tow VAUXHALL MOVANO_B 2018 Owner's Guide

Vehicle care209Raise the vehicle (max. 3 cm) bypressing the wheel wrench until
the wheel is clear of the ground.
4. Unscrew wheel bolts/nuts completely and wipe clean with a
cloth.
Put wheel bolts/nuts somewhere
where the threads will not be
soiled.
5. Change the wheel.
6. Screw in the wheel bolts/nuts.
7. Lower vehicle.
8. Install the wheel wrench (depending on vehicle, attach
wheel wrench to adapters)
ensuring that it locates securely
and tighten each wheel bolt/nut in a crosswise sequence. Tighteningtorque is: 172 Nm (Front-wheel
drive), 235 Nm (Rear-wheel drive with twin rear wheels), 264 Nm
(Rear-wheel drive with single rear
wheels).
9. Refit wheel cover. Rear-wheel drive, with twin rear
wheels: Install the tyre valve
extender to the inner rear wheel
before refitting the wheel cover.Notice
If applicable, fit anti-theft bolts
nearest the tyre valve (otherwise it
may not be possible to refit the wheel
cover).
10. Stow the replaced wheel 3 209
and the vehicle tools 3 198.
11. Have the new wheel balanced on the vehicle. Check the tyre
pressure of the installed tyre
3 244 and also the wheel bolt/nut
torque as soon as possible.
Have the defective tyre renewed or
repaired.
Spare wheel Some vehicles are equipped with atyre repair kit instead of a spare wheel 3 204.
If mounting a spare wheel which is
different from the other wheels, this
wheel might be classified as a
temporary spare wheel and the
corresponding speed limits apply,
even though no label indicates this.
Seek the assistance of a workshop to
check the applicable speed limit.Caution
The use of a spare wheel that is smaller than the other wheels or in combination with winter tyres
could affect driveability. Have the defective tyre replaced as soon as
possible.
The spare wheel is held under the
vehicle frame using a winch and
secured by tightening a cable using
the wheel wrench and adapters
(depending on vehicle).
It may be necessary to jack the
vehicle up to gain access to the spare
wheel on a fully loaded vehicle with a flat rear tyre.

Vehicle care211
Place wheel below the vehicle frame,
directly beneath the winch
mechanism.
Then tighten cable using the wheel
wrench and adapters by connecting
to the slot position illustrated above
and turning wrench anticlockwise
until the wheel is secured in the fully
raised position.9 Warning
Ensure the front of the wheel (side
with tyre valve) is facing upwards
when the spare wheel is
reinstalled below the vehicle
frame.
Temporary spare wheel
Caution
The use of a spare wheel that is smaller than the other wheels or in combination with winter tyres
could affect driveability. Have the defective tyre replaced as soon as
possible.
Only mount one temporary spare
wheel. Do not drive faster than
50 mph. Take curves slowly. Do not
use for a long period of time.
If your vehicle gets a flat tyre on the
rear while towing another vehicle,
mount the temporary spare wheel in
the front and the full tyre in the rear.
Tyre chains 3 203.
Summer and winter tyres
If you use winter tyres, the spare
wheel may still be fitted with a
summer tyre.
If you use the spare wheel when it is
fitted with a summer tyre the vehicle's driveability may be affected,
especially on slippery road surfaces.
Directional tyres Fit directional tyres such that they rollin the direction of travel. The rolling
direction is indicated by a symbol
(e.g. an arrow) on the sidewall.
The following applies to tyres fitted
opposing the rolling direction:
● Driveability may be affected. Have the defective tyre renewed
or repaired as soon as possible
and fit it instead of the spare
wheel.

214Vehicle care
Lead connection order:1. Connect the red lead to the positive terminal (1) of the booster
battery.
2. Connect the other end of the red lead to the jump start terminal (2)
of the vehicle with the discharged
vehicle battery.
3. Connect the black lead to the negative terminal (3) of the
booster battery.
4. Connect the other end of the black
lead to a vehicle grounding point
(4), such as the engine block or an
engine mounting bolt. Connect as
far away from the discharged
vehicle battery as possible,
however at least 60 cm.
Route the leads so that they cannot
catch on rotating parts in the engine
compartment.
To start the engine: 1. Start the engine of the vehicle providing the jump start.
2. After five minutes, start the other engine. Start attempts should be
made for no longer than
15 seconds at an interval of
one minute.
3. Allow both engines to idle for approx. three minutes with the
leads connected.
4. Switch on electrical consumers (e.g. headlights, heated rear
window) of the vehicle receiving
the jump start.
5. Reverse above sequence exactly when removing leads.Towing
Towing the vehicle The towing eye and wheel wrench are
stowed with the vehicle tools 3 198.
Disengage the cover using a suitable
tool and remove.
Screw the towing eye clockwise into
the front towing point and tighten fully using the wheel wrench.
Attach a tow rope - or better still a tow
rod - to the towing eye, never to the
bumper or front suspension units.

