display VAUXHALL MERIVA 2015.5 Workshop Manual

196Vehicle care
If w flashes for 60-90 seconds and
then illuminates continuously, there is a fault in the system. Consult a
workshop.
After inflating, driving may be
required to update the tyre pressure
values in the DIC. During this time w
may illuminate.
If w illuminates at lower temperatures
and extinguishes after some driving,
this could be an indicator for getting
low pressure. Check tyre pressure.
Vehicle messages 3 105.
If the tyre pressure shall be reduced
or increased, switch off ignition.
Only mount wheels with pressure
sensors, otherwise the tyre pressure
will not be displayed and w
illuminates continuously.
A temporary spare wheel is not
equipped with pressure sensors. The
tyre pressure monitoring system is
not operational for these wheels.
Control indicator w illuminates. For
the further three wheels the system
remains operational.The use of commercially available
liquid tyre repair kits can impair the
function of the system. Factory-
approved repair kits can be used.
External high-power radio equipment
could disrupt the tyre pressure
monitoring system.
Each time the tyres are replaced tyre
pressure monitoring system sensors
must be dismounted and serviced. For the screwed sensor: replace
valve core and sealing ring. For
clipped sensor: replace complete
valve stem.
Vehicle loading status Adjust tyre pressure to load condition according to tyre information label or
tyre pressure chart 3 233, and select
the relevant setting in the menu Tire
Load in the Driver Information Centre,
Vehicle Information Menu 3 100.
Select:
■ Light for comfort pressure up to
3 people.
■ Eco for Eco pressure up to
3 people.
■ Max for full loading.
TPMS Sensor Matching
Process
Each TPMS sensor has a unique
identification code. The identification
code must be matched to a new tyre/
wheel position after rotating the tyres
or exchanging the complete wheel set and if one or more TPMS sensorswere replaced. The TPMS sensor

Vehicle care197
matching process should also be
performed after replacing a spare tyre with a road tyre containing the TPMS
sensor.
The malfunction light w and the
warning message or code should go
off at the next ignition cycle. The
sensors are matched to the tyre/
wheel positions, using a TPMS
relearn tool, in the following order: left
side front tyre, right side front tyre,
right side rear tyre and left side rear
tyre. The turn light at the current
active position is illuminated until
sensor is matched.
Consult your workshop for service or
to purchase a relearn tool. There are
2 minutes to match the first tyre/wheel position, and 5 minutes overall to
match all four tyre/wheel positions. If
it takes longer, the matching process
stops and must be restarted.The TPMS sensor matching process is:
1. Apply the parking brake; on vehicles with automatic
transmission set the selector lever
to P.
2. Turn the ignition on.
3. Press MENU on the turn signal
lever to select the Vehicle
Information Menu in the Driver
Information Centre (DIC).
4. Turn the adjuster wheel to scroll to
the tyre pressure menu.
5. Press the SET/CLR button to
begin the sensor matching
process. A message requesting
acceptance of the process should
display.
6. Press the SET/CLR button again
to confirm the selection. The horn sounds twice to signal the
receiver is in relearn mode.
7. Start with the left side front tyre.
8. Place the relearn tool against the tyre sidewall, near the valve stem.Then press the button to activate
the TPMS sensor. A horn chirpconfirms that the sensor
identification code has been
matched to this tyre and wheel
position.
9. Proceed to the right side front tyre,
and repeat the procedure in Step 8.
10. Proceed to the right side rear tyre,
and repeat the procedure in
Step 8.
11. Proceed to the left side rear tyre, and repeat the procedure in
Step 8. The horn sounds twice to
indicate the sensor identification
code has been matched to the left side rear tyre, and the TPMS
sensor matching process is no
longer active.
12. Turn off the ignition.
13. Set all four tyres to the recommended air pressure level
as indicated on the tyre pressure
label.
14. Ensure the tyre loading status is set according selected pressure
3 100.

