Have it
checked at your Scion dealer. If your engine stalls while driving...
1. Reduce your speed gradually, keeping a straight line. Move cautiously off the
road to a safe place.
2. Turn on your emergency flashers.
3. Try starting the engine again.
If the engine will not start, see “If your
vehicle will not start” on page 196.
CAUTION
If the engine is not running, the pow-
er assist for the brakes and steering
will not work so steering and braking
will be much harder than usual.
If your vehicle overheats
If your engine coolant temperature
gauge indicates overheating, if you ex-
perience a loss of power, or if you hear
a loud knocking or pinging noise, the
engine has probably overheated. You
should follow this procedure...
1. Pull safely off the road, stop the ve- hicle and turn on your emergency
flashers. Put the transmission in “P”
(automatic) or neutral (manual) and ap-
ply the parking brake. Turn off the air
conditioning if it is being used.
2. If coolant or steam is boiling out of the radiator or reservoir, stop the engine.
Wait until the steam subsides before
opening the hood. If there is no coolant
boiling over or steam, leave the engine
running and make sure the electric
cooling fan is operating. If it is not,
turn the engine switch off.
CAUTION
To help avoid personal injury, keep
the hood closed until there is no
steam. Escaping steam or coolant is
a sign of very high pressure.
If your engine stalls while
driving

200
3. Look for obvious coolant leaks from theradiator, hoses, and under the vehicle.
However, note that water draining from
the air conditioning is normal if it has
been used.
CAUTION
When the engine is running, keep
hands and clothing away from the
moving fan and engine drive belts.
4. If the coolant is leaking, stop the en-gine immediately. Call a Scion dealer
for assistance.
5. If there are no obvious leaks, check the coolant reservoir. If it is dry, add
coolant to the reservoir while the en-
gine is running. Fill it about half full.
CAUTION
Do not attempt to remove the radiator
cap when the engine and radiator are
hot. Serious injury could result from
scalding hot fluid and steam blown
out under pressure.
6. After the engine coolant temperaturehas cooled to normal, again check the
coolant level in the reservoir. If neces-
sary, bring it up to half full again. Seri-
ous coolant loss indicates a leak in the
system. You should have it checked as
soon as possible at your Scion dealer.
If you have a flat tire—
1. Reduce your speed gradually, keeping a straight line. Move cau-
tiously off the road to a safe place
well away from the traffic. Avoid
stopping on the center divider of
a highway. Park on a level spot
with firm ground.
2. Stop the engine and turn on your emergency flashers.
3. Firmly set the parking brake and put the transmission in “P” (auto-
matic) or reverse (manual).
4. Have everyone get out of the ve- hicle on the side away from traffic.
5. Read the following instructions thoroughly.

227
If you are a skilled do−it−yourself
mechanic, the Scion service manuals are
recommended. Please be aware that
do− it−yourself maintenance can affect your
warranty coverage. See “Owner ’s Warranty
Information Booklet” or “Owner ’s Manual
Supplement” for the details.
General maintenance
Listed below are the general maintenance
items that should be performed as fre-
quently as specified. In addition to check-
ing the items listed, if you notice any
unusual noise, smell or vibration, you
should investigate the cause or take your
vehicle to your Scion dealer or a qualified
service shop immediately. It is recom-
mended that any problem you notice be
brought to the attention of your dealer or
the qualified service shop for their advice.
CAUTION
Make these checks only with ade-
quate ventilation if you run the en-
gine.
IN THE ENGINE COMPARTMENT
Items listed below should be checked
from time to time, e.g. each time when
refueling.
Washer fluid
Make sure there is sufficient fluid in the
tank. See page 255 for additional informa-
tion. Engine coolant level
Make sure the coolant level is between
the “FULL” and “LOW” lines on the see
−
through reservoir when the engine is cold.
See page 242 for additional information.
Radiator, condenser and hoses
Check that the front of the radiator and
condenser are clean and not blocked with
leaves, dirt or insects. See page 242 for
additional information.
Battery electrolyte level
Your Scion has a maintenance free bat-
tery. You do not have to add distilled wa-
ter. For longer life of the battery, however,
see page 253 for additional information.
Brake fluid level
Make sure the brake fluid level is correct.
See page 243 for additional information.
Engine oil level
Check the level on the dipstick with the
engine turned off and the vehicle parked
on a level spot. See page 240 for addi-
tional information.

