ECU VAUXHALL VIVARO 2016 Owner's Guide

146Vehicle care
We recommend the use of the same
grade of engine oil that was used at
the last change.
The engine oil level must not exceed
the maximum mark MAX on the
dipstick.
Caution
Overfilled engine oil must be
drained or suctioned out.
To prevent spillage when
replenishing the engine oil, we
recommend using a funnel to top-up the engine oil. Ensure funnel is
securely located onto the filler pipe.
After topping-up, put the funnel into a
plastic bag and stow it securely.
A stabilization of the engine oil
consumption will not take place until the vehicle has been driven several
thousand miles. Only then can the
actual degree of consumption be
established.
If consumption exceeds more than
0.5 litres every 600 miles after this
running-in period, consult a
workshop.
Capacities 3 195.
Fit the cap on straight and tighten it.Engine air filter
Engine air flow indicator
On certain models, an indicator is
located in the engine induction
system and indicates if the air-intake
to the engine is restricted.
Clear:No restrictionRed tell-tale:Restricted
If the red tell-tale is displayed when
the engine is running, consult a
workshop.

154Vehicle careFront turn signal lights
1.Remove bulb holder from reflector
housing by rotating anticlockwise.
2. Renew bulb.
3. Install bulb holder in reflector housing.
Tail lights
Rear brake, turn signal and tail
lights
1. Remove the 3 screws (using the tool supplied).
2. Carefully pull lamp assembly from
retaining pins on the outer side
and remove.
3. Rotate bulb holder anticlockwise to separate from lamp assembly.
4. Renew bulb.
5. Push to install the bulb holder into
the lamp assembly, then rotate
clockwise to secure.
6. Check that the wiring harness is located correctly.
7. Replace lamp assembly into original position, ensuring that it isseated correctly.
8. Fit lamp assembly onto retaining pins and replace the 3 screws.

156Vehicle care4.Push to install the bulb holder into
the lamp assembly, then rotate
clockwise to secure.
5. Install lamp assembly with the 2 screws.
Number plate light
1. Prise out lamp using a flat blade screwdriver.
2. Prise off lens.
3. Renew bulb.
4. Install lens and replace lamp in housing.
Fog tail light
1. Remove the 2 screws (using thetool supplied) and remove lamp
assembly.
2. Rotate bulb housing anticlockwise
to separate from lamp assembly.
3. Renew upper bulb.
4. Push to install the bulb holder into
the lamp assembly, then rotate
clockwise to secure.
5. Install lamp assembly with the 2 screws.
Interior lights
Front and rear courtesy lights
1. Release lens assembly from the clips and the locator using a flat
blade screwdriver.
2. Renew bulb.
3. Install lens assembly.

162Vehicle careNo.Circuit41Load compartment power outlet42Driver power window43Rear power outlet44Starting / body control module45Heated seats46Heating / air conditioning47Windscreen wiper48Tachograph
After having changed defective fuses,
replace the trim panel.
Vehicle tools
Tools
The jack, wheel wrench, wheel bolt
sleeve, torx key, adapters, wheel
cover hook, towing eye are contained
in a unit, stowed under the driver's
seat.
Slide seat forwards and fold the
backrest forwards 3 43 to access the
tool box. The tool box may be secured
in position with a wing nut.
Wheel changing 3 171, Spare wheel
3 172.
Vehicles with tyre repair kit: The
wheel cover hook and torx key are
stored within the tyre repair kit case,
stowed under the driver's seat.
Tyre repair kit 3 168.

Vehicle care171Notice
The driving characteristics of the
repaired tyre is severely affected, therefore have this tyre replaced.
If unusual noise is heard or the
compressor becomes hot, turn
compressor off for at least
30 minutes.
Pay attention to storage information
and expiry date on sealant bottle. Its
sealing capability is not guaranteed
after this time.
Replace the used sealant bottle. Dispose of the sealant bottle as
prescribed by applicable laws.
Wheel changing
Some vehicles are equipped with a
tyre repair kit instead of a spare wheel 3 168.
Make the following preparations and
observe the following information:
● Park the vehicle on a level, firm and non-slippery surface. The
front wheels must be in the
straight-ahead position.
● Apply the parking brake and engage first gear or reverse gear.● Remove the spare wheel 3 172.
● Never change more than one wheel at a time.
● Use the jack only to change wheels in case of puncture, not
for a seasonal winter or summer
tyre change.
● If the ground on which the vehicle
is standing is soft, a solid board
(max. 1 cm thick) should be
placed under the jack.
● Take heavy objects out of the vehicle before jacking up.
● No people or animals may be in the vehicle when it is jacked-up.
● Never crawl under a jacked-up vehicle.
● Do not start the engine when the vehicle is raised on the jack.
● Clean wheel bolts/nuts and thread with a clean cloth before
mounting the wheel.9 Warning
Do not grease wheel bolt, wheel
nut and wheel nut cone.
1. Remove the wheel cover (using the hook supplied). Vehicle tools
3 162.
2. Loosen each of the wheel bolts by
half a turn using the wheel
wrench. Ensure the wrench
locates securely. The wrench
should turn anticlockwise to
loosen the bolts. Invert the wrench if necessary.