198Vehicle care
Temperature dependencyTyre pressure depends on the
temperature of the tyre. During
driving, tyre temperature and
pressure increase.
The tyre pressure value displayed in
the Driver Information Centre shows
the actual tyre pressure. Therefore it
is important to check tyre pressure
with cold tyres.
Tread depth Check tread depth at regular
intervals.
Tyres should be replaced for safety
reasons at a tread depth of 2-3 mm
(4 mm for winter tyres).
For safety reasons it is recommended
that the tread depth of the tyres on
one axle should not vary by more than
2 mm.
The legally permissible minimum
tread depth (1.6 mm) has been
reached when the tread has worn
down as far as one of the tread wear
indicators (TWI). Their position is
indicated by markings on the
sidewall.
If there is more wear at the front than
the rear, swap round front wheels and rear wheels periodically. Ensure that
the direction of rotation of the wheels
remains the same.
Tyres age, even if they are not used.
We recommend tyre replacement
every 6 years.
Changing tyre and wheel
size
If tyres of a different size than those
fitted at the factory are used, it may be necessary to reprogramme the
speedometer as well as the nominal
tyre pressure and make other vehicle modifications.
After converting to a different tyre
size, have the label with tyre
pressures replaced.9 Warning
Use of unsuitable tyres or wheels
may lead to accidents and will
invalidate the vehicle type
approval.
Wheel covers
Wheel covers and tyres that are
factory approved for the respective
vehicle and comply with all of the
relevant wheel and tyre combination requirements must be used.

216Vehicle care
Towing equipment
Do not clean the coupling ball bar with a steam-jet or high-pressure jet
cleaner.
Rear carrier system
Clean the rear carrier system with a
steam-jet or high-pressure jet cleaner
at least once a year.
Operate the rear carrier system
periodically if not in regular use, in
particular during winter.
Interior careInterior and upholsteryOnly clean the vehicle interior,
including the instrument panel fascia
and panelling, with a dry cloth or
interior cleaner.
Clean the leather upholstery with
clear water and a soft cloth. In case of
heavy soiling, use leather care.
The instrument cluster and the
displays should only be cleaned using
a soft damp cloth. If necessary use a
weak soap solution.Clean fabric upholstery with a
vacuum cleaner and brush. Remove
stains with an upholstery cleaner.
Clothing fabrics may not be
colourfast. This could cause visible
discolourations, especially on light-
coloured upholstery. Removable
stains and discolourations should be
cleaned as soon as possible.
Clean seat belts with lukewarm water or interior cleaner.Caution
Close Velcro fasteners as open
Velcro fasteners on clothing could
damage seat upholstery.
The same applies to clothing with
sharp-edged objects, like zips or
belts or studded jeans.
Plastic and rubber parts
Plastic and rubber parts can be
cleaned with the same cleaner as
used to clean the body. Use interior cleaner if necessary. Do not use any
other agent. Avoid solvents and petrol in particular. Do not use high-
pressure jet cleaners.

Service and maintenance217Service and
maintenanceGeneral information ...................217
Recommended fluids, lubricants and parts .................................... 218General information
Service information In order to ensure economical and
safe vehicle operation and to
maintain the value of your vehicle, it
is of vital importance that all
maintenance work is carried out at the proper intervals as specified.
The detailed, up-to-date service
schedule for your vehicle is available
at the workshop.
Service display 3 91.
European service intervals
Maintenance of your vehicle is
required every 20,000 miles or after
1 year , whichever occurs first, unless
otherwise indicated in the service
display.
A shorter service interval can be valid for severe driving behaviour, e.g. for
taxis and police vehicles.
The European service intervals are
valid for the following countries:Andorra, Austria, Belgium, Bosnia-
Herzegovina, Bulgaria, Croatia,
Cyprus, Czech Republic, Denmark,
Estonia, Finland, France, Germany,
Greece, Greenland, Hungary,
Iceland, Ireland, Italy, Latvia,
Lithuania, Luxembourg, Macedonia,
Malta, Montenegro, Netherlands,
Norway, Poland, Portugal, Romania,
Serbia, Slovakia, Slovenia, Spain,
Sweden, Switzerland, United
Kingdom.
Service display 3 91.
International service intervals Maintenance of your vehicle is
required every 10,000 miles or after
1 year , whichever occurs first, unless
otherwise indicated in the service
display.
The international service intervals are
valid for the countries which are not
listed in the European service
intervals.
Service display 3 91.

