steering TOYOTA YARIS 2017 Workshop Manual
[x] Cancel search | Manufacturer: TOYOTA, Model Year: 2017, Model line: YARIS, Model: TOYOTA YARIS 2017Pages: 549, PDF Size: 33.09 MB
Page 466 of 549

4668-2. Steps to take in an emergency
YARIS_F_OM_Europe_OM52J20E
WARNING
■When using the compact spare tire
● Remember that the compact spare tire provided is specifically designed
for use with your vehicle. Do not use your compact spare tire on another
vehicle.
● Do not use more than one compact spare tire simultaneously.
● Replace the compact spare tire with a standard tire as soon as possible.
● Avoid sudden acceleration, abrupt steering, sudden braking and shifting
operations that cause sudden engine braking.
■ When storing the compact spare tire
Be careful not to catch fingers or other body parts between the compact
spare tire and the body of the vehicle.
■ After using the tools and jack
Before driving, make sure all the tools and jack are securely in place in their
storage location to reduce the possibility of personal injury during a collision
or sudden braking.
■ When the compact spare tire is attached
The vehicle speed may not be correctly detected, and the following systems
may not operate correctly:
● ABS
● Brake assist
● VSC (if equipped)
● TRC (if equipped)
● PCS (Pre-Crash Safety system) (if equipped)
● LDA (Lane Departure Alert) (if equipped)
● Automatic High Beam (if equipped)
● Cruise control (if equipped)
● Navigation system (if equipped)
● EPS (Electric Power Steering)
■ Speed limit when using the compact spare tire
Do not drive at speeds in excess of 80 km/h (50 mph) when a compact
spare tire is installed on the vehicle.
The compact spare tire is not designed for driving at high speeds. Failure to
observe this precaution may lead to an accident causing death or serious
injury.
Page 481 of 549

4818-2. Steps to take in an emergency
8
When trouble arises
YARIS_F_OM_Europe_OM52J20E
WARNING
■Precautions for use of the sealant
● Ingesting the sealant is hazardous to your health. If you ingest sealant,
consume as much water as possible, and then immediately consult a doc-
tor.
● If sealant gets in eyes or adheres to skin, immediately wash it off with
water. If discomfort persists, consult a doctor.
■ When fixing the flat tire
● Stop your vehicle in a safe and flat area.
● Do not touch the wheels or the area around the brakes immediately after
the vehicle has been driven.
After the vehicle has been driven, the wheels and the area around the
brakes may be extremely hot. Touching these areas with hands, feet or
other body parts may result in burns.
● To avoid risk of burst or severe leakage, do not drop or damage the bottle.
Visually inspect the bottle before use. Do not use a bottle with shock,
crack, scratch, leakage or any other damage. In such case, immediately
replace.
● Connect the valve and hose securely with the tire installed on the vehicle.
If the hose is not properly connected to the valve, air leakage may occur
as sealant may be sprayed out.
● If the hose comes off the valve while inflating the tire, there is a risk that
the hose will move abruptly due to air pressure.
● After inflation of the tire has completed, the sealant may splatter when the
hose is disconnected or some air is let out of the tire.
● Follow the operation procedure to repair the tire. If the procedures not fol-
lowed, the sealant may spray out.
● Keep back from the tire while it is being repaired, as there is a chance of it
bursting while the repair operation is being performed. If you notice any
cracks or deformation of the tire, turn off the compressor switch and stop
the repair operation immediately.
● The repair kit may overheat if operated for a long period of time. Do not
operate the repair kit continuously for more than 40 minutes.
● Parts of the repair kit become hot during operation. Be careful when han-
dling the repair kit during and after operation. Do not touch the metal part
around the connecting area between the bottle and compressor. It will be
extremely hot.
● Do not attach the vehicle speed warning sticker to an area other than the
one indicated. If the sticker is attached to an area where an SRS airbag is
located, such as the pad of the steering wheel, it may prevent the SRS
airbag from operating properly.
Page 482 of 549

4828-2. Steps to take in an emergency
YARIS_F_OM_Europe_OM52J20E
WARNING
■Driving to spread the liquid sealant evenly
Observe the following precautions to reduce the risk of accidents.
Failing to do so may result in a loss of vehicle control and cause death or
serious injury.
● Drive the vehicle carefully at a low speed. Be especially careful when turn-
ing and cornering.
● If the vehicle does not drive straight or you feel a pull through the steering
wheel, stop the vehicle and check the following.
• Tire condition. The tire may have separated from the wheel.
• Tire inflation pressure. If the tire inflation pressure is 130 kPa (1.3 kgf/cm2
or bar, 19 psi) or less, the tire may be severely damaged.
Page 485 of 549