232
Engine compartment overview
1. Windshield washer fluid tank
2. Engine coolant reservoir
3. Engine oil filler cap
4. Engine oil level dipstick
5. Brake fluid reservoir
6. Fuse block
7. Battery
8. Electric cooling fans
9. Condenser
10. Radiator

234
CAUTION
When the engine is running, keep
hands, clothing, and tools away
from the moving fan and engine
drive belts. (Removing rings,
watches, and ties is advisable.)
Right after driving, the engine
compartment—the engine, radiator,
exhaust manifold and spark plug
boots, etc.—will be hot. So be care-
ful not to touch them. Oil, fluids
and spark plugs may also be hot.
If the engine is hot, do not remove
the radiator cap or loosen the drain
plugs to prevent burning yourself.
Do not leave anything that may
burn easily, such as paper or rags,
in the engine compartment.
Do not smoke, cause sparks or al-
low open flames around fuel or the
battery. Their fumes are flammable.
Be extremely cautious when work-
ing on the battery. It contains poi-
sonous and corrosive sulfuric acid.
Do not get under your vehicle with
just the body jack supporting it. Al-
ways use automotive jack stands or
other solid supports.
Be sure that the engine switch is
off if you work near the electric
cooling fans or radiator grille. With
the engine switch on, the electric
cooling fans will automatically start
to run if the engine coolant temper-
ature is high and/or the air condi-
tioning is on.
Use eye protection whenever you
work on or under your vehicle
where you may be exposed to flying
or falling material, fluid spray, etc.
Used engine oil contains potentially
harmful contaminants which may
cause skin disorders such as in-
flammation or skin cancer, so care
should be taken to avoid prolonged
and repeated contact with it. To re-
move used engine oil from your
skin, wash thoroughly with soap
and water.
Do not leave used oil within the
reach of children.
Dispose of used oil and filter only
in a safe and acceptable manner.
Do not dispose of used oil and fil-
ter in household trash, in sewers or
onto the ground. Call your dealer or
a service station for information
concerning recycling or disposal.
Take care when filling the brake and
clutch reservoirs because brake or
clutch fluid can harm your hands or
eyes. If fluid gets on your hands or
in your eyes, flush the affected area
with clean water immediately. If you
still feel uncomfortable with your
hands or eyes, go to the doctor.

235
NOTICE
Remember that battery and ignition
cables carry high currents or volt-
ages. Be careful of accidentally
causing a short circuit.
 Add only “Toyota Super Long Life
Coolant” or similar high quality eth-
ylene glycol based nonsilicate,
nonamine, nonnitrite, and nonbo-
rate coolant with longlife hybrid
organic acid technology to fill the
radiator. “Toyota Super Long Life
Coolant” is a mixture of 50% cool-
ant and 50% deionized water.
 If you spill some of the coolant, be
sure to wash it off with water to
prevent it from damaging the parts
or paint.
 Do not allow dirt or anything else
to fall through the spark plug holes.
 Use only spark plugs of the speci-
fied type. Using other types will
cause engine damage, loss of per-
formance or radio noise.
 Do not overfill automatic transmis-
sion fluid, or the transmission
could be damaged.
Do not drive with the air cleaner
filter removed, or excessive engine
wear could result. Also backfiring
could cause a fire in the engine
compartment.
 Be careful not to scratch the glass
surface with the wiper frame.
 When closing the hood, check to
see that you have not forgotten any
tools, rags, etc.
Parts and tools
Here is a list of parts and tools you will
need to perform do −it−yourself mainte-
nance. Remember all Scion parts are de-
signed in metric sizes, so your tools must
be metric.
CHECKING THE ENGINE OIL LEVEL
Parts (if level is low):
“Genuine Motor Oil” or equivalent. See
page 241 for details about engine oil
selection.
Tools:
Rag or paper towel
Funnel (only for adding oil)
CHECKING THE ENGINE COOLANT
LEVEL
Parts (if level is low):
“Toyota Super Long Life Coolant” or
similar high quality ethylene glycol
based non −silicate, non −amine, non− ni-
trite, and non −borate coolant with long −
life hybrid organic acid technology.
“Toyota Super Long Life Coolant” is a
mixture of 50% coolant and 50% deion-
ized water.
Tools:
Funnel (only for adding coolant)

