ECU VAUXHALL VIVARO 2018 Owner's Guide

Vehicle care193
3.Place lifting pad spigot of the jack
under the jacking hole located
nearest the wheel concerned.
Ensure the jack is positioned
correctly. The jack base must be
on the ground directly below the
jacking hole in a manner that
prevents it from slipping.
4. Install wrench onto the jack and raise the vehicle by turning the
wrench until the wheel is clear of
the ground.
5. Unscrew wheel bolts completely by turning anticlockwise and wipe
clean with a cloth.
Put wheel bolts somewhere
where the threads will not be
soiled.
6. Change the wheel. Spare wheel 3 193.
7. Screw in the wheel bolts.
8. Lower the vehicle and remove jack.
9. Tighten each of the wheel bolts in
a crosswise sequence using the
wheel wrench. Ensure the wrench is securely located. The wrench
should turn clockwise to tighten
the bolts. Invert the wrench if
necessary.
Tightening torque is 160 Nm.
10. Replace the wheel cover, ensuring that the valve hole in thewheel cover is aligned with the
tyre valve before installing.
Notice
If applicable, fit anti-theft bolts
nearest the tyre valve (otherwise it
may not be possible to refit the wheel
cover).11. Stow the replaced wheel 3 193
and the vehicle tools 3 183.
12. Have the new wheel balanced on the vehicle.
Check the tyre pressure of the
installed tyre 3 217.
Check the wheel bolt torque.
Have the defective tyre renewed or
repaired as soon as possible.
Spare wheel
Some vehicles are equipped with a tyre repair kit instead of a spare wheel
3 189.
If mounting a spare wheel which is
different from the other wheels, this
wheel might be classified as a
temporary spare wheel and the
corresponding speed limits apply,
even though no label indicates this.
Seek the assistance of a workshop to
check the applicable speed limit.

194Vehicle careCaution
The use of a spare wheel that issmaller than the other wheels or in combination with winter tyres
could affect driveability. Have the defective tyre replaced as soon as
possible.
It may be necessary to jack the
vehicle up to gain access to the spare
wheel on a fully loaded vehicle with a
flat rear tyre.
Wheel changing 3 192.
The spare wheel is mounted under
the rear underbody and may be
secured using a security bolt that can
only be removed using the wheel bolt sleeve supplied.
Vehicle tools 3 183.9 Warning
Due to the weight of the tyre
assembly, exercise caution when
releasing the spare wheel carrier.
Do not fully remove bolt 1.
Support the spare wheel with a
suitable object to prevent the
wheel falling suddenly when
loosening the carrier bolts - risk of injury!
To release the spare wheel carrier,fully remove bolt 2 then loosen bolt 1,
ensuring it is not fully removed. Then
move the spare wheel carrier up and
down and from side to side, until it
clears bolt 1, and lower the carrier
assembly.
When installing the wheel ensure that
the spare wheel carrier is correctly
positioned before tightening the bolts.
Summer and winter tyres
If you use winter tyres, the spare
wheel may still be fitted with a
summer tyre.
If you use the spare wheel when it is
fitted with a summer tyre the vehicle's driveability may be affected,
especially on slippery road surfaces.
Directional tyres
Fit directional tyres such that they roll in the direction of travel. The rolling
direction is indicated by a symbol
(e.g. an arrow) on the sidewall.
The following applies to tyres fitted
opposing the rolling direction:
● Driveability may be affected. Have the defective tyre renewed
or repaired as soon as possible
and fit it instead of the spare
wheel.
● Do not drive faster than 50 mph.
● Drive particularly carefully on wet
and snow-covered road
surfaces.

Customer information223● vehicle reactions in particulardriving situations (e.g. inflation ofan airbag, activation of the
stability regulation system)
● environmental conditions (e.g. temperature)
These data are exclusively technical
and help identifying and correcting
errors as well as optimising vehicle
functions.
Motion profiles indicating travelled
routes cannot be created with these
data.
If services are used (e.g. repair
works, service processes, warranty
cases, quality assurance),
employees of the service network
(manufacturer included) are able to
read out this technical information
from the event and error data storage
modules applying special diagnostic
devices. If required, you will receive
further information at these
workshops. After an error has been
corrected, the data are deleted from
the error storage module or they are
constantly overwritten.When using the vehicle, situations
may occur in which these technical
data related to other information
(accident report, damages on the
vehicle, witness statements etc.) may
be associated with a specific person - possibly, with the assistance of an
expert.
Additional functions contractually
agreed upon with the client (e.g.
vehicle location in emergency cases)
allow the transmission of particular vehicle data from the vehicle.
Radio Frequency
Identification (RFID)
RFID technology is used in some vehicles for functions such as tyre
pressure monitoring and ignition
system security. It is also used in
connection with conveniences such
as radio remote controls for door
locking/unlocking and starting, and in-
vehicle transmitters for garage door
openers. RFID technology in
Vauxhall vehicles does not use or
record personal information or link with any other Vauxhall system
containing personal information.