Vehicle care215Caution
Do not tow the vehicle from the
rear. The front towing eye must
only be used for towing and not
recovering a vehicle.
Switch on ignition to permit operation
of brake lights, horn and windscreen
wipers, and move the steering wheel
slightly to release the steering wheel
lock.
Switch off the air suspension system 3 139.
Move the selector lever to neutral.
Release the parking brake.
Caution
Vehicles with manual
transmission automated: If neutral cannot be selected, the vehiclemust only be towed with the drive
wheels raised off the ground.
The vehicle should always be
towed with the ignition switched
off.
Manual transmission automated
3 149.Caution
Drive slowly. Do not drive jerkily.
Excessive tractive force can
damage the vehicle.
When the engine is not running,
considerably more force is needed to
brake and steer.
To prevent the entry of exhaust fumes
from the towing vehicle, switch on the air recirculation system 3 116 and
close the windows.
Seek the assistance of a workshop.
After towing, unscrew the towing eye
and refit the cover.
Towing another vehicle
Attach a tow rope - or better still a tow
rod - to the rear towing eye, never to
the rear axle and suspension units.
Caution
The rear towing eye must only be
used for towing and not recovering a vehicle.

218Vehicle careAfter the underbody is washed, checkthe underbody and have it waxed if
necessary.
Bitumen/rubber materials could
damage the PVC coating. Have
underbody work carried out by a
workshop.
Before and after winter, wash the
underbody and have the protective
wax coating checked.
Towing equipment
Do not clean the coupling ball bar with
a steam-jet or high-pressure jet
cleaner.
Interior care
Interior and upholstery Only clean the vehicle interior,
including the instrument panel fascia
and panelling, with a dry cloth or
interior cleaner.
Clean leather upholstery with clear
water and a soft cloth. In case of
heavy soiling, use leather care.The instrument cluster and the
displays should only be cleaned using
a soft damp cloth. If necessary use a
weak soap solution.
Clean fabric upholstery with a
vacuum cleaner and brush. Remove
stains with an upholstery cleaner.
Clothing fabrics may not be
colourfast. This could cause visible
discolourations, especially on light-
coloured upholstery. Removable
stains and discolourations should be
cleaned as soon as possible.
Clean seat belts with lukewarm water or interior cleaner.Caution
Close Velcro fasteners as open
Velcro fasteners on clothing could damage seat upholstery.
The same applies to clothing with
sharp-edged objects, like zips or
belts or studded jeans.
Plastic and rubber parts
Plastic and rubber parts can be
cleaned with the same cleaner as
used to clean the body. Use interior cleaner if necessary. Do not use any
other agent. Avoid solvents and petrol in particular. Do not use high-
pressure jet cleaners.

244Technical dataTyre pressuresFront-wheel driveTyre pressure with full load16)17)EngineGross Vehicle WeightTyreFront
[kPa/bar] (psi)Rear
[kPa/bar] (psi)M9T2800215/65 R16 C 109/107R340/3.4 (49)360/3.6 (52)3300215/65 R16 C 109/107R360/3.6 (52)430/4.3 (62)3500225/65 R16 C 112/110R380/3.8 (55)460/4.6 (68)3900225/65 R16 C 112/110R380/3.8 (55)460/4.6 (68)16) The spare wheel should be set to the highest applicable pressure shown in the table.
17) When towing a trailer with a fully laden vehicle, the tyre pressure must be increased by 20 kPa/0.2 bar (3.0 psi) and the maximum
speed limited to 60 mph.Rear-wheel drive, with single rear wheelsTyre pressure with full load 16)17)EngineGross Vehicle WeightTyreFront
[kPa/bar] (psi)Rear
[kPa/bar] (psi)M9T3500235/65 R16 C 115/113R360/3.6 (52)450/4.5 (65)16) The spare wheel should be set to the highest applicable pressure shown in the table.
17) When towing a trailer with a fully laden vehicle, the tyre pressure must be increased by 20 kPa/0.2 bar (3.0 psi) and the maximum
speed limited to 60 mph.