239
DOITYOURSELF MAINTENANCE
Engine and Chassis
Checking the engine oil level240
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking the engine coolant level 242
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking the radiator and condenser 242
. . . . . . . . . . . . . . . . . . . . . . . . .
Checking brake fluid 243
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . .
Checking tire inflation pressure 243
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking and replacing tires 246
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rotating tires 248
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . .
Installing snow tires and chains 248
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacing wheels 250
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . .
SECTION 7 2

242
Look at the seethrough coolant reser-
voir when the engine is cold. The cool-
ant level is satisfactory if it is between
the “FULL” and “LOW” lines on the
reservoir. If the level is low, add the
coolant. (For the coolant type, see
“Coolant type selection” described be-
low.)
The coolant level in the reservoir will vary
with engine temperature. However, if the
level is on or below the “LOW” line, add
coolant. Bring the level up to the “FULL”
line.
If the coolant level drops within a short
time after replenishing, there may be a
leak in the system. Visually check the
radiator, hoses, engine coolant filler cap,
radiator cap and drain cock and water
pump.
If you can find no leak, have your Scion
dealer test the cap pressure and check
for leaks in the cooling system.
CAUTION
To prevent burning yourself, do not
remove the radiator cap when the en-
gine is hot.
Coolant type selection
Use of improper coolants may damage
your engine cooling system.
Only use “Toyota Super Long Life Coolant”
or similar high quality ethylene glycol
based non−silicate, non −amine, non −nitrite,
and non −borate coolant with long −life hy-
brid organic acid technology. (Coolant with
long− life hybrid organic acid technology is
a combination of low phosphates and or-
ganic acids.)
“Toyota Super Long Life Coolant” is a mix-
ture of 50% coolant and 50% deionized
water. This coolant provides protection
down to about –35 C (–31 F).
NOTICE
Do not use plain water alone.
Scion recommends “Toyota Super Long
Life Coolant”, which has been tested to
ensure that it will not cause corrosion nor
result in malfunction of your engine cool-
ant system with proper usage. “Toyota Su-
per Long Life Coolant” is formulated with
long− life hybrid organic acid technology
and has been specifically designed to
avoid engine cooling system malfunction
on Scion vehicles.
Please contact your Scion dealer for fur-
ther details. If either of the above parts are extremely
dirty or you are not sure of their condi-
tion, take your vehicle to a Scion dealer.
CAUTION
To prevent burning yourself, be care-
ful not to touch the radiator or con-
denser when the engine is hot.
NOTICE
To prevent damage to the radiator
and condenser, do not perform the
work by yourself.
Checking the engine coolant
level
Checking the radiator and
condenser