172Vehicle care
3.Place lifting pad spigot of the jack
under the jacking hole located
nearest the wheel concerned.
Ensure the jack is positioned
correctly. The jack base must be
on the ground directly below the
jacking hole in a manner that
prevents it from slipping.
4. Install wrench onto the jack and raise the vehicle by turning the
wrench until the wheel is clear of
the ground.
5. Unscrew wheel bolts completely by turning anticlockwise and wipe
clean with a cloth.
Put wheel bolts somewhere
where the threads will not be
soiled.
6. Change the wheel. Spare wheel 3 172.
7. Screw in the wheel bolts.
8. Lower the vehicle and remove jack.
9. Tighten each of the wheel bolts in
a crosswise sequence using the
wheel wrench. Ensure the wrench locates securely. The wrench
should turn clockwise to tighten
the bolts. Invert the wrench if
necessary.
Tightening torque is 160 Nm.
10. Replace the wheel cover, ensuring that the valve hole in thewheel cover is aligned with the
tyre valve before installing.
Notice
If applicable, fit anti-theft bolts
nearest the tyre valve (otherwise it
may not be possible to refit the wheel
cover).11. Stow the replaced wheel 3 172
and the vehicle tools 3 162.
12. Have the new wheel balanced on the vehicle.
Check the tyre pressure of the
installed tyre 3 196.
Check the wheel bolt torque.
Have the defective tyre renewed or
repaired as soon as possible.
Spare wheel
Some vehicles are equipped with a tyre repair kit instead of a spare wheel
3 168.
If mounting a spare wheel which is
different from the other wheels, this
wheel might be classified as a
temporary spare wheel and the
corresponding speed limits apply,
even though no label indicates this.
Seek the assistance of a workshop to
check the applicable speed limit.

Vehicle care173Caution
The use of a spare wheel that issmaller than the other wheels or in combination with winter tyres
could affect driveability. Have the defective tyre replaced as soon as
possible.
It may be necessary to jack the
vehicle up to gain access to the spare
wheel on a fully loaded vehicle with a
flat rear tyre.
Wheel changing 3 171.
The spare wheel is mounted under
the rear underbody and may be
secured using a security bolt that can
only be removed using the wheel bolt sleeve supplied. Vehicle tools 3 162.9 Warning
Due to the weight of the tyre
assembly, exercise caution when
releasing the spare wheel carrier.
Do not fully remove bolt 1.
Support the spare wheel with a
suitable object to prevent the
wheel falling suddenly when
loosening the carrier bolts - risk of injury!
To release the spare wheel carrier,loosen bolt 1, ensuring it is not fully
removed. Fully remove bolt 2, then
pull the carrier to the left, until it clears bolt 1, and lower the carrier assembly.
When installing the wheel ensure that
the spare wheel carrier is correctly
positioned before tightening the bolts.
Summer and winter tyres
If you use winter tyres, the spare wheel may still be fitted with a
summer tyre.
If you use the spare wheel when it is
fitted with a summer tyre the vehicle's driveability may be affected,
especially on slippery road surfaces.
Directional tyres Fit directional tyres such that they rollin the direction of travel. The rolling
direction is indicated by a symbol
(e.g. an arrow) on the sidewall.
The following applies to tyres fitted
opposing the rolling direction:
● Driveability may be affected. Have the defective tyre renewed
or repaired as soon as possible.
● Do not drive faster than 50 mph.
● Drive particularly carefully on wet
and snow-covered road
surfaces.

Customer information199Vehicle data recording
and privacy
Event data recorders Data storage modules in the
vehicle
A large number of electronic
components of your vehicle contain
data storage modules temporarily or
permanently storing technical data
about the condition of the vehicle,
events and errors. In general, this
technical information documents the
condition of parts, modules, systems
or the environment:
● operating conditions of system components (e.g. filling levels)
● status messages of the vehicle and its single components (e.g.
number of wheel revolutions / rotational speed, deceleration,
lateral acceleration)
● dysfunctions and defects in important system components● vehicle reactions in particulardriving situations (e.g. inflation of
an airbag, activation of the
stability regulation system)
● environmental conditions (e.g. temperature)
These data are exclusively technical
and help identifying and correcting
errors as well as optimising vehicle
functions.
Motion profiles indicating travelled
routes cannot be created with these
data.
If services are used (e.g. repair
works, service processes, warranty
cases, quality assurance),
employees of the service network
(manufacturer included) are able to
read out this technical information
from the event and error data storage
modules applying special diagnostic
devices. If required, you will receive
further information at these
workshops. After an error has been
corrected, the data are deleted from
the error storage module or they are
constantly overwritten.When using the vehicle, situations
may occur in which these technical
data related to other information
(accident report, damages on the
vehicle, witness statements etc.) may
be associated with a specific person - possibly, with the assistance of an
expert.
Additional functions contractually
agreed upon with the client (e.g.
vehicle location in emergency cases)
allow the transmission of particular vehicle data from the vehicle.
Radio Frequency
Identification (RFID)
RFID technology is used in some
vehicles for functions such as tyre
pressure monitoring and ignition
system security. It is also used in
connection with conveniences such
as radio remote controls for door
locking/unlocking and starting, and in-
vehicle transmitters for garage door
openers. RFID technology in
Vauxhall vehicles does not use or
record personal information or link
with any other Vauxhall system
containing personal information.

