adblue VAUXHALL VIVARO 2016.5 User Guide

Driving and operating127AdBlue canisterNotice
Only use the designated AdBlue
canisters for refilling, to prevent a
topping-up of too much AdBlue.
Additionally, the fumes in the tank
are captured in the canister and do
not emerge.
Notice
Since AdBlue has a limited
durability, check the date of expiry
before refilling.
1. Switch off engine and remove key
from ignition switch.
2. Pull fuel filler flap to open.3. Unscrew protective cap anticlockwise from the filler neck.
4. Open AdBlue canister.
5. Mount one end of the hose on the
canister and screw the other end
on the filler neck.
6. Lift the canister until it is empty.
7. Unscrew the hose from the filler neck.
8. Mount the protective cap and turn
clockwise until it engages.
9. Close fuel filler flap and left-hand door.
Notice
Dispose of AdBlue canister and
hose according to environmental requirements.
Notice
Let the vehicle idle for 10 seconds to
allow the system to detect the
AdBlue refill.
Failure to observe this procedure will result in the system only recognising
the AdBlue refill after 20 minutes of
driving.If the AdBlue refill is detected
successfully, AdBlue level warnings
will disappear.
If the AdBlue refill is not detected
some time after running the engine,
seek the assistance of a workshop.
Filler cap
Only use genuine filler caps. Adblue
tank has a special filler cap.
Fault
If the system detects an operating fault, control indicator Y illuminates
together with F and a warning chime.
Seek the assistance of a workshop
immediately.
A corresponding message appears in the Driver Information Centre 3 90.

162Vehicle careNo.Circuit1Adblue injection battery2Vehicle battery (with electronic
key system)3APC battery backup (with elec‐
tronic key system)4Heating and ventilation system5Adaptations6Adaptations7Heating and ventilation system8Additional heating and ventila‐
tion / air conditioning system9Supplementary heating and
ventilation system10Electric exterior mirrors / addi‐
tional adaptations11Heated exterior mirrors12Radio / multimedia / electric
exterior mirrors / diagnostic
socket13Multimedia / trailer hitchNo.Circuit14Courtesy lights / battery
discharge protection15Fuel injection system / tyre pres‐ sure monitoring system / elec‐
tronic key system16Hazard warning flashers / turn
and lane-change signals17Central locking18Left-hand high beam / right-
hand low beam / tail lights / left- hand daytime running light19Front fog lights / rear fog lights /
number plate lighting20Alarm / horn / lighting / wiper21Instrument cluster22Light switch23Rear window wiper / wind‐
screen washer pump / horn24APC general battery25Reversing lightsNo.Circuit26Brake switch27Fuel injection / starter28Airbag / steering column lock29Passenger power window30Power steering31Brake lights32APC battery backup (with elec‐
tronic key system)33Service display34Cigarette lighter / power outlet35Right-hand high beam / left-
hand low beam / sidelights /
right-hand daytime running light36Brake lights / ABS / immobiliser37Interior lighting / air conditioning38Starting with electronic key
system39Rear window wiper40Warning chimes

Service and maintenance183Engine oil viscosity grades
The SAE viscosity grade gives
information of the thickness of the oil.
Multigrade oil is indicated by two figures, e.g. SAE 5W-30. The first
figure, followed by a W, indicates the
low temperature viscosity and the
second figure the high temperature viscosity.
Select the appropriate viscosity grade depending on the minimum ambient
temperature 3 186.
All of the recommended viscosity
grades are suitable for high ambient
temperatures.
Coolant and antifreeze
Use only silicate-free long life coolant (LLC) antifreeze approved for thevehicle. Consult a workshop.
The system is factory filled with
coolant designed for excellent
corrosion protection and frost
protection down to approx. -28 °C.
This concentration should be
maintained all year round. The use of additional coolant additives that
intend to give additional corrosionprotection or seal against minor leaks
can cause function problems. Liability
for consequences resulting from the
use of additional coolant additives will be rejected.
Brake fluid
Over time, brake fluid absorbs
moisture which will reduce braking
effectiveness. The brake fluid should therefore be replaced at the specified interval.
AdBlue Only use AdBlue to reduce the
nitrogen oxides in the exhaust
emission 3 123.

188Technical dataSales designation1.6 CDTi 953)1.6 CDTi 115 3)1.6 CDTi BiTurbo 125 3)1.6 CDTi BiTurbo 1453)Engine identifier codeR9M 413R9M 413R9M 452R9M 452Number of cylinders4444Piston displacement [cm 3
]1598159815981598Engine power [kW] (PS)70 (95)85 (115)92 (125)107 (145)at rpm3500350035003500Torque [Nm]260300320340at rpm1500150015001500Fuel typeDieselDieselDieselDiesel3) Euro 6 with Adblue.
Adblue 3 123.

Technical data197Capacities
Engine oilEngineR9M 408R9M 450,
R9M 413,
R9M 452Engine oil including filter [l] (approx.)6.07.4between MIN and MAX [l] (approx.)2.13.5
Fuel tank
Fuel tank, nominal capacity [l]80
AdBlue tank
AdBlue, nominal capacity [l]22.5

202IndexAAbsorptive Glass Mat battery .....150
Accessories and vehicle modifications .......................... 145
Adaptive forward lighting .............98
Adblue .......................................... 93
AdBlue .......................... 88, 123, 182
AdBlue tank ................................ 197
Adjustable air vents ...................112
AGM battery ............................... 150
Airbag and belt tensioners ...........85
Airbag deactivation ................57, 85
Airbag label............................. 53, 57
Airbag system .............................. 53
Air conditioning regular operation ................................ 113
Air conditioning system .............. 104
Air intake .................................... 113
Air recirculation ...................104, 176
Air vents...................................... 112
Alert .............................................. 92
Antifreeze ................................... 148
Antilock brake system ................ 129
Antilock brake system (ABS) .......87
Anti-theft alarm system ................35
Anti-theft bolts............................. 171
Anti-theft locking system .............. 33
Anti-theft security lock ..................23
Appearance care ........................177
Armrest ........................................ 46Ashtrays ....................................... 79
Automatic anti-dazzle ..................39
Automatic fuel cut-off ..................119
Automatic light control .................97
Automatic locking ........................28
Autostop ....................... 89, 118, 119
Auxiliary heater ........................... 108
B Battery ........................................ 150
Battery discharge protection ......102
Battery, jump starting.................. 174
Belts.............................................. 49 Bench seat.................................... 68
BlueInjection ............................... 123
Bonnet ....................................... 146
Bottle holders................................ 68
Brake and clutch fluid .................182
Brake assist ............................... 130
Brake fluid .................................. 150 Brakes ............................... 128, 150
Brake system ............................... 86
Breakdown.................................. 176
Bulb replacement ....................... 154
C
Capacities .................................. 197
Car Pass ...................................... 20
Catalytic converter .....................123
Central locking system ................23
Centre high-mounted brake light 156