272
A
Adding washer fluid255
. . . . . . . . . . . . . . . .
Adjustment
Front seats 26
. . . . . . . . . . . . . . . . . . . . . . .
Seat belt 31
. . . . . . . . . . . . . . . . . . . . . . . . .
Air conditioning filters 136
. . . . . . . . . . . . . . .
Air conditioning system 130
. . . . . . . . . . . . .
Airbags 40
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Anti −glare inside rear view mirror 82 . . . . .
Anti −lock brake system
warning light 97
. . . . . . . . . . . . . . . . . . . . . .
Anti −theft steering column lock 108 . . . . . .
Appearance care Cleaning the interior 223
. . . . . . . . . . . . . .
Protecting your Scion from
corrosion 220
. . . . . . . . . . . . . . . . . . . . . .
Washing and waxing 221
. . . . . . . . . . . . . .
Automatic transmission
Driving with an automatic transmission 109
. . . . . . . . . . . . . . . . . . .
Shift lock override button 215
. . . . . . . . . .
Shift pattern 109
. . . . . . . . . . . . . . . . . . . . .
Shift speed 109
. . . . . . . . . . . . . . . . . . . . . .
AUX adapter 145
. . . . . . . . . . . . . . . . . . . . . . .
Auxiliary catch, Engine hood 21
. . . . . . . . .
B
Back door 20
. . . . . . . . . . . . . . . . . . . . . . . . . .
Back door lock 20
. . . . . . . . . . . . . . . . . . . . . .
Battery Checking battery condition 252 . . . . . . . .
Gas caution 252
. . . . . . . . . . . . . . . . . . . . .
Handling safety 252
. . . . . . . . . . . . . . . . . .
Recharging precautions 253
. . . . . . . . . . .
Winter driving tips 189
. . . . . . . . . . . . . . . .
Before starting the engine 186
. . . . . . . . . . .
Bottle holders 148
. . . . . . . . . . . . . . . . . . . . . .
Brake pad wear limit indicators 162 . . . . . .
Brake system 159
. . . . . . . . . . . . . . . . . . . . . .
Brake system warning light 97
. . . . . . . . . .
Brakes
Fluid level 243
. . . . . . . . . . . . . . . . . . . . . . .
Pad wear indicators 162
. . . . . . . . . . . . . .
Parking 124
. . . . . . . . . . . . . . . . . . . . . . . . .
Break −in tips 152
. . . . . . . . . . . . . . . . . . . . . .
Brightness control 88
. . . . . . . . . . . . . . . . . . .
C
Carbon monoxide caution 155
. . . . . . . . . . .
Cargo and luggage Capacity 179
. . . . . . . . . . . . . . . . . . . . . . . .
Distribution 180
. . . . . . . . . . . . . . . . . . . . . .
Stowage precautions 180
. . . . . . . . . . . . .
Certification label 162
. . . . . . . . . . . . . . . . . . Charging system warning light 97
. . . . . . . .
Checking and replacing fuses 254 . . . . . . . .
Checking and replacing tires 246 . . . . . . . .
Checking brake fluid 243
. . . . . . . . . . . . . . . .
Checking the engine oil level 240 . . . . . . . .
Checking the radiator and condenser 242
. . . . . . . . . . . . . . . . . . . . . . .
Child restraint Child restraint system 61
. . . . . . . . . . . . .
Installation 63
. . . . . . . . . . . . . . . . . . . . . . .
Precautions 60
. . . . . . . . . . . . . . . . . . . . . .
Types of child restraint system 62 . . . . . .
Cleaning the interior 223
. . . . . . . . . . . . . . . .
Clock 143
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cold weather Operation 189
. . . . . . . . . . . . .
Controls, Instrument panel 2
. . . . . . . . . . . .
Cooling system Coolant level 242
. . . . . . . . . . . . . . . . . . . .
Engine overheating 199
. . . . . . . . . . . . . . .
Radiator and reservoir 242
. . . . . . . . . . . .
Radiator cap 242
. . . . . . . . . . . . . . . . . . . . .
Winter driving tips 189
. . . . . . . . . . . . . . . .
Corrosion prevention 220
. . . . . . . . . . . . . . .
Cruise control 125
. . . . . . . . . . . . . . . . . . . . .
Cup holders 147
. . . . . . . . . . . . . . . . . . . . . . .