218Service and maintenance
Confirmations
Confirmation of service is recorded in the Service and Warranty Booklet.The date and mileage is completed
with the stamp and signature of the servicing workshop.
Make sure that the Service and
Warranty Booklet is completed
correctly as continuous proof of
service is essential if any warranty or goodwill claims are to be met, and is
also a benefit when selling the
vehicle.
Service interval with remaining engine oil life duration The service interval is based on
several parameters depending on
usage.
The service display lets you know
when to change the engine oil.
Service display 3 91.Recommended fluids,
lubricants and parts
Recommended fluids and
lubricants Only use products that meet the
recommended specifications.
Damage resulting from the use of
products not compliant with these
specifications will not be covered by
the warranty.9 Warning
Operating materials are
hazardous and could be
poisonous. Handle with care. Pay
attention to information given on
the containers.
Engine oil
Engine oil is identified by its quality
and its viscosity. Quality is more
important than viscosity when
selecting which engine oil to use. The oil quality ensures e.g. engine
cleanliness, wear protection and oil
aging control, whereas viscosity
grade gives information on the oil's
thickness over a temperature range.
Dexos is the newest engine oil quality
that provides optimum protection for gasoline and diesel engines. If it is
unavailable, engine oils of other listed qualities have to be used.
Recommendations for gasoline
engines are also valid for
Compressed Natural Gas (CNG),
Liquified Petroleum Gas (LPG) and
Ethanol (E85) fuelled engines.
Select the appropriate engine oil
based on its quality and on the
minimum ambient temperature
3 222.
Topping up engine oil
Engine oils of different manufacturers
and brands can be mixed as long as
they comply with the required engine
oil quality and viscosity.
Use of engine oil with only
ACEA A1/B1 or only A5/B5 quality is
prohibited, since it can cause long-
term engine damage under certain
operating conditions.

242
Fuel selector ................................ 91
Fuse box ..................................... 187
Fuses ......................................... 186
G Gauges ......................................... 89
General information ...................163
Glovebox ..................................... 61
Graphic-Info-Display, Colour- Info-Display ............................ 103
H Halogen headlights ....................176
Hand brake ......................... 146, 147
Hazard warning flashers ............120
Headlight flash ........................... 117
Headlight range adjustment ......118
Headlights .......................... 116, 117
Headlights when driving abroad 118
Head restraint adjustment .............8
Head restraints ............................ 34
Heated mirrors ............................. 29
Heated rear window ..................... 32
Heated steering wheel .................83
Heating ........................................ 40
Heating and ventilation system . 125
High beam ........................... 99, 117
Hill start assist ........................... 148
Horn ....................................... 13, 83I
Identification plate .....................221
Ignition switch positions .............136
Immobiliser ............................ 28, 99
Indicators ...................................... 89
Information displays.................... 100
Instrument cluster ........................89
Instrument panel fuse box .........189
Instrument panel illumination .....186
Instrument panel illumination control .................................... 122
Instrument panel overview ........... 10
Interior care ............................... 216
Interior lighting ............................ 122
Interior lights ...................... 122, 186
Interior mirrors .............................. 30
Interruption of power supply ......144
Introduction .................................... 3
ISOFIX child restraint systems ....60
J
Jump starting ............................. 210
K Keys ............................................. 19
Keys, locks ................................... 19
Keys, memorised settings ............21L
Lashing eyes ............................... 77
Light covers, misted.................... 121
Lighting features .........................123
Light switch ................................ 116
Load compartment ................26, 73
Load compartment cover .............75
Load compartment fuse box ......190
Loading information .....................80
Low fuel ....................................... 98
M Malfunction indicator light ............95
Manual anti-dazzle ......................30
Manual mode ............................. 144
Manual transmission .................. 145
Manual windows ..........................31
Memorised settings ......................21
Mirror adjustment ........................... 8
Misted light covers .....................121
Moonroof ..................................... 33
N New vehicle running-in ..............136
Number plate light .....................185
O
Object detection systems ...........152
Octane rating .............................. 225
Odometer ..................................... 90