4858-2. Steps to take in an emergency
8
When trouble arises
YARIS_F_OM_Europe_OM52J20E
One of the following may be the cause of the problem:
● One or both of the battery terminals may be disconnected.
● The battery may be discharged. (P. 488)
● There may be a malfunction in the steering lock system (vehicles
with a smart entry & start system).
Contact any authorized Toyota dealer or repairer, or another duly qualified
and equipped professional, if the problem cannot be repaired, or if repair
procedures are unknown.
When the engine does not start, the following steps can be used as an
interim measure to start the engine if the engine switch is functioning
normally:
Set the parking brake.
Shift the shift lever to P (Multidrive) or N (manual transmission).
Turn the engine switch to ACCESSORY mode.
Press and hold the engine switch for about 15 seconds while
depressing the brake pedal (Multidrive) or brake pedal and clutch
pedal (manual transmission) firmly.
Even if the engine can be started using the above steps, the system
may be malfunctioning. Have the vehicle inspected by any authorized
Toyota dealer or repairer, or another duly qualified and equipped pro-
fessional.
The starter motor does not turn over, the interior lights and
headlights do not turn on, or the horn does not sound.
Emergency start function (vehicles with a smart entry & start
system)
1
2
3
4
Page 517 of 549

5179-1. Specifications
9
Vehicle specifications
YARIS_F_OM_Europe_OM52J20E
*1: Minimum pedal clearance when depressed with a force of 300 N (31.0 kgf,
67.4 lbf) while the engine is running
*2: Parking brake lever travel when pulled up with a force of 200 N (20.4 kgf,
45.0 lbf)
Brakes
Pedal clearance*164 mm (2.52 in.) Min.
Pedal free play1 — 6 mm (0.04 — 0.24 in.)
Parking brake lever travel*2
Rear drum brake
5 — 7 clicks
Rear disc brake
4 — 6 clicks
Fluid typeSAE J1704 or FMVSS No.116 DOT 4
Steering
Free playLess than 30 mm (1.2 in.)
Page 518 of 549

5189-1. Specifications
YARIS_F_OM_Europe_OM52J20E
14-inch tires (Type A)
14-inch tires (Type B)
15-inch tires (Type A)
*: For some models, ECO tire pressure is shown on the tire pressure label.
( P. 475)
“For optimizing fuel economy, ECO tire pressure is recommended.
Tire pressure affects traveling comfort, road noise and steering character-
istics.”
Tires and wheels
Tire size175/65R14 82T
Tire inflation pressure
(Recommended cold
tire inflation pressure)
220 kPa (2.2 kgf/cm2 or bar, 32 psi)
Wheel size14 5J
Wheel nut torque103 N·m (10.5 kgf·m, 76 ft·lbf)
Tire size175/70R14 84S
Tire inflation pressure
(Recommended cold
tire inflation pressure)
Front wheel
kPa (kgf/cm2 or bar, psi)
Rear wheel
kPa (kgf/cm2 or bar, psi)
250 (2.5, 36)240 (2.4, 35)
Wheel size14 5J
Wheel nut torque103 N·m (10.5 kgf·m, 76 ft·lbf)
Tire size175/65R15 84H
Tire inflation pressure
(Recommended cold
tire inflation pressure)
Front wheel
kPa (kgf/cm2 or bar, psi)
Rear wheel
kPa (kgf/cm2 or bar, psi)
Standard tire pressure:
230 (2.3, 33)
ECO tire pressure*:
250 (2.5, 36)
Standard tire pressure:
220 (2.2, 32)
ECO tire pressure*:
240 (2.4, 35)
Wheel size15 5J, 15 5 1/2J
Wheel nut torque103 N·m (10.5 kgf·m, 76 ft·lbf)
Page 531 of 549

531What to do if... (Troubleshooting)
YARIS_F_OM_Europe_OM52J20E
●Vehicles with a Multidrive:
Is the shift lever in P? ( P. 182)
●Vehicles with a manual transmission:
Did you turn the key while firmly depressing the clutch pedal? ( P. 182)
●Is the battery discharged? (P. 488)
●Vehicles with a Multidrive:
Did you press the engine switch while firmly depressing the brake pedal?
( P. 185)
●Vehicles with a manual transmission:
Did you press the engine switch while firmly depressing the clutch pedal?
( P. 185)
●Vehicles with a Multidrive:
Is the shift lever in P? ( P. 185)
●Is the electronic key anywhere detectable inside the vehicle? (P. 128)
●Is the steering wheel unlocked? (P. 188)
●Is the electronic key battery weak or depleted?
In this case, the engine can be started in a temporary way. ( P. 486)
●Is the battery discharged? (P. 488)
If you think something is wrong
The engine does not start
(vehicles without a smart entry & start system)
The engine does not start
(vehicles with a smart entry & start system)
Page 532 of 549