276
R
RadiatorCoolant, Engine 242 . . . . . . . . . . . . . . . . . .
Rear console box 147 . . . . . . . . . . . . . . . . . .
Rear seat Fold −down 29 . . . . . . . . . . . . . . . . . . . . . . .
Rear view mirror Inside rear view mirror 82 . . . . . . . . . . . . .
Outside rear view mirror 80 . . . . . . . . . . .
Rear window defogger switch 90 . . . . . . . . .
Rear window wiper and washer 90 . . . . . . .
Reporting safety defects
for U.S. owners 270 . . . . . . . . . . . . . . . . . .
S
Seat adjustment precautions
Front seats 26 . . . . . . . . . . . . . . . . . . . . . . .
Seat belt extender 35 . . . . . . . . . . . . . . . . . . .
Seat belt reminder buzzer 97 . . . . . . . . . . . .
Seat belt reminder light 97 . . . . . . . . . . . . . .
Seat belt pretensioner warning light 97 . . . . . . . . . . . . . . . . . . . . . .
Seat belts Cleaning 223 . . . . . . . . . . . . . . . . . . . . . . . .
Seat belt precautions 31 . . . . . . . . . . . . . .
Seat belt pretensioners 37 . . . . . . . . . . . .
Seating capacity 179 . . . . . . . . . . . . . . . . . . .
Seats 26 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Service and maintenance 226 . . . . . . . . . . .
Service reminder indicators 97 . . . . . . . . . . Side door locks 14
. . . . . . . . . . . . . . . . . . . . .
Side vents 136 . . . . . . . . . . . . . . . . . . . . . . . . .
Spare fuse 254 . . . . . . . . . . . . . . . . . . . . . . . .
Spare tire 203 . . . . . . . . . . . . . . . . . . . . . . . . .
Specifications 261 . . . . . . . . . . . . . . . . . . . . .
SRS driver and front passenger airbags 40 . . . . . . . . . . . .
SRS warning light 97 . . . . . . . . . . . . . . . . . . .
Starting Cold weather 186 . . . . . . . . . . . . . . . . . . . .
Engine 186 . . . . . . . . . . . . . . . . . . . . . . . . . .
Jump starting 197 . . . . . . . . . . . . . . . . . . . .
Starting a flooded engine 196 . . . . . . . . . . . .
Steering Tilt steering wheel 80
. . . . . . . . . . . . . . . . .
Steering column
Column lock 108
. . . . . . . . . . . . . . . . . . . . .
Suspension and chassis 164
. . . . . . . . . . . .
Switch
Emergency flasher 87
. . . . . . . . . . . . . . . .
Headlight, dimmer and turn signal 86
. . . . . . . . . . . . . . . . . . . . . .
Ignition 108
. . . . . . . . . . . . . . . . . . . . . . . . . .
Overdrive 109
. . . . . . . . . . . . . . . . . . . . . . .
Rear window defogger 90
. . . . . . . . . . . . .
Power window 18
. . . . . . . . . . . . . . . . . . . .
Windshield wiper and washer 89 . . . . . . .
T
Theft prevention labels 163
. . . . . . . . . . . . . .
Three −way catalytic converter 154 . . . . . . .
Tie −down hooks 149
. . . . . . . . . . . . . . . . . . . .
Tilt steering wheel 80
. . . . . . . . . . . . . . . . . . .
Tire pressure warning light 97, 118 . . . . . . .
Tire pressure warning system 118 . . . . . . .
Tires Changing 206
. . . . . . . . . . . . . . . . . . . . . . . .
Flat tire 200
. . . . . . . . . . . . . . . . . . . . . . . . .
Glossary 172
. . . . . . . . . . . . . . . . . . . . . . . .
Inflation pressure 243
. . . . . . . . . . . . . . . .
Replacing 246
. . . . . . . . . . . . . . . . . . . . . . .
Rotation 248
. . . . . . . . . . . . . . . . . . . . . . . . .
Size 169, 265
. . . . . . . . . . . . . . . . . . . . . . .
Snow tires and chains 248
. . . . . . . . . . . .
Spare 203
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Symbols 165
. . . . . . . . . . . . . . . . . . . . . . . .
Tire identification number (TIN) 168 . . . .
Tools 203
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Total load capacity 179
. . . . . . . . . . . . . . . . .
To w i n g Capacity 179
. . . . . . . . . . . . . . . . . . . . . . . .
Dinghy towing 190
. . . . . . . . . . . . . . . . . . .
Emergency towing 213
. . . . . . . . . . . . . . . .
If your vehicle needs to be
towed 211
. . . . . . . . . . . . . . . . . . . . . . . . .
Trailer 192
. . . . . . . . . . . . . . . . . . . . . . . . . .
Traction control system 114
. . . . . . . . . . . . .
Trailer towing 192
. . . . . . . . . . . . . . . . . . . . . .
Trip meter 95
. . . . . . . . . . . . . . . . . . . . . . . . . .
Turn signals 86
. . . . . . . . . . . . . . . . . . . . . . . .