243
Oil............................................... 170
Oil, engine .......................... 218, 222
Oil pressure .................................. 98
Operate pedal ............................... 96
Outside temperature ....................86
Overrun cut-off ........................... 137
P Parking ................................ 17, 140
Parking assist ............................ 152
Parking brake ............................ 147
Parking lights ............................. 121
Particulate filter ........................... 141
Performance .............................. 228
Performing work ........................169
Personalisation ........................... 112
Pollen filter ................................. 133
Power outlets ............................... 88
Power steering fluid ....................172
Power windows ............................ 31
Preheating ................................... 97
Puncture ..................................... 204
Q
Quickheat ................................... 132
R Radio Frequency Identification (RFID) ..................................... 238
Radio remote control ...................20Reading lights ............................ 123
Rear carrier system ......................64
Rear doors ................................... 25
Rear floor storage cover ..............76
Rear fog light ............................... 99
Rear fog lights ........................... 121
Rear seats .................................... 41
Rear storage ................................. 75
Rear view camera ...................... 154
Rear window wiper/washer .......... 85
Recommended fluids and lubricants ........................ 218, 222
Reduced engine power ...............99
Refuelling ................................... 159 Remote control ............................. 20
Retained power off .....................136
Reversing lights .........................121
Ride control systems ..................149
Roof .............................................. 33
Roof load ...................................... 80
Roof rack ..................................... 79
S
Safety belts ................................... 44
Safety net .................................... 77
Seat adjustment ....................... 6, 36
Seat belt ........................................ 8
Seat belt reminder .......................94
Seat belts ..................................... 44
Seat heating ................................. 40Seat position ................................ 36
Selector lever ............................. 143
Service ............................... 133, 217
Service display ............................ 91
Service information ....................217
Service vehicle soon .................... 95
Side airbag system ......................52
Sidelights .................................... 116
Side turn signal lights ................184
Spare wheel ............................... 208
Speedometer ............................... 89
Starting and operating ................136
Starting off ................................... 16
Starting the engine ....................136
Steering ...................................... 135
Steering wheel adjustment ......9, 82
Steering wheel controls ...............82
Steering wheel, heated .................83
Stop-start system........................ 138
Storage ......................................... 61
Storage compartments .................61
Sunvisor lights ........................... 123
Sun visors .................................... 33
Symbols ......................................... 4
T
Tachometer ................................. 90
Tailgate ......................................... 26
Tail lights ................................... 182
Technical data ............................ 225

244
Three-point seat belt .................... 45
Tools .......................................... 192
Top-tether fastening eyes ............60
Tow bar....................................... 163
Towing ................................ 163, 212
Towing another vehicle .............213
Towing a trailer ........................... 163
Towing equipment .....................164
Towing the vehicle .....................212
Traction Control system ............. 149
Traction Control system off .......... 97
Trailer coupling ........................... 163
Trailer towing ............................. 163
Transmission ............................... 16
Transmission display .................142
Tread depth ............................... 198
Trip computer ............................ 109
Trip odometer .............................. 90
Tunnel detection .........................117
Turn and lane-change signals ...120
Turn signal ................................... 94
Tyre chains ................................ 199
Tyre designations ......................193
Tyre pressure ............................ 194
Tyre pressure monitoring system ............................... 97, 194
Tyre pressures ........................... 233
Tyre repair kit ............................. 199
Tyres and wheel size, changing. 198U
Ultrasonic parking assist ...... 97, 152
Underseat storage .......................63
Upholstery .................................. 216
Upshift .......................................... 97
Using this manual ..........................3
V Variable effort steering .................97
Vehicle battery ........................... 174
Vehicle battery, jump starting .....210
Vehicle checks............................ 169
Vehicle data ................................ 222
Vehicle data recording and privacy ..................................... 237
Vehicle dimensions .................... 231
Vehicle Identification Number ....220
Vehicle jack ................................ 192
Vehicle messages .....................105
Vehicle personalisation .............112
Vehicle security ............................ 27
Vehicle specific data ......................3
Vehicle storage ........................... 168
Vehicle tools ............................... 192
Vehicle unlocking ........................... 6 Vehicle weight ........................... 230
Ventilation ................................... 125W
Warning chimes .........................108
Warning lights ............................... 89
Warning triangle .......................... 78
Washer and wiper systems .........14
Washer fluid ............................... 173
Welcome lighting ........................123
Wheel changing .........................204
Wheel covers ............................. 198
Wheels and tyres .......................193
Windows ....................................... 30
Windscreen................................... 30 Windscreen wiper/washer ...........84
Winter tyres ............................... 193
Wiper blade replacement ..........176