532What to do if... (Troubleshooting)
YARIS_F_OM_Europe_OM52J20E
●Vehicles without a smart entry & start system:
Is the engine switch in the “ON” position?
If you cannot release the shift lever by depressing the brake pedal with the
engine switch in the “ON” position. ( P. 195)
●Vehicles with a smart entry & start system:
Is the engine switch in IGNITION ON mode?
If you cannot release the shift lever by depressing the brake pedal with the
engine switch in IGNITION ON mode. ( P. 195)
●Vehicles without a smart entry & start system:
It is locked to prevent theft of the vehicle if the key is pulled from the engine
switch. ( P. 184)
●Vehicles with a smart entry & start system:
It is locked automatically to prevent theft of the vehicle. ( P. 188)
●Is the window lock switch pressed?
The power window except for the one at the driver’s seat cannot be oper-
ated if the window lock switch is pressed. ( P. 154)
●The auto power off function will be operated if the vehicle is left in ACCES-
SORY or IGNITION ON mode (the engine is not running) for a period of
time. ( P. 187)
The shift lever cannot be shifted from P even if you depress
the brake pedal (vehicles with a Multidrive)
The steering wheel cannot be turned after the engine is
stopped
The windows do not open or close by operating the power
window switches
The engine switch is turned off automatically
(vehicles with a smart entry & start system)
Page 534 of 549

534Alphabetical index
YARIS_F_OM_Europe_OM52J20E
Alphabetical index
A/C..................................... 312, 320
Air conditioning filter.............. 400
Automatic air conditioning
system ................................ 320
Manual air conditioning
system ................................ 312
ABS (Anti-lock Brake
System) .................................. 265
Function ................................ 265
Warning light ......................... 440
Air conditioning filter .............. 400
Air conditioning
system ............................ 312, 320
Air conditioning filter.............. 400
Automatic air conditioning
system ................................ 320
Manual air conditioning
system ................................ 312
Airbag manual on-off system ... 51
Airbags ....................................... 39
Airbag manual on-off
system .................................. 51
Airbag operating conditions .... 46
Airbag precautions for
your child .............................. 41
Airbag warning light .............. 440
Correct driving posture............ 30
Curtain shield airbag
operating conditions ............. 46
Curtain shield airbag
precautions ........................... 43
General airbag precautions..... 41
Locations of airbags................ 39
Modification and
disposal of airbags................ 45
Side airbag operating
conditions ............................. 46
Side airbag precautions .......... 43
Side and curtain shield
airbags operating
conditions ............................. 46
Side and curtain shield
airbags precautions .............. 43
SRS airbags............................ 39
Alarm
Warning buzzer..................... 439
Anchor brackets ........................ 69
Antenna
Radio ............................ 288, 350
Smart entry &
smart system ...................... 127
Anti-lock Brake System
(ABS) ...................................... 265
Function ................................ 265
Warning light ......................... 440
Armrest ..................................... 347
Ashtray ..................................... 344
Assist grips .............................. 348
Audio system (with a navigation/
multimedia system)*
Audio system
(without a navigation/
multimedia system)............... 278
CD player .............................. 289
iPod....................................... 297
MP3/WMA disc ..................... 289
Optimal use........................... 282
Radio .................................... 284
Steering wheel audio
switch ................................. 280
USB memory ........................ 304
USB port ............................... 281
A
Page 537 of 549

537Alphabetical index
YARIS_F_OM_Europe_OM52J20E
Daytime running light
system .................................... 207
Replacing light bulbs ............. 425
Defogger
Outside rear view
mirrors ........................ 314, 324
Rear window ................. 314, 324
Windshield .................... 314, 324
Diesel Particular Filter
system .................................... 270
Warning lights ....................... 444
Dimensions .............................. 502
Display
Drive information ..................... 93
Multi-information display ......... 92
Do-it-yourself maintenance .... 359
Door lock
Back door .............................. 121
Side doors ............................. 114
Smart entry & start system.... 127
Wireless remote control ........ 103
Doors
Back door .............................. 121
Door glasses ......................... 154
Door lock ....................... 114, 121
Open door warning buzzer.... 128
Open door warning light ........ 442
Outside rear view mirrors ...... 151
Rear door child-protector ...... 119
Side doors ............................. 114
Side windows ........................ 154
Double locking system.............. 81
Driver’s seat belt reminder
light ......................................... 443
Driving ...................................... 160
Break-in tips .......................... 163
Correct driving posture............ 30
Procedures............................ 160
Winter drive tips .................... 272
Eco Driving Indicator Light..... 164
Electric Power Steering
(EPS)....................................... 265
Function ................................ 265
Warning light ......................... 440
Electronic key .......................... 102
Battery-saving function ......... 129
If the electronic key does not
operate properly ................. 486
Replacing the battery ............ 402
Emergency brake signal ......... 265
Emergency flashers ................ 428
Emergency, in case of
If the electronic key does
not operate properly ........... 486
If the engine will not start ...... 484
If the vehicle battery is
discharged .......................... 488
If the warning buzzer
sounds................................ 439
If the warning light
turns on .............................. 439
If you have a flat tire ..... 453, 468
If you lose your keys ............. 105
If you run out of fuel and
the engine stalls ................. 497
If you think something is
wrong.................................. 437
If your vehicle becomes
stuck ................................... 499
If your vehicle has to be
stopped in an emergency ... 429
If your vehicle needs to be
towed .................................. 431
If your vehicle overheats ....... 493
DE