224IndexAAbsorptive Glass Mat battery .....169
Accessories and vehicle modifications .......................... 163
Adaptive forward lighting ...........108
AdBlue .................. 98, 103, 139, 202
AdBlue tank ................................ 216
Adjustable air vents ...................125
AGM battery ............................... 169
Airbag and belt tensioners ...........95
Airbag deactivation ................62, 95
Airbag label............................. 57, 62
Airbag system .............................. 57
Air conditioning regular operation ................................ 126
Air conditioning system .............. 115
Air intake .................................... 126
Air recirculation ...................115, 196
Air vents...................................... 125
Alert ............................................ 102
Antifreeze ................................... 167
Antilock brake system ................ 146
Antilock brake system (ABS) .......97
Anti-theft alarm system ................36
Anti-theft bolts............................. 192
Anti-theft locking system .............. 35
Anti-theft security lock ..................24
Appearance care ........................198
Armrest ........................................ 48
Ashtrays ....................................... 88Automatic anti-dazzle ..................41
Automatic fuel cut-off ..................133
Automatic light control ...............107
Automatic locking ........................30
Autostop ............................. 132, 134
Auxiliary heater ........................... 120
B Battery ........................................ 169
Battery discharge protection ......113
Battery, jump starting.................. 195
Belts.............................................. 53 Bench seat.................................... 74
BlueInjection ............................... 139
Bonnet ....................................... 164
Bottle holders................................ 74
Brake and clutch fluid .................202
Brake assist ............................... 147
Brake fluid .................................. 168
Brakes ............................... 145, 168
Brake system ............................... 96
Breakdown.................................. 196 Bulb replacement ....................... 173
C
Capacities .................................. 216
Car Pass ...................................... 20
Catalytic converter .....................138
Central locking system ................24
Centre high-mounted brake light 175
Changing tyre and wheel size ...188

228Rear view camera ...................... 155
Rear windows .............................. 42
Rear window wiper/washer .......... 85
Recommended fluids and lubricants ........................ 202, 206
Refuelling ................................... 158 Registered trademarks ...............222
Remote control ............................. 20
Restraining lattice .........................79
Reversing light ........................... 176
Reversing lights .........................110
Ride control systems ..................147
Roof load ...................................... 80
Roof rack ..................................... 80
S Safety belts ................................... 53
Safety net .................................... 78
Seat adjustment ....................... 7, 46
Seat belt ........................................ 8
Seat belt reminder .......................95
Seat belts ..................................... 53
Seat folding .................................. 48
Seat heating ................................. 48
Seat position ................................ 45
Seats ............................................ 74
Selective catalytic reduction .......139
Service ............................... 127, 201
Service display ............................ 91
Service information ....................201Service vehicle soon .................... 96
Side airbag system ......................61
Sidelights .................................... 106
Side turn signal lights ................175
Sliding door .................................. 31
Sliding side door ........................... 31
Spare wheel ............................... 193
Spare wheel security tool ...........183
Speed limiter......................... 89, 153
Speedometer ............................... 89
Starting and operating ................130
Starting off ................................... 17
Starting the engine ...............17, 132
Steering ...................................... 129
Steering column controls ..............83
Steering wheel adjustment ......9, 83
Steering wheel controls ...............83
Stop engine .................................. 96
Stop-start system............ 17, 99, 134
Storage ......................................... 71
Storage box .................................. 74
Storage compartment ...................73
Storage compartments .................71
Sun visors .................................... 43
Symbols ......................................... 4
T
Tablet holder................................. 71
Tachograph ........................ 100, 105
Tachometer ................................. 90Tailgate......................................... 33
Tailgate emergency release .........33
Tail lights ................................... 174
Technical data ............................ 207
Temporary spare wheel ..............193
Three-point seat belt .................... 54
Toll road stickers .......................... 41
Tools .......................................... 183
Top-Tether .................................... 63
Torx key ...................................... 183
Touchscreen ............................... 100
Tow bar....................................... 160
Towing ................................ 160, 196
Towing another vehicle .............197
Towing a trailer ........................... 161
Towing eye ......................... 183, 196
Towing the vehicle .....................196
Traction Control system ............. 147
Trailer coupling ........................... 160
Trailer stability assist .................161
Trailer towing ............................. 161
Transmission ............................... 16
Tread depth ............................... 188
Trip computer ............................ 103
Trip odometer .............................. 89
Turbo engine warm-up ...............132
Turn and lane-change signals ...109
Turn signal ................................... 94
Tyre chains ................................ 189
Tyre changing ............................. 192

229Tyre designations ......................184
Tyre pressure ............................ 184
Tyre pressure monitoring system ............................... 98, 186
Tyre pressures ........................... 217
Tyre repair kit ............................. 189
Tyres .......................................... 184
Tyres and wheel size, changing. 188
U Ultrasonic parking assist............. 153
Underseat storage .......................74
Upholstery .................................. 200
Upshift .......................................... 97
USB socket ................................... 86
Using this manual ..........................3
V Vehicle battery ...................169, 195
Vehicle checks............................ 164
Vehicle data ................................ 206
Vehicle data recording and privacy ..................................... 222
Vehicle dimensions .................... 212
Vehicle Identification Number ....204
Vehicle jack ................................ 183
Vehicle messages .....................101
Vehicle security ............................ 35
Vehicle shutdown ......................133
Vehicle specific data ......................3
Vehicle storage ........................... 163Vehicle tools....................... 183, 196
Vehicle unlocking ........................... 6
Vehicle weight ........................... 209
Ventilation ................................... 114
W
Warning chimes .........................102
Warning lights ............................... 89
Warning messages .....................101
Warning triangle .......................... 80
Washer and wiper systems .........14
Washer fluid ............................... 168
Washing the vehicle ...................198
Welcome lighting ........................112
Wheel changing .........................192
Wheel cover hook .......................183
Wheel covers ............................. 188
Wheels and tyres .......................184
Wheel wrench ............................. 183
Wide view mirror ........................... 40
Windows ................................. 41, 42
Windscreen................................... 41
Windscreen stickers .....................41
Windscreen wiper/washer ...........84
Winter tyres ............................... 184
Wiper blade replacement ..........172