Technical data245Rear-wheel drive, with twin rear wheelsTyre pressure with full load16)17)EngineGross Vehicle WeightTyreFront
[kPa/bar] (psi)Rear
[kPa/bar] (psi)M9T3500195/75 R16 C 107/105R420/4.2 (61)420/4.2 (61)4500195/75 R16 C 107/105R420/4.2 (61)420/4.2 (61)16) The spare wheel should be set to the highest applicable pressure shown in the table.
17) When towing a trailer with a fully laden vehicle, the tyre pressure must be increased by 20 kPa/0.2 bar (3.0 psi) and the maximum
speed limited to 60 mph.
The tyre pressure information label on the driver's door frame indicates the original equipment tyres and the correspondent
tyre pressures. Always inflate tyres to the pressures shown on the label.
Tyre pressure information label 3 199.
Tyre designations 3 199.

Customer information247Ohmstrasse 4, 85716
Unterschleissheim, Germany
Operation frequency: 125 kHz
Maximum output:
42 dBμA/m @ 10 m
Infotainment system IntelliLink Touch
Continental Automotive GmbH
1 Rue de Clairefontaine, 78120
Rambouillet, France
Operation frequency: N/A
Maximum output: N/A
NAVI 50 IntelliLink / NAVI 80
IntelliLink
LGE
LG Electronics European Shared
Service Center B.V., Krijgsman 1,
1186 DM Amstelveen, The
Netherlands
Operation frequency: 2.4 GHz
Maximum output: 100 mW EIRP
Infotainment system R16 / R16 BT
USB / CD18 BT USB
Visteon Electronics04 Rue Nelson Mandela, Zone
Industrielle Borj Cedria, 2055 Bir El
Bey, TunisiaOperation
frequency (MHz)Maximum output
(dBm)2400 – 2483,5
MHz100 mW EIRP
Infotainment system R15 BT / CD16
BT / CD16 BT DAB+
HUMAX Poland Sp.z.o.o.
Ul. Przemyslowa 4, 97-400
Belchatow, Poland
Operation
frequency (MHz)Maximum output
(dBm)2402 – 2480 MHz4dBm EIRP
Navigation module
TomTom Int’l BV
De Ruijterkade 154, 1011 AC
Amsterdam, The Netherlands
Operation
frequency (MHz)Maximum output
(dBm)2400 - 2483.5
MHz100 mW EIRP
Parking heater remote control
receiver
Eberspaecher Climate Control
Systems GmbH & Co. KG
Eberspaecherstrasse 24, 73730
Esslingen, Germany
Operation frequency: N/A
Maximum output: N/A
Parking heater remote control
transmitter
Eberspaecher Climate Control
Systems GmbH & Co. KG
Eberspaecherstrasse 24, 73730
Esslingen, Germany
Operation frequency: 434,6 MHz
Maximum output: 10dBm
Telematics control unit
Continental Automotive
1 Rue de Clairefontaine, 78120
Rambouillet, France