200IndexAAbsorptive Glass Mat battery .....149
Accessories and vehicle modifications .......................... 143
Adaptive forward lighting .............97
Adblue .......................................... 91
AdBlue .......................... 87, 121, 181
AdBlue tank ................................ 195
Adjustable air vents ...................109
AGM battery ............................... 149
Airbag and belt tensioners ...........84
Airbag deactivation ................56, 84
Airbag label............................. 52, 56
Airbag system .............................. 52
Air conditioning regular operation ................................ 110
Air conditioning system .............. 102
Air intake .................................... 110
Air recirculation ...................102, 175
Air vents...................................... 109
Alert .............................................. 90
Antifreeze ................................... 147
Antilock brake system ................ 126
Antilock brake system (ABS) .......86
Anti-theft alarm system ................33
Anti-theft bolts............................. 171
Anti-theft locking system .............. 32
Anti-theft security lock ..................23
Appearance care ........................177
Armrest ........................................ 45Ashtrays ....................................... 78
Automatic anti-dazzle ..................38
Automatic fuel cut-off ..................117
Automatic light control .................95
Automatic locking ........................28
Autostop ............................... 88, 116
Auxiliary heater ........................... 106
B Battery ........................................ 149
Battery, jump starting.................. 174
Belts.............................................. 48 Bench seat.................................... 67
BlueInjection ............................... 121
Bonnet ....................................... 144
Bottle holders................................ 66
Brake and clutch fluid .................181
Brake assist ............................... 127
Brake fluid .................................. 148
Brakes ............................... 126, 148
Brake system ............................... 85
Breakdown.................................. 175
Bulb replacement ....................... 152
C Capacities .................................. 195
Car Pass ...................................... 20
Catalytic converter .....................121
Central locking system ................23
Centre high-mounted brake light 155
Changing tyre and wheel size ...167

204Seat position ................................ 42
Seats ............................................ 67
Selective catalytic reduction .......121
Service ............................... 111, 180
Service display ............................ 80
Service information ....................180
Service vehicle soon .................... 85
Side airbag system ......................55
Sidelights ...................................... 95
Side turn signal lights ................155
Sliding door .................................. 29
Spare wheel ............................... 172
Spare wheel security tool ...........162
Speed limiter......................... 78, 134
Speedometer ............................... 78
Starting and operating ................114
Starting off ................................... 17
Starting the engine ...............17, 116
Steering ...................................... 113
Steering column controls ..............74
Steering wheel adjustment ......9, 74
Steering wheel controls ...............74
Stop engine .................................. 85
Stop-start system.................. 17, 117
Storage ......................................... 65
Storage box .................................. 67
Storage compartments .................65
Sun visors .................................... 40
Symbols ......................................... 4T
Tablet holder................................. 65 Tachograph ............................ 89, 93
Tachometer ................................. 79
Tailgate ......................................... 31
Tail lights ................................... 154
Technical data ............................ 186
Temporary spare wheel ..............172
Three-point seat belt .................... 49
Toll road stickers .......................... 38
Tools .......................................... 162
Top-tether fastening eyes ............64
Torx key ...................................... 162
Tow bar....................................... 140
Towing ................................ 140, 175
Towing another vehicle .............176
Towing a trailer ........................... 140
Towing eye ......................... 162, 175
Towing the vehicle .....................175
Traction Control system ............. 128
Trailer coupling ........................... 140
Trailer stability assist .................141
Trailer towing ............................. 140
Transmission ............................... 16
Tread depth ............................... 167
Trip computer .............................. 91
Trip odometer .............................. 79
Turbo engine warm-up ...............116
Turn and lane-change signals .....97
Turn signal ................................... 83Tyre chains ................................ 168
Tyre changing ............................. 171
Tyre designations ......................163
Tyre pressure ............................ 163
Tyre pressure monitoring system ............................... 87, 164
Tyre pressures ........................... 196
Tyre repair kit ............................. 168
Tyres .......................................... 163
Tyres and wheel size, changing. 167
U Ultrasonic parking assist............. 134
Underseat storage .......................67
Upholstery .................................. 178
Upshift .......................................... 86
Using this manual ..........................3
V Vehicle battery ...................149, 174
Vehicle checks............................ 144
Vehicle data ................................ 185
Vehicle data recording and privacy ..................................... 199
Vehicle dimensions .................... 190
Vehicle Identification Number ....183
Vehicle jack ................................ 162
Vehicle messages .......................90
Vehicle security ............................ 32
Vehicle shutdown ......................117
Vehicle specific data ......................3