253Charging system .......................... 96
Child locks ................................... 26
Child restraint installation locations ................................... 64
Child restraints.............................. 61
Child restraint systems ................61
Cigarette lighter ........................... 88
Cleaning the vehicle ...................216
Climate control ............................. 15
Climate control systems .............115
Clock ............................................ 86
Coat hooks ................................... 72
Collision damage repair ..............250
Control indicators.......................... 92
Control of the vehicle .................132
Controls ........................................ 83
Convex shape .............................. 34
Coolant ....................................... 178
Coolant and antifreeze ...............220
Coolant heater ............................ 122
Cornering light ....................110, 187
Coupling ball bar ........................171
Cruise control ....................100, 158
Cupholders .................................. 72
D Danger, Warnings and Cautions ...4
Dashboard .................................... 10
Daytime running lights ...............109
Declaration of conformity ............246DEF............................................ 142
Demisting and defrosting ..............15
Diesel exhaust fluid ....................142
Diesel fuel ................................... 167
Diesel fuel filter .......................... 182
Diesel fuel system bleeding .......183
Diesel particle filter ....................141
Door locks..................................... 21
Door open .................................. 100
Doors ............................................ 27
DPF (diesel particle filter) ...........141
Drink holders ................................ 72
Driver assistance systems ..........158
Driver Information Centre ...........101
Driving characteristics and towing tips .............................. 170
Driving economically................... 132
Driving hints ................................ 132
E ECO mode .................................. 132
ecoScoring.................................. 103
Electric adjustment ......................35
Electrical accessories ...................86
Electrical system......................... 193
Electronic climate control system 117
Electronic driving programmes ..151
Electronic Stability Program 98,
156, 171
Electronic Stability Program off ...98Emergency exit .......................38, 40
End-of-life vehicle recovery .......175
Engine compartment fuse box ...194
Engine coolant ........................... 178
Engine coolant temperature ........98
Engine coolant temperature gauge ....................................... 90
Engine data ............................... 225
Engine Drag Torque Control ......156
Engine exhaust .......................... 141
Engine identification ...................223
Engine oil ...........176, 220, 224, 243
Engine oil additives ....................220
Engine oil level monitor ................91
Engine oil pressure ......................99
Engine oil viscosity grades .........220
Enhanced Traction function....... ................................ 155, 156, 158
Event data recorders ..................250
Exhaust gases ............................ 141
Exit lighting ................................ 114
Exterior care .............................. 216
Exterior light ............................... 100
Exterior lighting ....................12, 107
Exterior mirrors ............................. 34
F
Fault ........................................... 152
Fire extinguisher ........................... 79
First aid ......................................... 79

256Reversing lights .........................111
Ride control systems ..........155, 158
Ride height ................................. 139
Roof .............................................. 40
Glass panel ............................... 40
Roof load ...................................... 80
Roof rack ..................................... 80
S Safety belts ................................... 51
Safety net .................................... 78
Seat adjustment ....................... 7, 43
Seat belt ........................................ 8
Seat belt reminder .......................95
Seat belts ..................................... 51 Seat heating ................................. 48
Seat position ................................ 42
Selective catalytic reduction .......142
Selector lever ............................. 150
Service ............................... 129, 219
Service display ......................91, 96
Service information ....................219
Service vehicle soon .................... 96
Side airbag system ......................59
Sidelights .................................... 107
Side turn signal lights ................190
Side windows................................ 38
Sliding door .................................. 27
Sliding side door ........................... 27
Spare wheel ............................... 209Speed limiter......................... 88, 162
Speedometer ............................... 88
Starting and operating ................133
Starting off ................................... 16
Starting the engine .......16, 134, 150
Steering ...................................... 132
Steering column controls ..............83
Steering wheel adjustment ......9, 83
Steering wheel controls ...............83
Stop engine .................................. 97
Stop-start system............ 16, 99, 135
Storage ......................................... 71
Storage compartments .................71
Storage net ............................. 72, 73
Sun visors .................................... 39
Suspension height ......................139
Suspension seat ........................... 43
Swivelling shelf ............................. 72
Symbols ......................................... 4
T
Tachograph ........................ 100, 105
Tachometer ................................. 89
Tail lights ................................... 188
Technical data ....................224, 225
Three-point seat belt .................... 52
Tools .......................................... 198
Top-Tether .................................... 61
Touchscreen ............................... 101
Tow bar....................................... 170Towing ........................................ 170
Towing another vehicle .............215
Towing a trailer ........................... 170
Towing equipment .....................171
Towing eye ................................. 214
Towing the vehicle .....................214
Traction Control system ............. 155
Trailer coupling ........................... 170
Trailer stability assist .................171
Trailer towing ............................. 170
Transmission ............................... 16
Transmission display ...........92, 149
Tread depth ............................... 202
Trip computer ............................ 103
Trip odometer .............................. 89
Turbo engine warm-up ...............134
Turn and lane-change signals ...110
Turn signal ................................... 95
Tyre chains ................................ 203
Tyre changing ............................. 207
Tyre designations ......................199
Tyre pressure ............................ 199
Tyre pressure monitoring system ............................... 98, 200
Tyre pressures ........................... 244
Tyre repair kit ............................. 204
Tyres .......................................... 199
Tyres and wheel size, changing. 203